engine MERCEDES-BENZ ML SUV 2008 Owners Manual

347
Notes on the technical data
.............348
Genuine Mercedes-Benz parts .........348
Vehicle electronics ...........................349
Vehicle identification plates ............350
Engine ................................................ 352
Performance ...................................... 353
Tyres and wheels .............................. 354
Vehicle dimensions ..........................361
Vehicle weights ................................. 363
Trailer coupling* ............................... 365
Service products and capacities .....366
Frequencies for garage door open-
ers* .................................................... 373 Technical data
164_AKB; 5; 5, en-GB
wobuchh,
Version: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 347 Dateiname: 6515_4293_02_buchblock.pdf; preflight

Genuine Mercedes-Benz parts
348 Notes on the technical data
i The technical data was determined in
accordance with EU directives. All data
applies to the vehicle's standard equip-
ment. The data may therefore differ for
vehicles with optional equipment. You can
obtain further information from a
Mercedes-Benz Service Centre. Genuine Mercedes-Benz parts
Mercedes-Benz tests genuine parts and con-
version parts and accessories which have
been specifically approved for your vehicle for
their reliability, safety and suitability. Despite
ongoing market research, Mercedes-Benz is
unable to evaluate other parts. Mercedes-
Benz therefore accepts no responsibility for
the use of such parts in Mercedes-Benz vehi-
cles, even if they have been independently or
officially approved.
In Germany and some other countries, certain
parts are only officially approved for installa-
tion or modification if they comply with legal
requirements. All genuine Mercedes-Benz
parts meet this requirement. The use of non-
approved parts may invalidate the vehicle's
general operating permit. This is the case if:
R they cause a change of the vehicle type
from that for which the vehicle's general
operating permit was granted
R other road users could be endangered
R the emission or noise levels are adversely
affected
The use of non-approved parts could affect
your vehicle's operating safety. Mercedes-
Benz therefore recommends genuine Mercedes-Benz parts and conversion parts
and accessories that have been approved for
your vehicle. H
Environmental note
Daimler also supplies reconditioned
assemblies and parts which are of the same
quality as new parts. These parts have the
same warranty as new parts.
Genuine Mercedes-Benz parts and approved
conversion parts and accessories are availa-
ble from Mercedes-Benz Service Centres.
There, you can also receive advice about tech-
nical modifications and have the parts pro-
fessionally fitted.
Always quote the vehicle identification num-
ber and the engine number when ordering
genuine parts. You will find these numbers on
the vehicle data card in the Service Booklet
or on your vehicle's identification plates
(Y page 350). Technical data
164_AKB; 5; 5, en-GB
wobuchh,
Version: 2.10.6 2008-05-11T11:55:12+02:00 - Seite 348Dateiname: 6515_4293_02_buchblock.pdf; preflight

Vehicle electronics
349Vehicle electronics
Tampering with the engine electron-
ics
G
Risk of accident
Only have work on the engine electronics
and related components carried out at a
qualified specialist workshop which has the
necessary specialist knowledge and tools
to carry out the work required. Mercedes-
Benz recommends that you use a
Mercedes-Benz Service Centre for this pur-
pose. In particular, work relevant to safety
or on safety-related systems must be car-
ried out at a qualified specialist workshop.
The vehicle's roadworthiness could other-
wise be affected.
! Only have work done on the engine elec-
tronics and its associated parts, such as
control units, sensors and connector leads,
carried out at a qualified specialist work-
shop, e.g. a Mercedes-Benz Service
Centre. Otherwise, vehicle components
may wear more quickly and your vehicle's
warranty and operating permit may be inva-
lidated. Retrofitting electrical and electronic
equipment
Electrical and electronic equipment can jeop-
ardise the operating safety of your vehicle. If
equipment of this kind is retrofitted, it must
be type-approved and bear the emark. The
e mark may be obtained from the equipment
manufacturer or an authorised testing centre.
! Damage or consequential damage arising
from fitting equipment not approved
by Mercedes-Benz is not covered by the
Mercedes-Benz warranty.
If you wish to install two-way radios in the
vehicle, you must obtain formal approval.
Mercedes-Benz approves the installation of
two-way radios if such equipment is installed
professionally and a low-reflection exterior
aerial is used.
The transmission output of the two-way radio
must not exceed the maximum transmission
outputs listed. G
Risk of accident
Two-way radios may interfere with the vehi-
cle electronics and thereby jeopardise the
operational safety of the vehicle and your
own safety if: R
they do not have an exterior aerial
R the exterior aerial is not a low-reflection
aerial
R the exterior aerial has been fitted incor-
rectly G
Risk of injury
Excessive electromagnetic radiation may
also cause damage to your health and the
health of others. Using an exterior aerial
takes into account current scientific dis-
cussions relating to the possible health haz-
ards that may result from electromagnetic
fields.
For this reason, only have the exterior aerial
fitted at a qualified specialist workshop
which has the necessary specialist knowl-
edge and tools to carry out the work
required. Mercedes-Benz recommends
that you use a Mercedes-Benz Service
Centre for this purpose. In particular, work
relevant to safety or on safety-related sys-
tems must be carried out at a qualified
specialist workshop.
i Mercedes-Benz recommends the use of
an approved exterior aerial. This ensures
optimal reception quality for mobile tele- Technical data
164_AKB; 5; 5, en-GB
wobuchh
,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 349 ZDateiname: 6515_4293_02_buchblock.pdf; preflight

Vehicle identification plates
351Vehicle identification number (VIN)
In addition to the information on the vehicle
identification plate, the vehicle identification
number (VIN) is also stamped onto the cross
member under the second row of seats. 1
Seat
2 Carpet X
Fold seat 1forwards.
X Lift up carpet 2.
You will see the vehicle identification num-
ber (VIN). Engine number
The engine number is stamped on the engine
block (crankcase). More information can be
obtained from any Mercedes-Benz Service
Centre. Technical data
164_AKB; 5; 5, en-GB
wobuchh
,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 351 ZDateiname: 6515_4293_02_buchblock.pdf; preflight

Engine
352 Engine
ML 350 ML 500 ML 63 AMG
Rated output 200 kW (272 bhp) 285 kW (388 bhp) 375 kW (510 bhp)
At engine speed 6,000 rpm 6,000 rpm 6,800 rpm
Rated torque 350 Nm 530 Nm 630 Nm
At engine speed 2,400 – 5,000 rpm 2,800 – 4,800 rpm 5,200 rpm
Number of cylinders 6 8 8
Displacement
3,498 cm
3 5,461 cm
3 6,208 cm
3 Maximum engine speed 6,500 rpm 6,500 rpm 7,200 rpm
ML 280 CDI ML 320 CDI ML 420 CDI
Rated output 140 kW (190 bhp) 165 kW (224 bhp) 225 kW (306 bhp)
At engine speed 4,000 rpm 3,800 rpm 3,600 rpm
Rated torque 440 Nm 510 Nm 700 Nm
At engine speed 1,400 – 2,800 rpm 1,600 – 2,800 rpm 2,000 – 2,600 rpm
Number of cylinders 6 6 8
Displacement
2,987 cm
3 2,987 cm
3 3,996 cm
3 Maximum engine speed 4,500 rpm 4,500 rpm 4,600 rpmTechnical data
164_AKB; 5; 5, en-GB
wobuchh,
Version: 2.10.6 2008-05-11T11:55:12+02:00 - Seite 352Dateiname: 6515_4293_02_buchblock.pdf; preflight

Tyres and wheels
359Spare wheel*
Your vehicle may be equipped with TIREFIT, a "Minispare"/collapsible emergency spare wheel* or a spare wheel* depending on the country,
the engine and the wheels fitted.
i Vehicles with MOExtended tyres (tyres with run-flat characteristics) are not equipped with a TIREFIT kit at the factory.
! The spare wheel* must be inflated to the maximum tyre pressure given in the table on the inside of the fuel filler flap. ML 350
ML 280 CDI / ML 320 CDI / ML 420 CDI ML 500
18" "Minispare" emer-
gency spare wheel*
50 Tyres T 155/90 - 18 113M —
Tyre pres-
sure 4.2 bar —
Wheels 4.0B x 18 H2 ET 40 —
19" "Minispare" emer-
gency spare wheel*
50 Tyres — T 155/80 R19 114M
Tyre pres-
sure — 4.2 bar
Wheels — 4.5B x 19 H2 ET 40
50
Use of snow chains not possible. Technical data
* optional
164_AKB; 5; 5, en-GB
wobuchh
,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 359 ZDateiname: 6515_4293_02_buchblock.pdf; preflight

Vehicle dimensions
361Vehicle dimensions
ML 350 ML 500 ML 63 AMG
Vehicle length (ECE) 4,781 mm 4,781 mm 4,814 mm
Vehicle width with mir-
rors folded out 2,124 mm 2,124 mm 2,127 mm
Vehicle height
51 1,815 mm — —
Vehicle height
52 1,774 – 1,884 mm 1,774 – 1,884 mm 1,765 – 1,845 mm
Ground clearance
52 186 – 291 mm 186 – 291 mm 146 – 226 mm
Ground clearance
53 201 mm 201 mm –
Wheelbase 2,915 mm 2,915 mm 2,915 mm
ML 280 CDI ML 320 CDI ML 420 CDI
Vehicle length (ECE) 4,781 mm 4,781 mm 4,781 mm
Vehicle width with mir-
rors folded out 2,124 mm 2,124 mm 2,124 mm
Vehicle height
51 1,815 mm 1,815 mm —
Vehicle height
52 1,774 – 1,884 mm 1,774 – 1,884 mm 1,774 – 1,884 mm
51
Vehicles with roof rails* but without the AIRMATIC package*.
52 Vehicles with roof rails* and with the AIRMATIC package*, Off-Road Pro engineering package* or ML 63 AMG (depending on the current suspension setting). Technical data
* optional
164_AKB; 5; 5, en-GB
wobuchh
,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 361 ZDateiname: 6515_4293_02_buchblock.pdf; preflight

Vehicle dimensions
362 ML 280 CDI ML 320 CDI ML 420 CDI
Ground clearance
52 186 – 291 mm 186 – 291 mm 186 – 291 mm
Ground clearance
54 201 mm 201 mm 201 mm
Wheelbase 2,915 mm 2,915 mm 2,915 mm
Tailgate opening dimensions
1
Max. headroom
2 Tailgate opening height Vehicle
55 1 2
Steel sus-
pension 199 cm 213 cm
AIRMATIC
pack-
age* 56 195 - 203 cm 208 - 216 cm ML 63
AMG
57 194 - 202 cm 207 - 215 cm
Off-Road
Pro engi-
neering
pack-
age*
58 195 - 206 cm 208 - 219 cm
53
Valid for Highway level suspension setting.
51 Vehicles with roof rails* but without the AIRMATIC package*.
52 Vehicles with roof rails* and with the AIRMATIC package*, Off-Road Pro engineering package* or ML 63 AMG (depending on the current suspension setting).
54 Valid for Highway level suspension setting.
55 These values are approximate and apply to an unladen vehicle with standard equipment.
56 Valid for the suspension settings Highway level with ADS Sport to Raised level.
57 Valid for the suspension settings Highway level to Raised level.
58 Valid for the suspension settings Highway level with ADS Sport to Off-road level 3. Technical data
* optional
164_AKB; 5; 5, en-GB
wobuchh ,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 362 Dateiname: 6515_4293_02_buchblock.pdf; preflight

Service products and capacities
366 Service products and capacities
Notes on service products and capaci-
ties
Service products are:
R fuels (e.g. petrol, diesel)
R lubricants (e.g. engine oil, transmission oil)
R coolant
R brake fluid
R windscreen washer fluid
Mercedes-Benz recommends that you only
use those products which have been tested
and specially approved by Mercedes-Benz for
your vehicle and are listed in the Mercedes-
Benz Owner's Manual in the relevant chapter
since:
R parts and service products are matched
R damage caused by the use of non-approved
service products is not covered by the war-
ranty
You can recognise service products approved
by Mercedes-Benz by the following inscrip-
tion on the containers:
R MB-Freigabe (e.g. MB-Freigabe 229.51)
R MB Approval (e.g. MB Approval 229.51) Other designations or recommendations that
relate to a level of quality or a specification in
accordance with an MB Approval have not
necessarily been approved by Mercedes-
Benz.
You can obtain further information from any
Mercedes-Benz Service Centre. G
Risk of injury
When handling, storing and disposing of
any service products, please observe the
relevant regulations, as you could other-
wise endanger yourself and others.
Keep service products away from children.
To protect your health, do not allow service
products to come into contact with your
eyes or open wounds. See a doctor imme-
diately if any service product is swallowed. H
Environmental note
Dispose of service products in an environ-
mentally-responsible manner. Fuels
G
Risk of explosion
Fuel is highly flammable. Fire, naked flames
and smoking are therefore prohibited when
handling fuels.
Switch off the engine and the auxiliary heat-
ing* before refuelling. G
Risk of injury
Do not allow fuel to come into contact with
skin or clothing.
Allowing fuels to come into direct contact
with your skin or inhaling fuel vapours is
damaging to your health.
Tank capacity Total capacity 95 l
Of which reserve
fuel Approximately 13 l
Of which reserve
fuel
ML 63 AMG Approximately 15 l
!
Do not use petrol to refuel vehicles with a
diesel engine. Do not use diesel to refuel Technical data
* optional
164_AKB; 5; 5, en-GB
wobuchh,
Version: 2.10.6 2008-05-11T11:55:12+02:00 - Seite 366Dateiname: 6515_4293_02_buchblock.pdf; preflight

Service products and capacities
367
vehicles with a petrol engine. Never mix
diesel with petrol. Even small amounts of
the wrong fuel result in damage to the
injection system. Damage resulting from
adding the wrong fuel is not covered by the
warranty.
More information about refuelling and fuels
can be found in the "Operation" section. Notes on fuel consumption
The vehicle will use more fuel than usual in
the following situations: R
at very low temperatures
R in urban traffic
R on short trips
R when towing a trailer
R in mountainous terrain
The consumption figures have been deter-
mined according to EU Directive
RL 80 /1268 /EEC.
i Only for certain countries: the respective
current consumption and emission values
of your vehicle can be found in the COC
papers (EC-CERTIFICATE OF CONFORM-
ITY). These documents are supplied when
the vehicle is delivered.
! Do not use any special additives, as they
can cause malfunctions and engine dam-
age. Damage resulting from the use of such additives is not covered by the Mercedes-
Benz warranty. H
Environmental note
CO 2(carbon dioxide) is the gas which sci-
entists believe to be principally responsible
for global warming (the greenhouse effect).
Your vehicle's CO 2emissions are directly
related to fuel consumption and therefore
depend on:
R efficient use of the fuel by the engine
R driving style
R other non-technical factors, such as envi-
ronmental influences or road conditions
You can minimise your vehicle's CO 2emis-
sions by driving carefully and having it serv-
iced regularly. Technical data
164_AKB; 5; 5, en-GB
wobuchh
,V ersion: 2.10.6
2008-05-11T11:55:12+02:00 - Seite 367 ZDateiname: 6515_4293_02_buchblock.pdf; preflight