light Mercury Mariner Hybrid 2007 Owner's Manuals

Board Diagnostics System (OBD-II). This OBD-II system protects the
environment by ensuring that your vehicle continues to meet
government emission standards. The OBD-II system also assists your
authorized dealer in properly servicing your vehicle. When the
indicator illuminates, the OBD-II system has detected a malfunction.
Temporary malfunctions may cause the
indicator to illuminate.
Examples are:
1. The vehicle has run out of fuel—the engine may misfire or run poorly.
2. Poor fuel quality or water in the fuel.
3. The fuel cap may not have been securely tightened. SeeFuel filler
capin this chapter.
These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel and/or properly tightening the fuel cap. After three
driving cycles without these or any other temporary malfunctions
present, the
indicator should turn off—A driving cycle consists of a
cold engine startup followed by mixed city/highway driving. No additional
vehicle service is required.
If the
indicator remains on, have your vehicle serviced at the first
available opportunity.
Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If the
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
287

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Check fluid levels with the ignition
in the RUN position. Fluid levels
between the “MIN” and “MAX” lines
are within the normal operating
range; there is no need to add fluid.
If the fluid levels are outside of the
normal operating range the
performance of your brake system could be compromised; seek service
from your authorized dealer immediately.
Brake pad replacement information
The Regenerative Braking System checks the integrity of the brake
system at times when the vehicle is parked. This is done by developing
brake pressure for short periods of time. In order to change the brake
pads, it is necessary to enter the Pad Service Mode. This will prevent
brake pressure from being applied.
To enter the Pad Service Mode, perform the following with the vehicle
stationary:
1. Place the vehicle in Park and turn ignition to the ON position.
2. Apply the brake pedal.
3. Turn the ignition OFF, then ON three times and then release the brake
pedal. The total time elapsed for the three ignition cycles and brake
release must be less than 3 seconds.
The brake warning lamp will:
•flash as stored hydraulic pressure is released.
•remain illuminated once the pressure is completely released.
•flash if the brake is applied.
To exit the Pad Service Mode:
1. Apply the brake pedal and turn the ignition OFF then ON. This will
cause brake pressure to be developed within the brake system. Once
brake pressure is developed, the brake warning light will turn off.
2. The Pad Service Mode will also be exited if the gear shift lever is
moved from the (P) Park position, the vehicle is moved (wheels rotate)
or the ignition is turned OFF.
MAX
MIN
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
288

Convenience
To make your service visit even more convenient, in many cases, you’ll
find extended evening hours and Saturday hours. How’s that for quality
service?
Factory-trained Technicians
Ford and Lincoln Mercury service technicians participate in extensive
factory-sponsored training to help them become the experts on the
operation of your vehicle. Many participate in Ford-sponsored training to
become certified. Ask your dealer about the training and certification
their technicians have received.
Factory Authorized Systems Checks
In the event that your vehicle experiences a component related concern,
please contact your Ford or Lincoln Mercury dealership. The Ford Motor
Company Trained Technicians who work at Ford or Lincoln Mercury
dealerships are specifically trained to understand your vehicle.
A proper repair begins with a thorough system check. A Factory
Authorized Systems Check can ONLY be found at a Ford or Lincoln
Mercury dealership. In some circumstances, the technician may need to
request your authorization to perform additional operations to determine
the final diagnosis. The technician’s goal is to ensure that your vehicle is
fixed right the first time, at the best value to you.
The following list represents several of the Factory Authorized Systems
Checks available at a participating Ford or Lincoln Mercury dealers:
•Air Conditioning
•Check Engine Light
•All Wheel Drive and4X4
•Automatic Transmission
•Engine Cooling and Cabin Heating
•Steering and Suspension
•Charge/Start/Battery
•Wheel Alignment
•Anti-Lock Brake System
Genuine Ford and Motorcraft Replacement Parts
Ford and Lincoln Mercury dealerships stock Ford and Motorcraft
branded replacement parts. These parts meet or exceed Ford Motor
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
304

Company’s specifications, and we stand behind them. Maintenance parts
installed at your Ford or Lincoln Mercury dealership carry a nationwide,
12 months, 12,000 mile parts and labor limited warranty. Your dealer can
give you details.
Value Shopping for Your Vehicle’s Maintenance Needs
Your dealership recognizes the competitive landscape of maintenance and
light repair automotive services. With factory-trained technicians, and
one-stop service from routine maintenance like oil changes and tire
rotations to repairs like brake service, check out the value your Ford and
Lincoln Mercury dealers can offer.
WHICH MAINTENANCE SCHEDULE SHOULD YOU FOLLOW?
Owner Checks and Services
Refer to Mileage Intervals for Additional Checks and Services
Certain basic maintenance checks and inspections should be performed
by the owner or a service technician at the intervals indicated. Service
information and supporting specifications are provided in thisOwner’s
Guide.
Any adverse condition should be brought to the attention of your dealer
or qualified service technician as soon as possible for the proper service
advice. The owner maintenance service checks are generally not covered
by warranties so you may be charged for labor, parts or lubricants used.
Maximum Oil Change Interval
❑12 months, 10,000 miles (16,000 km) or 200 hours of engine operation.
Motorcraft Premium Gold Engine Coolant change interval
❑6 years or 100,000 miles (160,000 km) - change Motorcraft Premium Gold Engine Coolant (whichever comes first)❑After initial change - change Motorcraft Premium Gold Engine Coolant every 3 years or 50,000 miles (80,000 km).
Check every month
❑Check function of all interior and exterior lights❑Check tires for wear and correct air pressure, including spare tire
❑Check windshield washer fluid level
❑Check engine oil level
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
305

Multi-point Inspection
In order to keep your vehicle running right, it is important that you have
the systems on your vehicle checked regularly. This can help identify any
potential issue before there are any problems. Ford Motor Company
suggests the following multi-point inspection to be performed at every
scheduled maintenance as the way to ensure your vehicle keeps running
right.
NORMAL SCHEDULED MAINTENANCE AND LOG
The following section contains the “Normal Schedule”. This schedule is
presented at specific mileage (kilometer) intervals with exceptions
noted.
ADDITIONAL INFORMATION AVAILABLE ON THE WEB
To learn more about the importance of routine and dealer-performed
maintenance on your vehicle, please visit the Ford Customer Service Web
Check every six months
❑Check lap/shoulder belts and seat latches for wear and function❑Check that externally mounted spare tire is properly stowed (tight)
❑Check parking brake for proper operation
❑Check safety warning lamps (brake, ABS, air bag, safety belt) for operation
❑Check cooling system fluid level and coolant strength
❑Check low voltage (underhood) battery connections and clean if necessary
❑Check washer spray, wiper operation and clean all wiper blades (replace as necessary)
❑Check and lubricate all hinges, latches and outside locks. Inspect for correct operation
❑Check and lubricate door rubber weatherstrips. Inspect for excessive wear
❑Check and clean body and door drain holes. Inspect for clogs and obstructions
Multi-point inspection - Recommended at every visit
❑Check and top up fluid levels: brake, engine coolant recovery reservoir, motor/electronics reservoir and window washer.❑Inspect tires for wear and correct air pressure.
❑Check exhaust system for leaks, damage, loose parts and foreign materials.
❑Check low voltage (underhood) battery performance.
❑Check operation of horn, exterior lamps, turn signals and hazard warning lights.
❑Check radiator, coolers and heater and air conditioning hoses.
❑Inspect windshield washer spray and wiper operation.
❑Check windshield for cracks, chips and pitting.
❑Inspect for oil and fluid leaks.
❑Inspect engine air cleaner filter and elements.
❑Inspect half-shaft dust boots.
❑Check shocks, struts and other suspension components for leaks and damage.
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Scheduled Maintenance Guide
306

A
Accessory delay ..........................86
Air cleaner filter ...............291–293
Airbag supplemental restraint
system ........................141, 150, 153
and child safety seats ............143
description ..............141, 150, 153
disposal ....................................156
driver airbag ............143, 151, 154
indicator light .........149, 152, 155
operation .................143, 151, 154
passenger airbag .....143, 151, 154
side airbag ...............................150
All Wheel Drive (AWD),
driving off road .........................211
Ambulance packages ..................10
Anti-lock brake system
(see Brakes) ......................202–203
Anti-theft system ..............114, 117
arming the system ..................117
disarming a triggered
system .....................................118
triggering .................................118
Audio system (see Radio) .........20
Automatic transaxle
fluid, adding ............................289
fluid, checking ........................289
Automatic transmission
driving an automatic
overdrive .................................207
fluid, refill capacities ..............295
fluid, specification ..................295
Auxiliary power point .................84
Axle
lubricant specifications ..........295
refill capacities ........................295
B
Battery .......................................270acid, treating emergencies .....270
jumping a disabled
battery .............................240, 244
maintenance-free ....................270
replacement, specifications ...293
servicing ..................................270
BeltMinder .................................137
Brakes ........................................202
anti-lock ...........................202–203
anti-lock brake system (ABS)
warning light ...........................203
fluid, checking and adding ....288
fluid, refill capacities ..............295
fluid, specifications .................295
lubricant specifications ..........295
parking ....................................204
shift interlock ..........................206
Bulbs ............................................77
C
Capacities for refilling fluids ....295
Cargo area shade ......................102
Cell phone use ............................11
Child safety restraints ..............157
child safety belts ....................157
Child safety seats ......................160
attaching with tether straps ..164
in front seat ............................161
in rear seat ..............................161
Cleaning your vehicle
engine compartment ..............256
instrument panel ....................258
interior .....................................259
interior trim ............................259
plastic parts ............................257
washing ....................................255
waxing .....................................255
wheels ......................................256
wiper blades ............................257
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
326

choosing the right fuel ...........281
comparisons with EPA fuel
economy estimates .................285
detergent in fuel .....................282
filling your vehicle
with fuel ..................278, 280, 283
filter, specifications ........278, 293
fuel pump/high voltage
shut-off switches ....................220
improving fuel economy ........283
octane rating ...................282, 297
quality ......................................282
running out of fuel .................282
safety information relating to
automotive fuels .....................278
Fuses ..................................221, 223
G
Gas cap (see Fuel cap) ............280
Gas mileage
(see Fuel economy) .................283
Gauges .........................................18
H
Hazard flashers .........................219
Head restraints .................119, 122
Headlamps ...................................71
aiming ........................................74
autolamp system .......................71
bulb specifications ....................77
daytime running lights .............73
flash to pass ..............................72
high beam .................................72
replacing bulbs .........................78
turning on and off ....................71
Hood ..........................................264
I
Ignition ...............................199, 297Illuminated visor mirror .............84
Infant seats
(see Safety seats) .....................160
Inspection/maintenance (I/M)
testing ........................................287
Instrument panel
cleaning ...................................258
cluster ........................................14
lighting up panel and
interior .......................................74
J
Jump-starting your
vehicle ................................240, 244
K
Keyless entry system ...............113
autolock ...................................106
keypad .....................................113
locking and unlocking doors ..114
programming entry code .......113
Keys ...........................................115
positions of the ignition .........199
L
Lamps
autolamp system .......................71
bulb replacement
specifications chart ..................77
daytime running light ...............73
fog lamps ...................................73
headlamps .................................71
headlamps, flash to pass ..........72
instrument panel, dimming .....74
interior lamps .....................75–77
replacing bulbs .........................78
Lane change indicator
(see Turn signal) ........................75
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
328

Liftgate ......................................101
Lights, warning and indicator ....14
anti-lock brakes (ABS) ..........203
Load limits .................................188
Loading instructions .................194
Locks
autolock ...................................106
childproof ................................108
Lubricant specifications ...........295
Lug nuts ....................................239
Luggage rack .............................103
M
Manual transmission
fluid capacities ........................295
lubricant specifications ..........295
Message center ...........................92
english/metric button ...............95
system check button ................94
warning messages .....................95
Mirrors .........................................87
automatic dimming rearview
mirror ........................................87
fold away ...................................87
heated ........................................88
side view mirrors (power) .......87
Moon roof ....................................91
Motorcraft parts ........260, 278, 293
N
Navigation system .......................30
quick start .................................35
radio functions ..........................40
setting the clock .......................66
O
Octane rating ............................282Oil (see Engine oil) ..................267
P
Parking brake ............................204
Parts (see Motorcraft parts) ....293
Passenger Occupant
Classification Sensor .................129
Power distribution box
(see Fuses) ...............................225
Power door locks ......................105
Power mirrors .............................87
Power point .................................84
Power steering ..........................204
Power Windows ...........................85
Preparing to drive your
vehicle ........................................205
R
Radio ............................................20
Rear window defroster ...............70
Relays ........................................221
Remote entry system ...............108
illuminated entry ............112–113
locking/unlocking
doors ................................105, 109
panic alarm .............................110
replacement/additional
transmitters .............................111
replacing the batteries ...........110
Reverse sensing system ...........208
Roadside assistance ..................218
Roof rack ...................................103
S
Safety Belt Maintenance ..........136
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
329

Safety belts (see Safety
restraints) ..................127, 131–135
Safety Canopy ...................151, 153
Safety defects, reporting ..........254
Safety restraints ........127, 131–135
belt minder .............................137
extension assembly ................136
for adults .........................132–134
for children .....................156–157
Occupant Classification
Sensor ......................................129
safety belt maintenance .........136
warning light and
chime ...............................136–137
Safety seats for children ..........160
Safety Compliance
Certification Label ....................298
Scheduled Maintenance
Guide .........................................302
General Maintenance
Information .............................302
Normal Scheduled
Maintenance and Log .............306
Special Operating
Conditions ...............................320
What Maintenance Schedule
Should You Follow? ................305
Seat belts
(see Safety restraints) .............127
Seats ..........................................119
child safety seats ....................160
heated ......................................122
SecuriLock passive anti-theft
system ........................................114
Servicing your vehicle ..............262
Setting the clock
AM/FM/In-dash 6 CD ..........23, 27
Snowplowing ...............................10Spark plugs,
specifications .....................293, 297
Special notice
ambulance conversions ............10
utility-type vehicles ..................10
Specification chart,
lubricants ...................................295
Speed control ..............................88
Starting your vehicle ........199, 201
jump starting ..................240, 244
Steering wheel
tilting .........................................83
T
Tilt steering wheel ......................83
Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....184
Warning Displays ......................14
Tires ...................................170–171
alignment ................................177
care ..........................................174
changing ..................................231
checking the pressure ............174
inflating ...................................172
label .........................................183
replacing ..................................176
rotating ....................................178
safety practices .......................177
sidewall information ...............179
snow tires and chains ............188
spare tire .................................229
terminology .............................171
tire grades ...............................171
treadwear ........................170, 175
Towing .......................................194
recreational towing .................198
trailer towing ..........................194
wrecker ....................................247
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
330

Transmission .............................206
brake-shift interlock (BSI) ....206
fluid, checking and adding
(automatic) .............................289
fluid, refill capacities ..............295
lubricant specifications ..........295
Turn signal ..................................75
V
Vehicle Identification Number
(VIN) ..........................................298
Vehicle loading ..........................188
Ventilating your vehicle ...........202
W
Warning lights (see Lights) .......14Washer fluid
..............................266
Water, Driving through
.............217
Windows
power
.........................................85
rear wiper/washer
.....................83
Windshield washer fluid and
wipers
checking and adding fluid
.....266
liftgate reservoir
.....................266
operation
...................................82
replacing wiper blades
...........267
Wrecker towing
.........................247
2007 Mariner Hybrid(mhv)
Owners Guide (post-2002-fmt)
USA(fus)
Index
331