fuel cap Mercury Mountaineer 1998 Owner's Manuals

What you should do if the
check engine light illuminates
Light turns on solid:
This means that the OBD II system
has detected a malfunction.
Temporary malfunctions may cause
yourCheck Enginelight to
illuminate. Examples are:
1. The vehicle has run out of fuel.
(The engine may misfire or run
poorly.)
2. Poor fuel quality or water in the
fuel.
3. The fuel cap may not have been
properly installed and securely
tightened.
These temporary malfunctions can
be corrected by filling the fuel tank
with good quality fuel and/or
properly installing and securely
tightening the gas cap. After three
driving cycles without these or any
other temporary malfunctions
present, theCheck Enginelight
should turn off. (A driving cycle
consists of a cold engine startup
followed by mixed city/highway
driving.) No additional vehicle
service is required.
If theCheck Enginelight remains
on, have your vehicle serviced at
the first available opportunity.
Light is blinking:
Engine misfire is occurring which
could damage your catalytic
converter. You should drive in a
moderate fashion (avoid heavy
acceleration and deceleration) and
Instrumentation
7

Engine oil pressure gauge
This shows the engine oil pressure
in the system. Sufficient pressure
exists as long as the needle
remains in the normal range (the
area between the ªHº and ªLº).
If the gauge indicates low
pressure, switch off the engine
immediately. Check the oil level.
Add oil if needed (refer to
Checking and adding engine oil
in theMaintenance and care
chapter). If the oil level is correct,
have your vehicle checked at your
dealership or by a qualified
technician.
Fuel gauge
Displays approximately how much
fuel is in the fuel tank (when the
key is in the ON position). The
fuel gauge may vary slightly when
the vehicle is in motion. The
ignition should be in the OFF
position while the vehicle is being
refueled. When the gauge first
indicates empty, there is a small
amount of reserve fuel in the tank.
When refueling the vehicle from
empty indication, the amount of
fuel that can be added will be less
than the advertised capacity due to
the reserve fuel.
The FUEL DOOR icon and arrow
indicates which side of the vehicle
the fuel filler door is located.
H
L
EF
Instrumentation
15

for hooking up trailer lamps.
Using a step bumper
The rear bumper is equipped with
an integral hitch and requires only
a ball with a 19 mm (3/4 inch)
shank diameter. The bumper has a
1 590 kg (3 500 lb.) trailer weight
and 159 kg (350 lb.) tongue weight
capability.
Use a frame-mounted weight
distributing hitch for trailers over
1 590 kg (3 500 lb).
Driving while you tow
Do not drive faster than 88 km/h
(55 mph) when towing a trailer.
Speed control may shut off if you
are towing on long, steep grades.
When towing a trailer:
²Use D (Drive) or a lower gear
when towing up or down steep
hills. This will eliminate
excessive downshifting and
upshifting for optimum fuel
economy and transmission
cooling.
²Anticipate stops and brake
gradually.
Servicing after towing
If you tow a trailer for long
distances, your vehicle will require
more frequent service intervals.
Refer to the Severe Duty Schedule
in your ªService Guideº for more
information.
Driving
131

4. Use only a DOT 3 brake fluid
certified to meet Ford
specifications. Refer toLubricant
specificationsin theCapacities
and specificationschapter.
Brake fluid is toxic.
If you use a brake fluid
that is not DOT 3, you will
cause permanent damage to your
brakes.
Do not let the reservoir for
the master cylinder run
dry. This may cause the brakes
to fail.
WINDSHIELD WASHER FLUID
Checking and adding washer
fluid
Check the washer fluid whenever
you stop for fuel. The reservoir is
highlighted with a
symbol.
If the level is low, add enough fluid
to fill the reservoir. In very cold
weather, do not fill the reservoir all
the way.
RADIATOR
COOLANT
ONLY
WASHERFLUIDONLY
Maintenance and care
163

²Remove the tire chains when
they are no longer needed. Do
not use tire chains on dry roads.
²The suspension insulation and
bumpers will help prevent
vehicle damage. Do not remove
these components from your
vehicle when using snow tires
and chains.
WHAT YOU SHOULD KNOW
ABOUT AUTOMOTIVE FUELS
Important safety precautions
Do not overfill the fuel
tank. The pressure in an
overfilled tank may cause
leakage and lead to fuel spray
and fire.
If you do not use the
proper fuel cap, the
pressure in the fuel tank can
damage the fuel system or cause
it to work improperly in a
collision.
The fuel system may be
under pressure. If the fuel
cap is venting vapor or if you
hear a hissing sound, wait until it
stops before completely
removing the cap.
Automotive fuels can
cause serious injury or
death if misused or mishandled.
Maintenance and care
183

MOTORCRAFT PART NUMBERS
Component 4.0L SOHC engine 5.0L engine
Air filter FA-1658 FA-1658
Fuel filter FG-872 FG-872
Battery (standard) BXT-65-650 BXT-65-650
Battery (optional) - BXT-65-850
Oil filter FL-1A FL-820S
PCV valve EV-225 EV-152
Spark plugs* AGRF-22P AWSF-32EE
* Refer to Vehicle Emissions Control Information (VECI) decal for
spark plug gap information.
REFILL CAPACITIES
Fluid Ford Part
NameApplication
Capacity
Engine oil
(including filter
change)Motorcraft 5W30
Super Premium
Motor OilAll
4.7L
(5.0 quarts)
Brake fluid Ford High
Performance
DOT 3 Brake
FluidAll
Fill to the MAX
line on reservoir
Power steering
fluidMotorcraft
MERCONtAT FAll Fill to line on
reservoir
Capacities and specifications
204

axles, add 118 ml (4 oz.) of
additive friction modifier
C8AZ-19B546-A, Ford specification
EST-M2C118±A, whenever the
lubricant is changed.
4Refer to your ªService Guideº for
axle fluid change intervals.
LUBRICANT SPECIFICATIONS
FluidFord part
name or
equivalentFord part
numberFord
specification
Windshield
washer fluid
reservoirFord Ultra-Clear
Windshield
Washer
ConcentrateC9AZ-19550-AA
OR -BAESR-M17P5-A
Body hinges,
latches, door
stricker plates
and rotors, seat
tracks, fuel filler
door hinge and
spring, hood
latch, auxiliary
latchMulti-Purpose
GreaseD7AZ-19584-AA
OR
DOAZ-19584-AAESR-M1C159-A
AND
ESB-M1C93-B
Driveshaft, slip
spline, universal
jointsPremium Long
Life GreaseXG-1-C or K ESA-M1C75-B
Engine coolantFord Premium
Cooling System
FluidE2FZ-19549-AA ESE-M97B44-A
Engine oilMotorcraft 5W30
Super Premium
Motor OilXO-5W30-QSPWSS-M2C153-G
with API
Certification
Mark
Capacities and specifications
207

applications must add 118ml
(4 oz.) of additive friction modifier
C8AZ-19B546±A, Ford specification
EST-M2C118±A to the rear axle
whenever the axle has been
serviced.
ENGINE DATA
Engine 5.0L engine 4.0L SOHC engine
Cubic inches 302 245
Horsepower 215 @ 4200 rpm 205 @ 5000 rpm
Torque 288 lbs.ft. @ 3300 rpm 250 lb. ft. @ 3000 rpm
Required fuel grade 87 octane 87 Octane
Firing order 1-3-7-2-6-5-4-8 1-4-2-5-3-6
Spark plug gap 1.3 mm-1.4 mm
(0.052-.056 inch)1.3 mm-1.4 mm
(0.052-.056 inch)
Ignition system EDIS EDIS
Compression ratio 9.0:1 9.7:1
VEHICLE DIMENSIONS
Dimensions mm (in.)
(1) Overall length 4 788 (188.5)
(2) Overall width 1 783 (70.2)
(3) Maximum height 1 725 (67.9)
(4) Wheelbase 2 835 (111.6)
(5) Front track/ rear 1 486/1487 (58.5/58.5)
Capacities and specifications
209

Air bag supplemental restraint
system ..........................................73
and child safety seats ..............75
description ................................74
disposal ......................................78
indicator light ...........................77
passenger air bag .....................76
Air conditioning
manual heating and air
conditioning system .......18,21,23
Air suspension
description ..............................103
All wheel drive (AWD) .............118
Ambulance packages ....................3
Anti-lock brake system (ABS)..101
Anti-theft system ........................55
Autolamp system (see
Headlamps) .................................38
Automatic dimming mirror ...37,38
Battery .......................................173
voltage gauge ............................14
Brake fluid
checking and adding ..............162
Brakes ........................................100
anti-lock ...................................100
anti-lock brake system (ABS)
warning light ...........................101
fluid, checking and adding ....162
Brake-shift interlock .................104
Break-in period .............................2
Bulbs, replacing ........................190
headlamps ...............................191
specifications ..........................193
Cargo cover ............................44,45
Changing a tire .........................144
Child safety seats ........................81
built-in child seat ......86,87,91,92
Childproof locks ..........................41
Chime
headlamps on ............................12
Cleaning your vehicle ...............196
built-in child seat ...................201engine compartment ..............197
fabric ........................................200
instrument panel ....................200
plastic parts ............................199
safety belts ..............................201
tail lamps .................................200
washing ....................................196
waxing .....................................196
wheels ......................................199
windows ..................................203
woodtone trim ........................203
Compass, electronic ....................35
calibration .................................37
set zone adjustment .................36
Control trac 4WD system .........111
Controls .......................................42
Defrost
rear window ..............................24
Driving under special
conditions ...........................115,120
high water ........................115,120
slippery roads ....116,117,121,122
Emission control system ..........187
Engine ........................................209
service points ...................156,157
Engine block heater ...................97
Engine coolant
checking and adding ..............164
disposal ....................................166
refill capacities ........................167
Engine oil ...........................158,161
changing oil and oil filter .......161
checking and adding .......158,160
Exhaust fumes ............................98
Floor mats ...................................43
Foglamps .....................................16
Four-Wheel Drive vehicles
control trac ........................25,111
special driving
instructions ......................113,114
Fuel
calculating fuel economy .......187
Index
213

improving fuel economy ........134
octane rating ...........................185
quality ......................................186
safety information relating to
automotive fuels .....................183
Fuel gauge ...................................15
Fuel pump shut-off switch .......135
Fuse panels
instrument panel ....................138
power distribution box ...........141
Fuses ...................................136,137
Gauges, Mechanical ....................12
engine coolant temperature
gauge .........................................13
Hazard flashers .........................135
Head restraints ......................62,65
Headlamps ...................................16
daytime running lights .............16
flashing ......................................17
high beam .................................17
Heating ........................................18
High beams
indicator light .............................9
Hood
release lever ............................156
Instrument panel
lighting up panel and interior..17
Jump-starting your
vehicle .................................149,151
attaching cables ......................150
disconnecting cables ..............151
Keyless entry system
autolock .....................................50
keypad .......................................52
locking and unlocking doors ....54
programming entry code ....53,54
Keys
key in ignition chime ...............12
Liftgate ........................................43
Lights, warning and indicator
air bag ..........................................8
anti-lock brakes (ABS) ..............9anti-theft ...................................10
brake ............................................9
charging system ........................10
check engine ............................6,7
cruise indicator .........................11
door ajar ....................................10
fuel reset .....................................8
overdrive off ..............................11
safety belt ...................................8
turn signal indicator ...................9
Load limits
trailer towing ..........................125
Lubricant specifications ...........207
Luggage rack .............................133
Mirrors
cleaning ...................................203
side view mirrors (power) .......41
Moon roof ....................................34
Motorcraft parts ........................204
Odometer .....................................13
Off road driving, 4-wheel
drive ....................................114,119
Overhead console
compass/temperature display ..33
storage compartment ...............33
Panic alarm feature, remote
entry system ................................47
Parking brake ............................102
Power door locks ........................40
Power steering
fluid, checking and adding ....167
Radio (see Electronic sound
systems) ......................................25
Rear window
washer .......................................32
Recreational towing, all wheels
on the ground ...........................133
Refill capacities for fluids ........204
Relays ........................................136
Remote entry system .................46
illuminated entry ......................49
locking/unlocking doors ......46,47
Index
214