jack MERCEDES-BENZ ML350 2003 W163 Owner's Manual

149 Controls in detail
Driving systems
Parktronic system* (Parking assist)
The Parktronic system assists the driver
during parking maneuvers. It visually and
audibly indicates the distance between the
vehicle and an obstacle.
With the ignition on, Parktronic engages
automatically at speeds up to approxi-
mately 10 mph (15 km / h) and deactivates
during higher speeds.Parktronic monitors your vehicle’s environ-
ment by means of six sensors in the front
bumper and four sensors in the rear
bumper.
1Sensors located in front bumperWarning!
G
Parktronic is a supplemental system. It is
not intended to nor does it replace the need
for extreme care. The responsibility during
parking and other critical maneuvers rests
always with the driver.
Make sure that no persons or animals are lo-
cated in the area in which your are maneu-
vering. They could otherwise be injured.
Special attention must be paid to objects
with smooth surfaces or low silhouettes
(e.g. trailer couplings, painted posts, or
street curbs). Such objects may not be de-
tected by the system and can damage the
vehicle.
The operational function of the Parktronic
can be affected by dirty sensors, especially
at times of snow and ice. For notes on clean-
ing the Parktronic system sensors
(page 220).
Interference caused by other ultrasonic sig-
nals (e.g. working jackhammers or the air
brakes of trucks) can cause the system to
send erratic indications, and should be tak-
en into consideration.

187 Operation
Driving instructions
Checklist before off-road driving
Tires

Check the tread depth and maintain
specified tire pressure (see tire pres-
sure label inside the fuel filler flap).


Check tires for possible damage and
remove foreign objects.


Replace missing valve caps.
Rims


Dented or bent rims can cause tire
pressure loss and damage the tire
beads. For this reason, check and, if
necessary, change rims before driving
off-road.Vehicle tool kit


Check if the vehicle jack is functional.


In all cases take the vehicle tool kit, a
strong tow rope, a shovel and a small
plank (to put under the vehicle jack on
sandy soil) with you.
Driving in steep terrain
Slope angle125° (ML 320, ML 350, ML 500)
21° (ML 55 AMG)
226°(ML 320, ML 350, ML 500)
23° (ML 55 AMG)
!Observe the following during off-road
driving:

Adjust vehicle speed to condition of
terrain. The more uneven, rutty and
steeper the terrain, the lower the
speed should be


Watch out for obstacles, such as
rocks, holes, tree stumps and ruts.


Be especially careful when driving
in unknown territory. It may be nec-
essary to get out of the vehicle and
scout the path you intend to take.


Continuous and speedy driving in
sandy soil overcomes the vehicle
rolling resistance, and helps to pre-
vent the vehicle from sinking into
the ground.


Do not initiate jumps with the vehi-
cle. It interrupts the forward mo-
mentum of the vehicle.


Always drive onto slopes with the
the engine running and the vehicle
in gear.

237 Practical hints
Where will I find ...?
Vehicle tool kit
The vehicle tool kit is stored in the cargo
area behind the right trim panel.
Turn handles1 90° in direction of ar-
rows.

Fold down the panel2.3Screw
4Vehicle jack with tool kit

Turn screw3 counterclockwise.

Remove vehicle jack.
Vehicles with CD-changer*
(page 238).
The jack is exclusively designed for lifting
the vehicle during a wheel change. Always
lower the vehicle on sufficient capacity
jackstands before working under the vehi-
cle.1Vehicle jack
2Wheel bolt wrench
3Screwdriver
4Interchangeable slot
Screwdriver3 is placed inside the wheel-
bolt wrench handle.

238 Practical hintsWhere will I find ...?Vehicle jack
Please also observe the safety guidelines
in the “Flat tire” section (
page 255)
when using the jack.
Vehicle with CD-changer*
To access the vehicle tool kit, swing the
CD-changer out of the panel.
1Screw
2CD-changer

Turn screw1 counterclockwise.

Swing the CD-changer2 out of the pan-
el.
Electric air pump (ML 55 AMG)
The electric air pump is located behind the
spare wheel.
Remove the spare wheel (
page 240).
1Electric air pump

Open the strap and remove the electric
air pump.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface.
Make sure that the jack arm is fully seated
in the jack take-up bracket. Always lower
the vehicle onto sufficient capacity jack-
stands before working under the vehicle.

255 Practical hints
Flat tire
Flat tire
Mounting the spare wheel Preparing the vehicle

Park the vehicle as far as possible from
moving traffic on a hard surface.

Turn on the hazard warning flashers.

Engage the steering wheel lock in the
straight ahead position and set the
parking brake.

Move the selector lever toP.

Have any passenger exit the vehicle at
a safe distance from the roadway.

Take the spare wheel out of its carrier
(page 239).
ML 55 AMG: (
page 240).Lifting the vehicle

Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
(not included) or other sizable objects.
When changing wheel on a level surface:

Place one chock in front of and one be-
hind the wheel that is diagonally oppo-
site to the wheel being changed.
When changing wheel on a hill:

Place chocks on the downhill side
blocking both wheels of the other axle.

Take the two-piece wheel wrench and
the jack out of the rear compartment
area (
page 237). Assemble wheel
wrench.
Warning!
G
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire pressure and do not exceed
vehicle speed of 50 mph (80 km/h).
Drive to the nearest Mercedes-Benz Light
Truck Center as soon as possible to have the
spare wheel replaced with a regular road
wheel.
Never operate the vehicle with more than
one spare wheel mounted.

256 Practical hintsFlat tire

On wheel to be changed, loosen but do
not yet remove the wheel bolts (ap-
proximately one full turn with wrench).
The jack take-up brackets are located di-
rectly behind the front wheel housings and
in front of the rear wheel housings.1Take-up bracket
2Jack

Place jack on firm ground.

Position jack2 under the take-up
bracket1 so that it is always vertical
(plumb-line) as seen from the side,
even if the vehicle is parked on an in-
cline.

Jack up the vehicle until the wheel is a
maximum of 1.2 in (3 cm) from the
ground. Never start engine while vehi-
cle is raised.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure that the jack
arm is fully seated in the jack take-up brack-
et. Always lower the vehicle onto sufficient
capacity jackstands before working under
the vehicle.
!Do not position the jack on the body of
the vehicle, as this may cause damage
to the vehicle.

258 Practical hintsFlat tireLowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.1-5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of
110 ft lb (150 Nm).

Store jack and tool kit.
Warning!
G
Use only genuine equipment
Mercedes-Benz wheel bolts. They are identi-
fied by the Mercedes star. Other wheel bolts
may come loose.
Do not tighten the wheel bolts when the ve-
hicle is raised. Otherwise the vehicle could
tip over.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
110 ft lb (150 Nm).iThe removed road wheel cannot be
stored in the spare wheel carrier or in-
side the storage compartment in the
rear cargo area (ML 55 AMG), but
should be transported in the rear cargo
compartment wrapped in a protective
cover supplied with the vehicle.
The protective cover is located in the
rear cargo compartment behind the
cover in the right side trim panel.

308 IndexInterior lighting 107
Activating automatic control 107
Deactivating automatic control 107
Manual operation 108
Reading lamps 108
Interior storage spaces 152
Armrest 153
Cup holder 155
Glove box 152
Storage compartment in front of
armrest 153
Storage compartment under front
passenger seat* 152
Intermittent wiping 122
J
Jack 237, 238
Jump starting 264
K
Key
Global locking 85
Global unlocking 85
Loss of 86
Positions in steering lock 33
Remote control with folding key 84
Unlocking liftgate 85Unlocking the driver’s door, fuel filler
flap 85
Key positions in steering lock 33
Key, Mechanical 242
Key, Remote control
Unlocking with 32
Kickdown 117, 294
L
Labels, identification 276
Lamp bulbs, exterior 247
Lamps, exterior
Front 247
Rear 248
Lamps, indicator and warning
4-ETS 224, 226
ABS 225
Adjustable steering column 229
AIRBAG OFF 59, 232
BAS 73, 225, 226
Battery indicator lamp 233
Brake pad wear 234
Brakes 228
CHECK ENGINE 232
Coolant 230
EBP 229Engine diagnostics 232
ESP 224, 225, 226
Front fog lamps 229
Fuel reserve 233
Instrument cluster ??–233
Low engine oil level 229
LOW RANGE 226
Low washer system fluid level 234
Seat belts 234
Service indicator 215
SRS 54, 227
Turn signals 25
LATCH child seat anchors 68
LATCH child seat mounts 68
Layout of poly-V-belt drive 277
Leather upholstery
Cleaning 222
Lever
For cruise control 146
License plate lamps
Replacing bulbs 248, 252
Liftgate
Closing 88
Opening 85, 87
Opening from inside 87
Opening from outside 87

312 IndexPower windows
Blocking of rear door window
operation 69
Side windows 134
Synchronizing 136
Practical hints
First aid kit 236
Fuses 271
Lamps in instrument cluster 224
Spare wheel 239
Towing the vehicle 267
Vehicle jack 238
Vehicle tool kit 237
Premium unleaded gasoline 286
Problems
While driving 49
With vehicle 18
Product information 9
R
Radio transmitters, control and
operation 197
Rain sensor 122, 123
Rapid seat heating
Switching off 91
Switching on 91
Reading lamp 29Reading lamps 108
Rear automatic climate control 131
Adjusting air volume and air distribu-
tion manually 132
Automatic mode 132
Rear bench seat
Foldable 93
Rear door window
Blocking operation 69
Rear fog lamp 248
Bulb 248
Switching off 106
Switching on 105
Rear lamp bulbs
Replacing 251
Rear parking lamp
Replacing bulbs 251
Rear passenger compartment ventilation
and climate control
Activating 131
Deactivating 131
Rear passenger compartment ventilation
and rear automatic climate control 131
Rear quarter windows 136
Opening 136Rear quarter windows*
Closing 136
Rear seats 93
Easy entry/exit feature* 95
Enlarging cargo area 93
Folding down backrest 93
Folding up 94
Folding up backrest 94
Fore and aft 93
Lowering 94
Third row* 96
Rear standing lamp
Replacing bulbs 251
Rear towing eyes 269
Rear view mirror automatic antiglare 119
Rear view mirrors see Mirrors
Rear window defroster 131
Activating 131
Deactivating 131
Rear window wiper 123
Rain sensor* 123
Rear window wiper/washer 48
Reconnecting
Vehicle battery 262
Refrigerant
Air conditioning 286

317 Index
Tilt
Head restraint 36
Time
Setting hours 112
Setting minutes 112
Tire inflation pressure
Checking 201, 211
Tire speed rating 184, 296
Tire traction 183
Tires 209, 279, 291
Direction of rotation 210
Driving instructions 182
Retreads 209
Rims and tires 279
Rotating 212
Service life 210
Temperature 211
Temperature grades 292
Tread depth 213
Wear pattern 212
Winter 213
Tools 237
Vehicle jack 237
Vehicles with CD-changer* 238
Wheel bolt wrench 237Tow-away alarm 29, 79
Arming 79
Disarming 79
Disarming for transport 79
Towing
Trailer 192
Towing a trailer 194
Automatic transmission 117
Towing eyes
Front 269
Rear 269
Towing the vehicle 267
Stranded vehicle 270
Tracking services
For stolen vehicle 168
Traction 291, 296
Trailer
Attaching 194
Loading 193
Towing 194
Trailer hitches 192
Trailer towing 192
Attaching a trailer 194
Checking weights 193
Electrical connections 192
Hitches 192Loading 193
Parking 196
Weights and ratings 193
Trailer weights and ratings 193
Transfer case 296
Transmission control – LOW RANGE
mode 118
Switching off 118
Switching on 118
Transmission selector lever 245
Unlocking manually 245
Tread depth (tires) 213
Treadwear 291
Trip computer
Average fuel consumption 175
Compass 173
Distance remaining 175
Selecting functions 172
Setting date 172
Stop watch 175
Switching on 172
Trip computer* 29, 172
Country 176
Language 176
Trip odometer
Resetting 112