cockpit MERCEDES-BENZ G500 2005 W463 Owner's Manual

Contents
Introduction.......................................... 9
Product information ................................ 9
Operator’s Manual ............................... 10
Service and warranty information .. 10
Important notice for California
retail buyers and lessees of
Mercedes-Benz automobiles .......... 11
Maintenance .................................. 12
Roadside Assistance ...................... 12
Change of address or ownership.... 13
Operating your vehicle outside
the USA or Canada......................... 13
Where to find it .................................... 15
Symbols ............................................... 16
Operating safety .................................. 17
Proper use of the vehicle ............... 17
Problems with your vehicle.................. 18
Reporting safety defects...................... 19
Reporting safety defects ................ 19
Vehicle data recording ......................... 20
Information regarding electronic
recording devices ........................... 20
At a glance.......................................... 21
Cockpit ................................................. 22
Instrument cluster ................................ 24
Multifunction steering wheel ................ 26
Center console ..................................... 28
Upper part ...................................... 28
Lower part ...................................... 29
Overhead control panel ........................ 30
Door control panel................................ 31
Getting started................................... 33
Unlocking ............................................. 34
Unlocking with the SmartKey ......... 34
Adjusting .............................................. 37
Seats .............................................. 37
Steering wheel ................................ 40
Mirrors ............................................ 41
Driving .................................................. 43
Fastening the seat belt ................... 43
Starting the engine ......................... 48
Switching on headlamps ................. 51
Turn signals .................................... 52
Windshield wipers ........................... 53
Rear window wiper/washer............ 54
Problems while driving.................... 55
Parking and locking .............................. 57
Parking brake ................................. 57
Switching off headlamps................. 58
Turning off engine ........................... 58

21 At a glance
Cockpit
Instrument cluster
Multifunction steering wheel
Center console
Overhead control panel
Door control panel

22 At a glanceCockpit

23 At a glance
Cockpit
Item
Page
1
Combination switch

Turn signals
52


Windshield wipers
53


High beam
52
2
Headlamp cleaning system
162
3
Cruise control lever
176
4
Instrument cluster
24
5
Lever for voice control
system*, see separate
operating instructions
Item
Page
6
Starter switch
35
7
Glove box
190
8
Multifunction steering
wheel
26,
124,
211
9
Horn
a
Steering wheel adjustment
lever
40,
211
b
Exterior lamp switch
51,
110
c
Exterior rear view mirror
adjustment
41

197 Controls in detail
Useful features
Telephone*
Radio transmitters, such as a portable tele-
phone or a citizens band unit, should only
be used inside the vehicle if they are con-
nected to an antenna that is installed on
the outside of the vehicle.
The external antenna must be approved by
Mercedes-Benz. Please contact an autho-
rized Mercedes-Benz Light Truck Center
for information on the installation of an ap-
proved external antenna. Refer to the radio
transmitter operation instructions regard-
ing use of an external antenna.You can take and place telephone calls
using thes andt buttons on the
multifunction steering wheel. Use the con-
trol system for performing other telephone
functions (
page 145).
See separate instruction manual for infor-
mation on how to operate the telephone.
Warning!
G
Never operate radio transmitters equipped
with a built-in or attached antenna (i.e. with-
out being connected to an external antenna)
from inside the vehicle while the engine is
running. Doing so could lead to a malfunc-
tion of the vehicle’s electronic system, pos-
sibly resulting in an accident and/or
personal injury.
Warning!
G
Please do not forget that your primary re-
sponsibility is to drive the vehicle. A driver’s
attention to the road must always be
his /her primary focus when driving. For
your safety and the safety of others, we rec-
ommend that you pull over to a safe location
and stop before placing or taking a tele-
phone call.
If you choose to use the telephone
1 while
driving, please use the hands-free device
and only use the telephone when road, traf-
fic and weather conditions permit. Some ju-
risdictions prohibit the driver from using a
cellular telephone while driving a vehicle.
Only operate the COMAND (Cockpit
Management and Data System)
1 if road,
traffic and weather conditions permit.
Bear in mind that at a speed of just 30 mph
(approximately 50 km / h), your vehicle is
covering a distance of 44 feet
(approximately 14 m) every second.
1Observe all legal requirements

326 Practical hintsUnlocking/locking in an emergency
Press lock cylinder2 and pull on tail-
gate handle3.

Open the tailgate to the side.
Locking the vehicle
If you are unable to lock the vehicle with
the SmartKey, lock it with the mechanical
key as follows:
Close the passenger doors and the tail-
gate.

Press the central locking switch in the
cockpit (
page 99).

Check to see whether the locking
knobs on the passenger doors are still
visible. If necessary, push them down
manually.

Slide the mechanical key2 out of the
SmartKey.

Lock the driver’s door with the me-
chanical key.

Check if the tailgate is locked. If neces-
sary lock the tailgate with the mechan-
ical key.
Fuel filler flap
The emergency release is in the cargo
compartment behind the rear panel trim.
1Edge protection
2Rear panel trim
Open the tailgate.

Remove edge protection1 from the
door pillar.

Remove rear panel trim2.
Warning!
G
The tailgate swings open to one side. Always
make sure there is sufficient clearance for
tailgate.iUnlocking your vehicle with the me-
chanical key will trigger the anti-theft
alarm system. To cancel the alarm, do
one of the following:

Press button Œ or ‹ on the
SmartKey.


Insert the SmartKey in the starter
switch.


360 Practical hintsFusesThe fuse box is located on the left side of
the cockpit in the passenger compart-
ment. It contains:

Fuse chart


Spare fuses


Special spare extractor
Additional fuses are located in:


Battery box


Front passenger footwell under the
cockpit


Middle tunnel
Fuse box in passenger compartment
Opening
1Cover
Open the driver’s door.

Remove cover1 in direction of ar-
rows.
Fuse box in battery box
The battery box is located under the cover
in the rear footwell.
Replacement of fuses can only be per-
formed by a Mercedes-Benz Light Truck
Center.
iOnly install fuses that have been tested
and approved by Mercedes-Benz and
that have the specified amperage rat-
ing.
Never attempt to repair or bridge a
blown fuse. Have the cause determined
and remedied by an authorized
Mercedes-Benz Light Truck Center.
!Do not use sharp objects such as a
screw driver to open fuse box cover1
in the dashboard, as this could damage
it.

381 Technical terms
ABS
(A
ntilock B
rake S
ystem)
Prevents the wheels from locking up
during braking so that the vehicle can
continue to be steered.
Accessory weight
(
page 271)
Air pressure
(page 271)
Aspect ratio
(page 271)
BabySmart
TM1
airbag deactivation
system
This system detects if a special system
compatible child restraint seat is in-
stalled on the front passenger seat. The
system will automatically deactivate
the passenger front airbag when such a
seat is properly installed (indicator
lamp7 in the center console
comes on).BabySmart
TM
compatible child seats
Special restraint system for children.
The sensor system for the passenger
seat prevents deployment of the pas-
senger front airbag if a BabySmart
TM
compatible child seat is installed. See
an authorized Mercedes-Benz Light
Truck Center for availability.
BAS
(B
rake A
ssist S
ystem)
System for potentially reducing braking
distances in emergency braking situa-
tions. The system is activated when it
senses an emergency based on how
fast the brake is applied.
Bar
(
page 271)
Bead
(page 271)CAC
(C
ustomer A
ssistance C
enter)
Mercedes-Benz customer service cen-
ter, which can help you with any ques-
tions about your vehicle and provide
assistance in the event of a break-
down.
CAN system
(C
ontroller A
rea N
etwork)
Data bus network serving to control ve-
hicle functions such as door locking or
windshield wiping.
Cockpit
All instruments, switches, buttons and
indicator/warning lamps in the passen-
ger compartment needed for vehicle
operation and monitoring.
Cold tire inflation pressure
(
page 271)
1BabySmart
TM is a trademark of Siemens
Automotive Corp.

390 IndexCentigrade
Setting temperature units 135
Central locking
From inside 99
Switch 99
Switching on/off (control
system) 141
Unlocking from inside 99
Certification label 366
Changing
Key setting 142
Charging
Vehicle battery 351
Checking
Coolant level 237, 244
Oil level 237, 239
Checklist
Off-road driving 225
Child safety 72
Infant and child restraint systems 62,
68, 72
LATCH child seat anchors 77
Child safety switch see Blocking of rear
door window operation
Cigarette lighter 195Cleaning
Cup holders 284
Gear selector lever 284
Hard plastic trim items 284
Headlamps 162
Headliner 284
Illuminated door sill panels 285
Instrument cluster 284
Leather upholstery 285
Light alloy wheels 284
MB Tex upholstery 285
Plastic and rubber parts 285
Rear Parking Assist sensors* 283
Seat belts 284
Steering wheel 284
Windows 283
Windshield 54
Wiper blades 283
Wood trims 285
Cleaning tires 250
Climate control 164
Adjusting 167
Defogging windshield 167
Defrosting 168
Rear window defroster 163
Setting the temperature 166Clock 25
Closing
Glove box 190
Hood 239
Side windows 171
Tailgate 98
Tilt/sliding sunroof 173, 328
Tilt/sliding sunroof with
SmartKey 175
Windows 171
Windows with SmartKey 172
Closing tilt/sliding sunroof
In an emergency 328
Cockpit 22, 381
Cockpit management and data system
(COMAND) 382
Cold tire inflation pressure 271
COMAND 382
COMAND see separate operating
instructions
Combination switch 23, 114
High beam flasher 52, 114
High beam headlamps 114
Turn signals 52
Windshield wipers 53

397 Index
Instrument cluster 24, 120, 383
Cleaning 284
Coolant temperature display 120
Illumination 120
Lamps in 294
Multifunction display 123
Outside temperature indicator 122
Selecting language 136
Instrument lighting 120
Instruments and controls see Cockpit
Interior lighting 116
Delayed shut-off 140
Manual operation 117
Interior rear view mirror
Adjusting 41
Intermittent wiping 54
Interval wiping 55
Switching off 55
Switching on 55J
Jack 322
Jump starting 354K
Key, mechanical 325
Key, SmartKey
Battery check lamp 94
Checking the batteries 95
Factory setting 94
Global locking 94
Global unlocking 94
Loss of 96
Positions in starter switch 35
Remote controls 92
Restoring to factory setting 95
Selective setting 94
Starting the engine 49
Unlocking with 34
Key-dependency memory
Settings 143
Keys 92
Kickdown 153, 383
Kilometers/miles in speedometer 136
Kilopascal 272
Km/h or mph in speedometer 136