check engine light Mercury Villager 1996 s User Guide

Servicing Your Villager
311
[SV15500(ALL)02/94]
10-1/2 pica
art:0040196-B
Selecting the right viscosity for your climate
%*
[SV15575(ALL)03/95]
Synthetic engine oils which are CERTIFIED and of the preferred
viscosity may be used in your engine. The engine oil and oil
filter must still be changed according to the maintenance
schedule.
%*
[SV15600(ALL)01/95]
Checking and Adding Engine Oil
*
[SV15700(ALL)03/95]
Since the proper amount of engine oil is important for safe
engine operation, check the oil using the dipstick each time you
put fuel in your vehicle. Remember the engine must be off, the
oil must be warm and the vehicle must be parked on level
ground.
%*
[SV15800(ALL)03/95]
Checking the engine oil level:
*
[SV15900(ALL)02/95]1.
Turn the engine off after it has warmed up and allow a few
minutes for the engine oil to drain back into the oil pan.
[SV16000(ALL)07/95]2.
Set the parking brake fully and make sure that the gearshift
is securely latched in P (Park).
*
[SV16100(ALL)02/95]3.
Open the hood. Protect yourself from engine heat.
*
[SV16200(ALL)03/95]4.
Locate the engine oil dipstick (highlighted in yellow) and
carefully pull it out of the engine.
File:15vxsvn.ex
Update:Wed Jun 5 12:25:18 1996

312
*
[SV16300(ALL)01/95]5.
Wipe the dipstick clean and put it back into position, making
sure it is fully seated.
[SV16400(ALL)05/93]
7-1/2 pica art:0040218-A
Engine oil dipstick
[SV16500(ALL)05/94]6.
Carefully pull the dipstick out again. If the oil level is below
the ªLº line, add engine oil as necessary. If the oil level is
beyond the letter ªH,º engine damage or high oil
consumption may occur and some oil must be removed from
the engine.
*
[SV16600(ALL)01/95]7.
Put the dipstick back in and make sure it is fully seated.
%*
[SV16650(ALL)03/95]
Adding engine oil
*
[SV16700(ALL)01/95]
It may be necessary to add some oil between oil changes. Make
sure you use a CERTIFIED engine oil of the preferred viscosity.
Your vehicle's warranty coverage may not apply if engine
damage is caused by the use of improper engine oil.
*
[SV16800(ALL)03/95]
Add engine oil through the oil filler cap highlighted in yellow.
To add oil, remove the filler cap and use a funnel to pour oil
into the opening. Be careful not to overfill the engine. Recheck
the oil level after you finish adding oil.
File:15vxsvn.ex
Update:Wed Jun 5 12:25:18 1996

370
%*
[SV46500(ALL)01/95]
Engine
*
[SV46600(ALL)01/93]
n
Start the engine every fifteen days. Run it at fast idle until it
reaches normal operating temperature.
*
[SV46700(ALL)01/93]
n
With your foot on the brake, shift the transaxle into all gears
while the engine is running.
%*
[SV46800(ALL)01/95]
Fuel system
%*
[SV47000(ALL)07/94]
n
Fill fuel tank with high-quality unleaded fuel until the first
automatic shutoff of the fuel pump nozzle.
*
[SV47100(ALL)09/95]
NOTE: During extended periods of vehicle storage (60 days or
more), fuel may deteriorate due to oxidation. This can
damage rubber and other polymers in the fuel system
and may also clog small orifices.
*
[SV47200(ALL)01/95]
Ford Gas Stabilizer should be added whenever actual or
expected storage periods exceed 60 days. Follow the instructions
on the label. The vehicle should then be operated at idle speed
to circulate the additive throughout the fuel system.
*
[SV47300(ALL)01/95]
A volatile corrosion inhibitor added to the fuel system will
protect the fuel system's inner surfaces from corrosion. Follow
the instructions packaged with the product.
%*
[SV47400(ALL)01/95]
Cooling system
*
[SV47500(ALL)01/93]
n
Protect your vehicle against freezing temperatures.
%*
[SV47600(ALL)01/95]
Battery
*
[SV47700(ALL)01/93]
n
Check and recharge the battery as necessary.
*
[SV47800(ALL)01/95]
n
Keep connections clean and covered with a light coat of
grease.
File:15vxsvn.ex
Update:Wed Jun 5 12:25:18 1996

389
Index
Coolant (see Engine coolant)
checking and adding................ 314
drain and flush................... 318
preparing for storage................ 370
specifications.................... 368
temperature gauge................ 78,82
warnings...................... 314
Cooling fan...................... 296
Cruise control (see Speed control)............ 128
Customer Assistance Centre, Ford of Canada....... 282
D
Dashboard (see Instrument panel)............. 89
Daytime running light system............. 114
Defrost, windshield................... 91
Dipstick
automatic transaxle fluid............... 331
engine oil..................... 311
power steering fluid................. 335
Disabled vehicle (see Towing).............. 273
Dispute Settlement Board................ 278
Doors
door ajar warning light................ 74
lubricant specifications................ 368
Driving under special conditions
bad weather.................... 240
heavy load..................... 241
high speed..................... 240
high water..................... 241
slippery roads................... 240
tips for safe driving................. 239
towing a trailer................... 242
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

390
E
Electrical system
circuit breakers................... 346
fuses......................337±338
relays....................... 347
Electronic sound system
antenna...................... 121
radio reception................... 226
tuning the radio.................. 210
warranty and service information........... 228
Emergencies, roadside
assistance..................... 275
battery acid spills................255, 331
fuel........................ 307
towing....................... 273
Emergency brake (parking brake)............ 237
Emission control system
catalytic converter.................. 362
emissions warranty................. 362
Engine
check engine warning light.............. 72
does not start................... 61,63
fuel injected engine, starting.............. 59
fuel pump shut-off switch............... 63
preparing to start................... 59
service points.................... 300
starting....................... 60
starting after a collision............... 273
storing your vehicle................. 369
Engine block heater................... 62
Engine coolant.................... 314
checking and adding................ 314
disposal...................... 296
drain and flush................... 318
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

391
Index
Engine coolant (continued)
preparing for storage................ 370
proper solution................... 333
recovery reservoir................300, 314
specifications.................... 368
temperature gauge................ 78,82
Engine coolant temperature gauge
description.................... 78,82
mechanical.................... 78,82
Engine coolant temperature guage:electronic...... 78,82
Engine fan...................... 296
Engine:idle speed control................. 62
Engine oil
changing oil and oil filter............311, 313
checking and adding................ 311
dipstick...................... 311
disposal....................296, 333
engine oil pressure warning light............ 73
filter, specifications................. 367
specifications.................... 310
synthetic oil.................... 310
ªbreak-inº oils.................... 5
viscosity...................... 310
Entry system, illuminated............... 120
Exhaust fumes...................... 64
F
Fan, engine fan, avoiding injury............. 296
Federal Communications Commission.......... 228
Flashers, hazard.................... 112
Flashing the lamps................... 124
Flat tire........................ 259
Ford Dispute Settlement Board............. 278
Ford Motor Company of Canada............ 282
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

392
Ford of Canada Customer Assistance Centre....... 282
Foreign registration.................. 284
French owner guides, how to obtain........... 3
Fuel
calculating fuel economy............... 308
choosing the right fuel............... 305
filling your vehicle with fuel............. 303
filter, specifications................. 367
fuel filler door release lever...........303, 367
fuel gauge.................... 77,83
low fuel warning light................. 76
octane rating.................... 305
quality....................... 305
running out of fuel................. 308
safety information relating to automotive fuels..... 307
storing your vehicle................. 370
treating emergencies................. 307
Fuel cap
removing...................... 303
replacing...................... 303
Fuel filler door.................... 303
remote release................... 303
Fuel filter, specifications................ 367
Fuel gauge..................... 77,83
Fuel pump shut-off switch
engine does not start................ 273
starting after a collision............... 273
Fuse panels
engine compartment................. 344
instrument panel.................. 338
Fuses
charts....................... 338
checking and replacing............... 337
circuit breakers................... 346
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

396
Lights, warning and indicator
airbag........................ 71
anti-lock brakes (ABS)................. 70
brake........................ 69
charging system................... 73
check engine..................... 72
door ajar....................... 74
engine oil pressure.................. 73
hazard warning light................ 112
high beam...................... 77
low fuel....................... 76
oil pressure...................... 73
rear ABS....................... 70
safety belt...................... 70
turn signal indicator................. 123
Load limits
GAWR....................... 241
GVWR....................... 241
trailer towing.................... 249
Lubricant specifications................ 368
Luggage rack..................... 173
Lug nuts
anti-theft...................... 267
tightening sequence................. 271
M
Maintenance (see Servicing).............. 295
Map pockets..................... 166
Master cylinder, brakes................ 333
Mileage, calculating fuel economy............ 308
Mirrors
automatic dimming rearview mirror......... 139
dual electric remote control............. 170
rearview...................... 169
side view mirrors (manual)............. 170
side view mirrors (power).............. 170
Motorcraft parts.................... 367
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

397
Index
O
Octane rating..................... 305
Odometer
description...................... 79
trip odometer..................... 80
Oil filter....................... 313
Oil (see Engine oil).................. 310
Oil viscosity...................... 310
On-board diagnostic (OBD II) system.......... 364
Overdrive....................... 231
Overseas offices.................... 284
P
Parking brake
operation...................... 237
warning light..................... 69
Parts (see Motorcraft Parts)............... 367
PCV valve, specifications................ 367
Power door locks................... 140
Power features
door locks..................... 140
mirrors....................... 169
windows...................... 155
Power steering
dipstick...................... 335
driving with power steering............. 234
fluid, checking and adding.............. 335
fluid, specifications................. 368
servicing...................... 234
Prop rod, hood.................... 298
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996

400
Spark plugs, specifications............... 367
Special driving conditions............... 239
Specification chart, lubricants.............. 368
Speed control
accelerating..................... 131
canceling a set speed................ 132
resetting...................... 132
resuming a set speed................ 132
tap up/tap down.................. 132
when towing a trailer................ 252
Speedometer...................... 79
Starting your vehicle
preparing to start your vehicle............. 59
starting a cold engine................. 60
starting after a collision............... 273
Steering, power.................... 234
Steering wheel
locking........................ 57
speed controls................... 128
Storage compartments
cargo net...................... 171
map pockets.................... 166
Storing your vehicle.................. 369
Supplemental air bag readiness light........... 71
Supplemental Restraint System (SRS)........... 23
T
Tachometer....................... 80
mechanical cluster................... 80
Tail lamps
bulb replacement................348, 355
cleaning...................... 114
Temperature control (see Climate control)......... 91
Tether anchor installation (see Child restraints)....... 39
Tires
changing...................... 259
checking the pressure................ 322
cleaning...................... 329
File:vxixn.ex
Update:Fri Jun 7 09:28:47 1996