check engine Mercury Montego 2007 s Owner's Guide

Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If the
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Refer to thescheduled maintenance informationfor the service
interval schedules. If adding fluid is necessary, use only MERCON
AT F.
1. Start the engine and let it run
until it reaches normal operating
temperature (the engine coolant
temperature gauge indicator will be
near the center of the normal area
between H and C).
2. While the engine idles, turn the
steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is in this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the range between the MIN and MAX lines. Be
sure to put the cap back on the reservoir.
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
261

If your transaxle does not engage normally, do not attempt to
drive. The vehicle should be towed to your authorized dealer for
evaluation.
Checking 6–speed automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Checking automatic transmission fluid at operating temperature
(158°F-176°F [70°C-80°C])
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry, lint-free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect
the fluid level. The fluid should read
within the hot range on the dipstick
if at normal operating temperature
(158°F-176°F [70°C-80°C]).
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
263

The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
System
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS
You can find a
transmission/transaxle code on the
Safety Compliance Certification
Label. The following table tells you
which transmission or transaxle
each code represents.
Description Code
CVT (continuously variable transaxle) C
Six-speed automatic (Aisin F21) A
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
270

A
Accessory delay ..........................67
Air cleaner filter .......................265
Air conditioning ....................46, 48
Airbag supplemental restraint
system ........................127, 136, 138
and child safety seats ............129
description ..............127, 136, 138
disposal ....................................141
driver airbag ............129, 137, 139
indicator light .................135, 141
operation .................129, 137, 139
passenger airbag .....129, 137, 139
side airbag ...............................136
All Wheel Drive (AWD),
driving off road .........................190
Antifreeze
(see Engine coolant) ................245
Anti-lock brake system
(see Brakes) ......................180–181
Anti-theft system ..............100, 104
arming the system ..................104
disarming a triggered
system .....................................105
triggering .................................105
Audio system
(see Radio) ............................16, 21
Automatic transaxle
fluid, adding ....................262–263
fluid, checking ................262–263
fluid, refill capacities ..............266
fluid, specification ..................266
Automatic transmission
driving an automatic
overdrive .........................185, 187
B
Battery .......................................243acid, treating emergencies .....243
jumping a disabled battery ....213
maintenance-free ....................243
replacement, specifications ...265
servicing ..................................243
BeltMinder
...............................123
Brakes ........................................180
anti-lock ...........................180–181
anti-lock brake system (ABS)
warning light ...........................181
fluid, checking and adding ....262
fluid, refill capacities ..............266
fluid, specifications .................266
lubricant specifications ..........266
parking ....................................181
shift interlock ..........................184
Bulbs ............................................56
C
Capacities for refilling fluids ....266
Cargo net .....................................87
Cassette tape player ...................16
Cell phone use ..............................7
Changing a tire .........................206
Child safety restraints ..............142
child safety belts ....................142
Child safety seats ......................145
attaching with tether straps ..149
in front seat ............................146
in rear seat ..............................146
Cleaning your vehicle
engine compartment ..............229
instrument panel ....................231
interior .....................................232
interior trim ............................232
plastic parts ............................230
washing ....................................228
waxing .....................................228
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
273

wheels ......................................229
wiper blades ............................230
Climate control (see Air
conditioning or Heating) ......46, 48
Clock ............................................63
Clock adjust
6-CD in dash .............................23
AM/FM/CD
.................................17
Compass, electronic
set zone adjustment
.................80
Console
........................................64
overhead
....................................63
Controls
power seat
...............................108
steering column
........................72
Coolant
checking and adding
..............245
refill capacities
................250, 266
specifications
..........................266
Cruise control
(see Speed control)
....................69
Cupholder(s)
.............................113
Customer Assistance
................197
Ford Extended Service
Plan
..........................................225
Getting assistance outside the
U.S. and Canada
.....................226
Getting roadside assistance
...197
Getting the service you
need
.........................................221
Ordering additional owner’s
literature
.................................227
Utilizing the
Mediation/Arbitration
Program
...................................225D
Daytime running lamps
(see Lamps) ................................54
Dipstick
automatic transmission
fluid ..................................262–263
engine oil .................................239
Driving under special
conditions ..........................191, 194
sand .........................................192
snow and ice ...........................195
through water .................193, 196
E
Electronic message center .........78
Emergencies, roadside
jump-starting ..........................213
Emission control system ..........259
Engine ........................................268
cleaning ...................................229
coolant .....................................245
idle speed control ...................243
lubrication specifications .......266
refill capacities ........................266
service points ..........................237
starting after a collision .........199
Engine block heater .................180
Engine oil ..................................239
change oil soon warning,
message center .......................239
checking and adding ..............239
dipstick ....................................239
filter, specifications ........242, 265
recommendations ...................242
refill capacities ........................266
specifications ..........................266
Exhaust fumes ..........................180
F
Fluid capacities .........................266
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
274

Keys ...........................................102
positions of the ignition .........177
L
Lamps
autolamp system .......................52
bulb replacement
specifications chart ..................57
daytime running light ...............54
fog lamps ...................................53
headlamps .................................52
headlamps, flash to pass ..........53
instrument panel, dimming .....54
interior lamps .....................56–57
replacing bulbs ...................57, 60
Lane change indicator
(see Turn signal) ........................56
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........181
Load limits .................................168
Locks
autolock .....................................88
childproof ..................................91
doors ..........................................88
Lubricant specifications ...........266
Lug nuts ....................................213
Lumbar support, seats .............107
M
Message center ...........................78
english/metric button ...............83
system check button ................83
warning messages .....................83
Mirrors .........................................67
automatic dimming rearview
mirror ........................................67
fold away ...................................68
heated ........................................68side view mirrors (power) .......67
Moon roof ....................................72
Motorcraft parts ........233, 251, 265
N
Navigation system .......................30
O
Octane rating ............................254
Oil (see Engine oil) ..................239
P
Parking brake ............................181
Parts (see Motorcraft parts) ....265
Passenger Occupant
Classification Sensor .................115
Power adjustable foot pedals .....68
Power distribution box
(see Fuses) ...............................203
Power door locks ........................88
Power mirrors .............................67
Power point .................................64
Power steering ..........................183
fluid, checking and adding ....261
fluid, refill capacity ................266
fluid, specifications .................266
Power Windows ...........................65
R
Radio ......................................16, 21
Relays ........................................200
Remote entry system .................93
illuminated entry ................97–98
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
276