tailgate MERCEDES-BENZ ML320CDI 2007 W163 Comand Manual

491 Practical hints
Replacing bulbs
Opening the passenger side trim panel:
1Lock
2Cover in right side trim panel
Insert a suitable object such as a coin
into the slot of lock1.

Turn lock1 counterclockwise by 90°.

Remove cover2.Replacing bulbs
Example rear lamp passenger-side1Brake lamp
2Backup lamp
3Rear fog lamp (only driver’s side), tail
lamp, parking and standing lamp
4Side marker lamp
5Turn signal lamp
Depending on which bulb needs to be
replaced, turn the respective bulb
socket1-5 counterclockwise.

Press gently onto the respective bulb
and turn counterclockwise out of its
bulb socket.

Press the new bulb gently into its bulb
socket and turn clockwise until it en-
gages.

Align the respective bulb
socket1-5 and turn it clockwise.

Make sure bulb socket is attached
properly.

Close the respective cover in the cargo
compartment.

Close the tailgate (
page 121).

492 Practical hintsReplacing bulbsLicense plate lamp
1License plate lamp cover
2Screws
Loosen screws2.

Remove license plate lamp cover1.

Replace the tubular bulb.

Reinstall license plate lamp cover1.

Retighten screws2.
Adjusting headlamp aim
VVertical centerline
HHeadlamp mounting high, measured
from the centerCorrect headlamp adjustment is extremely
important. To check and readjust a head-
lamp, follow the steps described:

Park the vehicle on a level surface
25 feet (7.6 m) from a vertical test
screen or wall.

Switch the headlamps on
(page 136).
If the beam does not show a beam pattern
as indicated in the figure left, then follow
the steps below:

Open hood (
page 356).
i
High beam adjustments simultaneously aim
the low beam.
Vehicle should have a normal tailgate load.

497 Practical hints
Flat tire
Flat tire
Preparing the vehicle
Park the vehicle in a safe distance from
moving traffic on a hard, flat surface
when possible.

Turn on the hazard warning flasher
(page 142).

Turn the steering wheel so that the
front wheels are in a straight-ahead
position.

Set the parking brake (
page 57).

Set the automatic transmission to park
positionP (
page 187).

Turn off the engine (
page 39).

Remove the SmartKey from the starter
switch.
Vehicles with KEYLESS-GO*:
Turn off the engine by pressing the
KEYLESS-GO* button once
(page 67).

Open the driver’s door (this puts
the starter switch in position0,
same as with the SmartKey re-
moved from the starter switch). The
driver’s door then can be closed
again.

Have any passenger exit the vehicle at
a safe distance from the roadway.
Warning!
G
The dimensions of the spare wheel
(Minispare wheel or collapsible tire) are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a spare wheel
mounted. Adapt your driving style accord-
ingly.
The spare wheel is for temporary use only.
When driving with a spare wheel mounted,
ensure proper tire pressure and do not ex-
ceed a vehicle speed of 50 mph (80 km/h).
Drive to the nearest Mercedes-Benz Light
Truck Center as soon as possible to have the
spare wheel replaced with a regular road
wheel.
Never operate the vehicle with more than
one spare wheel mounted.
Do not switch off the ESP
® when a
Minispare wheel is mounted.
Warning!
G
Vehicles with air suspension package*:
Do not open or close any doors or the
tailgate while mounting a spare wheel. The
vehicle could rise or lower to a previously
selected level. You or others could be
injured as a result.
i
Open door only when conditions are safe to
do so.


524 Practical hintsFusesRemoving/installing cover
Open the tailgate (
page 119).

Insert a suitable object such as a coin
into the slot of lock1 (
page 523).

Turn lock1 counterclockwise by 90°
in direction of arrow.

Remove cover2.

Install cover2 in reverse order.
Fuse box in passenger compartment
The fuse box is located behind a cover in
the dashboard on the front passenger side.
1CoverOpening

Open the front passenger door.

Open the glove box (
page 294).

Insert flat, blunt object as a lever into
the edge of the cover1 at the position
indicated by the arrow.

Loosen cover1 from dashboard using
lever.

Using your hands, pull cover1 out
and remove.
Closing

Hook cover1 into the opening at the
front.

Press cover1 back on until it engag-
es.
!
Do not use sharp objects such as a screw-
driver to open the fuse box cover1 in the dash-
board, as this could damage the fuse box cover
or the dashboard.

559 Index
Emergency operations
Remote door unlock, Tele Aid* 315
Unlocking/opening the tailgate 476
Emergency Tensioning Device see ETD
Emergency, In case of
Battery, Jump starting 515
Engine shut-down 525
First aid kit 469
Flat tire 497
Fuses 522
Hazard warning flasher 142
Instrument cluster, Indicator
lamps 414, 415, 416, 417, 418,
419, 420, 421, 422, 423, 424
Roadside Assistance 12, 312
Towing the vehicle 518
Emission control 350
Information label 531
System warranties 10
Vacuum line routing diagram
label 531Engine
Belt layout (ML 320 CDI) 532
Belt layout (ML 350) 532
Belt layout (ML 500) 532
Belt layout (ML 63 AMG) 533
Block heater (Canada only) 400
Break-in recommendations 358
Cleaning 406
Compartment 356
Emergency engine shut-down 525
Malfunction indicator lamp 29, 449
Maximum engine speed 146, 534,
535
Messages in the
multifunction display 449
Number 531
Starting 54
Starting with KEYLESS-GO* 55
Starting with the SmartKey 55
Tachometer 29, 146
Technical data 534
Turning off with KEYLESS-GO* 67
Turning off with the SmartKey 67Engine coolant see Coolant
Engine oil 358, 546
Adding 361, 546
Additives 546
Changing 361, 546
Checking level 358
Checking level with the
control system (ML 500 only) 358
Checking with the oil dipstick
(except ML 500) 360
Consumption 358
Filler neck (ML 350, ML 320 CDI) 361
Filler neck (ML 500, ML 63 AMG) 361
Messages in display 359, 453
Messages in the
multifunction display 453
Recommended engine oils
and oil filters 546
Engine oil level 358
ESP
®
27, 98
Four wheel electronic traction system
with ESP
®
98
Messages in the
multifunction display 436, 437
Off-road-ESP®
101
Warning lamp 27, 419, 420

563 Index
Interior lighting 142
Delayed shut-off 173
Interior rear view mirror 49
Antiglare positions 200
Auto-dimming mirrors* 201
Interior storage spaces see
Storage compartments
Intermittent wiping
Windshield wipers 61
J
Jack 471
Lifting the vehicle 498
Jump starting 515
K
Key, Mechanical 475
Key, SmartKey 108
Batteries 111, 480
Battery check lamp 108
Checking battery condition 111
Closing the power windows
(Convenience closing feature) 239
Closing the tilt/sliding sunroof*
(Convenience closing feature) 239
Closing, Power tailgate* 123
Factory setting 109Locking/unlocking 38, 68, 108
Locking/unlocking, Global
setting 109
Loss of 111
Messages in the
multifunction display 457
Opening the power windows
(Summer opening feature) 239
Opening the tilt/sliding sunroof*
(Summer opening feature) 239
Remote control 108
Replacing batteries 480
Selective setting 110
Starter switch positions 40
Starting the engine 54
Turning off the engine 67
Unlocking and opening,
Power tailgate* 111
Key, SmartKey with KEYLESS-GO*
Batteries 116, 480
Battery check lamp 112
Checking battery condition 116
Closing the power windows
(Convenience closing feature) 239
Closing the tilt/sliding sunroof*
(Convenience closing feature) 239Closing, Power tailgate* 124
Closing/locking, Power
tailgate* 125
Factory setting 115
Important notes 113
Locking/unlocking 39, 68, 112
Locking/unlocking, Global
setting 115
Loss of 117
Messages in the
multifunction display 456, 457
Opening the power windows
(Summer opening feature) 239
Opening the tilt/sliding sunroof*
(Summer opening feature) 239
Remote control 112
Replacing batteries 480
Selective setting 115
Start/stop button 41
Starter switch positions 40, 41
Starting the engine 55
Turning off the engine 67
Unlocking and opening,
Power tailgate* 117

572 IndexT
Tachometer 29, 146
Overspeed range 146
Tail lamps 490
Cleaning lenses 408
Messages in the
multifunction display 462
Replacing bulbs 483, 491
Tailgate
Closing 121
Closing from the inside,
Electrically* 121
Closing from the outside
(vehicles without
KEYLESS-GO*) 123
Opening 119
Opening from the inside,
Electrically* 119
Opening from the outside 119
Unlocking and opening the tailgate in
an emergency 476
Unlocking and opening with
KEYLESS-GO*, Power
tailgate* 117
Unlocking and opening with SmartKey,
Power tailgate* 111Tar stains 405
Technical data 527
Air conditioning refrigerant 546
Brake fluid 544, 546
Capacities fuels, coolants, lubricants
etc. 543, 544
Coolant 549
Dimensions, Vehicle 541
Electrical system 540
Engine 534
Engine oil 546
Engine oil additives 546
Fuel requirements 548
Fuels, coolants, lubricants, etc. 543
Gasoline additives 547
Main dimensions 541
Premium unleaded gasoline 547
Rims 536
Tires 536
Weights 542
Windshield washer and headlamp
cleaning system* 545
Windshield washer and headlamp
cleaning* system 551Tele Aid* 308
Call priority 314
Emergency calls 310
Hands-free microphone 33
Information 313
Initiating an emergency call
manually 311
Messages in the
multifunction display 464
Remote door unlock 315
Roadside Assistance 312
SOS button 311
Stolen Vehicle Recovery
services 315
System self-check 309
Telephone cradle*
Changing 307