Instrument MITSUBISHI 3000GT 1993 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine GENERAL - Junction Block19
/
L
To roofwiring -harness
Front
/ITo frontwiring harness
- TO instrument panel
wiring harness
Theft-
alarm
horn
relay
L ,.c !!II {+J . ,i/11
\oi
Z16FO304
Back
To bodywiringharness
W-9
Z16FOO5800002704
/
id
TSB Revision

Downloaded from www.Manualslib.com manuals search engine GENERAL - How to Diagnose
Changeover k&bZ1680224
Z1680225
INSPECTION1. Visual and aural checks
Check relay operation, blower motor rotation, light illumina-d
tion, etc. visually or aurally. The flow of current is invisiblebut can be checked by the operation of the parts.
2. Simple checks
For example, if a headlight does not come on and a faultyfuse or poor grounding is suspected, replace the fuse
with a new one or ground the light to the body by a jumper
wire to determine which part is responsible for the problem.3. Checking with instruments
Use an appropriate instrument in an adequate range andread the indication correctly. You must have sufficient
knowledge and experience to handle instruments correctly.
INSPECTION INSTRUMENTS
In inspection, make use of the following instruments.1. Test lights
A test light consists of a 12 V bulb and lead wires. It
is used to check voltages or short circuits.
2. Self-power test light
A self-power test light consists of a bulb, battery and lead
wires connected in series. It is used to check continuity
or grounding.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CONFIGURATION
DIAGRAMSCONTENTS
_I
Dash Panel................................50Instrument Panel and Floor Console..........54Engine and Transaxle
CA/T>.................48Interior.....................................56
.................46
Luggage Compartment......................58
Engine Compartment........................38Overall Configuration Diagram...............36
How to Read Configuration Diagram.........37

Downloaded from www.Manualslib.com manuals search engine 36CONFIGURATION DIAGRAMS - Overall Configuration Diagram
OVERALL CONFIGURATION DIAGRAM
Roof wiring
CHBACK>Instrument panel
wiring harness
- ,;
/Front wiring“l,
Door wiring*harness
harness
.-----y ,,\.Body wiring
harness (LH)Y36FOO19

Body wiring
harness (RH)Roof wiring
Instrument panel
wiring harness
Control wiring/harness
Door wiring*
harness
/Z36FO124Front wiring‘x\..e----qT .\, ’ Body\Niring00002733
harness‘-*harness (LH)
NOTE
(1)This illustration shows only the major wiring harness.
(2)* indicates also equipped at the right side.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - How to Read Configuration Diagram37
,lHOW TO READ CONFIGURATION DIAGRAM
id actual vehicles.
L
Denotes connector No.The same connector No. is used throughout the circuit dia-
grams to facilitate connector location searches. The first al-
phabetical symbol indicates the location site of the connector
and a number that follows in the unique number. Numbers areassigned to parts in clockwise order on the diagram.
Examole: A-l 2
/Number specific to connector (serial number)
Connector location site symbol
A: Engine compartment
B: Engine and transaxle
C: Dash panel
D: Instrument panel and floor consoleE: Interior
F: Luggage compartment
Denotes ground point.Same ground number is used throughout cir-cuit diagrams to facilitate search of ground
point. Refer to P.4 for details of ground points.
A-01X
A-02X
A-03X
A-04X
A-05X
A-06X
A-07X
A-08X
A-09X
A AL\,
$~~~;~.--.-.*/hhA, ”
L^---,.-I II-m 1 lta>.I
J
n-1°KA-11X
\
LI
ueriotes a sermon covereaby a corrugated tube.236F0122
A-01X Headlight relayA-18A-02X ABS power relayA-l 9ignition timing adjustment connector
Front washer motorA-03X Fog light relayA-20
A-04XRadiator fan motor relay(L0)A-21Evaporative emission purge solenoid
EGR solenoidA-05X Taillight relay
A-06X Horn relay
A-22(Vehicles for California)
A-07X Radiator fan motor relay (HI)EGR temperature sensor
A-09X Starter relayA-23(Vehicles for California)
No connection A-l OX Generator relayA-24Brake fluid level sensorA-11XIOD or Storage connectorA-25
A-12ABS front speed sensor (RH)A-26ECS front shock absorber (LH)
Theft-alarm horn
A-13Theft-alarm horn
A-14ECS front shock absorber (RH)A-27
Washer fluid level sensorA-28
Auto-cruise vacuum pump
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 50CONFIGURATION DIAGRAMS - Dash Panel
DASH PANEL
Connector
symbol
C
01thru
45
NOTE*I: 1992 models
*2: Up to 1995 models
c-01c-02
c-o.3
c-04x
C-06X
c-07x
C-08c-09
C-l 0
C-l 1
c-12
Body wiring harness (LH)
and front wiring harness combination
Body wiring harness (LH)
and front wiring harness combination
Body wiring harness (LH)
and front wiring harness combination
Door lock power relay 1
Defogger relay
Power window relay
Diode (for seat belt warning circuit)
Diode (for seat belt warning circuit)
Column switch
Column switch
Diode (for theft-alarm circuit)c-13
c-14
C-l 5
C-l 6
C-l 7
C-l 8
C-l 9c-20
c-21c-22
C-23
C-24
/ i
i
.m
/\\
LJ
Accelerator pedal switch*’
Control wiring harness and instrument panel
wiring harness combination
Body wiring harness (LH) and instrument panel
wiring harness combination
Air conditioning control panel
Air conditioning control panel
Air conditioning switch
Blower switch
Heater control panel illumination light
Blend air damper control motor
Mode selection damper control motor
Power transistor (for full-auto air conditioning
circuit)
Blower resistor
I TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54CONFIGURATION DIAGRAMS - Instrument Panel and Floor Console
INSTRUMENT PANEL AND FLOOR CONSOLED-11 D;‘2D-1 0 ‘.,, \
I
Connectorsymbol
D
later
1993 and
D-03
D-Or ~~\\ Id&
D-02
4D-49 _
D-4i /
D-41
D-36I- -’rL?A/D-:” “- D-331 D-30“-c.w -\D-31 D-29
D-01
D-02
D-03
D-04
D-05
D-06
D-08
D-09
D-l 0
D-11
D-12
D-13
D-14
D-15Pop-up switch and fog light switch
Front speaker (LH)
Combination meter
Combination meter
Combination meter
Defogger switch and ECS switch
Hazard switch
Combination gauge
Diode (for 4WS fluid level warning light circuit)
Glove box illumination light
Photo sensor
Front speaker (RH)
Glove box illumination light switch
Instrument panel wiring harness and control
wiring harness combination
1 TSB Revision
NOTE
I:I*l: Up to 1993 models*? Up to 1994 models
(3)
*3:From 1996 models
D-l 6
D-17
D-18
D-19
D-20
D-21
D-22
D-23
D-24
D-25
D-26
D-27
D-28
Instrument panel wiring harness and body
wiring harness
(RH) combination
Ashtray illumination light
Cigarette lighter
Cigarette lighter
Cigarette lighter illumination light
Power seat switch
Body wiring harness (LH) and console wiring
harness combination
SRS diagnosis unit
SRS diagnosis unit
SRS diagnosis unit*’
SRS diagnosis unit
ABS G sensor
Parking brake switch

Downloaded from www.Manualslib.com manuals search engine /
id
CONFIGURATION DIAGRAMS - Instrument Panel and Floor Console55
D-13
D-14
D-15
\D-17
D-46
D-23
D-24
D-29
D-30
D-31
D-32
D-33
D-34
D-35
D-36
D-37
D-38
D-39
D-40
D-41
/
id, D-42
D:2736fO18100004269
D-26
D-25*’
Active aero switch
Accessory socket
Accessory socket
Auto-cruise main switch
Seatbelt warning buzzer
Radio
Radio
Radio
Rear wiper and washer switch Active exhaust
switch*;!
Remote-control mirror switch
Rheostat
Instrument panel wiring harness -and body
wiring harness (LH) combination
Instrument panel wiring harness and body
wiring harness (LH) combination
D-43
D-44
D-45
D-46
D-47
D-48
D-49
D-50
D-51
D-52
D-53
Instrument panel wiring harness and body
wiring harness (LH) combination
Instrument panel wiring harness and adapter
wiring harness combination
Instrument panel wiring harness and front wiring
harness combination
Telephone cableRadio or body wiring harness and radio sub
wiring harness combination
Top switch
Instrument panel wiring harness and body
wiring harness (LH) combination
Parking switch
Chime*3
Body wiring harness (LH) and header wiring
harness combination*3
Body wiring harness (LH) and header wiring
harness combination*3
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54-6CHASSIS ELECTRICAL - Ignition Switch
IGNITION SWITCHSPECIAL
TOOL
ToolTool number and nameSupersessionApplication
MB990803
Steering wheel pullerGeneral service toolRemoval of steering wheel
IGNITION SWITCHREMOVAL AND INSTALLATION
40 Nm29 ft.lbs.6 Nm
6
Steering lock cylinder removalsteps
Ignition switch segment removalsteps
1. Air bag module (Refer to GROUP 52B
4Ab
- Air Bag Module and Clock Spring.)3. Knee protector
2. Steering wheel(Refer to GROUP 52A - Instrument
3. Knee protector
Panel.)
LRedE;)to GROUP 52A - Instrument:i:4. Column cover, lower
5. Column cover, upper
:::4. Column cover, lower6. Lap cooler duct and foot shower duct
5. Column cover, upper10. Key reminder switch segment
6. Lap cooler duct and foot shower duct11. Ignition switch segment
,A+ 7. Column switch and clock springassembly
NW
8. Ignition key illumination ring
9. Steering lock cylinder
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CHASSIS ELECTRICAL - Meters and Gauges
COMBINATION GAUGESREMOVAL AND INSTALLATION
54-33
Removal steps
1. Instrument panel(Refer to GROUP 52A
- InstrumentPanel.)
0 Distribution duct[Refer to GROUP 55 - Ventilators
(Instrument Panel).]
2. Combination gaugeDISASSEMBLY AND REASSEMBLY
i;
Disassembly steps
1. Gauge bracket2. Gauge glass
3. Window plate4. Voltage gauge
or
pressure gauge
5. Oil pressure gauge
6. Engine coolant temperature gauge
7. Printed-circuit board
8. Gauge caseTSB Revision
J