seat Mercury Sable 2004 s Repair Manual

6. Wipe the indicator clean. Insert the indicator fully, then remove it
again.
•If the oil level isbetween the two holes or between the MIN and
MAX marks (depending on application),the oil level is acceptable.
DO NOT ADD OIL.
•3.0L Vulcan engine
•3.0L Duratec engine
•If the oil level is below the add 1QT or MIN mark, add enough oil to
raise the level within the 1QT-FULL or the MIN-MAX range
(depending on application).
•Oil levels above the F in FULL or above the MAX mark, may cause
engine damage. Some oil must be removed from the engine by a
service technician.
7. Put the indicator back in and ensure it is fully seated.
Adding engine oil
1. Check the engine oil. For instructions, refer toChecking the engine
oilin this chapter.
2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
192

3. Recheck the engine oil level. Make sure the oil level is not above the MAX
mark or the letter F in FULL on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
5. Fully install the engine oil filler cap by turning the filler cap clockwise
until it stops.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level indicator and/or the engine oil filler cap removed.
Engine oil and filter recommendations
Look for this certification
trademark.
Use SAE 5W-20 engine oil.
Only use oils“Certified For Gasoline Engines”by the American
Petroleum Institute (API). To protect your engine’s warranty use
Motorcraft SAE 5W-20 or an equivalent 5W-20 oil meeting Ford
specification WSS-M2C153–H.SAE 5W-20 oil provides optimum fuel
economy and durability performance meeting all requirements for
your vehicle’s engine.
Do not use supplemental engine oil additives, cleaners or other engine
treatments. They are unnecessary and could lead to engine damage that
is not covered by Ford warranty.
Change your engine oil according to the appropriate schedule listed in
the scheduled maintenance guide.
Ford production and aftermarket (Motorcraft) oil filters are designed for
added engine protection and long life. If a replacement oil filter is used
that does not meet Ford material and design specifications, start-up
engine noises or knock may be experienced.
It is recommended you use the appropriate Motorcraft oil filter (or
another brand meeting Ford specifications) for your engine application.
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
193

BRAKE FLUID RESERVOIR
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the“MIN”and
“MAX”lines are within the normal
operating range, there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range, the performance of your
brake system could be
compromised, seek service from
your dealer immediately.
TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to yourScheduled Maintenance Guidefor scheduled intervals for
fluid checks and changes. Your transaxle does not consume fluid.
However, the fluid level should be checked if the transaxle is not working
properly, i.e., if the transaxle slips or shifts slowly or if you notice some
sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 30 km [20 miles]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 30 km (20 miles) or until it reaches normal operating
temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine compartment
in this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
214

•kPa:Kilopascal, a metric unit of air pressure.
•PSI:Pounds per square inch, a standard unit of air pressure.
•B-pillar:The structural member at the side of the vehicle behind the
front door.
•Bead area of the tire:Area of the tire next to the rim.
•Sidewall of the tire:Area between the bead area and the tread.
•Tread area of the tire:Area of the perimeter of the tire that
contacts the road when mounted on the vehicle.
•Rim:The metal support (wheel) for a tire or a tire and tube assembly
upon which the tire beads are seated.
INFORMATION CONTAINED ON THE TIRE SIDEWALL
Federal law requires tire manufacturers to place standardized
information on the sidewall of all tires. This information identifies and
describes the fundamental characteristics of the tire and also provides a
U.S. DOT Tire Identification Number for safety standard certification and
in case of a recall.
Information on“P”type tires
P215/65R15 95H is an example of a
tire size, load index and speed
rating. The definitions of these
items are listed below. (Note that
the tire size, load index and speed
rating for your vehicle may be
different than this example.)
1.P:Indicates a tire, designated by
the Tire and Rim Association
(T&RA), that may be used for
service on cars, SUVs, minivans and
light trucks.
Note:If your tire size does not
begin with a letter this may mean it
is designated by either ETRTO
(European Tire and Rim Technical Organization) or JATMA (Japan Tire
Manufacturing Association).
2.215:Indicates the nominal width of the tire in millimeters from
sidewall edge to sidewall edge. In general, the larger the number, the
wider the tire.
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
218

Fluid Ford Part
NameApplication Capacity
Windshield
washer fluid -
RearMotorcraft
Premium
Windshield
Washer
ConcentrateWagon 1.8L (60.9 oz.)
1Add the coolant type originally equipped in your vehicle.
2Use of synthetic or synthetic blend motor oil is not mandatory. Engine
oil need only meet the requirements of Ford specification
WSS-M2C153–H and the API Certification mark.
LUBRICANT SPECIFICATIONS
ItemsFord Part Name
or equivalentFord Part
NumberFord
Specification
Brake fluid Motorcraft High
Performance
DOT 3 Motor
Vehicle Brake
FluidPM-1 ESA-M6C25-A
and DOT 3
Door latch, hood
latch, auxiliary
hood latch, seat
tracks, trunk and
liftgate latchesMulti-Purpose
GreaseXG-4 or XL-5 ESR-M1C159-A
or ESA-M1C93-B
Lock cylinders Penetrating and
Lock LubricantMotorcraft XL-1 none
Automatic
transaxle
( 4F50N
1)Motorcraft
MERCONVATFXT-5-QM
MERCONV
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
231

A
Accessory delay ..........................48
Air bag supplemental restraint
system ........................107–108, 113
and child safety seats ............109
description ......................108, 113
disposal ....................................115
driver air bag ..........108, 110, 114
indicator light .........................113
operation .................108, 110, 114
passenger air bag ...108, 110, 114
side air bag ..............................113
Air cleaner filter .......................229
Air conditioning ..........................25
Antifreeze
(see Engine coolant) ................196
Anti-lock brake system
(see Brakes) ..............................133
Anti-theft system ........................85
arming the system ....................85
disarming a triggered system ..86
Audio system (see Radio) ...15, 18
Automatic transaxle
fluid, adding ............................214
fluid, checking ........................214
fluid, refill capacities ..............230
fluid, specification ..................233
Automatic transmission
driving an automatic
overdrive .................................138
Auxiliary power point .................47
Axle
lubricant specifications ..........231
B
Battery .......................................194acid, treating emergencies .....194
jumping a disabled battery ....162
maintenance-free ....................194
replacement, specifications ...229
servicing ..................................194
BeltMinder .................................102
Brakes ........................................132
anti-lock ...................................133
anti-lock brake system (ABS)
warning light ...........................133
fluid, checking and adding ....214
fluid, refill capacities ..............230
fluid, specifications .........231, 233
lubricant specifications ..231, 233
parking ....................................134
shift interlock ..........................136
Bulbs ............................................34
C
Capacities for refilling fluids ....230
Cargo area shade ........................69
Cargo cover .................................69
Cargo net ...............................68–69
CD changer .................................20
CD-single premium ...............15, 18
Cell phone use ............................67
Certification Label ....................235
Changing a tire .........................157
Child safety restraints ..............116
child safety belts ....................116
Child safety seats ......................118
attaching with tether straps ..123
in front seat ............................120
in rear seat ......................120, 122
Cigar lighter
Power Point ..............................47
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
241

Cleaning your vehicle
engine compartment ..............180
instrument panel ....................182
interior .....................................182
interior trim ............................183
plastic parts ............................181
washing ....................................179
waxing .....................................179
wheels ......................................180
wiper blades ............................182
Climate control (see Air
conditioning or Heating) ............25
Clock adjust
AM/FM/CD .................................18
AM/FM/Tape ..............................15
Compass, electronic
set zone adjustment .................60
Console ........................................66
Controls
power seat .................................89
Coolant
checking and adding ..............196
refill capacities ................200, 230
specifications ..................231, 233
Cruise control
(see Speed control) ....................50
Customer Assistance ................148
Ford accessories for your
vehicle .....................................184
Ford Extended Service
Plan ..........................................172
Getting assistance outside
the U.S. and Canada ..............176
Getting roadside assistance ...148
Getting the service you
need .........................................170
Ordering additional owner’s
literature .................................177
The Dispute Settlement
Board .......................................172Utilizing the
Mediation/Arbitration
Program ...................................175
D
Daytime running lamps
(see Lamps) ................................29
Defrost
rear window ..............................27
Dipstick
automatic transmission
fluid ..........................................214
engine oil .................................190
Doors
lubricant specifications ..........231
Driving under special
conditions ..................................140
through water .........................140
E
Electronic message center .........57
Emergencies, roadside
jump-starting ..........................162
Emergency Flashers .................149
Emission control system ..........210
Engine ........................................233
cleaning ...................................180
coolant .....................................196
idle speed control ...................194
lubrication
specifications ..................231, 233
refill capacities ........................230
service points ..................187–188
starting after a collision .........149
Engine block heater .................132
Engine oil ..................................190
checking and adding ..............190
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
242

dipstick ....................................190
filter, specifications ........193, 229
recommendations
...................193
refill capacities
........................230
specifications
..................231, 233
Exhaust fumes
..........................132
F
Flexible Fuel Vehicle (FFV)
....201
Floor mats
...................................67
Fluid capacities
.........................230
Foglamps
.....................................29
Fuel
............................................201
calculating fuel
economy
............................59, 206
cap
...........................................203
capacity
...................................230
choosing the right fuel
...........204
comparisons with EPA fuel
economy estimates
.................209
detergent in fuel
.....................206
filling your vehicle with
fuel
...........................201, 203, 207
filter, specifications
........206, 229
fuel pump shut-off switch
.....149
improving fuel economy
........206
octane rating
...................204, 233
quality
......................................205
running out of fuel
.................206
safety information relating
to automotive fuels
................201
Fuel - flex fuel vehicle
(FFV)
.................................201, 204
Fuses
..........................................151G
Garage Door Opener
(see Homelink wireless control
system) ........................................53
Gas cap (see Fuel cap) ............203
Gas mileage (see Fuel
economy) ...................................206
Gauges .........................................13
H
Hazard flashers .........................149
Headlamps ...................................29
aiming ........................................31
autolamp system .......................29
bulb specifications ....................34
daytime running lights .............29
flash to pass ..............................30
high beam .................................30
replacing bulbs .........................36
turning on and off ....................29
Heating
heating and air conditioning
system .................................23, 25
HomeLink universal
transceiver (see Garage door
opener) ........................................57
Homelink wireless control
system ..........................................53
Hood ..........................................186
I
Ignition ...............................128, 233
Infant seats
(see Safety seats) .....................118
Inspection/maintenance (I/M)
testing ........................................211
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
243

Instrument panel
cleaning ...................................182
cluster ........................................10
lighting up panel and
interior .......................................30
J
Jack ............................................157
positioning ...............................157
storage .....................................157
Jump-starting your vehicle ......162
K
Keyless entry system .................80
Keys
positions of the ignition .........128
L
Lamps
autolamp system .......................29
bulb replacement
specifications chart ..................34
daytime running light ...............29
fog lamps ...................................29
headlamps .................................29
headlamps, flash to pass ..........30
instrument panel, dimming .....30
interior lamps .....................32–35
replacing
bulbs ..................34, 36, 38–41, 43
Lane change indicator
(see Turn signal) ........................32
Liftgate ........................................68
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........133
Load limits .................................140Locks
childproof ..................................73
doors ..........................................72
Lubricant specifications ...231, 233
Luggage rack ...............................71
Lumbar support, seats ...............88
M
Message center ...........................57
english/metric button ...............62
system check button ................63
warning messages .....................63
Mirrors ...................................47–48
automatic dimming rearview
mirror ........................................48
heated ........................................49
side view mirrors (power) .......49
Moon roof ....................................53
Motorcraft parts ................206, 229
O
Octane rating ............................204
Oil (see Engine oil) ..................190
Overdrive ...................................137
P
Parking brake ............................134
Parts (see Motorcraft parts) ....229
Passenger Occupant
Classification Sensor ...................92
Pedals (see Power adjustable
foot pedals) .................................50
Power adjustable foot pedals .....50
Power distribution box
(see Fuses) ...............................154
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
244

Power door locks ........................72
Power Point
Cigar lighter ..............................47
Power steering ..........................135
fluid, checking and adding ....212
fluid, refill capacity ................230
fluid, specifications .........231, 233
Power Windows ...........................48
R
Radio ......................................15, 18
Rear window defroster ...............27
Relays ........................................156
Remote entry system
illuminated entry ......................78
locking/unlocking doors ...........72
opening the trunk .....................76
Roadside assistance ..................148
Roof rack .....................................71
S
Safety Belt Maintenance ..........106
Safety belts (see Safety
restraints) ..................91, 94–97, 99
Safety defects, reporting ..........178
Safety restraints ............91, 94–100
belt minder .............................102
extension assembly ................106
for adults .............................95–97
for children .....................115–116
lap belt ......................................99
Occupant Classification
Sensor ........................................92
safety belt maintenance .........106
warning light and
chime ...............................101–102Safety seats for children ..........118
Seat belts
(see Safety restraints) ...............91
Seats ............................................87
child safety seats ....................118
front seats .................................88
Servicing your vehicle ..............185
Setting the clock
AM/FM/CD .................................18
AM/FM/Tape ..............................15
Spare tire
(see Changing the Tire) ...........157
Spark plugs,
specifications .....................229, 233
Specification chart,
lubricants ...........................231, 233
Speed control ..............................50
Starting a flex fuel vehicle .......131
Starting your
vehicle ........................128–129, 131
jump starting ..........................162
Steering wheel
tilting .........................................46
T
Tilt steering wheel ......................46
Tires ...........................157, 216–217
alignment ................................224
care ..........................................222
changing ..................157, 159, 162
checking the pressure ............222
label .........................................222
replacing ..................................227
rotating ....................................224
safety practices .......................227
sidewall information ...............218
snow tires and chains ............228
2004 Sable(sab)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
245