oil capacity MERCEDES-BENZ ML320 2008 W164 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2008, Model line: ML320, Model: MERCEDES-BENZ ML320 2008 W164Pages: 561
Page 381 of 561
380 Operation
Tires and wheels
Bar
Another metric unit for air pressure. There
are 14.5038 pounds per square inch (psi)
to 1 bar; there are 100 kilopascals (kPa)
to 1 bar.
Bead
The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the
rim.
Cold tire inflation pressure
Tire inflation pressure when your vehicle
has been sitting for at least 3 hours or
driven no more than 1 mile (1.6 km).
Curb weight
The weight of a motor vehicle with stan-
dard equipment including the maximum
capacity of fuel, oil, and coolant, and, if so
equipped, air conditioning and additional
optional equipment, but without passen-
gers and cargo.DOT (Department of Transportation)
A tire branding symbol which denotes the
tire meets requirements of the
U.S. Department of Transportation.
GAWR (G
ross Axle Weight Rating)
The GAWR is the maximum permissible
axle weight. The gross vehicle weight on
each axle must never exceed the GAWR for
the front and rear axle indicated on the
certification label located on the driver’s
door B-pillar.
GTW (G
ross Trailer Weight)
The GTW is the weight of the trailer plus
the weight of all cargo, equipment, luggage
etc. loaded on the trailer.GVW (G
ross Vehicle Weight)
The GVW comprises the weight of the
vehicle including fuel, tools, spare wheel,
installed accessories, passengers and
cargo and, if applicable, trailer tongue
load. The GVW must never exceed the
GVWR indicated on the certification label
located on the driver’s door B-pillar.
GVWR (G
ross Vehicle Weight Rating)
This is the maximum permissible vehicle
weight of the fully loaded vehicle (weight of
the vehicle including all options, passen-
gers, fuel, and cargo and, if applicable,
trailer tongue load). It is indicated on
certification label located on the driver’s
door B-pillar.
Kilopascal (kPa)
The metric unit for air pressure. There are
6.9 kPa to 1 psi; another metric unit for air
pressure is bars. There are 100 kilopascals
(kPa) to 1 bar.
Page 523 of 561
522 Technical data
Fuels, coolants, lubricants
Capacities
Vehicle components and their respective
lubricants must match. Therefore only use
products tested and approved by
Mercerdes-Benz.
Please refer to the Factory Approved
Service Products pamphlet (USA only), or
inquire at an authorized Mercedes-Benz
Light Truck Center.
Warning!G
Comply with all valid regulations with re-
spect to handling, storing and disposing of
service fluids. Otherwise you could
endanger persons or the environment.
Keep service fluids out of the reach of
children.
For health reasons, you should prevent
service fluids from coming into direct
contact with your skin or clothing.
If a service fluid is swallowed, contact a
physician immediately.
ModelCapacityFuels, coolants, lubricants, etc.
Engine with oil filterML 320 CDI9.0 US qt (8.5 l)Approved engine oils
ML 3508.5 US qt (8.0 l)Approved engine oils
ML 5509.5 US qt (9.0 l)Approved engine oils
ML 63 AMG10.3 US qt (9.7 l)Approved engine oils
Automatic transmissionML 320 CDI
ML 350, ML 5509.5 US qt (9.0 l)MB Automatic Transmission Fluid
ML 63 AMG9.7 US qt (9.2 l)MB Automatic Transmission Fluid
Page 524 of 561
523 Technical data
Fuels, coolants, lubricants
ModelCapacityFuels, coolants, lubricants, etc.
Transfer case
single speedAll models0.53 US qt (0.5 l)MB Automatic Transmission Fluid
Front axleAll models1.2 US qt (1.1 l)Hypoid gear oil
Rear axleAll models1.2 US qt (1.1 l)Hypoid gear oil
Power steeringML 350approx. 1.3 US qt (1.2 l)MB Power Steering Fluid or approved
Dexron III ATF
ML 320 CDI
ML 5501
1Data preliminary.
approx. 2.3 US qt (2.2 l)MB Power Steering Fluid
Front wheel hubsAll modelsapprox. 1.5 oz (43 g) eachHigh temperature roller bearing grease
Brake systemAll models-MB Brake Fluid (DOT 4+)
Cooling systemML 320 CDI,
ML 350approx. 10.0 US qt (9.5 l)MB Anticorrosion/Antifreeze
ML 5501approx. 12.7 US qt (12.0 l)MB Anticorrosion/Antifreeze
ML 63 AMGapprox. 12.2 US qt (11.5 l)MB Anticorrosion/Antifreeze
Page 525 of 561
524 Technical data
Fuels, coolants, lubricants
ModelCapacityFuels, coolants, lubricants etc.
Fuel tankAll models25.1 US gal (95.0 l)Gasoline engine:
Premium unleaded gasoline
Minimum Posted Octane 91
(Avg. of 96 RON/86 MON)
Diesel engine:
ULTRA-LOW SULFUR HIGHWAY DIESEL FUEL
(15 ppm SULFUR MAXIMUM)
including a reserve ofAll except
ML 63 AMGapprox. 3.5 US gal (13.0 l)
including a reserve ofML 63 AMGapprox. 4.0 US gal (15.0 l)
Air conditioning systemAll modelsR-134a refrigerant and special PAG lubricant
oil (never R-12)
Windshield washer system and
headlamp cleaning system*All models8.1 US qt (7.7 l)MB Windshield Washer Concentrate1
1Use MB Windshield Washer Concentrate “MB SummerFit” and water for temperatures above freezing or MB Windshield Washer Concentrate “MB SummerFit” and
commercially available premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 530).
Page 539 of 561
538 Index
Fluids
Automatic transmission fluid 345
Brake fluid 340, 523, 525
Capacities 522
Engine coolant 340, 345, 528
Engine oil 343, 525
Power steering fluid 523
Windshield washer and headlamp
cleaning system* 340, 524, 530
Fog lamps 138, 139
Corner-illuminating front fog
lamps* 140
Messages in the multifunction
display 439
Rear fog lamp 139
Replacing bulbs 469
4-ETS 104
Off-road - 4-ETS 105
Front air bags 77
Front defroster 210, 225
Front lamps see HeadlampsFront passenger front air bag 72, 77
Messages in the multifunction
display 421, 422, 423, 424
Front passenger front air bag off indicator
lamp 31, 83
Front seat head restraints see
Head restraints
Front towing eye 501
Fuel 338
Additives 527
Capacities, Fuel tank 524
Consumption statistics 179
Diesel fuel 524
Filling the tank 337
Fuel filler flap and cap 337, 457
Fuel gauge 29
Fuel tank reserve warning lamp 29,
410
Premium unleaded gasoline 338,
526
Requirements, Octane rating 526Fuel cap
Messages in the multifunction
display 435
Fuel consumption statistics
Since last reset 179
Since start 179
Fuel filler flap 337
Locking/unlocking 337
Opening 337
Opening in an emergency 457
Fuel tank
Capacity 524
Filler flap 337
Fuel, Premium unleaded gasoline 524
Fuels, coolants, lubricants etc. 522
Fuses 504
Fuse box in cargo compartment 505
Fuse box in engine compartment 505
Fuse box in passenger
compartment 506
Fuse chart 448
Replacing 504