transmission fluid MERCEDES-BENZ SLK320 2004 R171 Owner's Manual
[x] Cancel search | Manufacturer: MERCEDES-BENZ, Model Year: 2004, Model line: SLK320, Model: MERCEDES-BENZ SLK320 2004 R171Pages: 314, PDF Size: 3.48 MB
Page 5 of 314
Contents
Tele Aid ........................................ 144
Garage door opener ..................... 153
Operation......................................... 159
The first 1000 miles (1500 km) ......... 160
Driving instructions............................ 161
Drive sensibly – save fuel............. 161
Drinking and driving ..................... 161
Pedals .......................................... 161
Power assistance ......................... 162
Brakes .......................................... 162
Driving off .................................... 163
Parking......................................... 163
Tires ............................................. 164
Hydroplaning................................ 165
Tire traction ................................. 165
Tire speed rating .......................... 166
Winter driving instructions ........... 167
Standing water ............................. 168
Passenger compartment .............. 168
Driving abroad.............................. 168
Control and operation of radio
transmitter ................................... 168
Catalytic converter....................... 169
Emission control .......................... 170Coolant temperature..................... 170
At the gas station ............................... 171
Refueling....................................... 171
Check regularly and before a
long trip ........................................ 172
Engine compartment .......................... 174
Hood ............................................. 174
Engine oil ...................................... 175
Transmission fluid level................. 180
Coolant ......................................... 180
Battery .......................................... 183
Windshield washer system and
headlamp cleaning system*.......... 184
Tires and wheels................................. 185
Important guidelines ..................... 185
Life of tire ..................................... 186
Direction of rotation...................... 186
Checking tire inflation pressure .... 186
Rotating wheels ............................ 187
Winter driving ..................................... 188
Winter tires ................................... 188
Block heater (Canada only) ........... 189
Snow chains.................................. 189
Maintenance....................................... 190
Clearing the service indicator ....... 190
Service term exceeded ................. 191Calling up the service indicator .... 191
Resetting the service indicator ..... 191
Vehicle care ....................................... 192
Cleaning and care of vehicle ......... 192
Practical hints.................................. 199
What to do if … ................................... 200
Lamps in instrument cluster ......... 200
Additional indicators in the
speedometer display .................... 210
Lamp in center console ................ 211
Where will I find ...? ............................ 212
First aid kit.................................... 212
Vehicle tool kit, vehicle jack ......... 212
Spare wheel (SLK 230
Kompressor, SLK 320) .................. 213
TIREFIT kit (SLK 32 AMG only) ...... 214
Unlocking/locking in an emergency .. 216
Unlocking the vehicle ................... 216
Locking the vehicle ....................... 217
Changing batteries in remote
control .......................................... 218
Synchronizing remote control ....... 219
Fuel filler flap ................................ 219
Page 6 of 314
Contents
Manually unlocking the
transmission selector lever .......... 220
Opening/closing in an emergency ..... 221
Raising retractable hardtop
manually ...................................... 221
Replacing bulbs ................................. 226
Bulbs ............................................ 226
Replacing bulbs for front lamps.... 228
Replacing bulbs for rear lamps ..... 230
Adjusting headlamp aim
(Halogen headlamps only) ............ 231
Replacing wiper blades ...................... 233
Removing wiper blades ................ 233
Installing wiper blades.................. 234
Flat tire .............................................. 235
Preparing the vehicle.................... 235
Sealing tires with TIREFIT kit 1 ..... 235
Sealing tires with TIREFIT kit 2 ..... 240
Mounting the spare wheel ............ 244
Battery ............................................... 251
Disconnecting the battery ............ 252
Removing the battery ................... 252
Charging and reinstalling battery . 252
Reconnecting the battery ............. 252
Jump starting ..................................... 254Towing the vehicle ............................. 256
Towing eye ................................... 258
Installing towing eye bolt ............. 259
Fuses ................................................. 260
Main fuse box............................... 260
Auxiliary fuse box ......................... 261
Technical data................................. 263
Spare parts service ............................ 264
Warranty coverage............................. 265
Loss of Service and Warranty
Information Booklet ..................... 265
Identification labels ........................... 266
Layout of poly-V-belt drive ................. 267
SLK 230 Kompressor ................... 267
SLK 320 ....................................... 267
SLK 32 AMG................................. 267
Engine................................................ 268
Rims and Tires ................................... 269
Same size tires ............................. 270
Mixed size tires ............................ 271
Spare wheel with collapsible tire.. 273
Electrical system ............................... 274
Main Dimensions ............................... 275
Weights.............................................. 276Fuels, coolants, lubricants etc. .......... 277
Capacities .................................... 277
Engine oils ................................... 279
Engine oil additives ...................... 279
Air conditioning refrigerant .......... 279
Brake fluid.................................... 279
Premium unleaded gasoline ......... 280
Fuel requirements ........................ 280
Gasoline additives ........................ 280
Coolants ...................................... 281
Windshield washer system and
headlamp washer system* .......... 283
Consumer information ....................... 284
Uniform tire quality grading ......... 284
Technical terms............................... 287Index................................................. 293
Page 163 of 314
163 Operation
Driving instructions
After hard braking, it is advisable to drive
on for some time, rather than immediately
parking, so that the air stream will cool
down the brakes faster.
Driving off
Apply the brakes to test them briefly after
driving off. Perform this procedure only
when the road is clear of other traffic.
Warm up the engine smoothly. Do not
place full load on the engine until the oper-
ating temperature has been reached.
When starting off on a slippery surface, do
not allow a drive wheel to spin for an ex-
tended period with the ESP switched off.
Doing so may cause serious damage to the
drivetrain which is not covered by the
Mercedes-Benz Limited Warranty.
Parking
Warning!
G
If other than recommended brake pads are
installed, or other than recommended brake
fluid is used, the braking properties of the
vehicle can be degraded to an extent that
safe braking is substantially impaired. This
could result in an accident.!When driving down long and steep
grades, relieve the load on the brakes
by shifting into a lower gear to use the
engine’s braking power. This helps pre-
vent overheating of the brakes and re-
duces brake pad wear.
!Simultaneously depressing the acceler-
ator pedal and applying the brake re-
duces engine performance and causes
premature brake and drivetrain wear.
Warning!
G
Do not park this vehicle in areas where com-
bustible materials such as grass, hay or
leaves can come into contact with the hot
exhaust system, as these materials could be
ignited and cause a vehicle fire.
To reduce the risk of personal injury as a re-
sult of vehicle movement, before turning off
the engine and leaving the vehicle always:
Keep right foot on brake pedal.
Firmly depress parking brake pedal.
Move the selector lever to positionP
(manual transmission: first or reverse
gear).
Slowly release brake pedal.
When parked on an incline, turn front
wheels towards the road curb.
Turn the key to steering lock position0.
Take the key and lock vehicle when
leaving.
Page 180 of 314
180 OperationEngine compartmentBe careful not to spill any oil when adding.
Avoid environmental damage caused by oil
entering the ground or water.
Screw filler cap2 back on filler neck.
More information on engine oil can be
found in the “Technical data” section
(
page 277) and (
page 279).
Transmission fluid level
The transmission fluid level does not need
to be checked. If you notice transmission
fluid loss or gear shifting malfunctions,
have an authorized Mercedes-Benz Center
check the transmission.Coolant
The engine coolant is a mixture of water
and anticorrosion/antifreeze. To check
the coolant level, the vehicle must be
parked on level ground and the engine
must be cool.
The coolant expansion tank is located on
the passenger side of the engine compart-
ment.
!Excess oil must be siphoned or drained
off. It could cause damage to the
engine and catalytic converter not
covered by the Mercedes-Benz Limited
Warranty.
Warning!
G
In order to avoid any possibly serious burns:
Use extreme caution when opening the
hood if there are any signs of steam or
coolant leaking from the cooling system,
or if the coolant temperature gauge indi-
cates that the coolant is overheated.
Do not remove pressure cap on coolant
reservoir if engine temperature is above
194°F (90°C). Allow engine to cool
down before removing cap. The coolant
reservoir contains hot fluid and is under
pressure.
Using a rag, slowly open the cap approx-
imately ½ turn to relieve excess pres-
sure. If opened immediately, scalding
hot fluid and steam will be blown out un-
der pressure.
Do not spill antifreeze on hot engine
parts. Antifreeze contains ethylene gly-
col which may burn if it comes into con-
tact with hot engine parts.
Page 277 of 314
277 Technical data
Fuels, coolants, lubricants etc.
Fuels, coolants, lubricants etc.
CapacitiesVehicle components and their respective
lubricants must match. Therefore use only
brands tested and approved by Mer-
cedes-Benz.Please refer to the Factory Approved Ser-
vice Products pamphlet, or inquire at your
Mercedes-Benz Center.
Model
Capacity
Fuels, coolants, lubricants etc.
Engine with oil filter
SLK 230 Kompressor
6.1 US qt (5.5 l)
Recommended engine oils
SLK 320
SLK 32 AMG
8.5 US qt (8.0 l)
Automatic transmission*
8.5 US qt (8.0 l)
MB Automatic Transmission Oil
Manual transmission
SLK 230 Kompressor
1.6 US qt (1.5 l)
MB Manual Transmission Oil
SLK 320
1.9 US qt (1.8 l)
Rear axle
1.4 US qt (1.3 l)
Hypoid gear oil SAE 90, 85 W 90
Power steering
approx. 1.1 US qt (1.0 l)
MB Power Steering Fluid
Front wheel hubs
approx. 1.5 oz (43 g) each
High temperature roller bearing grease
Brake system
0.5 US qt (0.5 l)
MB Brake Fluid (DOT 4)
Cooling system
SLK 230 Kompressor
approx. 9.8 US qt (9.3 l)
MB 325.0 Anticorrosion/Antifreeze Agent
SLK 320
approx. 11.8 US qt (11.2 l)
SLK 32 AMG
approx. 15.3 US qt (14.5 l)
Page 294 of 314
294 IndexAlarm
Audible 65, 71, 72
Canceling 71, 72
Visual 71
Alarm system
Anti-theft 71
Alignment bolt 246
Alignment bolt (vehicle tool kit) 287
Anticorrosion/antifreeze 282
Antiglare
Automatic 99
Antilock brake system (ABS) 287
Anti-theft alarm system
Arming 71
Canceling alarm 71, 72
Disarming 71
Anti-theft systems 71
Anti-theft alarm system 71
Immobilizer 71
Tow-away alarm 72
Armrest
Storage compartment 141
Ashtray 142
ATF (automatic transmission fluid)* 180
Audio system 121Audio and telephone, operation 111
Button and soft key operation 115
Cassette mode 118
Operating and display elements 112
Operating safety 111
Operation 115
Radio mode 116
Switching off 115
Switching on 115
Telephone operation 125
Audio systems 111
Automatic antiglare for rear view
mirror 99
Automatic central locking
Activating 80
Deactivating 80
Automatic lighting control
Deactivating 87
Automatic locking when driving 79
Automatic transmission 93
Accelerator position 98
Emergency operation (Limp Home
Mode) 98
Gear ranges 95Gear selector lever position 95
Gear shifting malfunctions 98
Kickdown 98
Manual shifting 94
One-touch gearshifting 94
Program mode selector switch 97
Selector lever position 93
Winter program mode 97
Automatic transmission*
Fluid level 180
Starting with 41
Transmission fluid 180
B
BabySmart
TM
Airbag deactivation system 62
Compatible child seats 62, 287
Self-test 63
BabySmart
TM airbag deactivation
system 287
Backrest tilt 31
Backup lamps 227, 230
Bulbs 227
BAS 67, 287
Page 311 of 314
311 Index
Windows see Side windows
Windshield
Defogging 110
Refilling washer fluid 184
Replacing wiper blades 233
Washer fluid 184, 283
Washer system 283
Windshield washer fluid 283
Filler neck 184
Mixing ratio 283
Refilling 184
Wiping with 45
Windshield washer system 283
Windshield wipers 44
Fast wiper speed 44
Replacing wiper blades 233
Single wipe 45
Switching on 44
Wiping with windshield washer
fluid 45Winter driving 188
Block heater 189
Snow chains 189
Tires 188
Transmission program mode 97
Winter driving instructions 167
Winter tires 188
Wiper blades
Cleaning 195
Installing 234
Removing 233
Removing insert 233
Replacing 233Wiping
And washing simultaneously 45
Interval 44
With windshield washer fluid 45
X
Xenon headlamps* 291