air conditioning MERCEDES-BENZ G500 2006 W463 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2006, Model line: G500, Model: MERCEDES-BENZ G500 2006 W463Pages: 417, PDF Size: 9.99 MB
Page 6 of 417
Contents
Automatic transmission ..................... 149
Gear selector lever position ......... 151
Driving tips ................................... 153
Gear ranges ................................. 154
One-touch gearshifting................. 155
Emergency operation
(Limp Home Mode) ...................... 156
Transfer case ..................................... 157
Transfer case position .................. 157
Switching transfer case................ 157
Differential locks ............................... 159
A few words about differentials
and differential locks.................... 160
Switching differential locks
on and off..................................... 161
Good visibility .................................... 163
Rear view mirrors ......................... 163
Headlamp cleaning system .......... 165
Sun visors .................................... 165
Rear window defroster ................. 166Climate control ................................... 168
Setting the temperature................ 170
Adjusting air distribution
and volume ................................... 171
Defrosting ..................................... 172
Air recirculation ............................ 172
Residual engine heat utilization .... 173
Deactivating the climate control
system .......................................... 173
Air conditioning............................. 174
Rear passenger compartment
adjustable air vents....................... 174
Power windows .................................. 175
Opening and closing the windows. 175
Power tilt/sliding sunroof................... 178
Opening and closing the power
tilt/sliding sunroof ........................ 178
Driving systems .................................. 181
Cruise control ............................... 181
Rear Parking Assist* ..................... 184Loading .............................................. 187
Roof rack ...................................... 187
Cargo compartment cover ............ 187
Enlarged cargo compartment ....... 188
Split rear seat bench .................... 188
Partition net* (MB Accessory) ...... 189
Loading instructions ..................... 192
Cargo tie-down rings..................... 193
Useful features ................................... 194
Storage compartments ................. 194
Ashtrays........................................ 198
Cigarette lighter ............................ 199
Electrical outlet............................. 200
Floormats ..................................... 201
Telephone* ................................... 201
Tele Aid ......................................... 202
Garage door opener ...................... 210
Heated steering wheel .................. 215
Page 9 of 417
Contents
Technical data.................................. 365
Parts service ...................................... 366
Warranty coverage ............................. 367
Loss of Service and Warranty
Information Booklet...................... 367
Identification labels............................ 368
Layout of poly-V-belt drive ................. 369
G 500 ........................................... 369
G 55 AMG..................................... 369
Engine ................................................ 370
Rims and tires .................................... 371
Rims and Tires.............................. 372
Spare wheels ................................ 373
Electrical system................................ 374
Main dimensions, vehicle weights
and ratings ......................................... 375
Main dimensions .......................... 375
Vehicle weights and ratings ......... 375Fuels, coolants, lubricants, etc. ......... 376
Capacities .................................... 376
Engine oils.................................... 377
Engine oil additives ...................... 378
Air conditioning refrigerant .......... 378
Brake fluid .................................... 378
Premium unleaded gasoline ......... 378
Fuel requirements ........................ 379
Gasoline additives ........................ 379
Coolants....................................... 380
Anticorrosion/antifreeze.............. 381
Windshield/rear window
washer system and headlamp
cleaning system ........................... 382Technical terms............................... 383
Index................................................. 389
Page 171 of 417
170 Controls in detail
Climate control
The climate control is operational whenev-
er the engine is running. You can operate
the climate control system in either the au-
tomatic or manual mode. The system cools
or heats the interior depending on the se-
lected interior temperature and the cur-
rent outside temperature.Nearly all dust particles, pollutants and
odors are filtered out before outside air en-
ters the passenger compartment through
the air distribution system.
The air conditioning will not engage (no
cooling) if the AC
OFF mode is selected
(
page 174).
Setting the temperature
Use temperature controls2 and3 to
separately adjust the air temperature on
each side of the passenger compartment.
You should raise or lower the temperature
setting in small increments, preferably
starting at 72°F (22°C).
Warning!G
When operating the climate control, the air
that enters the passenger compartment
through the air vents in the footwell can be
very hot or very cold (depending on the set
temperature). This may cause burns or frost-
bite on unprotected skin in the immediate
area of the air vents. Always keep sufficient
distance between unprotected parts of the
body and the footwell air vents. If necessary,
change the air flow using the air distribution
controls to direct the air away from the foot-
well air vents (
page 171).
Warning!G
Follow the recommended settings for heat-
ing and cooling given on the following pag-
es. Otherwise the windows could fog up,
impairing visibility and endangering you and
others.
i
If the vehicle interior is hot, ventilate
the interior before driving off.
Keep the air intake grille in front of the
windshield free of snow and debris.
i
When operating the climate control
system in automatic mode, you will
only rarely need to adjust the tempera-
ture, air volume, and air distribution.
Page 175 of 417
174 Controls in detail
Climate control
Air conditioning
The air conditioning is operational while
the engine is running and cools the interior
air to the temperature set by the operator.
Deactivating
It is possible to deactivate the air condi-
tioning (cooling) function of the climate
control system. The air in the vehicle will
then no longer be cooled or dehumidified.
Press button°.
The indicator lamp on the button°
comes on.Activating
Moist air can fog up the windows. You can
dehumidify the air with the air conditioner.
Press button° again.
The indicator lamp on the button°
goes out.
The air conditioner uses the refrigerant
R134a. This refrigerant is free of CFCs
which are harmful to the ozone layer.Rear passenger compartment
adjustable air vents
1Air volume control for center air vents
2Left center air vent, adjustable
3Right center air vent, adjustable
i
Condensation may drip out from under-
neath the vehicle. This is normal and
not an indication of a malfunction.
!
If the° button on the climate con-
trol panel starts to blink, this indicates
that the air conditioner is losing refrig-
erant. The compressor has turned itself
off. The air conditioner cannot be
turned on again.
Have the air conditioner checked at
the nearest authorized
Mercedes-Benz Light Truck Center.
Page 274 of 417
273 Operation
Tires and wheels
Tire ply material
1Plies in sidewall
2Plies under tread
This marking tells you about the type of
cord and number of plies in the sidewall
and under the tread.Tire and loading terminology
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
automatic transmission, power steering,
power brakes, power windows, power
seats, radio, and heater, to the extent that
these items are available as
factory-installed equipment (whether
installed or not).
Air pressure
The amount of air inside the tire pressing
outward on each square inch of the tire.
Air pressure is expressed in pounds per
square inch (psi), or kilopascal (kPa) or
bars.
Aspect ratio
Dimensional relationship between tire
section height and section width
expressed in percentage.Bar
Another metric unit for air pressure. There
are 14.5038 pounds per square inch (psi)
to 1 bar; there are 100 kilopascals (kPa)
to 1 bar.
Bead
The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the
rim.
Cold tire inflation pressure
Tire inflation pressure when your vehicle
has been sitting for at least three hours or
driven no more than one mile (1.6 km).
Curb weight
The weight of a motor vehicle with stan-
dard equipment including the maximum
capacity of fuel, oil, and coolant, and, if so
equipped, air conditioning and additional
optional equipment, but without passen-
gers and cargo.
i
For illustration purposes only. Actual
data on tires are specific to each vehi-
cle and may vary from data shown in
above illustration.
Page 370 of 417
369 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
For dimensions of the poly-V-belt, see
technical data (
page 370).
G500
1Automatic belt tensioner
2Power steering pump
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulleyG55AMG
The G 55 AMG has two poly-V-belts
(belt one shown in purple/belt two shown
in black).
1Idler pulley
2Automatic belt tensioner
3Power steering pump
4Air conditioning compressor
5Crankshaft
6Coolant pump
7Generator (alternator)
8Idler pulley
9Automatic belt tensioner
aSupercharger
Page 378 of 417
377 Technical data
Fuels, coolants, lubricants, etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Products pamphlet, or
contact an authorized Mercedes-Benz
Light Truck Center.Using engine oils and oil filters of specifica-
tion other than those expressly required
for the Maintenance System (U.S. vehi-
cles) or FSS (Canada vehicles), or changing
of oil and oil filter at change intervals
longer than those called for by the
Maintenance System (U.S. vehicles) or
FSS (Canada vehicles) will result in engine
damage not covered by the
Mercedes-Benz Limited Warranty.Please follow Maintenance System (U.S.
vehicles) or FSS (Canada vehicles) recom-
mendations for scheduled oil changes.
Failure to do so will result in engine dam-
age not covered by the Mercedes-Benz
Limited Warranty.
ModelCapacityFuels, coolants, lubricants, etc.
Cooling systemG 500
G55AMGapprox. 12.7 US qt (12.0 l)
approx. 13.4 US qt (12.7 l)MB Anticorrosion/Antifreeze
Air conditioning systemR-134a refrigerant and
special PAG lubricant oil (never R-12)
Windshield/rear window washer system
and headlamp cleaning systemapprox. 7.9 US qt (7.5 l)MB Windshield Washer Concentrate
and water1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 382).
Page 379 of 417
378 Technical data
Fuels, coolants, lubricants, etc.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine. Damage or
malfunctions resulting from blending oil
additives are not covered by the
Mercedes-Benz Limited Warranty.
Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
ing system. Never use R-12 (CFC) or
mineral-based lubricating oil. Otherwise
damage to the system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Light Truck Cen-
ter will provide you with additional
information.Premium unleaded gasoline
Warning!G
Under extremely strenuous operating condi-
tions, this moisture content can lead to the
formation of bubbles in the system, thus re-
ducing the system’s efficiency.
Therefore, the brake fluid must be replaced
every two years, preferably in the spring.
Warning!G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious inju-
ry. Whenever you are around gasoline, avoid
inhaling fumes and skin contact, extinguish
all smoking materials. Never allow sparks,
flame or smoking materials near gasoline!
Page 390 of 417
389 Index
A
ABS 25, 80, 383
LOW RANGE mode 81
Malfunction indicator lamp 290, 291
Messages in display 300
Warning lamp 290, 291
Accelerator position (Automatic
transmission) 153
Accessory weight 273
Accident
In case of 56
Activating
Air conditioning (cooling) 174
Air recirculation mode 172
Anti-theft alarm system 88
Central locking (control system) 142
Defrost 172
Easy-entry/exit feature 143
ESP 87
Exterior headlamps 51
Exterior lamps 111
Exterior rear view mirror parking
position 164
Headlamps 51
Rear window defroster 166
Windshield wipers 53Adding
Coolant 249
Engine oil 247
Additional turn signals 336
Adjusting 37
Air distribution 171
Air volume 171
Backrest tilt 39
Exterior rear view mirror 41
Head restraint height 39
Head restraint height, rear seats 103
Head restraint tilt 39
Instrument cluster illumination 120
Interior rear view mirror 41
Mirrors 41
Multicontour seat* 104
Seat cushion length 104
Seat cushion tilt 39
Seat fore and aft adjustment 38
Seat height 39
Seats 37
Steering column in/out 40
Steering column up/down 40
Steering wheel 40Air conditioning (cooling)
Turning off 174
Turning on 174
Air conditioning refrigerant 378
Air distribution
Adjusting 171
Air pressure 273
Air pressure see Tire inflation pressure
Air recirculation mode 172
Activating 172
Deactivating 172
Air volume
Adjusting 171
AIRBAG OFF indicator lamp 297
Airbags 63
BabySmart
TM airbag deactivation
system 74, 383
Front 67
Safety guidelines 66
Window curtain airbags 68
Page 395 of 417
394 Index
D
Data recording (vehicle) 20
Daytime running lamp mode 112
Setting 138, 139
Deactivating
Air conditioning (cooling) 174
Air recirculation mode 172
Alarm 89
Anti-theft alarm system 89
Central locking (control system) 142
Cruise control 182
Defrost 172
ESP 86
Exterior lamps 111
Exterior lamps delayed shut-off 140
Headlamps 58
Immobilizer 88
Interior lighting delayed shut-off 141
Rear window defroster 167
Tow-away alarm 90
Deep water see Standing water
Defogging
Windshield 171
Defrosting 172Delayed shut-off
Exterior lamps 140
Interior lighting 141
Department of Transportation see DOT
Dialing
A number (telephone) 148
Differential locks 159, 384
Switching off 162
Switching on 161
Difficulties
While driving see Problems while driv-
ing
With starting 49
Digital speedometer 128
Direction of rotation (tires) 255
Discharged battery
Jump starting 356
Disconnecting
Vehicle battery 354
Display
Selecting 138Displays
Digital speedometer 128
Maintenance service indicator 280
Messages 245, 298
Selecting 138
Showing vehicle status
messages 131
Distance to empty (range)
Calling up 145
Door control panel 31
Door handle 31
Door sill panels
Cleaning 288
Door unlock
With Tele Aid 209
Doors
Messages in display 310
Opening from the inside 96
Opening from the outside 94
DOT 274
Downhill driving
Cruise control 182
Downshifting 155
Drink holders see Cup holders
Drinking and driving 220