index Mercury Montego 2005 Owner's Manuals

Maintenance and Specifications 213
Engine compartment 215
Engine oil 216
Battery 220
Engine Coolant 222
Fuel information 228
Part numbers 241
Refill capacities 242
Lubricant specifications 245
Accessories 251
Index 253
All rights reserved. Reproduction by any means, electronic or mechanical
including photocopying, recording or by any information storage and retrieval
system or translation in whole or part is not permitted without written
authorization from Ford Motor Company. Ford may change the contents without
notice and without incurring obligation.
Copyright © 2004 Ford Motor Company
Table of Contents
3
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)

Information on “P” type tires
P215/65R15 95H is an example of a
tire size, load index and speed
rating. The definitions of these
items are listed below. (Note that
the tire size, load index and speed
rating for your vehicle may be
different from this example.)
1.P:Indicates a tire, designated by
the Tire and Rim Association
(T&RA), that may be used for
service on cars, SUVs, minivans and
light trucks.
Note:If your tire size does not
begin with a letter this may mean it
is designated by either ETRTO
(European Tire and Rim Technical Organization) or JATMA (Japan Tire
Manufacturing Association).
2.215:Indicates the nominal width of the tire in millimeters from
sidewall edge to sidewall edge. In general, the larger the number, the
wider the tire.
3.65:Indicates the aspect ratio which gives the tire’s ratio of height to
width.
4.R:Indicates a “radial” type tire.
5.15:Indicates the wheel or rim diameter in inches. If you change your
wheel size, you will have to purchase new tires to match the new wheel
diameter.
6.95:Indicates the tire’s load index. It is an index that relates to how
much weight a tire can carry. You may find this information in your
Owner’s Guide.If not, contact a local tire dealer.
Note:You may not find this information on all tires because it is not
required by federal law.
7.H:Indicates the tire’s speed rating. The speed rating denotes the
speed at which a tire is designed to be driven for extended periods of
time under a standard condition of load and inflation pressure. The tires
on your vehicle may operate at different conditions for load and inflation
pressure. These speed ratings may need to be adjusted for the difference
in conditions. The ratings range from 81 mph (130 km/h) to 186 mph
(299 km/h). These ratings are listed in the following chart.
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Tires, Wheels and Loading
143

If you did not take advantage of the Ford Extended Service Plan at the
time of purchasing your vehicle, you may still be eligible. Since this
information is subject to change, please ask your dealer for complete
details about Ford Extended Service Plan coverage options, or visit the
Ford ESP website at www.ford-esp.com.
GETTING ASSISTANCE OUTSIDE THE U.S. AND CANADA
Before exporting your vehicle to a foreign country, contact the
appropriate foreign embassy or consulate. These officials can inform you
of local vehicle registration regulations and where to find unleaded fuel.
If you cannot find unleaded fuel or can only get fuel with an anti-knock
index lower than is recommended for your vehicle, contact a regional
office or owner relations/customer relationship office.
The use of leaded fuel in your vehicle without proper conversion may
damage the effectiveness of your emission control system and may cause
engine knocking or serious engine damage. Ford Motor Company/Ford of
Canada is not responsible for any damage caused by use of improper
fuel. Using leaded fuel may also result in difficulty importing your vehicle
back into the U.S.
If your vehicle must be serviced while you are traveling or living in
Central or South America, the Caribbean, or the Middle East, contact the
nearest Ford dealership. If the dealership cannot help you, write or call:
FORD MOTOR COMPANY
WORLDWIDE DIRECT MARKET OPERATIONS
1555 Fairlane Drive
Fairlane Business Park #3
Allen Park, Michigan 48101
U.S.A.
Telephone: (313) 594-4857
FAX: (313) 390-0804
If you are in another foreign country, contact the nearest Ford
dealership. If the dealership employees cannot help you, they can direct
you to the nearest Ford affiliate office.
If you buy your vehicle in North America and then relocate outside of
the U.S. or Canada, register your vehicle identification number (VIN) and
new address with Ford Motor Company Worldwide Direct Market
Operations.
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Customer Assistance
205

Refueling
Fuel vapor burns violently and a fuel fire can cause severe
injuries. To help avoid injuries to you and others:
•Read and follow all the instructions on the pump island;
•Turn off your engine when you are refueling;
•Do not smoke if you are near fuel or refueling your vehicle;
•Keep sparks, flames and smoking materials away from fuel;
•Stay outside your vehicle and do not leave the fuel pump unattended
when refueling your vehicle — this is against the law in some places;
•Keep children away from the fuel pump; never let children pump fuel
Use the following guidelines to avoid static build-up when filling an
ungrounded fuel container:
•Place approved fuel container on the ground.
•DO NOT fill a fuel container while it is in the vehicle (including the
cargo area).
•Keep the fuel pump nozzle in contact with the fuel container while
filling.
•DO NOT use a device that would hold the fuel pump handle in the fill
position.
Fuel Filler Cap
Your fuel tank filler cap has an indexed design with a 1/4 turn on/off
feature.
When fueling your vehicle:
1. Turn the engine off.
2. Carefully turn the filler cap counterclockwise 1/4 of a turn until it
stops.
3. Pull to remove the cap from the fuel filler pipe.
4. To install the cap, align the tabs on the cap with the notches on the
filler pipe.
5. Turn the filler cap clockwise 1/4 of a turn until it clicks at least once.
If the
indicator comes on and stays on after you start the engine, the
fuel filler cap may not be properly installed. Turn off the engine, remove
the fuel filler cap, align the cap properly and reinstall it.
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
230

A
Accessory delay ..........................46
Air bag supplemental
restraint system ........107, 114, 116
and child safety seats ............109
description ..............107, 114, 116
disposal ....................................119
driver air bag ..........109, 115, 117
indicator light .................114, 119
operation .................109, 115, 117
passenger air bag ...109, 115, 117
side air bag ..............................114
Air cleaner filter .......................241
Air conditioning ....................26, 28
All Wheel Drive (AWD),
driving off road .........................175
Antifreeze
(see Engine coolant) ................222
Anti-lock brake system
(see Brakes) ..............................166
Anti-theft system ........................84
arming the system ....................85
disarming a triggered
system .......................................86
Audio system
(see Radio) ............................16, 19
Automatic transaxle
fluid, adding ............................239
fluid, checking ........................239
fluid, refill capacities ..............242
fluid, specification ..................247
Automatic transmission
driving an automatic
overdrive .........................170, 172
Axle
lubricant specifications ..........245
B
Battery .......................................220acid, treating emergencies .....220
jumping a disabled battery ....191
maintenance-free ....................220
replacement, specifications ...241
servicing ..................................220
BeltMinder .................................102
Brakes ........................................166
anti-lock ...................................166
anti-lock brake system
(ABS) warning light ...............166
fluid, checking and adding ....239
fluid, refill capacities ..............242
fluid, specifications .........245, 247
lubricant specifications ..245, 247
parking ....................................167
shift interlock ..........................169
Bulbs ............................................36
C
Capacities for refilling fluids ....242
Cargo net .....................................69
Cassette tape player ...................16
Cell phone use ............................68
Certification Label ....................248
Changing a tire .........................135
Child safety restraints ..............120
child safety belts ....................120
Child safety seats ......................122
attaching with tether straps ..126
in front seat ............................124
in rear seat ..............................124
Cleaning your vehicle
engine compartment ..............208
instrument panel ....................210
interior .....................................210
interior trim ............................210
plastic parts ............................209
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
253

washing ....................................207
waxing .....................................207
wheels ......................................208
wiper blades ............................209
Climate control (see Air
conditioning or Heating) ......26, 28
Clock ............................................43
Clock adjust
6-CD in dash .............................20
Compass, electronic
set zone adjustment .................59
Console ........................................68
overhead ....................................43
Controls
power seat .................................90
steering column ........................51
Coolant
checking and adding ..............222
refill capacities ................227, 242
specifications ..................245, 247
Cruise control
(see Speed control) ....................48
Cupholder(s) ...............................93
Customer Assistance ................182
Ford accessories for your
vehicle .....................................211
Ford Extended Service
Plan ..........................................204
Getting assistance outside the
U.S. and Canada .....................205
Getting roadside assistance ...182
Getting the service
you need .................................198
Ordering additional owner’s
literature .................................206
The Dispute Settlement
Board .......................................201
Utilizing the Mediation/
Arbitration Program ...............204D
Daytime running lamps
(see Lamps) ................................33
Dipstick
automatic transmission
fluid ..........................................239
engine oil .................................216
Doors
lubricant specifications ..........245
Driving under special
conditions ..........................176, 179
sand .........................................177
snow and ice ...........................180
through water .................178, 181
E
Electronic message center .........57
Emergencies, roadside
jump-starting ..........................191
Emission control system ..........236
Engine ........................................247
cleaning ...................................208
coolant .....................................222
idle speed control ...................220
lubrication
specifications ..................245, 247
refill capacities ........................242
service points ..........................215
starting after a collision .........183
Engine block heater .................165
Engine oil ..................................216
change oil soon warning,
message center .......................216
checking and adding ..............216
dipstick ....................................216
filter, specifications ........219, 241
recommendations ...................219
refill capacities ........................242
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
254

specifications ..................245, 247
Exhaust fumes ..........................165
F
Fluid capacities .........................242
Foglamps .....................................33
Four-Wheel Drive vehicles
driving off road .......................175
Fuel ............................................228
calculating fuel
economy ............................58, 233
cap ...........................................230
capacity ...................................242
choosing the right fuel ...........231
comparisons with EPA fuel
economy estimates .................236
detergent in fuel .....................232
filling your vehicle
with fuel ..................228, 230, 233
filter, specifications ........232, 241
fuel pump shut-off switch .....183
improving fuel economy ........233
octane rating ...................231, 247
quality ......................................232
running out of fuel .................232
safety information relating to
automotive fuels .....................228
Fuel pump shut-off switch .......183
Fuses ..........................................184
G
Garage Door Opener
(see Homelink wireless
control system) ...........................53
Gas cap (see Fuel cap) ............230
Gas mileage
(see Fuel economy) .................233
Gauges .........................................14H
Hazard flashers .........................183
Head restraints .....................87, 92
Headlamps ...................................32
aiming ..................................34–35
autolamp system .......................32
bulb specifications ....................36
daytime running lights .............33
flash to pass ..............................34
high beam .................................34
replacing bulbs .........................37
turning on and off ....................32
Heating
heating and air conditioning
system ...........................24, 26, 28
Homelink wireless control
system ..........................................53
Hood ..........................................214
I
Ignition ...............................162, 247
Infant seats
(see Safety seats) .....................122
Inspection/maintenance
(I/M) testing ..............................238
Instrument panel ........................43
cleaning ...................................210
cluster ........................................10
lighting up panel and
interior .......................................34
J
Jack ............................................135
positioning ...............................135
storage .....................................135
Jump-starting your vehicle ......191
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
255

K
Keyless entry system .................78
autolock .....................................80
Keys
positions of the ignition .........162
L
Lamps
autolamp system .......................32
bulb replacement
specifications chart ..................36
daytime running light ...............33
fog lamps ...................................33
headlamps .................................32
headlamps, flash to pass ..........34
instrument panel, dimming .....34
interior lamps ...........................36
replacing bulbs ...................36–40
Lane change indicator
(see Turn signal) ........................36
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........166
Load limits .................................152
Locks
autolock .....................................80
childproof ..................................71
doors ..........................................70
Lubricant specifications ...245, 247
Lug nuts ....................................142
Lumbar support, seats ...............88
M
Message center ...........................57
english/metric button ...............61
system check button ................62
warning messages .....................62
Mirrors ...................................43, 47automatic dimming rearview
mirror ........................................47
fold away ...................................47
side view mirrors (power) .......47
Moon roof ....................................52
Motorcraft parts ................232, 241
O
Octane rating ............................231
Oil (see Engine oil) ..................216
P
Parking brake ............................167
Parts (see Motorcraft parts) ....241
Passenger Occupant
Classification Sensor ...................95
Power adjustable foot pedals .....48
Power distribution box
(see Fuses) ...............................187
Power door locks ........................70
Power mirrors .............................47
Power point .................................44
Power steering ..........................168
fluid, checking and adding ....238
fluid, refill capacity ................242
fluid, specifications .........245, 247
Power Windows ...........................44
R
Radio ......................................16, 19
Relays ........................................184
Remote entry system .................73
illuminated entry ................77–78
opening the trunk .....................74
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
256

Reverse sensing system ...........173
Roadside assistance ..................182
S
Safety Belt Maintenance ..........106
Safety belts
(see Safety restraints) .94, 97–101
Safety Canopy ...........................116
Safety defects, reporting ..........206
Safety restraints ............94, 97–101
belt minder .............................102
extension assembly ................106
for adults ...........................98–100
for children .....................119–120
Occupant Classification
Sensor ........................................95
safety belt maintenance .........106
warning light and chime ........101
Safety seats for children ..........122
Seat belts
(see Safety restraints) ...............94
Seats ............................................87
child safety seats ....................122
front seats .....................87, 89, 91
heated ........................................28
memory seat .......................75, 91
Servicing your vehicle ..............213
Setting the clock
AM/FM/In-dash 6 CD ................20
Spare tire (see
Changing the Tire) ...........135, 138
Spark plugs,
specifications .....................241, 247
Specification chart,
lubricants ...........................245, 247
Speed control ..............................48Starting your
vehicle ........................162–163, 165
jump starting ..........................191
Steering wheel
controls ......................................51
tilting .........................................42
T
Tilt steering wheel ......................42
Tires ...........................130–131, 135
alignment ................................149
care ..........................................147
changing ..........................135, 138
checking the pressure ............133
inspecting and inflating .........132
label .........................................147
replacing ..................................134
rotating ....................................149
safety practices .......................148
sidewall information ...............142
snow tires and chains ............151
spare tire .................................136
terminology .............................131
tire grades ...............................131
treadwear ........................130, 147
Towing .......................................158
recreational towing .................161
trailer towing ..........................158
wrecker ....................................196
Traction control ........................167
Transaxle
fluid, refill capacities ..............242
lubricant specifications ..........247
Transmission .............................169
brake-shift interlock (BSI) ....169
fluid, checking and adding
(automatic) .............................239
lubricant specifications ..........245
Trunk ...........................................71
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
257

remote release ....................69, 74
Turn signal ..................................36
V
Vehicle dimensions ...................247
Vehicle Identification Number
(VIN) ..........................................249
Vehicle loading ..........................152
Ventilating your vehicle ...........165
W
Warning lights (see Lights) .......10Washer fluid
..............................216
Water, Driving through
.............181
Windows
power
.........................................44
Windshield washer fluid and
wipers
checking and adding fluid
.....216
operation
...................................41
replacing wiper blades
.............42
Wrecker towing
.........................196
2005 Montego(mgo)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
258