spare wheel MERCEDES-BENZ S500 2005 W220 User Guide

381 Practical hints
Where will I find ...?
Spare wheel
Removing the spare wheel
Take out the vehicle tool kit tray2.

Loosen the luggage bowl3. To do so,
turn the luggage bowl counterclock-
wise.

Remove the spare wheel4.
Storing the spare wheel

Place spare wheel4in wheel well.

Secure the spare wheel. To do so, turn
the luggage bowl3 clockwise to its
stop.

Place vehicle tool kit tray2 in luggage
bowl.
Spare wheel S 430, S 500 and S 600
(except Sport Package*)
The spare wheel rim is mounted with a full
sized tire of the same type as on the vehi-
cle, and it is fully functional.However, that spare wheel rim is weight
optimized and has a limited service life of
12 000 miles (20 000 km) use before a
standard wheel rim must replace it.
In case of flat tire, you may temporarily use
the spare wheel.
Do not operate vehicle with more than one
spare wheel mounted.
For more information, see “Rims and tires”
(
page 422).
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack take-up brackets
built into both sides of the vehicle. To help
avoid personal injury, use the jack only to lift
the vehicle during a wheel change. Never
get beneath the vehicle while it is supported
by the jack. Keep hands and feet away from
the area under the lifted vehicle. Always
firmly set parking brake and block wheels
before raising vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure the jack arm is
fully seated in the jack take-up bracket. Al-
ways lower the vehicle onto sufficient ca-
pacity jackstands before working under the
vehicle.
Warning!
G
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel rim is for temporary use
only. Use for over a total of 12 000 miles
(20 000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.

382 Practical hintsWhere will I find ...?Spare wheel S 55 AMG and Sport
Package*
In case of a flat tire, you may temporarily
use the spare wheel when observing the
following restrictions:

Do not exceed a vehicle speed of
50 mph (80 km/h).


Drive to the nearest tire repair facility
to have the flat tire repaired or re-
placed as appropriate.


Do not operate vehicle with more than
one spare wheel mounted.For more information, see “Rims and tires”
(
page 422).
Warning!
G
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire inflation pressure and do
not exceed vehicle speed of 50 mph
(80 km).
The spare wheel rim is for temporary use
only. Use for over a total of 12 000 miles
(20 000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.

398 Practical hintsFlat tirePreparing the vehicle
Park the vehicle as far as possible from
moving traffic on a hard surface.

Turn on the hazard warning flashers.

Turn the steering wheel so that the
front wheels are in a straight ahead
position.

Set the parking brake.

Move the gear selector lever toP.
Vehicles with SmartKey:

Turn off the engine (
page 57).

Remove the SmartKey from the starter
switch.Vehicles with SmartKey with
KEYLESS-GO*:

Turn off the engine by pressing the
KEYLESS-GO* button on the gear se-
lector lever once (
page 57).

Open the driver’s door (this puts the
starter switch in position0, same as
with the SmartKey removed from the
starter switch). The driver’s door then
can be closed again.

Have any passenger exit the vehicle at
a safe distance from the roadway.
Mounting the spare wheel
iOpen the door only when conditions
are safe to do so.
Warning!
G
Never operate the vehicle with more than
one spare wheel mounted.
The spare wheel rim is for temporary use
only. Use for over a total of 12 000 miles
(20 000 km) (aggregate of all uses) may
cause wheel rim failure leading to an acci-
dent and possible injuries.
The spare wheel should only be used tempo-
rarily and replaced with a regular road wheel
as quickly as possible.
S55AMG and Sport Package* only:
The spare wheel is for temporary use only.
When driving with spare wheel mounted, en-
sure proper tire inflation pressure and do
not exceed vehicle speed of 50 mph
(80 km/h).

399 Practical hints
Flat tire
Preparing the vehicle
Take vehicle tool kit tray and vehicle
jack out of trunk.

Take the spare wheel out of wheel well
(page 379).
Lifting the vehicle

Prevent the vehicle from rolling away
by blocking wheels with wheel chocks
(not included) or other sizable objects.
When changing wheel on a level surface:

Place one chock in front of and one be-
hind the wheel that is diagonally oppo-
site to the wheel being changed.
When changing wheel on a hill:

Place chocks behind the downhill sides
of both wheels of the axle not being
worked on.

Take the two-piece wheel wrench out
of the vehicle tool kit tray. Assemble
wheel wrench.

On wheel to be changed, loosen but do
not yet remove the wheel bolts (ap-
proximately one full turn with wrench).
The tube openings are located directly be-
hind the front wheel housings and in front
of the rear wheel housings.
The dimensions of the spare wheel are dif-
ferent from those of the road wheels. As a
result, the vehicle handling characteristics
change when driving with a mounted spare
wheel. Adapt your driving style accordingly.
Warning!
G
The jack is designed exclusively for jacking
up the vehicle at the jack tubes built both
sides of the vehicle. To help avoid personal
injury, use the jack only to lift the vehicle
during a wheel change. Never get beneath
the vehicle while it is supported by the jack.
Keep hands and feet away from the area un-
der the lifted vehicle. Always firmly set park-
ing brake and block wheels before raising
vehicle with jack.
Do not disengage parking brake while the
vehicle is raised. Be certain that the jack is
always vertical (plumb line) when in use, es-
pecially on hills. Always try to use the jack
on level surface. Make sure the jack arm is
fully inserted in the jack tube. Always lower
the vehicle onto sufficient capacity jack-
stands before working under the vehicle.

401 Practical hints
Flat tire
Removing the wheel
1Alignment bolt
Unscrew upper-most wheel bolt and re-
move.

Replace this wheel bolt with alignment
bolt1 supplied in the tool kit.

Remove the remaining bolts.

Remove the wheel.Mounting the new wheel

Clean contact surfaces of wheel and
wheel hub.

Guide the spare wheel onto the align-
ment bolt and push it on.

Insert wheel bolts and tighten them
slightly.

Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.
!Do not place wheel bolts in sand or dirt.
This could result in damage to the bolt
and wheel hub threads.
!To avoid paint damage, place wheel flat
against hub and hold it there while in-
stalling first wheel bolt.Warning!
G
Always replace wheel bolts that are dam-
aged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be re-
paired immediately. Do not continue to drive
under these circumstances! Contact an au-
thorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect wheel bolts or improperly tight-
ened wheel bolts can cause the wheel to
come off. This could cause an accident.
Make sure you are using the correct wheel
bolts.
Warning!
G
Use only genuine equipment
Mercedes-Benz wheel bolts. Other wheel
bolts may come loose.
Do not tighten the wheel bolts when the ve-
hicle is raised. Otherwise the vehicle could
tip over.

402 Practical hintsFlat tireLowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until vehicle is resting ful-
ly on its own weight.

Remove the jack.
1 - 5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of
110 lb-ft (150 Nm).

Before storing the jack in the trunk, it
should be fully collapsed, with handle
folded in.

Place the wheel bolt wrench, alignment
bolt and jack back in the vehicle tool kit
in the trunk and close the covering lid.Replacing jack support tube cover

Slide tongue of cover under the upper
edge of the tube opening.

Applying even pressure, press cover
until it snaps into place. Be careful not
to damage the locking tabs or clamp
the plastic retaining strap.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
110 lb-ft (150 Nm).
!You can also screw the faulty wheel
down into the spare wheel well in the
trunk.
Do not activate the tire inflation pres-
sure monitor* until the depressurized
tire is no longer in the vehicle.

426 Technical dataRims and tiresSpare wheel
S 430, S 430 4MATIC, S 500, S 500 4MATIC
(except Sport Package* and except
Appearance Package*)
S 430, S 430 4MATIC, S 500, S 500 4MATIC
(Sport Package* and Appearance Package*)
S600, S 55 AMG
Rims (light alloy)
71/2 J x 17 H2
8 J x 18 H2
Wheel offset
2.0 in (51 mm)
1.73 in (44 mm)
Summer tires (radial-ply tires)
-
245/45 R18 96Y
All-season tires (radial-ply tires)
225/55 R17 97H M+S
-

452 IndexExterior rear view mirror
Auto-dimming on the driver’s
side 186
Exterior rear view mirrors
Adjusting 41
Folding electrically 188
Parking position for 171
F
Fahrenheit (°F)
Setting temperature units 163
Fastening the seat belts 43
Fine adjustment
Cruise control 216
Distronic* 223
First aid kit 379
Flat tire 398
Lowering the vehicle 402
Mounting the spare wheel 398
Preparing the vehicle 398
Flexible Service System (FSS) 328
Flexible Service System see FSS
Fog lamp, rear 134, 390
Replacing bulb 395Fog lamps
Replacing bulbs 390
Fog lamps, front
Messages in display 366
Switching on 134
Folding electrically
Exterior rear view mirrors 188
Four wheel electronic traction system
(4MATIC)
with ESP 85
4MATIC 85
Front air bags 65
Front lamps
Messages in display 366–369
Replacing bulbs 390, 392
Switching on 131
Front passenger front air bag off indicator
lamp 346
Front seat head restraints
Installing 116
Power seat 116
Removing 116
FSS (Flexible Service System) 328
FSS (Flexible Service System) (Canada
vehicles) 439Fuel 284
Fuel reserve warning lamp 341
Premium unleaded gasoline 284
Reserve warning lamp 25
Fuel consumption statistics
After start 157
Since last reset 158
Fuel filler flap 283
Locking 283
Opening 385
Unlocking 283
Fuel tank
Filler flap 283
Fuels, coolants, lubricants etc. 429
Functions (control system) 145, 147
Resetting 161
Fuse box 412, 413
Fuse chart 380
Fuses 411
Auxiliary fuse box in trunk 412
Fuse box in engine compartment 413
Fuse box in passenger
compartment 412
Fuse chart 380
Fuse extractor 380
Spare fuses 380

465 Index
Snow chains 327
Spare fuses 380
Spare wheel
Mounting 398
Speed
Setting current 215
Setting to last stored speed in Distron-
ic* (“Resume” function) 223
Speed settings
Cruise control 216
Distronic* 222, 223
To last stored speed (“Resume” func-
tion) in Cruise control 216
Speedometer
Displays 219
Settings units 163
Speedometer display mode
Selecting 163
Sporty driving style 232
SRS 68, 441
Indicator lamp 345
SRS indicator lamp 60Standing lamps 131
Replacing bulbs 390, 394
Standing water
Driving instructions 280
Starting difficulties 47
Starting the engine 46
Steering column
Height adjustment 40
Length adjustment 40
Steering wheel
Adjusting 40
Adjustment 40
Cleaning 335
Heated steering wheel* 253
Steering wheel adjustment 40
Steering wheel gearshift control S 55 AMG
Automatic transmission 181
Stolen vehicle
Recovery services 263
Stopping
Tilt/sliding sunroof 213
Windows 209Storage compartments 243
Armrest 245, 246, 247
Cup holder 248, 250
Glove box 244
In front of armrest 247
Parcel net 250
Storage compartment in front of
armrest 245
Storage tray 245, 246, 247
Under the front seats 248
Storing (Memory function*)
Positions into memory 129
Storing tires 298
Submenus
Convenience 169
For settings 145
In control system 147
Instrument cluster 163
Lighting 164
Resetting functions in Control
system 161
Selecting 161
Settings menu 161
Vehicle 168

469 Index
Vehicle care 330
Cup holder 335
Distronic* system sensor cover 333
Engine cleaning 332
Gear selector lever 335
Hard plastic trim items 335
Headlamps 332
Instrument cluster 335
Leather upholstery 336
Light alloy wheels 335
Nubuck leather upholstery 336
Ornamental moldings 332
Paintwork 331
Parktronic* system sensor 333
Plastic and rubber parts 336
Power-wash 331
Seat belts 335
Side markers 332
Steering wheel 335
Tail lamps 332
Tar stains 331
Turn signals 332
Upholstery 336
Vehicle washing 332
Window cleaning 334
Wiper blades 333Wood trims 336
Vehicle data recording 19
Vehicle level 230, 232
Changing 230, 233
Setting 230, 233
Automatic 230, 233
Manual 230, 233
Vehicle lighting
Checking 285
Vehicle loading terminology 322
Vehicle maximum load on the tire 324
Vehicle status message memory 159
Calling up 159
Displaying 159
Vehicle submenu
Limiting opening height of trunk lid*
(Control system) 169
Vehicle tool kit 379, 380
Alignment bolt 380
Fuse chart 380
Fuse extractor 380
Gloves 380
Screwdriver 380
Spare fuses 380
Wheel wrench 380Vehicle washing 332
Ventilated storage compartment 204
Ventilation
Storage compartment 204
VIN (Vehicle Identification Number) 442
Voice control system* 442
Hands-free microphone 29
W
Warning indicators
Parktronic* 237
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 225
Distronic* 219
Drivers seat belts 66
Parking brake 49
Warranty coverage 417
Washing the vehicle 330
Wear pattern (tires) 325
Weights 428
Wheel change
Tightening torque 402
Wheels
Tires and wheels 296
Window curtain air bags 66