fuel pressure Mercury Sable 1996 Owner's Manuals

263 %
*
[SV05075(ALL)04/95]
Cleaning the Engine
*
[SV06000(ALL)04/95]
A clean engine is more efficient because the
engine is able to cool properly. A build up of
grease and dirt acts as an insulator, keeping the
engine warmer than normal.
*
[SV06020(ALL)04/95]
q
Extreme care must be used if a power washer
is used to clean the engine. The high pressure
fluid could penetrate sealed parts and
assemblies causing damage or malfunctions.
*
[SV06040(ALL)04/95]
q
In order to avoid possible cracking of the
engine block or fuel injection pump, do not
spray a hot engine or injection pump with
cold water.
*
[SV06060(ALL)04/95]
q
The alternator, distributor and air intake must
be covered. Covering these components will
help prevent water damage.
*
[SV06080(ALL)04/95]
q
Never wash or rinse the engine while it is
running. Water getting into the engine may
cause internal damage.
%
*
[SV06100(ALL)03/95]
Filling the Fuel Tank
[SV06800(ALL)04/95]
1. Turn the engine off. After opening the fuel
door, remove the cap carefully and slowly
by turning it counterclockwise 1/4 turn until
it stops. Pull to remove the cap. A tether
attaches the cap to the fuel filler pipe.
[SV06825(ALL)04/95]
one inch art:0001470-AFile:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

264 [SV06850(ALL)04/95]
RWARNING
The fuel system may be under
pressure. If the fuel cap is venting
vapor or if you hear a hissing sound,
wait until it stops before completely
removing the cap. Otherwise, fuel
may spray out and injure you or
others.
*
[SV06900(ALL)03/95]
2. Make sure that you pump unleaded fuel and
put the nozzle all the way inside the fuel
filler pipe.
*
[SV06950(ALL)02/95]
NOTE: To help reduce early nozzle shutoffs
and fuel spillage, park your vehicle so
that the fuel filler door is not
downhill. Do not tilt or turn the nozzle
upside down when filling. Avoid
excessively fast fuel dispensing rates
(over 10 gallons [38 liters] per minute).
*
[SV07150(ALL)01/95]
3. If you spill any fuel on the body of your
vehicle, clean it off immediately. The fuel
may dull or soften the paint if you do not
wash it off.
[SV07200(ALL)11/94]
4. To replace the fuel cap, align the tabs on the
cap with the notches on the filler pipe. Turn
it clockwise until it stops.
[SV07250(ALL)04/95]
5. Push the fuel door closed.
[SV07275(ALL)04/95]
If the Service Engine Soon warning light comes
on and stays on when you start the engine, the
fuel cap may not be properly seated. Turn off
the engine, remove the fuel cap and replace it,
being careful to align the cap properly. For more
information, seeWarning lightsin the Index.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

265 %
*
[SV07300(ALL)03/95]
RWARNING
If you lose the fuel cap, replace it
with one that is an authorized
Motorcraft service part or an
equivalent part. If you do not use the
proper fuel cap, the pressure in the
fuel tank can damage the fuel system
or cause it to work improperly in a
collision, endangering you and your
passengers.
*
[SV07350(ALL)01/95]
NOTE: If you replace your fuel cap with an
aftermarket fuel filler cap, the customer
warranty may be void for any damage
to the fuel tank and/or fuel system.
*
[SV07500(ALL)03/95]
Choosing the Right Fuel
[SV07601(ALL)12/95]
Use only UNLEADED FUEL. Using leaded fuel
is prohibited by federal law. Any vehicle
damage may not be covered by your warranty.
%*
[SV08725(ALL)03/95]
Octane Recommendations
[SV08800(ALL)04/95]
Your vehicle is designed to use regular fuel
with an octane rating of 87.In most cases it is
not necessary to use a fuel with an octane rating
higher than 87. At service stations, the octane
rating is displayed in a label on the pumps.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

269
your ability to safely operate your vehicle.
Avoid breathing vapors while refueling. If fuel
vapors are inhaled in excessive quantities, move
the victim to fresh air and seek medical
attention.
*
[SV10220(ALL)03/95]
Fuels can also be harmful if absorbed through
the skin. Be careful not to splash fuel on
yourself or your clothing. If fuel is splashed on
the skin, promptly remove contaminated clothing
and wash the skin thoroughly with soap and
water.
*
[SV10225(ALL)02/95]
Fuels can cause severe eye irritation and possibly
eye damage. If fuel is splashed in the eyes,
remove contact lenses (if worn), flush with large
amounts of water for 15 minutes, and seek
medical attention.
*
[SV10230(ALL)01/95]
You should be particularly careful if you are
taking the medication ªAntabuseº or other forms
of disulfiram for the treatment of alcoholism.
There is a possibility that breathing the vapors
of a gasoline-methanol blend, or skin contact
with such a blend, may cause the same kind of
adverse reaction as drinking an alcoholic
beverage. In sensitive individuals, serious
personal injury or sickness could result. Consult
a physician promptly if you experience an
adverse reaction.
*
[SV10250(ALL)01/95]
Fuel line service
[SV10270(ALL)11/94]
Fuel injection systems operate with pressurized
fuel. The fuel lines are under pressure even
when the engine is off. This system should be
serviced by an authorized dealer using only
Ford approved parts. Using other materials may
be hazardous or allow hydrocarbon emissions
above the legal levels set by the Federal
Government.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

271
*
[SV13526(ALL)04/95]
2. Then, every time you buy fuel, fill the tank
completely and write down the number of
miles (kilometers) that you have driven and
the number of gallons (liters) of fuel that
you buy.
*
[SV13530(ALL)04/95]
Keep a record for at least a month. This will
give you a more accurate estimate than
figuring the fuel economy based on only one
or two readings.
*
[SV13535(ALL)04/95]
3. Divide the total number of miles that you
have driven by the total number of gallons
that your vehicle has used. In metric,
multiply the number of liters used by 100
and divide the answer by the number of
kilometers traveled. This will give you the
number of liters used per 100 km.
*
[SV13540(ALL)01/95]
Comparisons With EPA Fuel Economy
Estimates
*
[SV13545(ALL)03/95]
EPA fuel economy figures are obtained from
laboratory tests under simulated road conditions
and thus are estimates which may not reflect the
actual conditions you experience or your style of
driving. In addition to your individual driving
habits, optional equipment such as air
conditioning can have substantial effects on fuel
economy. Other factors that may affect fuel
economy include vehicle load and tire inflation
pressure. The EPA fuel economy estimate is not
a guarantee that you will achieve the fuel
economy shown.
*
[SV13555(ALL)03/95]
Improving Fuel Economy
*
[SV13561(ALL)02/95]
Fuel economy is affected by a number of
variables which can reduce efficiency. You can
improve fuel economy by understanding these
variables and minimizing their effect.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

272
*
[SV13564(ALL)02/95]
The following decrease fuel economy:
*
[SV13568(ALL)02/95]
q
Lack of regular, scheduled maintenance
*
[SV13572(ALL)02/95]
q
Excessive speed
*
[SV13576(ALL)02/95]
q
Rapid acceleration
*
[SV13581(ALL)02/95]
q
Driving with your foot on the brake
*
[SV13584(ALL)02/95]
q
Sudden stops
*
[SV13589(ALL)02/95]
q
Extended engine idling
*
[SV13591(ALL)02/95]
q
Using speed control in hilly terrain
*
[SV13593(ALL)02/95]
q
Extended use of the A/C, defroster, rear
window defroster and other accessories
*
[SV13596(ALL)02/95]
q
Underinflated tires
*
[SV13598(ALL)02/95]
q
Heavy loads
*
[SV13599(ALL)02/95]
q
Aftermarket add-ons such as bike, ski or
luggage racks, bug deflectors, etc.
*
[SV13605(ALL)02/95]
Self-Service Pointers
*
[SV13611(ALL)01/95]
If you choose to do your own fueling, you
should also perform a few simple maintenance
routines. This extra effort will save you
additional money and contribute to the driving
efficiency of your vehicle.
*
[SV13615(ALL)01/95]
The following procedures require only a tire
gauge, a rag, an oil can spout and windshield
washer fluid.
*
[SV13620(ALL)01/95]
q
Check the engine oil at every refueling stop
*
[SV13625(ALL)01/95]
q
Clean the windshield, outside mirrors and
headlights
*
[SV13630(ALL)01/95]
q
Check windshield washer fluid
*
[SV13633(ALL)02/95]
q
Check tires for excessive wear or worn edges
*
[SV13636(ALL)01/95]
q
Check the tire pressure at least monthly
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

288 [SV23760(ALL)04/95]
one third page art:0001386-AInstalling the new filter
[SV23765(ALL)04/95]
5. Reinstall the water shield, sliding it from the
center of the vehicle toward the fender. As
you position it over the filter, guide the
hinged flap on the left side of the shield
down between the filter and the fender.
Slide the shield toward the fender until the
holes on the shield align with the holes on
the vehicle body. Reinstall the two screws
that hold the shield in place.
[SV23770(ALL)04/95]
6. Reinstall the leaf screen. Tuck the left rear
corner of the screen under the top of the
fender, then lower the screen into position.
Reinstall the four retainers, turning them 90Ê
to lock them into place. Reinstall the vacuum
line hose clips and the one loose clip in the
notches in the leaf screen.
%
*
[SV23800(ALL)03/95]
Tires
*
[SV23900(ALL)03/95]
Look at your tires each time you fill your fuel
tank. If one tire looks lower than the others,
check the pressure in all of them. Always follow
these precautions:
*
[SV24200(ALL)03/95]
q
Keep your tires inflated to the recommended
pressures.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

326 [SV41900(ALL)04/95]Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charging system warning
light, the service engine soon light, or the
temperature warning light. These sometimes
indicate that the emissions system is not
working properly.
*
[SV42000(ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV42100(ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[SV42200(ALL)02/92]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
*
[SV42300(ALL)01/95]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[SV42400(ALL)02/95]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
File:fcsvs.ex
Update:Wed Dec 20 09:36:55 1995

352 Index
Engine coolant
checking and adding......... 276
checking hoses............ 277
preparing for storage......... 334
recovery reservoir........... 276
refill capacities............ 329
specifications............. 331
Engine coolant temperature gauge,
description............... 84
Engine fan............... 256
Engine oil
changing oil and oil filter....... 275
checking and adding......... 274
dipstick............... 274
engine oil pressure warning light..... 77
filter, specifications.......... 330
refill capacities............ 329
specifications............. 331
synthetic oil............. 273
ªbreak-inº oils............. 6
Entry system, keyless.......... 128
Exhaust fumes.............. 71
Extended Service Plan, Ford........ 5
F
Flashers, hazard............. 118
Flashing the lights............ 116
Flat tire................. 221
Floor mats............... 152
Fluid refill capacities........... 329
Ford Customer Assistance Center..... 238
Ford Dispute Settlement Board...... 239
Ford Extended Service Plan........ 5
Ford Motor Company of Canada..... 243
Ford of Canada Customer
Assistance Centre........... 243
Foreign registration........... 245
French owner guides, how to obtain.... 3
Fuel
calculating fuel economy........ 270
File:fcixs.ex
Update:Tue Aug 8 10:58:02 1995

356 Index
Lamps (continued)
high beams.............. 115
illuminated mirrors.......... 155
interior lamps............. 110
map lamps.............. 111
trailer................ 216
Lap belts................. 20
Lights, warning and indicator
airbag................. 79
anti-lock brakes (ABS).......... 83
anti-theft................ 90
brake................. 75
charging system............. 76
door ajar................ 79
engine oil pressure........... 77
high beam............... 78
lamp out................ 89
low fuel................ 89
low washer fluid............ 88
oil pressure............... 77
overdrive off.............. 90
safety belt............... 75
service engine soon........... 80
speed control.............. 83
turn signal indicator........... 82
Load limits
GAWR................ 209
GVWR................ 209
trailer towing............. 212
Lubricant specifications......... 331
Luggage rack.............. 163
Lug nuts
anti-theft............... 230
standard............... 227
tightening sequence.......... 228
Lumbar support pad........... 149
File:fcixs.ex
Update:Tue Aug 8 10:58:02 1995