technical data MERCEDES-BENZ R320 2008 W251 User Guide

523 Technical data
Warranty coverage
Warranty coverage
Your vehicle is covered under the terms of
the warranties printed in the Service and
Warranty Information booklet. Your
authorized Mercedes-Benz Light Truck
Center will exchange or repair any defec-
tive parts originally installed on the vehicle
in accordance with the terms of the follow-
ing warranties:

New Vehicle Limited Warranty

Emission System Warranty

Emission Performance Warranty

California, Maine, Massachusetts, and
Vermont Emission Control Systems
WarrantyReplacement parts and accessories are
covered by the Mercedes-Benz Parts and
Accessories warranties, copies of which
are available at any Mercedes-Benz Light
Truck Center.Loss of Service and Warranty
Information Booklet
Should you lose your Service and Warranty
Information booklet, have an authorized
Mercedes-Benz Light Truck Center arrange
for a replacement. It will be mailed to you.

524 Technical data
Identification labels
1Certification label (on driver’s B-pillar)
The V
ehicle Identification Number (VIN)
can be found in the following locations:

on the certification label

embossed underneath the
passenger-side seat in the second
seat row (
page 525)

on the lower edge of the windshield
(
page 525)
Example certification label (U.S. vehicles)
2Paintwork code
3VIN
Example certification label
(Canada vehicles)
2Paintwork code
3VIN
iData shown on certification label are for
illustration purposes only. These data are
specific to each vehicle and may vary from data
shown in the illustration. Refer to certification
label on vehicle for actual data specific to your
vehicle.

525 Technical data
Identification labels
4Second-row seat
5VIN
6Carpet
Move second-row seat 4 on pas-
senger side to the rear as far as possi-
ble (
page 134).
Fold carpet 6 in direction of arrow.
You may have to cut the perforated
carpet using a sharp object, e.g. a
knife.7Emission control information label,
includes both federal and California
certification exhaust emission stan-
dards
8VIN (lower edge of windshield)
9Engine number (engraved on engine)
iWhen ordering parts, please specify vehicle
identification and engine number.

526 Technical data
Layout of poly-V-belt drive
R 320 CDI 4MATIC
1Coolant pump
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Idler pulley
8Generator (alternator)R 350, R 350 4MATIC, R 550 4MATIC
1Idler pulley
2Idler pulley
3Automatic belt tensioner
4Power steering pump
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)

527 Technical data
Engine
Engine
ModelR 320 CDI 4MATIC (251.122)1R 350 (251.156)1,2
R 350 4MATIC (251.165)1
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for the corresponding data of all special bodies and special
equipment.
2USA only.
Engine642272
Mode of operationDiesel 4-stroke engine4-stroke engine, gasoline injection
No. of cylinders66
Bore3.27 in (83.00 mm)3.66 in (92.90 mm)
Stroke3.62 in (92.00 mm)3.39 in (86.00 mm)
Total piston displacement182 cu in (2 987 cm3)213 cu in (3 498 cm3)
Compression ratio17.7:110.7:1
Output acc. to SAE J 1349215 hp/4 000 rpm
(160 kW/4 000 rpm)268 hp/6 000 rpm3
(200 kW/6 000 rpm)
3Premium fuel required. Performance may vary with fuel octane rating.
Maximum torque acc. to SAE J 1349400 lb-ft/1 600 - 2 400 rpm
(543 Nm/1 600 - 2 400 rpm)258 lb-ft/2 400 - 5 000 rpm
(350 Nm/2 400 - 5 000 rpm)
Maximum engine speed4 500 rpm6500 rpm
Firing order1-4-2-5-3-61-4-3-6-2-5
Poly-V-belt2 035 mm2404 mm

528 Technical data
Engine
ModelR 550 4MATIC (251.172)1,2
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Light Truck Center for
the corresponding data of all special bodies and special equipment.
2Canada only.
Engine273
Mode of operation4-stroke engine, gasoline injection
No. of cylinders8
Bore3.86 in (98.00 mm)
Stroke3.56 in (90.50 mm)
Total piston displacement333cuin (5461cm3)
Compression ratio10.7:1
Output acc. to SAE J 1349382 hp/6 000 rpm3
(285 kW/6 000 rpm)
3Premium fuel required. Performance may vary with fuel octane rating.
Maximum torque acc. to SAE J 1349391 lb-ft/2 800 - 4 800 rpm
(530 Nm/2 800 - 4 800 rpm)
Maximum engine speed6 500 rpm
Firing order1-5-4-2-6-3-7-8
Poly-V-belt2 404 mm

529 Technical data
Rims and tires
Rims and tires
!Only use tires which have been tested and
approved by Mercedes-Benz. Tires approved by
Mercedes-Benz are developed to provide best
possible performance in conjunction with the
driving safety systems on your vehicle such as
ABS or ESP
®. Tires specially developed for your
vehicle and tested and approved by
Mercedes-Benz can be identified by finding the
following on the tire’s sidewall:

MO = Mercedes-Benz Original equipment
tires
Using tires other than those approved by
Mercedes-Benz may result in damage that is
not covered by the Mercedes-Benz Limited
Warranty.
!Using tires other than those approved by
Mercedes-Benz can have detrimental effects,
such as

poor handling characteristics

increased noise

increased fuel consumption
Moreover, tires and rims not approved by
Mercedes-Benz may, under load, exhibit dimen-
sional variations and different tire deformation
characteristics that could cause them to come
into contact with the vehicle body or axle parts.
Damage to the tires or the vehicle may be the
result.
iFurther information on tires and rims is
available at any authorized Mercedes-Benz Light
Truck Center. A placard with the recommended
tire inflation pressures is located on the driver’s
door B-pillar (
page 366). Some vehicles may
have supplemental tire inflation pressure infor-
mation for driving at high speeds (
page 372)
or for vehicle loads less than the maximum
loaded vehicle condition (
page 372). If such
information is provided, it can be found on the
placard located on the inside of the fuel filler
flap.The tire inflation pressure should be checked
regularly and should only be adjusted on cold
tires. Follow tire manufacturer’s maintenance
recommendation included with vehicle.
iThe following pages also list the approved
wheel rim and tire sizes for equipping your vehi-
cles with winter tires. Winter tires are not avail-
able as standard or optional factory equipment,
but can be purchased from an authorized
Mercedes-Benz Light Truck Center.
Depending on vehicle model and the standard or
optional factory-equipped wheel rim/tire
configuration on your vehicle (Appearance
Package, Sport Package etc.), equipping your
vehicle with winter tires approved for your
vehicle model may also require the purchase of
two or four wheel rims of the recommended size
for use with these winter tires. Contact an
authorized Mercedes-Benz Light Truck Center
for more information.

530 Technical data
Rims and tires
Same size tires
ModelR 320 CDI 4MATIC
R 3501
R 350 4MATIC
R 320 CDI 4MATIC (Sport Package*)
R 350 (Sport Package*)1
R 350 4MATIC (Sport Package*)
R 550 4MATIC2
R 550 4MATIC (Sport Package*)2
Rims (light alloy)8 J x 18 H28Jx19H2
Wheel offset2.64 in (67 mm)2.64 in (67 mm)
All-season tires3255/55 R18 105H M+S255/50 R19 107H XL (Extra Load) M+S
Winter tires3,4255/55 R18 105H M+S.255/50 R19 107H XL (Extra Load) M+S.
1USA only.2Canada only.3Radial-ply tires4Not available as factory equipment.

531 Technical data
Rims and tires
ModelR 320 CDI 4MATIC (Sport Package*)
R 350 (Sport Package*)1
R 350 4MATIC (Sport Package*)
R 550 4MATIC (Sport Package*)2
R 320 CDI 4MATIC*
R350*1
R350 4MATIC*
R550 4MATIC*2
AMG rims (light alloy)8.5Jx19H28.5Jx20H2
Wheel offset2.52 in (64 mm)2.36 in (60 mm)
All-season tires1255/50 R19 107H XL (Extra Load) M+S –
Summer tires3 –265/45 ZR20 104Y
Winter tires3,4255/50 R19 107H XL (Extra Load) M+S. –
1USA only.2Canada only.3Radial-ply tires4Not available as factory equipment.

532 Technical data
Rims and tires
Spare wheel
ModelR 320 CDI 4MATIC
R 3501
R 350 4MATIC
R 550 4MATIC2
1USA only.2Canada only.
Rim (steel)6.5 B x 18 H2
Wheel offset1.58 in (40 mm)
Collapsible tire3
3Must not be used with snow chains.
195/75-18 106P
Recommended tire inflation pressure44 psi (3.0 bar)
!Please compare the recommended tire
inflation pressure for your vehicle with the tire
inflation pressure on the yellow label located on
the spare wheel rim.
If the tire inflation pressure on the yellow label
on the spare wheel rim differs from the values
given in this Operator’s Manual, inflate the
collapsible tire to the recommended tire inflation
pressure given on the yellow label on the spare
wheel rim.iPlease note that the tire inflation pressure of
the collapsible tire differs from the tire inflation
pressure of the road tires.