solenoid MITSUBISHI 3000GT 1993 2.G Workshop Manual
[x] Cancel search | Manufacturer: MITSUBISHI, Model Year: 1993, Model line: 3000GT, Model: MITSUBISHI 3000GT 1993 2.GPages: 738, PDF Size: 35.06 MB
Page 3 of 738
Downloaded from www.Manualslib.com manuals search engine
i Service Manual
3000~l-
1992-l 996
Volume
2
Electrical
FOREWORD
i
L
This Service Manual has been prepared with the latest service information available at the time of
publication. It is subdivided into various group
categories and each section contains diagnossis,
disassembly, repair, and installation procedures
along with complete specifications and tightening
references. Use of this manual will aid in properly
performing any servicing necessary to maintain or
restore the high levels of performance and reliability
designed into these outstanding vehicles.
@
A
.
.,
WESUF’FORTVOLUNTARY TECHNICIAN
CERTiFiCATlON THROUGH
National lnaltute forAUTOMOTIV ESERVICEEXCELLENC E
Mitsubishi Motors Corporation reserves the right to make changesin design or to make additions to or improvements in its products withou\
timposing any obligations upon itself to install them on its productspreviously manufactured.
L
--
GROUP / SECTION INDEX
General. . . . . . . . . . . . . . . . . . . . . . . .
Fusible Link, Fuse an d IOD or
Storage Connector Locatio n
. . . . . . . . . .w
Inspection Terminal Location . . . . . . . . .
Grounding Location . . . . . . . . . . . . . . . . . .w
m
Relay Location . . . . . . . . . . . . . . . . . . . . . -m
Sensor Locatio
n. . . . . . . . . . . . . -. . . . . . .w
Control Unit Location . . . . . . . . . . . . . . . . .m
Solenoid, Solenoid Valve Location . . . . .d
Diode Location . . . . . . . . . . . . . . -. . . . . . .w
Junction Block . . . . . . . . . . . . . . . . . . . . . . .II
Centralized Junction . . . . . . . . . #. . . . . . .w
Harness Connector Inspectio n. I . . . . . .w
How to Diagnose . . . . . . . . . . . . . -. . . . . . .
111
Configuration Diagrams . . . . . . . . . . . - . .m;
Circuit Diagrams . . . ..*.............
Engine Electrical ...............
ChassisElectrical
............ .
Alphabetical Index .............
NOTE:
For information concerning all compo-
nents other than the electrical system and
on-vehicle service procedures for engines
and transmissions, refer to Volume 1
“Chassis & Body” of this paired Service
Manual.
For overhaul procedures of engines or
transmission, refer to the separately is-
sued Engine Service Manual or Manual/
Automatic Transmission Service Manual.
@ 1995 Mitsubishi Motors CorporationReprinted in USA
Page 18 of 738
Downloaded from www.Manualslib.com manuals search engine 16GENERAL - Solenoid, Solenoid Valve Location
SOLENOID, SOLENOID VALVE LOCATION
to1995models for California
TS’B Revision
Page 39 of 738
Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - How to Read Configuration Diagram37
,lHOW TO READ CONFIGURATION DIAGRAM
id
L
Denotes connector No.The same connector No. is used throughout the circuit dia-
grams to facilitate connector location searches. The first al-
phabetical symbol indicates the location site of the connector
and a number that follows in the unique number. Numbers areassigned to parts in clockwise order on the diagram.
Examole: A-l 2
/Number specific to connector (serial number)
Connector location site symbol
A: Engine compartment
B: Engine and transaxle
C: Dash panel
D: Instrument panel and floor consoleE: Interior
F: Luggage compartment
Denotes ground point.Same ground number is used throughout cir-cuit diagrams to facilitate search of ground
point. Refer to P.4 for details of ground points.
A-01X
A-02X
A-03X
A-04X
A-05X
A-06X
A-07X
A-08X
A-09X
A AL\,
$~~~;~.--.-.*/hhA, ”
L^---,.-I II-m 1 lta>.I
J
n-1°KA-11X
\
LI
ueriotes a sermon covereaby a corrugated tube.236F0122
A-01X Headlight relayA-18A-02X ABS power relayA-l 9ignition timing adjustment connector
Front washer motorA-03X Fog light relayA-20
A-04XRadiator fan motor relay(L0)A-21Evaporative emission purge solenoid
EGR solenoidA-05X Taillight relay
A-06X Horn relay
A-22(Vehicles for California)
A-07X Radiator fan motor relay (HI)EGR temperature sensor
A-09X Starter relayA-23(Vehicles for California)
No connection
A-12ABS front speed sensor (RH)A-26ECS front shock absorber (LH)
Theft-alarm horn
A-13Theft-alarm horn
A-14ECS front shock absorber (RH)A-27
Washer fluid level sensorA-28
Auto-cruise vacuum pump
TSB Revision
Page 41 of 738
Downloaded from www.Manualslib.com manuals search engine A-23A-24 A-25A-26
A-27
CONFIGURATION DIAGRAMS - Engine Compartment39
sJ=+?6Foo1300004251
A-l 9
A-20
A-21
A-22A-23
A-24
A-25
A-26
Front washer motor
Evaporative emission purge solenoid
EGR solenoid (Vehicles for California)
EGR temperature sensor
(Vehicles for California)
No connection
Brake fluid level sensor
ECS front shock absorber (LH)
Theft-alarm horn
piFE&l
A-27
A-26
A-29
A-30
A-31X
A-32X
A-33X
A-34X
Theft-alarm horn
Auto-cruise vacuum pump
ABS front speed sensor (LH)4WS fluid level sensor
Condenser fan motor relay (HI)
Radiator fan motor control relay
Magnetic clutch relay
Condenser fan motor relay (LO)
Page 43 of 738
Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - Engine CompartmentENGINE
HOOD
A-73
\
/I IIA-46 A-45 A-44
A-43A-42
A-56
A-57A-58
A-59
A-60
A-61A-62
A-63
A-64
A-65
Engine coolant level sensorActive aero front venturi skirt
Fog light (RH)
Pop-up motor (RH)
Front wiring harness and headlight wiring
harness (RH) combination
Headlight (RH)
Front combination light (RH)
SRS front impact sensor (RH)
ABS hydraulic unit
ABS hydraulic unit
A-66Hood switch
A-67
Front wiring harness and control wiring harness
combination
A-66
Diode (for ABS circuit)
A-69
Resistor
A-70
Turbocharger waste gate solenoid
A-71
Fuel pressure solenoid
A-72
Control wiring harness and solenoid valve
harness combination
A-73
Inspection light
TSB Revision
Page 45 of 738
Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - Engine CompartmentA-23 A-24 A-25
A-26 A-27
i
L
A-30
A-31X
A-32XA-33X
tim-I
\; ,.,,,,/ /--fk!pJ / -
-_---__
jfy--@--o Id\ /
rilf+““1
=\
::-2II
36FOt2200004253
A-20
A-21
A-22
A-23
A-24
A-25
Evaporative emission purge solenoid
EGR solenoid
cTurbo, Non Turbo (Up to 1995 models for
California and from 1996
models)>
EGR temperature sensor*
No connection
Brake fluid level sensorECS front shock absorber (LH)
1 TSB Revision
A-26
A-27
A-28
A-29
A-30
A-31X
A-33X
A-34XTheft-alarm horn
Theft-alarm horn
Auto-cruise vacuum pumpABS front speed sensor (LH)
4WS fluid level sensor
Condenser fan motor relay (HI)
Magnetic clutch relay
Condenser fan motor relay (LO)
Page 47 of 738
Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - Engine Compartment45
; !i i\1 ._’ !\\-7’I \ ‘\
A-58
A-61A-62A-63A-64A-65A-66A-67A-66
A-46A-45A-43 A-76
Fog light (RH)
Headlight (LO, RH)
Front combination light (RH)
SRS front impact sensor (RH)
ABS hydraulic unit
ABS hydraulic unit
Hood switch
Front wiring harness and control wiring harness
combinationDiode (for ABS
circuit)*’
ENGINE HOOD
A-73A-69A-70
A-71A-72A-73A-76A-77A-78
A-79
Resistor
Turbocharger waste gate solenoid
Fuel pressure solenoid
Control wiring harness and solenoid valve
harness combination
Inspection light
Headlight (Hi, LH)
Headlight (HI, RH)
No connection
Motor antenna control unit cConvertible>*1 or
motor antenna
4onvertible>*2
TSB Revision
Page 51 of 738
Downloaded from www.Manualslib.com manuals search engine B-22
B-23
B-24
B-26
B-27
B-29
B-30
B-31
B-32
B-33
B-34
Rear View
B-46*4 B-328~33
CONFIGURATION DIAGRAMS - Engine and Transaxle 49 ~
I
A36F0169
Power transistor
Starter motor
Starter motor
Inhibitor switchELC-4
A/T control solenoid valve
Volume air flow sensor (with intake air
temperature sensor and atmospheric sensor)Control wiring harness and battery cable
combination
Injector No. 2Injector No. 4
Injector No. 6
Speed sensor
B-35
B-36
B-37
B-38
B-40
B-41
B-42
B-43
B-44
B-45
B-46
Idle air control motor (stepper motor)
Oil pressure gauge unit
Oil pressure switch
Power steering pressure switch
Camshaft position
sensor*2
Crankshaft position sensor*2
Kickdown servo switch*2AA fluid temperature
sensor*2Right bank heated oxygen sensor
(rear)*3Left bank heated oxygen sensor
(rear)*3
Manifold differential pressure sensor*4
TSB Revision
Page 58 of 738
Downloaded from www.Manualslib.com manuals search engine 56CONFIGURATION DIAGRAMS - Interior
INTERIOR
E-07E-08
E-06
‘-OfI/l--c
E-04
\
II/E-27
E-30
1E-25 1 E-i4 / E:22/E-21 1
E-29
E-28
NOTEE-26 E-39
*2 E-23 EJJ, +4 ,520*I: From 1993 models
l *: From 1994 models
E-01
E-02
E-03
E-04
E-05
E-06
E-07
E-08
E-09
E-10
E-11
E-l 2
E-13Body wiring harness (RH) and door wiring
harness (RH) combination
Vanity mirror illumination light (LH)
Door mirror (RH)
Door speaker (RH)
Dome lightPower window sub switch
Vanity mirror illumination light (RH)
Power window motor (RH)
Door light (RH)Door key cylinder unlock switch (RH)
Door lock actuator (RH)ABS control unit
ABS resistor
-=zAWD>*~
E-14
E-15
E-16
E-17
E-18
E-19
E-20
E-21
E-22
E-23
E-24
E-25
E-26
E-27
Front seat belt solenoid (RH)
Door switch (RH)
ABS rear speed sensor (RH)
Light automatic shut-OFF unit
Rear intermittent wiper relay
ABS rear speed sensor (LH)
Front seat belt solenoid (LH)
Door switch (LH)
Door lock actuator (LH)
Door key cylinder unlock switch (LH)Front seat belt switch (RH)
Door light (LH)Front seat belt switch (LH)
Power seat assembly
ITSBionI
Page 72 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit
POWER DISTRIBUTION CIRCUIT (UP TO 1993 MODELS) (CONTINUED)
$TEDQL’
G-W5W-B
G-W
[Beg; COMBINATION
G-W
J/Bs(c-69)
.AIR CONDITIONINGSEAT BELT.HIGH MOUNTEDCONTROL PANELSOLENOIDTug;T-ALARM
.GLOVE BOX1
STOP LIGHT.THEFT-ALARM1.STOP LIGHT,I~~~tjINATIONHORN RELAY1
BEb. 6
1
Et$:EE CONTROL
IOD ORSTORAGECONNECTOR
I._....[\i#yINATION
4~;;;""""
.LICENSE
PLATE LIGHT
.RADIO AND TAPE.REAR~~!&"""0"
.RHEOSTAT.VANITY MIRRORILLUMINATION
LIGHTPLAYER
.DOOR LOCKPOWER RELAY 1.DOOR LOCKPOWER RELAY 2.MOTOR ANTENNACONTROL UNIT
_- .__.. --
r
_.._.
.ACTIVE AERO
. @%!A
CONTROL UNIT
NATION.AIR CONDITIONING
,DOME LIGHT
CONTROL UNIT
-DOOR LIGHT
Y245~i6~"~~BT
E~;;;;~NIC
SUSPENSION
CONTROL UNIT
.ENGINECONTROL MODULE.ETACS UNIT.FOOT LIGHT
i
'ESE!
.LIGHT AUTOMATICSHUT-OFF UNIT
ILLl
.LUGGAGE
LIGt
fP;bfiRTMENT
.KEYLESS ENTRY
.RADIO AND
CONTROL UNIT
TAPE PLAYER.SPARE CONNECTOR
(
WIRELESS8%PHoNE
).TRANSAXLECONTROL MODULE
(A-13X) (c-sa) ic-ss) (c-70)
mj fl pjq p&qHROlMOOBA
I
TSB Revision