fuel pressure MITSUBISHI 3000GT 1994 2.G User Guide

Downloaded from www.Manualslib.com manuals search engine 54-18CHASSIS ELECTRICAL - Meters and Gauges
OPERATION
l
When the ignition key is at the “ON” position,the fuel gauge is activated.
l
When there is much fuel, the unit’s resistanceis small and the current flowing in the circuit
is great, so the gauge’s indicator indicates inthe “F” area.
l When there is little fuel, the unit’s resistance
is high and the current flowing in the circuit
is small, so the gauge’s indicator indicates inthe
“E” area.

lWhen the ignition key is at the “ON” position,
the engine coolant temperature gauge is acti-
vated.l
When the engine coolant temperature is high,
the unit’s resistance is low and there is a greatflow of current in the circuit, so the gauge’s
indicator indicates in the “H” area.
l
When the engine coolant temperature is low,
the unit’s resistance is high and there is a smallflow of current in the circuit, so the gauge’s
indicator indicates in the “C” area.
/Speed sensor (electrical speedometer type)>l Pulses are produced in accordance with the
vehicle speed, and vehicle-speed signals areinput to systems (the MFI system, etc.) that
regulate according to the vehicle speed.
TROUBLESHOOTING HINTS
1.The fuel gauge doesn’t function, or shows the
incorrect indication.
(1) Disconnect the connector of the fuel pumpand gauge unit assembly; the ‘F” side is
indicated when terminal (5) is then
grounded.l Check the fuel gauge.
2.The engine coolant temperature gauge doesn’t
function, or shows the incorrect indication.
(1)The “l-l” side is indicated when the connector
of the engine coolant temperature gauge
unit is disconnected and then grounded.l
Check the engine coolant temperature
gauge unit.
3. Systems dependent upon control according to
the vehicle speed do not function correctly.l Check the reed switch (mechanical
speedometer type)l Check the speed sensor (electrical
speedometer type)
coil pressure gauge>l
When the ignition key is at the “ON” position,
the oil pressure gauge is activated.
lWhen oil pressure is high, the internal contacts
of the gauge unit are kept closed for a longerperiod of time. This causes more current to
flow in the circuit, and the gauge pointer swings
to the high pressure side.
lWhen oil pressure is low, the internal contactsof the gauge unit open in a shorter period of
time. Therefore, there is less current flowing
in the circuit and the gauge pointer swings to
the low pressure side.

lWhen the ignition key is set to the “ON” position,the gauge indicator will be at
“0”.l
When the engine is started, the indicator will
move from
“0” to the minus (-) side, and then,as the boost level increases, it will move to
the plus
(+) side.
l When the ignition key is placed in the “ON”
position, the voltage gauge operates and indi-
cates a battery voltage of approximately 12 V.l
When the engine is started, the voltage gauge
indicates a battery voltage of 12 to 16 V, indicat-ing that the battery is on charge.
4. The oil pressure gauge doesn’t function, or
shows the incorrect indication.
(1)The “H” side is indicated when the connectorof the oil pressure gauge unit is discon-
nected and then grounded.l Check the oil pressure gauge unit.
5.The meter illumination light does not illuminate.
(1) The tail lights illuminate.l Check the rheostat.
6. The voltage gauge doesn’t function, or shows
the incorrect indication.l Check the voltage gauge.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX1
A
iiABSPOWER RELAY, Check . . . . . . . . . . . . . . . . . . . . , . . .
35-82-lRELAY.............................................35-110-1SIGNAL, On-vehicle Inspection.................13A-176,277-iACCELERATOR
CABLE..............................................
17-4-l
SWITCH
...............................23-51-l
........................17-4-l
ACTIVE AERO SYSTEM, Check.........................
51-7-l
ACTIVE EXHAUST
CONTROL UNIT, On-vehicle Inspection..........13A-173,274-lSYSTEM............................................15-40-l
AERO PARTS........................................51-19-lAIR BAG..........................................520-74-lMODULE......................................528-82, 87-lAIR CLEANER.........................................15-9-l
ELEMENT, Maintenance..............................00-45-lAIR CONDITIONING...................................55-3-l
.....................................55-54-l
.......................................55-6-lCOMPRESSOR.....................................55-79-l COMPRESSOR DRIVE BELT, Adjustment...............
55-18-lCONTROL PANEL...................................55-73-lCONTROL UNIT.....................................55-73-lENGINE COOLANT TEMPERATURE SWITCHEngine Cooling.....................................14-13-l.....................................55-79-l......................................55:53-lPOWER RELAY.....................................55-29-lPOWER TRANSISTOR...............................55-74-lSWITCH............................................55-33 -1Emission Control....................................17-65-lOn-vehicle inspection.........................13A-123,236-lANTENNAMotor............................................54-188-11FEEDER CABLE...................................54-188-11ANTI-LOCK BRAKE SYSTEM....................Refer to ABS
ASSIST LINK ..................................34-35-iAUTOMATIC TRANSAXLE.............................23-64-l
Maintenance
.........................................00-49-IAXLE
Rear
............................................27-6-l............................................27-2-l
HUB, Rear -&VD>
....................................
27-4-lSHAFT ......................................27-16-l
B
BALL JOINT SEALS, Maintenance. . . .
BAROMETRIC PRESSURE SENSOR
On-vehicle Inspection . . . . . . . . . . . .BASIC IDLE SPEED, Adjustment . . . . . .
BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . .
Discharged, Remedy . . . . . . . . . . . .
BELT LOCK CONTROLLER . . . . . . . . .
BLOWER. . . . . . . . . . . . . . . . . .
BOOSTER, Clutch . . . . . . . .BOOST METER, On-vehicle InspectionBRAKE
Parking. . . . . . . . . . ..*.............
BOOSTER . . . . . . . . . . . . . . . .
Operating Check . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . .00-52-l
..........13A-91,217-l..............
13A-55-l................64-3-11................35-82-l............55-32,74-t................
55-35-l.................21-6-l.........13A-171,273-l
.................36-8-l................35-87-l................35-64-l
DISC..........................................35-93,103-l
Front, Check.......................................35-70-IRear, Check........................................35-73-lFLUID LEVEL SENSOR, Check........................35-64-l
HOSES, Maintenance.................................00-52-I
LINE................................................35-91-lLINING.............................................35-74-lPAD
Disc, Front.........................................
35-66-l
Disc, Rear.............~..................>..........35-71-lPEDAL.............................................35-84-l
Check and Adjustment......................
:........35-63-lBUMPERFront...............................................51-8-lRear...............................................51-13-l
CAMSHAFT
OIL SEALS..........................................
11-21-lPOSITION SENSOR, On-vehicle Inspection......13A-103,225-lCATALYTIC CONVERTER..............................17-71-l.......................................15-30-l
.
..........................................
15-33-lCD AUTO CHANGER................................54-191-11CENTER PILLAR GLASS..............................42-33-l
CENTRAL DOOR LOCKING SYSTEM...................42-49-lCHARGE AIR COOLER................................15-11-l
CHARGING SYSTEM..................................l.6-2-11CIGARETTE LIGHTER..............................54-123-k
CLOCK SPRING, SRS..............................528-74-I
CLOSED THROTTLE POSITION SWITCH
Adjustment.......................................
13A-57-lOn-vehicle Inspection.........................13A-101,223-lCLUTCH
BOOSTER OPERATING, Check .................21-6-lCONTROL..........................................21-l O-ICOVER.............................................21-20-lDISC...............................................21-20-I
MASTER CYLINDER.................................21-14-lPEDAL..............................................21-8-lCheck and Adjustment................................21-5-l
RELEASE CYLINDER................................21-16-IVACUUM LINE cAWD>...............................21-18-I
COLUMN SWITCH..................................54-112-11COMBINATION GAUGES.............................54-33-kCOMBINATION LIGHT...............................54-106-11COMBINATION METERS.............................54-31-11COMPRESSOR CLUTCH RELAY,On-vehicle Inspection...........................13A-123,236-lCONDENSER.....................................55-79-l.....................................55-79-l CONTROLLER, Belt Lock..............................55-32-lCONTROL UNIT
Active Exhaust, On-vehicle Inspection...........13A-173,274-lECS.............................................338-20-I
Electronic CABS>..................................35-119-l
CONTROL VALVE.....................................37B-9-l
Fuel Tank Pressure..................................13F-6-IInspection..
........................................17-65-l
CRANKSHAFT
FRONT OIL SEAL....................................
11-25-lPOSITION SENSOR, On-vehicle Inspection......13A-107,227-l
REAR QIL SEAL.....................................11-26-l

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX
CROSSMEMBER......................................32-8-lCRUISE CONTROL......................................17-t
CABLE, Check and Adjustment........................17-31-l
SYSTEM............................................17-38-i
Check.............................................
17-32-l
CURB IDLE SPEED, Check............................11-11-l
CYLINDER HEAD GASKET............................11-28-l
D
DAMPER CONTROL MOTOR..........................55-75-lDAMPING FORCE CHANGEOVER ACTUATOR........338-19-I
DASHPOT, Check And Adjustment......................11-l 3-lDEFOGGER
Rear Window.....................................54-192-11
RELAY............................................54-204-11
SWITCH, Rear Window.............................54-203-11
DIFFERENTIALCase, Limited Slip cAWD>...........................27-40-ILimited Slip, Check cAWD>..........................27-15-tCARRIER ....................................27-25-l
DISC BRAKEFront..............................................35-93-lRear..............................................35-103-I
PADS, Maintenance..................................00-52-I
DOOR...............................................42-41-l
Adjustment.........................................42-12-lGLASS.............................................42-43-l
HANDLE............................................42-47-l
INSIDE HANDLE, Play Check..........................42-16-l
LATCH..............................................42-47-lMIRROR............................................51-31-l
REGULATOR........................................42-43-l
TRIM...............................................42-42- 1WATERPROOF FILM.................................42-42-lWINDOW GLASS, Adjustment.........................42-12-l
DRIP LINE WEATHERSTRIP...........................42-63-lDRIVE BELTCompressor, Adjustment.............................55-18-l
Maintenance.......................................00-47-I
Tension, Adjustment..................................11-7-l
Tension, Check.....................................37A-9-l
DRIVE SHAFTFront..............................................26-12-lRear...............................................27-19- I
BOOTS, Maintenance.................................00-52-l
OIL SEALS, Replacement
.......................23-53-l
........................................22-15-l
.........................................22-5-l
E
ECSOn-vehicle Inspection..............................,338-l 1 -I
CONTROL UNIT...................................338-20-IINDICATOR LIGHT.................................338-19-ISWITCH..........................................338-18-I
EGR
SOLENOID..........................................17-70-l
On-vehicle Inspection.........................13A-164,269-l
SYSTEM, Inspection..................................17-67-l
TEMPERATURE SENSOR............................17-68-l
On-vehicle Inspection.........................13A-i35,246-I
VALVE..............................................17-68-l
VALVE CONTROL VACUUM, Check....................17-67-l
ELECTRICAL LOAD SWITCH, On-vehicle Inspection 13A-127,238-l
ELECTRONIC CONTROL UNIT
CABS>.................35-119-l
ENGINE.............................................11-18-l
CONTROL...........................................17-5-lCOOLANT
Maintenance.......................................00-51 -IReplacement........................................14-4-l
COOLANT TEMPERATURE GAUGE UNIT..............14-13-l
COOLANT TEMPERATURE SENSOR
Engine and Emission Control.........................17-65-l
Engine Cooling.....................................14-13-IOn-vehicle Inspection..........................13A-93,219-lHOOD..............................................42-18-l
MOUNTING..........................................32-3-lOIL, Maintenance....................................00-47-l
OIL COOLER........................................11-36-lOIL FILTER, Maintenance.............................00-48-l
ROLL STOPPER......................................32-6-l
SPEED ADJUSTING SCREW, Adjustment.............
13A-59-l
EVAPORATIVE EMISSION
CANISTER..........................................
17-65-l
CONTROL SYSTEM.................................17-57-l
Check for Leaks and Clogging........................00-46-l
PURGE SOLENOID..................................17-64-lOn-vehicle Inspection.........................13A-162,268-lEVAPORATOR........................................55-37-lEXHAUSTGAS RECIRCULATION (EGR) SYSTEM................17-66-l
MANIFOLD
.......................................15-26-l
...........................................15-28-l
PIPE
.......................................15-30-l
...........................................15-33-l
SYSTEM
Active.............................................15-40-l
Maintenance.......................................00-60-l
F
FAN MOTORCondenser
.....................................55-79-l......................................55-46-l
RELAY, On-vehicle Inspection...................13A-129.240-t
FEEDER CABLE, Antenna...........................54-188-11FENDER.............................................42-24-l
FILLER TUBE CAP, Fuel Tank, Check....................17-65-lFLOOR CONSOLE..................................52A-1 O-I
FLOOR PAN, Check...................................42-16-l
FOG LIGHT........................................54-105-11
SWITCH..........................................54-109-11FRONT IMPACT SENSORS..........................526-68-l
FUELFILLER DOOR, Adjustment............................42-12-l
FILTER............................................13F-10-I
GAUGE UNIT........................................13F-6-IHOSES, Maintenance.................................00-45-l
LINE................................................13F-8-I
PRESSURE SOLENOID, On-vehicle Inspection...13A-166,270-l
PRESSURE TEST, On-vehicle Inspection........13A-180,279-lPUMP..............................................13F-6-I
On-vehicle Inspection..........................13A-72,200-l
PUMP CIRCUIT RESISTOR, On-vehicle Inspection .
13A-84,211-lPUMP OPERATION CHECK, On-vehicle Inspection 13A-179,279-lPUMP RELAY N0.2, On-vehicle Inspection........13A-84,211-l
SYSTEM, Maintenance...............................00-45-I
FUEL TANK..........................................13F-3-IFILLER DOOR.......................................42-23-lFILLER TUBE CAP, Check............................17-65-l
PRESSURE CONTROL VALVE........................
13F-6-IInspection..........................................17-65-l
FULL AUTO AIR CONDITIONING.......................55-54-l

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX0
OIL
Transmission, Replacement
eAWD>...........................................22-15- 1CFwD>............................................22-4-l
COOLER
Engine.............................................
11-36-lTransaxle..........................................23-62-lCOOLER HOSES, Transaxle..........................23-62-l
COOLER TUBES, Transaxle...........................23-62-lFILTER, Engine, Maintenance..........................00-48-l
LEVEL, Gear, Check LEVEL, Transmission, Check
............................................22-15-l.............................................22-4-lPAN................................................11-23-l
PRESSURE SWITCH, Power Steering, Check.........37A-13-l
SCREEN............................................11-23-lOPTICAL HORN LENS..............................54-106-11
P
PARK/NEUTRAL POSITION SWITCHAdjustment.........................................23-53-l
On-vehicle Inspection.........................13A-113,230-l
PARKING BRAKE......................................36-8-l
CABLE..............................................36-5-l
LEVER..............................................
36-5-lStroke Check........................................36-4-l
SWITCH, Check......................................36-4-l
POP-UP SWITCH...................................54-109-11
POSITION DETECTION SWITCH.....................338-19-l
POSITIVE CRANKCASE VENTILATION
SYSTEM, Inspection..................................
17-56-l
VALVE..............................................17-56-l
POWER STEERING
Stationary Steering Effort Check.......................37A-9-lFLUID............................................37A-10-I
GEAR BOX........................................37A-18-l
HOSES...........................................37A-33-l
OIL PRESSURE SWITCH, Check....................37A-13-l
OIL PUMP........................................37A-29-l
Pressure Test.....................................37A-12-l
PRESSURE SWITCH
On-vehicle Inspection.........................13A-121,235-l
POWER WINDOW....................................42-44-l
PROPELLER SHAFT...................................25-3-l
PROPORTIONING VALVE, Function Test.................35-65-l
PURGE CONTROL
SYSTEM, Check
.......................................17-58-l
...........................................17-60-lVALVE ......................................17-64-l
PURGE PORT VACUUM, Check........................17-63-l
R
RADIATOR............................................14-5-l
CAP, Pressure Test....................................14-4-l
RADIO.............................................54-186-11
ANTI-THEFT SYSTEM..............................54-156-11
RADIO REMOTE-CONTROL.........................64-l 86-k
REAR OIL PUMP, 4WS...............................378-11-l
DISCHARGE FLOW VOLUME, Check..................378-5-l
REAR WINDOW DEFOGGER........................54-192-11
SWITCH..........................................54-203-11
REFRIGERANT
Leak Repair Procedure..............................55-28-lLINE.....................................55-79-l......................................55-48-lREGULATOR, Door...................................42-43-lRELEASE CYLINDER, Clutch...........................21-16-lRESISTOR...........................................55-32-lRHEOSTAT........................................64-110-11
RIGHT MEMBER.......................................32-8-l
S
SEATFront
...........................................
52A-17-lRear . ............................................52A-25-lSEAT BELT.........................................52A-26-ISELECTOR LEVER...................................23-59-l
Operation Check....................................
23-51-lSENSORBarometric Pressure..............................Refer to B
Brake Fluid Level, Check.............................35-64-l
Camshaft Position................................Refer to C
Crankshaft Position...............................Refer to CEGR Temperature................................Refer to E
Engine Coolant Temperature.......................Refer to EFrontlmpact......................................528-68-IGcACTlVE EC%
..................................338-l 8-l.....................................35-117-l
Heated Oxygen..................................Refer to H
Induction Control Valve Position.....................
Refer to IIntake Air Temperature.............................Refer to I
Knock..........................................RefertoKSteering Angular Velocity...........................338-l 8-l
Throttle Position..................................
Refer to T
Vehicle Speed...................................Refer to V
Volume Air Flow..................................Refer to VWheelSpeed....................................Referto WSHIFT LEVER............................................22-16-lcFWD>.............................................22-8-l
SHIFT LOCK MECHANISM, Check......................23-52-lSHOCK ABSORBER............................................34-36-lcFWD>............................................34-13-lSOLENOIDEGR ...................17-70-IEGR, On-vehicle Inspection...................13A-164,269-l
Evaporative Emission Purge.......................
Refer to EFuel Pressure...................................Refer to F
Turbocharger Waste Gate.........................Refer to TSPARK PLUGMaintenance.......................................00-46-I
CABLE............................................
16-36-11SPEAKER..........................................54-187-11SPEEDOMETER CABLEReplacement............................................23-~-1 SPEED SENSOR, Wheel CABS>.......................35-113-l
SPEED SENSOR, Wheel, Output Voltage Measurement....35-75-lSRSMaintenance.......................................00-53-IDIAGNOSIS UNIT (SDU)............................528-71-ISTABILIZER BARFront Suspension.................................33A-12-l
Rear Suspension
...........................................34-38-l...........................................34-16-l