power steering Mercury Monterey 2005 s User Guide

If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
CHECKING AND ADDING POWER STEERING FLUID
Check the power steering fluid.
Refer to the scheduled maintenance
guide for the service interval
schedules. If adding fluid is
necessary, use only MERCONAT F.
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the correct operating range. Be sure to put the
cap back on the reservoir.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
278

REFILL CAPACITIES
Fluid Ford Part
NameApplication Capacity
Brake fluid Motorcraft High
Performance
DOT 3 Motor
Vehicle Brake
Fluid
1
All Fill to MAX line
on reservoir
Engine oil
(includes filter
change)
3
Motorcraft SAE
5W-20 Premium
Synthetic Blend
Motor Oil (US)
Motorcraft SAE
5W-20 Super
Premium Motor
Oil (Canada)4.2L engine 4.7L (5.0
quarts)
Engine coolant
2Motorcraft
Premium Gold
Engine Coolant
(yellow-colored)Without rear
heater14.0L (14.8
quarts)
With rear heater 15.0L (15.9
quarts)
Power steering
fluidMotorcraft
MERCONAT FAll Fill to line on
reservoir
Fuel tank N/A All 98.4L (26.0
gallons)
Automatic
transaxle fluidMotorcraft
MERCONV
AT FAll 13.0L (13.7
quarts)
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateAll Fill to line on
reservoir
1Use only brake fluids certified to meet Ford specifications. Refer to
Lubricant Specificationsin this chapter. DOT 3 fluid is recommended.
However, if DOT 3 is not available, DOT 4 fluid can be used.
2Add the coolant type originally equipped in your vehicle.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
286

Item Ford part
nameFord part
numberFord
specification
Door latch,
hood latch,
auxiliary hood
latch, door and
liftgate hinges,
striker plates,
seat tracks,
sliding door
both sides
(upper and
lower track)
and fuel filler
door hinge.Multi-Purpose
GreaseXG-4 or XL-5 ESB-M1C93-B
orESR-M1C159-A
Lock cylinders Penetrating and
Lock LubricantXL-1 none
Power steering
fluidMotorcraft
MERCONAT FXT-2-QDX MERCON
Automatic
transaxle
(4F50N)Motorcraft
MERCONV
AT F
2
XT-5-QM MERCONV
Disc brake
caliper railsMotorcraft
Silicone Brake
Caliper Grease
and Dielectric
CompoundXG-3-A ESE-M1C171-A
Constant
velocity jointsMotorcraft CV
Joint Grease
(High Temp.)XG-5 WSS-MIC258-A1
Windshield
washer fluidMotorcraft
Premium
Windshield
Washer
ConcentrateZC-32–A WSB-M8B16–A2
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid
is recommended. However, if DOT 3 is not available, DOT 4 fluid can be
used.
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Maintenance and Specifications
288

wheels ......................................249
wiper blades ............................250
Clock ............................................63
Compass, electronic ....................55
calibration .................................57
set zone adjustment .................56
Console ........................................71
overhead ....................................55
Controls
power seat ...............................110
steering column ........................71
Coolant
checking and adding ..............263
refill capacities ................267, 286
specifications ..................287, 289
Cruise control
(see Speed control) ....................68
Cupholder(s) .............................114
Customer Assistance ................222
Ford accessories for your
vehicle .....................................252
Ford Extended Service
Plan ..........................................245
Getting assistance outside the
U.S. and Canada .....................245
Getting roadside assistance ...222
Getting the service you
need .........................................239
Ordering additional owner’s
literature .................................246
The Dispute Settlement
Board .......................................242
D
Daytime running lamps
(see Lamps) ................................42Dipstick
automatic transmission
fluid ..........................................279
engine oil .................................257
Doors ...........................................58
lubricant specifications ..........287
power sliding ............................59
Driving under special
conditions ..................................217
through water .........................221
E
Emergencies, roadside
jump-starting ..........................232
Emission control system ..........276
Engine ........................................289
cleaning ...................................249
coolant .....................................263
idle speed control ...................261
lubrication
specifications ..................287, 289
refill capacities ........................286
service points ..........................256
starting after a collision .........223
Engine block heater .................209
Engine oil ..................................257
change oil soon warning,
message center .......................257
checking and adding ..............257
dipstick ....................................257
filter, specifications ........260, 285
recommendations ...................260
refill capacities ........................286
specifications ..................287, 289
Exhaust fumes ..........................209
F
Floor mats ...................................72
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
296

bulb replacement
specifications chart ..................48
daytime running light ...............42
fog lamps ...................................41
headlamps .................................41
headlamps, flash to pass ..........43
instrument panel, dimming .....44
interior lamps .....................46–48
replacing bulbs ...................48–52
Lane change indicator
(see Turn signal) ........................46
Liftgate ............................85, 89, 96
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........210
Load limits .................................194
Locks
autolock ...................................103
childproof ..................................92
doors ..........................................91
Low tire warning .................15, 191
Lubricant specifications ...287, 289
Lug nuts ....................................182
Luggage rack ...............................89
Lumbar support, seats .............112
M
Message center ...........................76
english/metric button ...............79
system check button ................79
warning messages .....................80
Mirrors ...................................55, 66
automatic dimming rearview
mirror ........................................66
fold away ...................................67
heated ........................................67
programmable memory ..........100
side view mirrors (power) .......66signal .........................................67
Motorcraft parts ................272, 285
O
Octane rating ............................271
Oil (see Engine oil) ..................257
Overdrive ...................................215
P
Park Assist ................................218
Parking brake ............................211
Parts (see Motorcraft parts) ....285
Passenger Occupant
Classification Sensor .................129
Pedals (see Power adjustable
foot pedals) .................................68
Power adjustable foot pedals .....68
Power distribution box
(see Fuses) ...............................228
Power door locks ................91, 103
Power liftgate ........................85, 96
Power mirrors .............................66
Power point .................................63
Power steering ..........................214
fluid, checking and adding ....278
fluid, refill capacity ................286
fluid, specifications .........287, 289
Power Windows ...........................65
R
Radio ................................17, 20, 23
Relays ........................................224
Remote entry system .................95
2005 Monterey(mty)
Owners Guide (post-2002-fmt)
USA_English(fus)
Index
298