washer fluid MERCEDES-BENZ SL500 2003 R230 Owner's Manual

Contents
Retractable hardtop........................... 159
Opening and closing the retractable
hardtop ........................................ 159
Driving systems ................................. 168
Cruise control .............................. 168
Distronic* .................................... 171
Active Body Control (ABC) ........... 183
Parktronic system* ...................... 186
Useful features .................................. 190
Interior storage spaces ................ 190
Ashtray......................................... 196
Cigarette lighter ........................... 197
Heated steering wheel* (Canada
only–model SL 500) ..................... 197
Easy-Pack load assist in the trunk 198
Electrical outlet ............................ 199
Telephone* .................................. 199
Tele Aid ........................................ 200
Garage door opener ..................... 208Operation......................................... 213
The first 1000 miles (1500 km) ......... 214
Driving instructions............................ 215
Drive sensibly – save fuel............. 215
Drinking and driving ..................... 215Pedals ........................................... 215
Power assistance .......................... 216
Brakes........................................... 216
Driving off ..................................... 218
Parking.......................................... 218
Tires .............................................. 219
Hydroplaning................................. 219
Tire traction .................................. 220
Tire speed rating ........................... 220
Winter driving instructions ............ 221
Standing water.............................. 222
Passenger compartment ............... 222
Driving abroad .............................. 222
Control and operation of radio trans-
mitters .......................................... 222
Catalytic converter........................ 223
Emission control ........................... 224
Coolant temperature..................... 224
At the gas station ............................... 225
Check regularly and before a
long trip ........................................ 226Engine compartment .......................... 227
Hood ............................................. 227
Engine oil ...................................... 228
Transmission fluid level ................ 230
Oil level in the ABC system ........... 230
Coolant ......................................... 230
Battery .......................................... 232
Windshield washer system and
headlamp cleaning system ........... 233
Tires and wheels ................................ 234
Important guidelines ..................... 234
Life of tires ................................... 235
Direction of rotation ..................... 235
Checking tire inflation pressure .... 235
Rotating wheels ............................ 238
Winter driving ..................................... 239
Winter tires ................................... 239
Block heater (Canada only) ........... 240
Snow chains ................................. 240
Maintenance ...................................... 241
Clearing the service indicator ....... 241
Service term exceeded ................. 241
Calling up the service indicator .... 242
Resetting the service indicator ..... 242
Vehicle care ....................................... 243
Cleaning and care of the vehicle ... 243

ContentsPractical hints.................................. 249
What to do if … .................................. 250
Lamps in instrument cluster ......... 250
Messages in the display ............... 257
Where will I find ...?............................ 288
First aid kit ................................... 288
Vehicle tool kit ............................. 288
Locking/unlocking in an emergency.. 290
Unlocking the vehicle ................... 290
Locking the vehicle ...................... 292
Lowering the Easy Pack feature
manually ....................................... 292
Changing batteries ....................... 293
Replacing bulbs ................................. 295
Bulbs ............................................ 295
Replacing bulbs for front lamps.... 298
Replacing bulbs for rear lamps ..... 299
Replacing wiper blades ...................... 301
Removing ..................................... 301
Installing....................................... 301
Flat tire .............................................. 302
Preparing the vehicle.................... 302
Sealing tires with TIREFIT kit 1 ..... 302
Sealing tires with TIREFIT kit 2 ..... 308
Mounting the spare wheel ............ 312Batteries ............................................ 319
Disconnecting the batteries ......... 320
Removing the batteries ................ 321
Charging and reinstalling
batteries....................................... 321
Reconnecting the batteries .......... 321
Jump starting ..................................... 323
Towing the vehicle ............................. 325
Installing towing eye bolt ............. 327
Fuses ................................................. 329
Main fuse box............................... 329
Technical data................................. 331
Spare parts service ............................ 332
Warranty coverage............................. 333
Loss of Service and Warranty
Information Booklet ..................... 333
Identification labels ........................... 334
Layout of poly-V-belt drive ................. 335
SL 500 ......................................... 335
SL 55 AMG ................................... 335
Engine................................................ 336
Rims and tires.................................... 337
Same size tires ............................. 337
Mixed size tires ............................ 338Spare wheel ................................. 338
Electrical system ............................... 339
Main dimensions ............................... 340
Weights ............................................. 341
Fuels, coolants, lubricants, etc. ......... 342
Capacities .................................... 342
Engine oils ................................... 343
Engine oil additives ...................... 343
Air conditioner refrigerant............ 343
Brake fluid.................................... 343
Premium unleaded gasoline ......... 344
Fuel requirements ........................ 344
Gasoline additives ........................ 344
Coolants ...................................... 345
Windshield and headlamp washer
system ......................................... 347
Consumer information ....................... 348
Uniform tire quality grading ......... 348
Technical terms............................... 351Index................................................. 357

44 Getting startedDrivingWindshield wipers
The combination switch is on the left of the
steering column.Combination switch1Single wipe
2Switching on windshield wipers
Make sure that the ignition is switched
on.Switching on windshield wipers

Turn the combination switch to the de-
sired position depending on the inten-
sity of the rain.
0 Windshield wipers off
I Intermittent wiping (interval depen-
dent on wetness of windshield)
IINormal wiper speed
IIIFast wiper speed (Canada only:
goes to setting II when the car is
standing still)
Single wipe

Press switch briefly in the direction of
arrow1.
The windshield wipers wipe one time
without washer fluid.
iThe intermittent wiping interval is de-
pendent on wetness of windshield.
Wiping will not occur with a door open.
!Do not leave windshield wipers in inter-
mittent setting when vehicle is taken to
an automatic car wash or during wind-
shield cleaning. Wipers will operate in
the presence of water sprayed on the
windshield, and wipers may be dam-
aged as a result.
The switch should not be left in inter-
mittent setting as the wipers will wipe
the windshield once every time the en-
gine is started. Dust that accumulates
on the windshield might scratch the
glass when wiping occurs on a dry
windshield.

45 Getting started
Driving
Wiping with windshield washer fluid
Push switch in the direction of arrow1
past the resistance point.
The windshield wiper operates with
washer fluid.
Information on filling up the washer reser-
voir can be found in the "Operation" sec-
tion (page 233).
Problems while driving
The engine runs erratically and misfires

An ignition cable may be damaged.


The engine electronics may not be op-
erating properly.


Unburned gasoline may have entered
the catalytic converter and damaged it.

Give very little gas.

Have the problem repaired by an au-
thorized Mercedes-Benz Center as
soon as possible.
The coolant temperature gauge is over
248°F (120°C)
The coolant is too hot and is no longer
cooling the engine.

Stop the vehicle as soon as possible
and turn off the engine. Allow engine
and coolant to cool.

Check the coolant level and add cool-
ant if necessary (
page 230).
!If leaves, snow, etc. block the wind-
shield wipers, the wiper motor turns
off.

For safety reasons, withdraw key
from starter switch. Remove block-
age.


Turn the windshield wipers on
again.
If windshield wipers fail to function at
all in switch positionI,


set the combination switch to the
next highest wiper speed.


have the windshield wipers
checked at the nearest authorized
Mercedes-Benz Center.

226 OperationAt the gas stationCheck regularly and before a long trip
1Windshield washer and headlamp
cleaning system
More information on refilling the reser-
voir can be found in the “Operation”
section on (
page 233).
2Brake fluid
More information on brake fluid can be
found in the “Technical data” section
(
page 342).
3Coolant level
More information on coolant can be
found in the “Coolant” section on
(page 230).Engine oil level
More information on engine oil can be
found in the Checking engine oil level sec-
tion on (
page 228).
Opening hood see (
page 227).
Vehicle lighting
Check function and cleanliness.More infor-
mation on replacing light bulbs can be
found in the “Practical hints” section
(
page 295).
Exterior lamp switch see “Switching on
headlamps” (
page 43).
Tire inflation pressure
More information on tire inflation pressure
can be found in the “Tires and wheels” sec-
tion (
page 234).

233 Operation
Engine compartment
Windshield washer system and headlamp cleaning system
Fluid for the windshield washer system and
the headlamp cleaning system is supplied
from the windshield washer reservoir. It
has a capacity of approx. 7.4 US qt. (7 l).
During all seasons, add MB Windshield
Washer Concentrate “S” to water. Pre-mix
the windshield washer fluid in a suitable
container.
Refill the reservoir with MB Windshield
Washer Concentrate and water (or
commercially available pre-mixed
windshield washer solvent / antifreeze,
depending on ambient temperatures).
Always use washer solvent/antifreeze
where temperatures may fall below
freezing. Failure to do so could result in
damage to the washer system/reser-
voir.The windshield washer system on this ve-
hicle is heated, so that a fluid mixture pro-
duced for temperatures of approximately
14°F (–10°C) should be sufficient.
More information can be found in the
“Technical data” section (
page 347).1Washer fluid reservoir
Warning!
G
Washer solvent / antifreeze is highly flam-
mable. Do not spill washer
solvent / antifreeze on hot engine parts, be-
cause it may ignite. You could be seriously
burned.
!Only use washer fluid which is suitable
for plastic lenses. Improper washer flu-
id can damage the plastic lenses of the
headlamps.

287 Practical hints
What to do if …
Left display
Right display
Possible cause
Possible solution
K
Visit workshop!
The retractable hardtop is mal-
functioning.

Have the retractable hardtop checked by an au-
thorized Mercedes-Benz Center.
Lock
hardtop
The roof is not properly locked.

Push or pull on the retractable hardtop switch
until the indicator lamp in the switch goes out
and the roof is completely open or closed
(page 159).
±
Display defective
Visit workshop!
Certain electronic systems are un-
able to relay information to the
control system. The following sys-
tems may have failed:

Coolant temperature gauge


Tachometer


Cruise control display

Have the electronic systems checked by an au-
thorized Mercedes-Benz Center (
page 256).
W
Washer fluid
Check level!
The fluid level has dropped to
about 1/3 of total reservoir ca-
pacity.

Add washer fluid (
page 233).

343 Technical data
Fuels, coolants, lubricants, etc.
Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, only
use engine oils recommended by
Mercedes-Benz. Information on recom-
mended brands is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Center.
Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may be harmful to the engine opera-
tion.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioner refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil are used in the air condition-
er system.
Never use R-12 (CFC) or mineral-based lu-
bricating oil, otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be re-
placed every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Center will pro-
vide you with additional information.
Model
Capacity
Fuels, coolants, lubricants etc.
Hydraulic system for retractable hardtop
0.42 US qt (0.4 l)
MB Hydraulic Fluid
Windshield washer and headlamp cleaning system
7.4 US qt (7 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing or MB Windshield Washer Concentrate “S” and commercially available pre-
mixed windshield washer solvent / antifreeze for temperatures below freezing. Follow suggested mixing ratios (
page 346).

347 Technical data
Fuels, coolants, lubricants, etc.
Windshield and headlamp washer system
Both the windshield and headlamp washer
systems are supplied from the windshield
washer fluid reservoir.
The windshield and headlamp washer fluid
reservoir has a capacity of approx.
7.4 US qt. (7 l).
Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed windshield washer
solvent / antifreeze, depending on am-
bient temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
(40 ml “S” to 4 l water)
For temperatures below freezing use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent / antifreeze:


1 part “S” to 100 parts solvent
(40 ml “S” to 4 l solvent).
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts because it may ignite.
You could be seriously burned.

363 Index
Fuel 225
Additives 344
Fuel requirements 344
Fuel reserve warning lamp 21, 255
Gasoline additives 344
Premium unleaded gasoline 225,
342, 344
Fuel consumption statistics
After start 132
Since reset 132
Fuel filler flap 225
Locking 225
Opening 225
Unlocking 225
Fuel requirements 344
Fuel reserve tank
Message in display 286
Fuel tank
Filler flap 225
Fuels, coolants, lubricants etc. -
capacities 342
Functions (control system) 111
Fuse chart 288, 329Fuses 329
Fuse chart 288, 329
Fuse extractor 288, 329
Main fuse box 329
Spare fuses 288, 329
G
Garage door opener 25, 208
Gasoline see Fuel
Gear range
Automatic transmission 139
Indicator 21
Limiting 139
Shifting into optimal 138
Glove box 19, 190
Closing 190
Opening 190
GPS 353
H
Hands-free microphone 25
Hardtop open/close control 24
Hardtop see Retractable hardtop
Hardtop switch 160
Hazard warning flasher 105
Hazard warning flasher switch 23Head restraints
Adjusting height 33
Adjusting tilt 34
Headlamp switch-off delay see Delayed
switch-off, exterior lamps
Headlamps
Automatic mode 103
Headlamp cleaning system 146, 233
Manual mode 103
Refilling washer fluid 233
Head-thorax airbag 65, 353
Heated steering wheel* 197
Height adjustments
Head restraints 33
Seats 33
Steering column 35
Vehicle level 184
High beam flasher 105
High beam headlamp indicator 21
High beam headlamps 43, 102, 296
Replacing bulbs 298
Switching on 104
Hood 227
Messages in display 279
Horn 19
Hydroplaning 219