oil pressure MERCEDES-BENZ R63AMG 2007 R171 Owner's Manual

Contents
Oxidation catalyst
(diesel engine).............................. 358
Emission control .......................... 358
Coolant temperature .................... 359
At the gas station .............................. 360
Refueling ...................................... 360
Check regularly and before
a long trip..................................... 362
Engine compartment ......................... 364
Hood ............................................ 364
Engine oil ..................................... 366
Transmission fluid level ................ 370
Coolant level ................................ 370
Windshield/rear window
washer system and headlamp
cleaning* system ......................... 372
Tires and wheels ................................ 373
Important guidelines .................... 373
Tire care and maintenance........... 374
Direction of rotation ..................... 375
Loading the vehicle ...................... 376
Recommended tire inflation
pressure ....................................... 380
Checking tire inflation pressure ... 382
Tire labeling.................................. 391
Load identification ....................... 395DOT, Tire Identification
Number (TIN) ................................ 396
Maximum tire load ........................ 397
Maximum tire inflation pressure ... 398
Uniform Tire Quality Grading
Standards (U.S. vehicles) .............. 398
Tire ply material ............................ 400
Tire and loading terminology......... 401
Rotating tires ................................ 404
Winter driving ..................................... 405
Winter tires ................................... 405
Snow chains.................................. 406
Maintenance....................................... 407
Maintenance service indicator
message ....................................... 407
Calling up the maintenance
service indicator display ............... 409
Resetting the maintenance
service indicator ........................... 409
Vehicle care........................................ 410
Cleaning and care of the vehicle ... 410
Practical hints.................................. 419
What to do if … ................................... 420
Lamps in instrument cluster ......... 420
Lamp in center console ................ 431
Vehicle status messages in the
multifunction display .................... 433
Where will I find ...? ............................ 472
First aid kit.................................... 472
Vehicle tool kit.............................. 472
Spare wheel .................................. 475
Unlocking / locking in an emergency .. 478
Unlocking the vehicle ................... 478
Locking the vehicle ....................... 479
Fuel filler flap ................................ 479
Opening / closing in an emergency..... 481
Power tilt/sliding sunroof* ........... 481
Resetting activated head restraints.... 482
Replacing SmartKey batteries ............ 483
Replacing bulbs .................................. 484
Bulbs............................................. 484
Replacing bulbs for front lamps .... 487
Replacing bulbs for rear lamps ..... 491
Replacing wiper blades ...................... 494
Front wiper blades ........................ 494
Rear wiper blade ........................... 495

23 At a glance
Exterior view
ItemPage
1Tailgate
Opening123
Closing125
Power tailgate*123,
125
Cargo compartment
Vehicle tool kit472
Spare wheel475
2Rear window defroster217
3Rear lamps485
4Fuel filler flap360
Refueling360
Fuel361,
542
5Exterior rear view mirrors
Adjusting49
Auto-dimming rear view
mirrors*213
Power folding*214
ItemPage
6Towing eye bolt
Vehicle tool kit472
Installing517
7Tires and wheels373,
532
Checking tire inflation
pressure382
Run Flat Indicator
(Canada vehicles)383
Tire Pressure Monitoring
System (U.S. vehicles)385
Advanced Tire Pressure
Monitoring System*
(Canada vehicles)388
Flat tire497
Spare wheel475
8Hood364
Engine oil366
Coolant370
ItemPage
9Windshield wipers60
Wiper blades, replacing494
Wiper blades, cleaning415
aWindshield
Cleaning with wiper fluid62
Cleaning415
bPower tilt/sliding sunroof*258
Panorama roof with power
tilt/sliding panel*261
cDoors
Locking and unlocking112
Opening and closing122
Locking/unlocking in an
emergency478
dFront lamps484
eHeadlamp cleaning system*212

163 Controls in detail
Control system
Menus, submenus and functions
Menu1Menu2Menu3Menu4Menu5
Standard displayAMG1
1AMG vehicles only.
AudioNavi*Airmatic*/Compass
(page 166)(page 168)(page 171)(page 173)(page 174)
Commands/submenus
Trip- and main odometerEngine oil temperatureSelecting radio stationRoute guidance
instructions, current
direction traveledAIRMATIC*
Checking tire inflation
pressureVehicle supply voltageSelecting satellite radio
station* (USA only)Compass
Checking coolant
temperatureRACETIMEROperating CD player
Calling up digital
speedometer or outside
temperatureOverall analysis
Calling up maintenance
service indicatorLap analysis
Checking engine oil level
iThe headings used in the menus table are
designed to facilitate navigation within thesystem and are not necessarily identical to those
shown in the control system displays.The first function displayed in each menu will
show you which part of the system you are in.

166 Controls in detail
Control system
Standard display menu
In the standard display, the main odometer
and the trip odometer appear in the multi-
function display.
1Trip odometer
2Main odometer
If you see another display, press
buttonè orÿ repeatedly until
the standard display appears.
Press buttonkorj to select
the functions in the standard display
menu.The following functions are available:Checking coolant temperature
FunctionPage
Checking tire inflation pressure382
Checking coolant temperature166
Calling up digital speedometer or
outside temperature167
Calling up maintenance service
indicator409
Checking engine oil level
(R 500 only)366
Warning!G

Driving when your engine is overheated
can cause some fluids which may have
leaked into the engine compartment to
catch fire. You could be seriously
burned.

Steam from an overheated engine can
cause serious burns which can occur
just by opening the hood. Stay away
from the engine if you see or hear steam
coming from it.
Stop the vehicle in a safe location away from
other traffic. Turn off the engine, get out of
the vehicle and do not stand near the vehicle
until the engine has cooled down.

361 Operation
At the gas station
Open the fuel filler flap completely.
Turn the fuel cap to the counterclock-
wise and hold on to it until possible
pressure is released.
Take off the fuel cap.
To prevent fuel vapors from escaping
into open air, fully insert filler nozzle
unit.
Only fill your tank until the filler nozzle
unit cuts out – do not top up or overfill.
Replace the fuel cap by turning it clock-
wise until it audibly engages.
Close the fuel filler flap.
You should hear the latch close shut.
!The fuel filler cap is tethered to the fuel filler
neck. Do not drop the cap. It could damage the
vehicle paint finish.
Warning!G
Overfilling of the fuel tank may create pres-
sure in the system which could cause a gas
discharge. This could cause the gas to spray
back out when removing the fuel pump
nozzle, which could cause personal injury.
iLeaving the engine running and the fuel cap
open can cause the yellow fuel tank reserve
warning lamp to flash and the? malfunction
indicator lamp (USA only) or the± malfunc-
tion indicator lamp (Canada only) comes on.
For more information, see “Practical hints”
(
page 424).
iGasoline engine:
Only use premium unleaded gasoline with a min-
imum Posted Octane Rating of 91 (average of
96 RON/86 MON). Information on gasoline
quality can normally be found on the fuel pump.
For more information on gasoline, see see “Pre-
mium unleaded gasoline (gasoline engine)”
(
page 541), see “Fuel requirements”
(
page 542), and the Factory Approved Service
Products pamphlet.
iDiesel engine:
Only use commercially available vehicular diesel
fuels No. 2 or No. 1 (ASTM D975 No. 2-D or
No. 1-D). Information on diesel quality can
normally be found on the fuel pump.
The sulfur content in diesel fuel should not
exceed 50 parts per million (ppm). When using
diesel fuel with a sulfur content of above
300 ppm, the engine oil interval should be
shortened.
For more information on diesel fuels, refer to the
Factory Approved Service Products pamphlet or
contact an authorized Mercedes-Benz Light
Truck Center.
!Diesel engine:
The engine is more susceptible to wear and
damage if you use

marine diesel fuel

heating oil

additives
The use of such non-approved fuels and/or
special additives is not covered by the
Mercedes-Benz Limited Warranty.

370 Operation
Engine compartment
Unscrew filler cap1 from filler neck.
Add engine oil as required. Be careful
not to overfill with oil.
Be careful not to spill any oil when adding.
Avoid environmental damage caused by oil
entering the ground or water.
Screw filler cap1 back on filler neck.
For more information on engine oil, see
“Technical data” section (
page 538) and
(
page 540).
Transmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Light
Truck Center check the automatic trans-
mission.Coolant level
The engine coolant is a mixture of water
and anticorrosion/antifreeze. To check
the coolant level, the vehicle must be
parked on level ground.
!Excess oil must be siphoned or drained off.
It could cause damage to the engine or
emission control system not covered by the
Mercedes-Benz Limited Warranty.Warning!G
In order to avoid any possibly serious burns:

Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.

Do not remove pressure cap on coolant
reservoir if coolant temperature is
above 158°F (70°C). Allow engine to
cool down before removing cap. The
coolant reservoir contains hot fluid and
is under pressure.

401 Operation
Tires and wheels
Tire and loading terminology
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
automatic transmission, power steering,
power brakes, power windows, power
seats, radio, and heater, to the extent that
these items are available as
factory-installed equipment (whether
installed or not).
Air pressure
The amount of air inside the tire pressing
outward on each square inch of the tire.
Air pressure is expressed in pounds per
square inch (psi), or kilopascal (kPa) or
bars.
Aspect ratio
Dimensional relationship between tire
section height and section width
expressed in percentage.Bar
Another metric unit for air pressure. There
are 14.5038 pounds per square inch (psi)
to 1 bar; there are 100 kilopascals (kPa)
to 1 bar.
Bead
The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the
rim.
Cold tire inflation pressure
Tire inflation pressure when your vehicle
has been sitting for at least 3 hours or
driven no more than 1 mile (1.6 km).
Curb weight
The weight of a motor vehicle with stan-
dard equipment including the maximum
capacity of fuel, oil, and coolant, and, if so
equipped, air conditioning and additional
optional equipment, but without passen-
gers and cargo.DOT (Department of Transportation)
A tire branding symbol which denotes the
tire meets requirements of the
U.S. Department of Transportation.
GAWR (G
ross Axle Weight Rating)
The GAWR is the maximum permissible
axle weight. The gross vehicle weight on
each axle must never exceed the GAWR for
the front and rear axle indicated on the
certification label located on the driver’s
door B-pillar.
GTW (G
ross Trailer Weight)
The GTW is the weight of the trailer plus
the weight of all cargo, equipment, luggage
etc. loaded on the trailer.

543 Technical data
Fuels, coolants, lubricants, etc.
These blends must also meet all other fuel
requirements, such as resistance to spark
knock, boiling range, vapor pressure, etc.
Diesel engine
Only use commercially available vehicular
diesel fuels No. 2 or No. 1 (ASTM D975 No.
2-D or No. 1-D).
To prevent malfunctions, diesel fuel with
improved cold flow characteristics is of-
fered in the winter months. Check with
your fuel retailer.Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which
provides:

Corrosion protection

Freeze protection

Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -35°F (-37°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).
The coolant solution must be used year
round to provide the necessary corrosion
protection and increase boil-over protec-
tion. Refer to Maintenance Booklet for
replacement interval.Coolant system design and coolant used
determine the replacement interval. The
replacement interval published in the
Maintenance booklet is only applicable if
MB 325.0 anticorrosion/antifreeze solu-
tion or other Mercedes-Benz approved
products of equal specification (see
Factory Approved Service Products pam-
phlet) are used to renew the coolant con-
centration or bring it back up to the proper
level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. -22°F [-30°C]). If you
use a solution that is more than 55% anti-
corrosion/antifreeze (freeze protection to
approx. -49°F [-45°C]), the engine temper-
ature will increase due to the lower heat
transfer capability of the solution. There-
fore, do not use more than this amount of
anticorrosion/antifreeze.
!Do not fill the tank with gasoline. Do not
blend diesel fuel with gasoline or kerosine. The
fuel system and engine will otherwise be
damaged, which is not covered by the
Mercedes-Benz Limited Warranty.

559 Index
display messages
Microphone, Hands-free 33
Mirrors
Adjusting 48
Auto-dimming* 213
Exterior rear view mirrors 49
Interior rear view mirror 48, 212
Mobile phone see Telephone*
MON 542
Multicontour seats* 136
Multifunction display 159
Changing settings see Control system
menus and Control system sub-
menus
Selecting language 179
Standard display 163
Multifunction display
messages 433–471
ABS 435, 442
AIRMATIC* 470–471
Brake fluid 454
Brake pads 452Coolant 455–457
Cruise control 436
Doors 460
EBP 453
Engine coolant 455–457
Engine oil 366, 367, 458
ESP
®436, 441, 442
Fog lamps, Front* 464
Fog lamps, Rear 466
Front passenger front air
bag 445–448
Fuel cap 460
Gear selector lever 443
Headlamps 463–468
Hood 460
Key, SmartKey 462
Key, SmartKey with
KEYLESS-GO* 461, 462
Lamps 465
Lamps, exterior 463
Low tire pressure 449
Parking brake 443, 453
Parking lamps 466SmartKey with KEYLESS-GO* 461
SRS 444
Tele Aid* 469
Telephone* 469
Windshield washer fluid 469
Multifunction steering wheel 30, 160
Button operation 160
N
Navigation system* 173
See separate COMAND system operat-
ing instructions
Net, Parcel 315
Net, Partition* 308
Neutral gear position, Automatic
transmission 197, 201
New vehicle, Break-in period 346
Night security illumination 149, 185
Normal occupant weight 402
Number, Vehicle Identification
(VIN) 526, 527