fuel cap MERCEDES-BENZ G55AMG 2006 W463 User Guide

296 Practical hints
What to do if …
ProblemPossible causeSuggested solution
nates briefly after starting the
engine.The warning lamp reminds you to fasten seat
belts.Fasten your seat belt.
The yellow fuel tank reserve warning lamp
illuminates while driving.The fuel level has gone below the reserve
mark.Refuel at the next gas station.
Also note the messages in the multi-
function display (
page 298).
The yellow fuel tank reserve warning lamp is
blinking.The fuel cap is not closed tight.Check the fuel cap.
1The red SRS indicator lamp
comes on while driving.There is a malfunction in the restraint sys-
tems. The airbags or emergency tensioning
device (ETD) could deploy unexpectedly or
fail to activate in an accident.Drive with added caution to the near-
est authorized Mercedes-Benz Light
Truck Center.
Warning!G
In the event a malfunction of the SRS is indi-
cated as outlined above, the SRS may not be
operational.
For your safety, we strongly recommend
that you visit an authorized Mercedes-Benz
Light Truck Center immediately to have the
system checked; otherwise the SRS may not
be activated when needed in an accident.This could result in serious or fatal injury, or
it might deploy unexpectedly and unneces-
sarily which could also result in an accident
and/or injury to you or to others.

313 Practical hints
What to do if …
Display symbolDisplay message Possible causePossible solution
A RESERVE FUEL
GO TO GAS STATIONThe fuel level has dropped below the re-
serve mark.Refuel at the next gas station
(
page 239).
CHECK GAS CAP
SEE OPERATOR’S MANUALA loss of pressure has been detected in
the fuel system. The fuel cap may not be
closed properly or the fuel system may be
leaky.Check the fuel cap (page 239).
If it is not closed properly:
Close the fuel cap.
If it is closed properly:
Have the fuel system checked by an
authorized Mercedes-Benz Light Truck
Center.
YHOOD OPEN!You are driving with the hood open.Close the hood (page 243).
I REMOVE KEY!You have forgotten to remove the
SmartKey.Remove the SmartKey from the starter
switch.
REPLACE KEY
DRIVE TO WORKSHOP!No additional code available for
SmartKey.Visit an authorized Mercedes-Benz
Light Truck Center.

376 Technical data
Fuels, coolants, lubricants, etc.
Capacities
Vehicle components and their respective
lubricants must match.Therefore use only products tested and ap-
proved by Mercedes-Benz.Please refer to the Factory Approved
Service Products pamphlet, or inquire at
an Mercedes-Benz Light Truck Center.
ModelCapacityFuels, coolants, lubricants, etc.
Engine with oil filterG500
G55AMG8.5 US qt (8.0 l)
9.0 US qt (8.5 l)Approved engine oils
Automatic transmission9.0 US qt (8.5 l)MB Automatic Transmission Fluid
Transfer case2.96 US qt (2.8 l)MB part no. A 001 989 28 03 10
Differential lock mechanism0.47 - 0.63 US qt
(0.45 - 0.6 l)Brake fluid DOT 3+4, SAE J1703
Front axleG500
G55AMG1.5 US qt (1.4 l)
1.5 US qt (1.4 l)Hypoid gear oil SAE 85W-90
Hypoid gear oil Castrol SAF-XJ
Rear axleG500
G55AMG1.9 US qt (1.8 l)
1.9 US qt (1.8 l)Hypoid gear oil SAE 85W-90
Hypoid gear oil Castrol SAF-XJ
Power steeringapprox. 1.06 US qt (1.0 l)MB Power Steering Fluid, or
approved Dexron III ATF
Front wheel hubsapprox. 1.5 oz (43 g) eachHigh temperature roller bearing grease
Fuel tank
including a reserve ofG500
G55AMG25.4 US gal (96.0 l)
25.1 US gal (95.0 l)
3.4 US gal (13.0 l)Premium unleaded gasoline:
Minimum Posted Octane 91
(average of 96 RON / 86 MON)

377 Technical data
Fuels, coolants, lubricants, etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines and durability for
our service intervals. Therefore, only use
approved engine oils and oil filters re-
quired for vehicles with Maintenance
System (U.S. vehicles) or FSS (Canada
vehicles). For a listing of approved engine
oils and oil filters, refer to the Factory
Approved Service Products pamphlet, or
contact an authorized Mercedes-Benz
Light Truck Center.Using engine oils and oil filters of specifica-
tion other than those expressly required
for the Maintenance System (U.S. vehi-
cles) or FSS (Canada vehicles), or changing
of oil and oil filter at change intervals
longer than those called for by the
Maintenance System (U.S. vehicles) or
FSS (Canada vehicles) will result in engine
damage not covered by the
Mercedes-Benz Limited Warranty.Please follow Maintenance System (U.S.
vehicles) or FSS (Canada vehicles) recom-
mendations for scheduled oil changes.
Failure to do so will result in engine dam-
age not covered by the Mercedes-Benz
Limited Warranty.
ModelCapacityFuels, coolants, lubricants, etc.
Cooling systemG 500
G55AMGapprox. 12.7 US qt (12.0 l)
approx. 13.4 US qt (12.7 l)MB Anticorrosion/Antifreeze
Air conditioning systemR-134a refrigerant and
special PAG lubricant oil (never R-12)
Windshield/rear window washer system
and headlamp cleaning systemapprox. 7.9 US qt (7.5 l)MB Windshield Washer Concentrate
and water1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent / antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 382).

380 Technical data
Fuels, coolants, lubricants, etc.
In areas where carbon deposits may be en-
countered due to lack of availability of gas-
olines which contain these additives,
Mercedes-Benz recommends the use of
additives approved by us for use on
Mercedes-Benz vehicles. Refer to Factory
Approved Service Products pamphlet for
a listing of approved product(s). Follow
directions on product label.
Do not blend other specific fuel additives
with fuel. This only results in unnecessary
cost and may be harmful to the engine
operation.
Damage or malfunction resulting from
poor fuel quality or from blending addition-
al fuel additives other than those tested
and approved by us for use on
Mercedes-Benz vehicles listed in the
Factory Approved Service Products
pamphlet are not covered by the
Mercedes-Benz Limited Warranty.Coolants
The engine coolant is a mixture of water
and anticorrosion / antifreeze, which pro-
vides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for
replacement interval.Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance Booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products
pamphlet) are used to renew the coolant
concentration or bring it back up to the
proper level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]).
If you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.

391 Index
Battery, vehicle 251, 353
Charging 353
Disconnecting 354
Messages in display 304, 305
Reconnecting 355
Bead 273
Block heater (Canada only) 279
Blocking rear door window operation 78
B-pillar 368
Brake assist system (BAS) 383
Brake fluid 241, 378
Brake lamp bulbs, left and right 336
Brake lamp, high mounted 336
Brake pads
Message in display 305
Brakes 221
Warning lamp 292, 293
Break-in period 218
Brush guard* 331
Lowering 332
Raising and securing 332Bulbs, replacing
Additional turn signals 336
Backup lamps 336, 344
Brake lamps 336, 344
Front fog lamps 336, 340
Front lamps 335, 336
Front turn signal lamps 336, 342
High and low beam 338
High beam lamps 336
High mounted brake lamp 336
License plate lamps 336, 345
Low beam lamps 336
Parking lamps 336, 338
Rear fog lamp 336, 344
Rear turn signal lamps 336
Side marker lamps 336, 342
Standing lamps 336, 338
Tail lamp assemblies 336
Tail lamp unit 343C
CAC (Customer Assistance Center) 383
Call priority
Tele Aid 208
Calling up
Maintenance service indicator 281
Range (distance to empty) 146
CAN system 383
Capacities
Fuels, coolants, lubricants, etc. 376
Cargo area see Cargo compartment
Cargo compartment
Tailgate 97, 98
Tie-down rings 193
Cargo compartment cover 187
Installing 187
Removing 187
Cargo tie-down rings 193
Catalytic converter 236
CD changer 324
CD player
Operating 130

396 Index
Engine oil level see Oil level
Enlarged cargo compartment 188
ESP 25, 80, 84, 384
Messages in display 302
Switching off 86
Switching on 87
Synchronizing 302
Warning lamp 295
ETD 62, 71, 384
Safety guidelines 66
Exterior lamp switch 110
Exterior lamps
Delayed shut-off 140
Exterior rear view mirrors
Adjusting 41
Parking position for 144
F
Fahrenheit
Setting temperature units 136
Fastening the seat belts 43
Fine adjustment
Cruise control 183
First aid kit 323Flat tire 348
Lowering the vehicle 352
Mounting the spare wheel 349
Spare wheel 325
Flexible Service System (FSS, Canada
vehicles) 384
Fog lamp, rear 114, 336
Fog lamps, front 113
Messages in display 315
4-ETS 80, 83
Front airbags 67
Front axle differential lock
Switching on 162
Front fog lamps
Replacing bulbs 336, 340
Front lamps
Messages in display 314, 316
Replacing bulbs 336, 338
Switching on 110
Front seat head restraints
Installing 102
Removing 101
Front towing eye 361
Front turn signal lamp
Replacing bulbs 342FSS (Flexible Service System, Canada
vehicles) 384
Fuel 240
Additives 379
Fuel reserve warning lamp 296
Gasoline additives 379
Premium unleaded gasoline 240,
376, 378
Refueling 239
Requirements 379
Reserve warning 25
Technical data 376
Fuel additives 379
Fuel consumption statistics
After start 145
Since last reset 145
Fuel filler flap 239
Locking 239
Opening 328
Unlocking 239
Fuel requirements 379
Fuel reserve tank
Message in display 313
Fuel tank
Capacity 376
Filler flap 239

397 Index
Fuels, coolants, lubricants, etc.
Capacities 376
Functions (control system) 125, 127
Resetting 133
Fuse box 362, 363, 364
Fuses 362
Fuse box in battery box 362
Fuse box in front passenger
footwell 363
Fuse box in middle tunnel 364
Fuse box in passenger
compartment 362
G
Garage door opener 30, 210
Gasoline see Fuel
Gasoline additives 379
GAWR 274
Gear range 385
Automatic transmission 154
Limiting 154
Shifting into optimal 155
Transfer case 157
Gear range limit
Canceling 155Gear selector lever
Cleaning 287
Position 151
Position (automatic
transmission) 149
Global
Locking 94
Unlocking 94
Global Positioning System (GPS) 385
Glove box 23, 194
Closing 194
Opening 194
Good visibility 163
GPS 385
Gross Axle Weight Rating see GAWR
Gross Trailer Weight see GTW
Gross Vehicle Weight Rating see GVWR
Gross Vehicle Weight see GVW
GTW 274
GVW 274
GVWR 274H
Hard plastic trim items
Cleaning 287
Hazard warning flasher 115
Head restraints 101
Power seats 39
Synchronizing 102
Headlamp cleaning system 249
Headlamps
Automatic control 111
Cleaning 285
Cleaning system 165, 249
Switching off 58
Switching on 51
Washer fluid 382
Washer system 382
Headlight switch-off delay see Delayed
switch-off, exterior lamps
Headliner
Cleaning 287
Heated seats 104
Heated steering wheel 215
Height adjustment
Head restraints 39
Seat belts 48
Steering wheel 40