brake Mercury Montego 2007 s Workshop Manual

Keep batteries out of reach of children. Batteries contain sulfuric
acid. Avoid contact with skin, eyes or clothing. Shield your eyes
when working near the battery to protect against possible splashing of
acid solution. In case of acid contact with skin or eyes, flush
immediately with water for a minimum of 15 minutes and get prompt
medical attention. If acid is swallowed, call a physician immediately.
Battery posts, terminals and related accessories contain lead and
lead compounds.Wash hands after handling.
Because your vehicle’s engine is electronically controlled by a computer,
some control conditions are maintained by power from the battery. When
the battery is disconnected or a new battery is installed, the engine must
relearn its idle and fuel trim strategy for optimum driveability and
performance. To begin this process:
1. With the vehicle at a complete stop, set the parking brake.
2. Put the gearshift in P (Park), turn off all accessories and start the
engine.
3. Run the engine until it reaches normal operating temperature.
4. Allow the engine to idle for at least one minute.
5. Turn the A/C on and allow the engine to idle for at least one minute.
6. Release the parking brake. With your foot on the brake pedal and with
the A/C on, put the vehicle in D (Drive) and allow the engine to idle for
at least one minute.
7. Drive the vehicle to complete the relearning process.
•The vehicle may need to be driven 10 miles (16 km) or more to
relearn the idle and fuel trim strategy.
•If you do not allow the engine to relearn its idle trim, the idle
quality of your vehicle may be adversely affected until the idle
trim is eventually relearned.
If the battery has been disconnected or a new battery has been installed,
the clock and radio settings must be reset once the battery is
reconnected.
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
244

•Revving the engine before turning it off may reduce fuel economy.
•Using the air conditioner or defroster may reduce fuel economy.
•You may want to turn off the speed control in hilly terrain if
unnecessary shifting between third and fourth gear occurs.
Unnecessary shifting of this type could result in reduced fuel
economy.
•Warming up a vehicle on cold mornings is not required and may
reduce fuel economy.
•Resting your foot on the brake pedal while driving may reduce fuel
economy.
•Combine errands and minimize stop-and-go driving.
Maintenance
•Keep tires properly inflated and use only recommended size.
•Operating a vehicle with the wheels out of alignment will reduce fuel
economy.
•Use recommended engine oil. Refer toLubricant specificationsin
this chapter.
•Perform all regularly scheduled maintenance items. Follow the
recommended maintenance schedule and owner maintenance checks
found inscheduled maintenance information.
Conditions
•Heavily loading a vehicle or towing a trailer may reduce fuel economy
at any speed.
•Carrying unnecessary weight may reduce fuel economy (approximately
1 mpg [0.4 km/L] is lost for every 400 lb [180 kg] of weight carried).
•Adding certain accessories to your vehicle (for example bug
deflectors, rollbars/light bars, running boards, ski/luggage racks) may
reduce fuel economy.
•Using fuel blended with alcohol may lower fuel economy.
•Fuel economy may decrease with lower temperatures during the first
8–10 miles (12–16 km) of driving.
•Driving on flat terrain offers improved fuel economy as compared to
driving on hilly terrain.
•Transmissions give their best fuel economy when operated in the top
cruise gear and with steady pressure on the gas pedal.
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
258

BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of your
brake system could be
compromised; seek service from
your authorized dealer immediately.
TRANSAXLE FLUID
Checking automatic transaxle fluid—CVT transaxle
Do not use supplemental transaxle fluid additives, treatments or
cleaning agents. The use of these materials or transaxle fluids
other than the recommended fluid, may affect transaxle operation
and result in damage to internal transaxle components.
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid changes. Your transaxle does not consume fluid.
However, the fluid level should be checked if the transaxle is not working
properly, i.e., if the transaxle slips, takes more than a couple of seconds
to engage into Drive/Reverse or if you notice some sign of fluid leakage.
It is recommended that an authorized dealer check fluid level and
add fluid if required.
If your transaxle has a low fluid condition sufficient to affect proper
operation the transaxle control module will send a signal to illuminate
the
on the instrument panel.
As long as the transaxle engages normally to drive or reverse, it is safe
to drive but if the
illuminates the vehicle should be taken to your
authorized dealer for evaluation as soon as possible.
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
262

If your transaxle does not engage normally, do not attempt to
drive. The vehicle should be towed to your authorized dealer for
evaluation.
Checking 6–speed automatic transmission fluid (if equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transaxle does not consume
fluid. However, the fluid level should be checked if the transaxle is not
working properly, i.e., if the transaxle slips or shifts slowly or if you
notice some sign of fluid leakage.
Checking automatic transmission fluid at operating temperature
(158°F-176°F [70°C-80°C])
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 20 miles [30 km]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry, lint-free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect
the fluid level. The fluid should read
within the hot range on the dipstick
if at normal operating temperature
(158°F-176°F [70°C-80°C]).
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
263

MAINTENANCE PRODUCT SPECIFICATIONS AND CAPACITIES
Items CapacityFord Part Name or
equivalentFord Part Number /
Ford Specification
Brake fluidBetween MAX and
MIN on reservoir
Motorcraft High
Performance DOT 3
Motor Vehicle Brake Fluid
PM-1 or PM-1-C /
ESA-M6C25-A or
WSS-M6C62-A
Door latch, hood latch,
auxiliary hood latch,
seat tracks, trunk and
liftgate latches— Multi-Purpose GreaseXG-4 or XL-5 /
ESA-M1C93-B
Lock cylinders —Motorcraft Penetrating
and Lock LubricantXL-1 /
None
Automatic CVT
transaxle fluid10.0 quarts
(9.5L)
1
Motorcraft Continuously
Variable Chain Type
Transmission Fluid
2
XT-7-QCFT /
WSS-M2C933-A
Automatic 6-speed
transaxle fluid7.4 quarts (7.0L)
1
Motorcraft Premium
Automatic Transmission
Fluid
2
XT-8-QAW /
WSS-M2C924-A
Rear Axle (AWD) fluid 1.5 pints (0.7L)Motorcraft SAE 80W-90
Premium Rear Axle
LubricantXY-80W90-QL /
WSP-M2C197-A
Coupler fluid 1.5 pints (0.7L)Volvo Transmission Oil,
Clutch1161641 /
None
Power Transfer Unit
(PTU) fluid1.9 pints (0.9L)
Motorcraft Specialty
Power Transfer Unit Fluid
XY-75W90-PTU /
None
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
266

The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
System
3. Vehicle line, series, body type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
TRANSMISSION/TRANSAXLE CODE DESIGNATIONS
You can find a
transmission/transaxle code on the
Safety Compliance Certification
Label. The following table tells you
which transmission or transaxle
each code represents.
Description Code
CVT (continuously variable transaxle) C
Six-speed automatic (Aisin F21) A
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
270

A
Accessory delay ..........................67
Air cleaner filter .......................265
Air conditioning ....................46, 48
Airbag supplemental restraint
system ........................127, 136, 138
and child safety seats ............129
description ..............127, 136, 138
disposal ....................................141
driver airbag ............129, 137, 139
indicator light .................135, 141
operation .................129, 137, 139
passenger airbag .....129, 137, 139
side airbag ...............................136
All Wheel Drive (AWD),
driving off road .........................190
Antifreeze
(see Engine coolant) ................245
Anti-lock brake system
(see Brakes) ......................180–181
Anti-theft system ..............100, 104
arming the system ..................104
disarming a triggered
system .....................................105
triggering .................................105
Audio system
(see Radio) ............................16, 21
Automatic transaxle
fluid, adding ....................262–263
fluid, checking ................262–263
fluid, refill capacities ..............266
fluid, specification ..................266
Automatic transmission
driving an automatic
overdrive .........................185, 187
B
Battery .......................................243acid, treating emergencies .....243
jumping a disabled battery ....213
maintenance-free ....................243
replacement, specifications ...265
servicing ..................................243
BeltMinder
...............................123
Brakes ........................................180
anti-lock ...........................180–181
anti-lock brake system (ABS)
warning light ...........................181
fluid, checking and adding ....262
fluid, refill capacities ..............266
fluid, specifications .................266
lubricant specifications ..........266
parking ....................................181
shift interlock ..........................184
Bulbs ............................................56
C
Capacities for refilling fluids ....266
Cargo net .....................................87
Cassette tape player ...................16
Cell phone use ..............................7
Changing a tire .........................206
Child safety restraints ..............142
child safety belts ....................142
Child safety seats ......................145
attaching with tether straps ..149
in front seat ............................146
in rear seat ..............................146
Cleaning your vehicle
engine compartment ..............229
instrument panel ....................231
interior .....................................232
interior trim ............................232
plastic parts ............................230
washing ....................................228
waxing .....................................228
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
273

Keys ...........................................102
positions of the ignition .........177
L
Lamps
autolamp system .......................52
bulb replacement
specifications chart ..................57
daytime running light ...............54
fog lamps ...................................53
headlamps .................................52
headlamps, flash to pass ..........53
instrument panel, dimming .....54
interior lamps .....................56–57
replacing bulbs ...................57, 60
Lane change indicator
(see Turn signal) ........................56
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........181
Load limits .................................168
Locks
autolock .....................................88
childproof ..................................91
doors ..........................................88
Lubricant specifications ...........266
Lug nuts ....................................213
Lumbar support, seats .............107
M
Message center ...........................78
english/metric button ...............83
system check button ................83
warning messages .....................83
Mirrors .........................................67
automatic dimming rearview
mirror ........................................67
fold away ...................................68
heated ........................................68side view mirrors (power) .......67
Moon roof ....................................72
Motorcraft parts ........233, 251, 265
N
Navigation system .......................30
O
Octane rating ............................254
Oil (see Engine oil) ..................239
P
Parking brake ............................181
Parts (see Motorcraft parts) ....265
Passenger Occupant
Classification Sensor .................115
Power adjustable foot pedals .....68
Power distribution box
(see Fuses) ...............................203
Power door locks ........................88
Power mirrors .............................67
Power point .................................64
Power steering ..........................183
fluid, checking and adding ....261
fluid, refill capacity ................266
fluid, specifications .................266
Power Windows ...........................65
R
Radio ......................................16, 21
Relays ........................................200
Remote entry system .................93
illuminated entry ................97–98
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
276

wrecker ....................................219
Traction control ........................182
Transaxle
fluid, checking and adding
(automatic) .....................262–263
fluid, refill capacities ..............266
lubricant specifications ..........266
Transmission .............................184
brake-shift interlock (BSI) ....184
Trunk ...........................................91
remote release ....................87, 94
Turn signal ..................................56
V
Vehicle Identification Number
(VIN) ..........................................269
Vehicle loading ..........................168Ventilating your vehicle
...........180
W
Warning lights (see Lights)
.......10
Washer fluid
..............................238
Water, Driving through
.............196
Windows
power
.........................................65
Windshield washer fluid and
wipers
checking and adding fluid
.....238
operation
...................................61
replacing wiper blades
...........239
Wrecker towing
.........................219
2007 Montego(mgo)
Owners Guide (post-2002-fmt)
USA(fus)
Index
278