automatic transmission fluid Mercury Montego 2006 Owner's Manuals

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
3.0L DOHC V6 DURATEC ENGINE
1. Engine coolant reservoir
2. Power steering fluid reservoir
3. Engine coolant bleed plug
4. Brake fluid reservoir
5. Battery
6. Power distribution box
7. Air filter assembly
8. 6–speed automatic transmission fluid dipstick (if equipped)
9. Engine oil dipstick
10. Engine oil filler cap
11. Windshield washer fluid reservoir
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
227

If your transaxle does not engage normally, do not attempt to
drive. The vehicle should be towed to your authorized dealer for
evaluation.
Checking 6–speed automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Checking automatic transmission fluid at operating temperature
(158°F-176°F [70°C-80°C])
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry, lint-free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect
the fluid level. The fluid should read
within the hot range on the dipstick
if at normal operating temperature
(158°F-176°F [70°C-80°C]).
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
252

Checking automatic transmission fluid at cool temperature
(32°F-81°F [17°C-27°C])
If a fluid check is necessary at a low
fluid temperature (32°F-81°F
[17°C-27°C]), perform the check
using the cold range on the dipstick.
However, the fluid must be re-checked at the proper fluid temperature.
Low fluid level
Do not drive the vehicle if the fluid
level does not show at all on the
dipstick.
High fluid level
Fluid levels above the safe range
may result in transaxle failure. An
overfill condition of transmission
fluid may cause shift and/or
engagement concerns and/or
possible damage.
High fluid levels can be caused by an overheating condition.
Adjusting automatic transmission fluid levels
Before adding any fluid, make sure the correct type is used. The type of
fluid used is normally indicated on the dipstick and also in the
Lubricant specificationssection in this chapter.
Note:Only one ATF fluid specification has been tested and approved for
use with 6-speed—Premium Automatic Transmission fluid. Mercon fluids
can not be used in a automatic 6-speed without damage or voiding
warranty.
Use of a non-approved automatic transmission fluid may cause
internal transaxle component damage.
If necessary, add fluid in 1/2 pint (250 mL) increments through the filler
tube until the level is correct.
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
253

Fluid Ford Part
NameApplication Capacity
Automatic
transaxleMotorcraft
Continuously
Variable Chain
Type
Transmission
Fluid
3
CVT automatic
transaxle10.0 quarts
(9.5L)4
Premium
Automatic
Transmission
Fluid
3
6–speed
automatic
transaxle7.4 quarts (7.0L)4
Rear Axle
LubricantMotorcraft SAE
80W-90
Premium Rear
Axle LubricantAWD 1.5 pints (0.7L)
Coupler Volvo
Transmission
Oil, ClutchCoupler 1.5 pints (0.7L)
Power Transfer
Unit (PTU)
fluidMotorcraft
Specialty
Power Transfer
Unit FluidPower Transfer
Unit (PTU)1.9 pints (0.9L)
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateAll 101 oz (3.0L)
1Add the coolant type originally equipped in your vehicle.2Use of synthetic or synthetic blend motor oil is not mandatory. Engine
oil need only meet the requirements of Ford specification
WSS-M2C930-A and the API Certification mark.
3Using any transmission fluid other than those that meet the
recommended specification may cause internal transaxle damage.
4Approximate dry fill capacity. Actual amount may vary during fluid
changes.
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
256

LUBRICANT SPECIFICATIONS
ItemsFord Part
Name or
equivalentFord Part
NumberFord
Specification
Brake fluid Motorcraft High
Performance
DOT 3 Motor
Vehicle Brake
FluidPM-1 or PM-1-C ESA-M6C25-A
or
WSS-M6C62-A
Door latch, hood
latch, auxiliary
hood latch, seat
tracks, trunk
and liftgate
latchesMulti-Purpose
GreaseXG-4 or XL-5 ESA-M1C93-B
Lock cylinders Motorcraft
Penetrating and
Lock LubricantXL-1 none
Automatic CVT
transaxleMotorcraft
Continuously
Variable Chain
Type
Transmission
Fluid
1
XT-7-QCFT WSS-M2C933–A
Automatic
6-speed
transaxleMotorcraft
Premium
Automatic
Transmission
Fluid
1
XT-8-QAW WSS-M2C924-A
Rear Axle
(AWD)Motorcraft SAE
80W-90
Premium Rear
Axle LubricantXY-80W90-QL WSP-M2C197–A
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
257

A
Accessory delay ..........................59
Air cleaner filter .......................254
Air conditioning ....................39, 41
Airbag supplemental restraint
system ........................118, 127, 129
and child safety seats ............120
description ..............118, 127, 129
disposal ....................................132
driver airbag ............120, 127, 130
indicator light .................126, 132
operation .................120, 127, 130
passenger airbag .....120, 127, 130
side airbag ...............................127
All Wheel Drive (AWD),
driving off road .........................181
Antifreeze
(see Engine coolant) ................234
Anti-lock brake system
(see Brakes) ......................171–172
Anti-theft system ..................92, 95
arming the system ....................95
disarming a triggered
system .......................................96
triggering ...................................96
Audio system (see Radio) ...16, 19
Automatic transaxle
fluid, adding ....................251–252
fluid, checking ................251–252
fluid, refill capacities ..............255
fluid, specification ..................259
Automatic transmission
driving an automatic
overdrive .........................176, 178
Axle
lubricant specifications ..........257
B
Battery .......................................232acid, treating emergencies .....232
jumping a disabled battery ....203
maintenance-free ....................232
replacement, specifications ...254
servicing ..................................232
BeltMinder .................................113
Brakes ........................................171
anti-lock ...........................171–172
anti-lock brake system
(ABS) warning light ...............172
fluid, checking and adding ....251
fluid, refill capacities ..............255
fluid, specifications .........257, 259
lubricant specifications ..257, 259
parking ....................................172
shift interlock ..........................175
Bulbs ............................................49
C
Capacities for refilling fluids ....255
Cargo net .....................................79
Cassette tape player ...................16
Cell phone use ..............................7
Changing a tire .........................197
Child safety restraints ..............133
child safety belts ....................133
Child safety seats ......................136
attaching with tether straps ..140
in front seat ............................137
in rear seat ..............................137
Cleaning your vehicle
engine compartment ..............220
instrument panel ....................221
interior .....................................222
interior trim ............................222
plastic parts ............................220
washing ....................................218
waxing .....................................219
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
265

wheels ......................................219
wiper blades ............................221
Climate control (see Air
conditioning or Heating) ......39, 41
Clock ............................................56
Clock adjust
6-CD in dash .............................20
AM/FM/CD .................................16
Compass, electronic
set zone adjustment .................72
Console ........................................56
overhead ..............................55–56
Controls
power seat ...............................100
steering column ........................64
Coolant
checking and adding ..............234
refill capacities ................239, 255
specifications ..................257, 259
Cruise control
(see Speed control) ....................61
Cupholder(s) .............................104
Customer Assistance ................188
Ford Extended Service
Plan ..........................................215
Getting assistance outside
the U.S. and Canada ..............216
Getting roadside assistance ...188
Getting the service you
need .........................................211
Ordering additional owner’s
literature .................................216
Utilizing the Mediation/
Arbitration Program ...............214
D
Daytime running lamps
(see Lamps) ................................47Dipstick
automatic transmission
fluid ..................................251–252
engine oil .................................229
Doors
lubricant specifications ..........257
Driving under special
conditions ..........................182, 185
sand .........................................183
snow and ice ...........................186
through water .................184, 187
E
Electronic message center .........70
Emergencies, roadside
jump-starting ..........................203
Emission control system ..........248
Engine ........................................259
cleaning ...................................220
coolant .....................................234
idle speed control ...................232
lubrication
specifications ..................257, 259
refill capacities ........................255
service points ..........................227
starting after a collision .........190
Engine block heater .................171
Engine oil ..................................229
change oil soon warning,
message center .......................229
checking and adding ..............229
dipstick ....................................229
filter, specifications ........231, 254
recommendations ...................231
refill capacities ........................255
specifications ..................257, 259
Exhaust fumes ..........................171
F
Fluid capacities .........................255
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
266

Transaxle
fluid, checking and adding
(automatic) .....................251–252
fluid, refill capacities ..............255
lubricant specifications ..........259
Transmission .............................175
brake-shift interlock (BSI) ....175
lubricant specifications ..........257
Trunk ...........................................82
remote release ....................79, 84
Turn signal ..................................49
V
Vehicle dimensions ...................259
Vehicle Identification Number
(VIN) ..........................................261
Vehicle loading ..........................158Ventilating your vehicle
...........171
W
Warning lights (see Lights)
.......10
Washer fluid
..............................228
Water, Driving through
.............187
Windows
power
.........................................57
Windshield washer fluid and
wipers
checking and adding fluid
.....228
operation
...................................54
replacing wiper blades
...........228
Wrecker towing
.........................209
2006 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
270