oil level MERCEDES-BENZ ML500 2003 W163 Owner's Manual

Contents
Loading.............................................. 139
Loading instructions..................... 139
Partition net* ............................... 141
Cargo area cover blind* ............... 143
Cargo floor plates ........................ 144
Roof rack*.................................... 145
Driving systems ................................. 146
Cruise control .............................. 146
Parktronic system*
(Parking assist) ............................ 149
Useful features .................................. 152
Interior storage spaces ................ 152
Cup holders.................................. 154
Armrest in rear seat bench .......... 155
Ashtrays and cigarette lighter ...... 156
Electrical outlet ............................ 158
Telephone* .................................. 158
Tele Aid* ...................................... 159
Garage door opener ..................... 168
Trip computer*............................. 172Operation......................................... 177
The first 1000 miles (1500 km) ......... 178
Driving instructions............................ 179
Drive sensibly – save fuel............. 179Drinking and driving ...................... 179
Pedals ........................................... 179
Power assistance .......................... 179
Brakes........................................... 180
Driving off ..................................... 181
Parking.......................................... 182
Tires .............................................. 182
Hydroplaning................................. 183
Tire traction .................................. 183
Tire speed rating ........................... 184
Winter driving instructions ............ 184
Standing water.............................. 185
Off-road driving ............................. 186
Trailer towing ................................ 192
Passenger compartment ............... 196
Driving abroad .............................. 197
Control and operation of radio
transmitters .................................. 197
Catalytic converter........................ 198
Emission control ........................... 198
Coolant temperature..................... 199
At the gas station ............................... 200
Check regularly and
before a long trip .......................... 201Engine compartment .......................... 202
Hood ............................................. 202
Engine oil ...................................... 203
Transmission fluid level ................ 206
Coolant ......................................... 206
Battery .......................................... 207
Windshield washer system and
headlamp cleaning system ........... 208
Tires and wheels ................................ 209
Important guidelines ..................... 209
Life of tire ..................................... 210
Direction of rotation ..................... 210
Checking tire inflation pressure .... 211
Rotating wheels ............................ 212
Winter driving ..................................... 213
Winter tires ................................... 213
Block heater (Canada only) ........... 214
Snow chains ................................. 214
Maintenance ...................................... 215
Clearing the service indicator ....... 215
Service term exceeded ................. 215
Calling up the service indicator .... 216
Resetting the service indicator ..... 216
Vehicle care ....................................... 217
Cleaning and care
of the vehicle ................................ 217

25 At a glance
Instrument cluster
Item
Page
1
Gauge for
Coolant tempera-
ture
111
Outside tempera-
ture
112
Fuel with fuel re-
serve warning lamp
233
2
Knob for
Activating instru-
ment cluster
110
Adjusting intensity
of instrument lamps
110
Main odometer
111
Trip odometer read-
out/reset
112
Flexible Service
System (FSS)
215
Item
Page
3
Left indicator lamps
with:¿
Brake Assist Sys-
tem (BAS)/Elec-
tronic Stability
Program (ESP) mal-
function warning
lamp
225
{
Electronic Traction
System (4-ETS) mal-
function indicator
lamp
226
-
Antilock Brake Sys-
tem (ABS) malfunc-
tion indicator lamp
225
2
Brake pad wear in-
dicator lamp
234
:
Low engine oil level
warning lamp
229
Item
Page
/
Low engine coolant
level warning lamp
230
ê
Low range indicator
lamp
226
?
Engine malfunction
indicator lamp
232
4
Speedometer with:v
4-ETS (Electronic
Traction Sys-
tem)/Electronic
Stability Program
(ESP) warning lamp
224
Trip/main odome-
ter
111
Flexible Service
System (FSS)
215
Engine oil level indi-
cator
204

201 Operation
At the gas station
Check regularly and before a long trip
Open the hood (
page 202)
1Engine oil level
More information on engine oil can be
found in the “Operation” section
(
page 203).
2Coolant level
For normal replenishing, use water (po-
table water quality). More information
on the coolant level can be found in the
“Operation” section (
page 206).
3Brake fluid
More information on brake fluid can be
found in the “Technical data” section
(
page 284).4Windshield washer and headlamp
cleaning system
More information on filling the reser-
voir can be found in the “Operation”
section (
page 208).
Vehicle lighting
Check function and cleanliness. More in-
formation on replacing light bulbs can be
found in the “Practical hints” section
(
page 247).
Combination switch (
page 102).
Tire inflation pressure
More information on tire inflation pressure
can be found in the “Operation” section
(
page 211).
iLeaving the engine running and the fuel
cap open can cause the
?
lamp to
illuminate.
See also “Practical hints” section
(
page 232).

203 Operation
Engine compartment
Closing
Let the hood drop from a height of ap-
proximately 1ft (30cm).
The hood will lock audibly.

Check to make sure that the hood is
fully closed.
If you can raise the hood at a point
above the headlamps, then it is not
properly closed. Open it again and let it
drop with somewhat greater force.
Engine oil
The amount of oil your engine needs will
depend on a number of factors, including
driving style. Higher oil consumption can
occur when

the vehicle is new


the vehicle is driven frequently at high-
er engine speeds.
Engine oil consumption checks should only
be made after the vehicle break-in period.
Checking engine oil level
When checking the oil level the vehicle
must


be parked on level ground


be at normal operating temperature


have been stationary for at least five
minutes with the engine turned off
Warning!
G
If you see flames or smoke coming from the
engine compartment, or if the coolant tem-
perature gauge indicates that the engine is
overheated, do not open the hood. Move
away from vehicle and do not open the hood
until the engine has cooled. If necessary,
call the fire department.Warning!
G
The engine is equipped with a transistorized
ignition system. Because of the high voltage
it is dangerous to touch any components (ig-
nition coils, spark plug sockets, diagnostic
socket) of the ignition system

with the engine running


while starting the engine


if ignition is “on” and the engine is
turned manually
Warning!
G
Be careful that you do not close the hood on
anyone.!Do not push the hood closed manually,
as this could damage it.

204 OperationEngine compartmentEngine oil level display
1Knob
2Display in speedometer
Switch on the ignition and wait until the
display
- - - - - -
appears in the
speedometer display2.

Within one second press knob1 twice.
One of the following messages will subse-
quently appear in the display:


OIL i.OThe oil level is correct. Engine oil does
not to be added.


– 1.0 L
Add 1 liter of engine oil.


– 1.5 L
Add 1.5 liters of engine oil.


– 2.0 L
Add 2 liters of engine oil.


OIL HIThe oil level is too high.
Have excess oil siphoned.The display
- - - - - -
flashes in the
speedometer display if a proper oil level
check cannot be performed.

Repeat the engine oil level check after
a few minutes.
!Excessive oil must be siphoned or
drained off. It could cause damage to
the engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.
iIf the engine oil level check cannot be
performed again via the display field,
use the dipstick to perform the engine
oil level check (
page 205).
In this case we recommend that you
have the system checked at a
Mercedes-Benz Light Truck Center.

205 Operation
Engine compartment
Oil dipstick
1Oil dipstick
2Oil filler cap
Remove the oil dipstick1.

Wipe the oil dipstick clean.

Fully insert dipstick in tube, and re-
move after three seconds.The engine oil level must be between the
lower (min) and upper (max) mark of the
dipstick.

Add engine oil if necessary.Adding engine oil

Unscrew the oil filler cap2 from the fill-
er neck. Be careful not to overfill with
oil.
Be careful not to spill any oil when adding.
Avoid environmental damage caused by oil
entering the ground or water.

Screw the oil filler cap back on the filler
neck.
More information on engine oil can be
found in the “Technical data” section
(
page 286).
iFill quantity between upper and lower
dipstick marking, the level is approxi-
mately 2.1 US qt (2.0 l).
!Excessive oil must be siphoned or
drained off. It could cause damage to
the engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.

216 OperationMaintenanceThe Mercedes-Benz Light Truck Center will
reset the service indicator following a com-
pleted service.Calling up the service indicator
Within 1 second press knob1 twice.
The FSS display will appear for ten sec-
onds.
Resetting the service indicator
In the event that the service on your vehi-
cle is not carried out by an authorized Mer-
cedes-Benz Light Truck Center, you can
reset the service indicator yourself.
Switch ignition on and immediately
press knob1 twice within one second.
The present status for days or distance
is displayed.

Within ten seconds turn the key in
steering lock to position0 (
page 33).

Press and hold knob1 while switching
the ignition on.
The present status for days or distance
is displayed once more.

Continue to hold knob1.
After approximately 10 seconds a sig-
nal sounds, and the display shows
10 000 miles (Canada: 15 000 km) for
approximately 10 seconds.

Release knob1.
iIf the service indicator was inadvertent-
ly reset, have a Mercedes-Benz Light
Truck Center correct it.
Only reset if the proper service has
been performed. Resetting the system
without performing the proper service
as called for by the FSS will cause the
FSS to incorrectly determine the next
service interval which will result in en-
gine damage not covered by the Mer-
cedes-Benz Limited Warranty.
If the battery is disconnected, the days
of disconnection will not be included in
the count shown by the service indica-
tor. To arrive at the true service dead-
line, you will need to subtract these
days from the days shown in the ser-
vice indicator.
Do not confuse the service indicator
with the engine oil level indicator
:
.

229 Practical hints
What to do if …
Problem
Possible cause
Suggested solution
É
-
The red brake warning lamp
lights up in addition to the yellow
ABS malfunction lamp and you
hear a warning sound.
There is a malfunction in the Electronic Brake
Proportioning (EBP) system.
The enhanced braking effect is not available.

Have the system checked immediate-
ly at an authorized Mercedes-Benz
Light Truck Center.
Failure to follow these instructions in-
creases the risk of accidents.
:
The yellow warning lamp blinks
after starting the engine or while
driving.
The engine oil level has sunk to the minimum
level. If the engine oil level continues to sink,
the warning lamp will light up.

Add approved oil at the next gas sta-
tion (
page 286).

If oil loss is visible on the engine, have
the malfunction corrected as soon as
possible at a Mercedes-Benz Light
Truck Center.
_
The red indicator lamp does not
go out after starting the engine.
The adjustable telescoping steering column
is not properly locked.

Lock the adjustable steering column
(page 37).
‡
The green front fog lamp indica-
tor lamp lights up when ignition
is turned on.
The front fog lamps are switched on.

Fog lamps (
page 105).

288 Technical dataFuels, coolants, lubricants etc.The coolant solution must be used year
round to provide the necessary corrosion
protection and increase in boil-over pro-
tection. You should have it replaced every
3years.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]). If
you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.If the coolant level is low, water and MB
anticorrosion /antifreeze should be used
to bring it up to the proper level (have cool-
ing system checked for signs of leakage).
Please make sure that the mixture is in ac-
cordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz Light
Truck Center.
Anticorrosion/antifreeze
Your vehicle contains a number of alumi-
num parts. The use of aluminum compo-
nents in motor vehicle engines
necessitates that anticorrosion/antifreeze
coolant used in such engines be specifical-
ly formulated to protect the aluminum
parts. (Failure to use such anticorro-
sion/antifreeze coolant will result in a sig-
nificantly shortened service life.)
Therefore, the following product is strongly
recommended for use in your vehicle:
Mercedes-Benz Anticorrosion/Antifreeze
agent.
Before the start of the winter season (or
once a year in hot southern regions), you
should have the anticorrosion/antifreeze
concentration checked. The coolant is also
regularly checked each time you bring your
vehicle to your authorized Mercedes-Benz
Light Truck Center for service.

302 IndexCargo floor plates 144
Installing 144
Removing 144
Storing 144
Cargo tie-down rings 140
Catalytic converter 198
CD-changer* 238
Center console 27
Lower part 28
Upper part 27
Central locking
Automatic 89
From inside 89
Switch 90
Unlocking from inside 89, 90
Central locking switch 90
Certification label 276
Charge indicator lamp 233
Charging
Vehicle battery 262
Chart
Fuses 271
CHECK ENGINE malfunction indicator
lamp 232
Checking
Coolant level 201, 206Oil level 201, 203
Tire inflate pressure 201
Vehicle lighting 201
Checking weights
Trailer and vehicle 193
Checklist
Off-road driving 187
Returning from off-road driving 191
Child safety 63
Airbags 56
Infant and child restraint systems 54,
60, 63
LATCH child seat mounts 68
Child safety switch see Blocking of rear
door window operation 69
Cigarette lighter
Front center console 156
Cleaning
Cup holder 221
Gear selector lever 221
Hard plastic trim items 221
Headlamps 121
Headliner 221
Instrument cluster 221
Leather upholstery 222
Light alloy wheels 221MB Tex upholstery 222
Plastic and rubber parts 222
Seat belts 221
Steering wheel 221
Windows 220
Windshield 48
Wiper blades 220
Cleaning and care of the vehicle see
Vehicle care 217
Clock 26, 112
Closing
Glove box 152
Hood 203
Liftgate 88
Rear quarter windows* 136
Side windows 135
Sliding/pop-up roof 246
Sliding/pop-up roof* 137
Closing sliding/pop-up roof
In an emergency 246
Cockpit 22, 293
Combination switch 102
High beam flasher 47, 102
Turn signals 47
Windshield wipers 47