02 sensor MITSUBISHI 3000GT 1994 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine
i Service Manual
3000~l-
1992-l 996
Volume
2
Electrical
FOREWORD
i
L
This Service Manual has been prepared with the latest service information available at the time of
publication. It is subdivided into various group
categories and each section contains diagnossis,
disassembly, repair, and installation procedures
along with complete specifications and tightening
references. Use of this manual will aid in properly
performing any servicing necessary to maintain or
restore the high levels of performance and reliability
designed into these outstanding vehicles.
@
A
.
.,
WESUF’FORTVOLUNTARY TECHNICIAN
CERTiFiCATlON THROUGH
National lnaltute forAUTOMOTIV ESERVICEEXCELLENC E
Mitsubishi Motors Corporation reserves the right to make changesin design or to make additions to or improvements in its products withou\
timposing any obligations upon itself to install them on its productspreviously manufactured.
L
--
GROUP / SECTION INDEX
General. . . . . . . . . . . . . . . . . . . . . . . .
Fusible Link, Fuse an d IOD or
Storage Connector Locatio n
. . . . . . . . . .w
Inspection Terminal Location . . . . . . . . .
Grounding Location . . . . . . . . . . . . . . . . . .w
m
Relay Location . . . . . . . . . . . . . . . . . . . . . -m
Sensor Locatio
n. . . . . . . . . . . . . -. . . . . . .w
Control Unit Location . . . . . . . . . . . . . . . . .m
Solenoid, Solenoid Valve Location . . . . .d
Diode Location . . . . . . . . . . . . . . -. . . . . . .w
Junction Block . . . . . . . . . . . . . . . . . . . . . . .II
Centralized Junction . . . . . . . . . #. . . . . . .w
Harness Connector Inspectio n. I . . . . . .w
How to Diagnose . . . . . . . . . . . . . -. . . . . . .
111
Configuration Diagrams . . . . . . . . . . . - . .m;
Circuit Diagrams . . . ..*.............
Engine Electrical ...............
ChassisElectrical
............ .
Alphabetical Index .............
NOTE:
For information concerning all compo-
nents other than the electrical system and
on-vehicle service procedures for engines
and transmissions, refer to Volume 1
“Chassis & Body” of this paired Service
Manual.
For overhaul procedures of engines or
transmission, refer to the separately is-
sued Engine Service Manual or Manual/
Automatic Transmission Service Manual.
@ 1995 Mitsubishi Motors CorporationReprinted in USA

Downloaded from www.Manualslib.com manuals search engine GENERAL - Sensor Location9SENSOR
LOCATION
NameSymbol
Name
Symbol
ABS front speed sensorYKickdown servo switchM
ABS rear speed sensorZ
Knock sensorE
Air inlet sensor (for A/C)SLeft bank heated oxygen sensorD
Air therm0 sensor (for A/C)RManifold differential pressure sensor*4CAutomatic transaxle oil temperature sensor M
4lT>Photo sensor
TCamshaft
posit!on sensor and crankshaft N. . .Power steering pressure switchFposrtton sensor” I
Camshaft position sensor (from 1993 model)GPulse generator A, B M
Crankshaft position sensor (from 1993 model)HRevolution pick-up sensorI
EGR temperature sensor*3CcTurbo, Non Turbo (for California)>Right bank heated oxygen sensorD
Engine coolant temperature sensor (for A/C)QSteering wheel angle speed sensor0
Engine coolant temperature sensorL(for engine control)Therm0 sensor*2
K
Engine coolant temperature switch (for
A/C)*2LThermostatI
Front impact sensorIx1 Throttle position sensorIJ 1
G sensor (for ABS)PJ( Vehicle speed sensor (Reed switch)*’Ip I
G sensor(for ECS)*31 Vehicle speed sensorIB 1
Heated oxygen sensor*”ID( Volume air flow sensortA 1/III
Interior temperature sensorIw II I
NOIF
I:;
:
*2:
Up to 1992 models(3)
*3:
Up to 1993 models(4)
*a:
Up to 1995 models
From 1996 models
19FO13400004237
TSB Revision

Downloaded from www.Manualslib.com manuals search engine GENERAL - Sensor Location
00002701
Volume air flow sensor

Y7FUlOlO
pressure sensor
AOSFOOM

Downloaded from www.Manualslib.com manuals search engine GENERAL - Sensor Location
o> - 1994,1995 models for Federal

CUD to1993models>
r- m0.: \I0
wRevolution pick-up sens’or\u
/c, fdI
Throttle position
sensor
(with built-in
closed throttle
position switch)
and from1966 models
‘-I I I
built-in closed
) ) 1\ \l/ / \ \v/~~1026
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 12GENERAL - Sensor Location

I
> servo switch
LII f$3&FZX ‘AI 6F0063
Steering wheel
angle speed sensorY12FOO72

Vehicle speed sensor1
Y66FOO12
ZWFOO47I216FO26-3
TSB Revision

Downloaded from www.Manualslib.com manuals search engine GENERAL - Sensor Location
-
216FOO51
Interior temperature
sensor
4
Qs
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - How to Read Configuration Diagram37
,lHOW TO READ CONFIGURATION DIAGRAM
id actual vehicles.
L
Denotes connector No.The same connector No. is used throughout the circuit dia-
grams to facilitate connector location searches. The first al-
phabetical symbol indicates the location site of the connector
and a number that follows in the unique number. Numbers areassigned to parts in clockwise order on the diagram.
Examole: A-l 2
/Number specific to connector (serial number)
Connector location site symbol
A: Engine compartment
B: Engine and transaxle
C: Dash panel
D: Instrument panel and floor consoleE: Interior
F: Luggage compartment
Denotes ground point.Same ground number is used throughout cir-cuit diagrams to facilitate search of ground
point. Refer to P.4 for details of ground points.
A-01X
A-02X
A-03X
A-04X
A-05X
A-06X
A-07X
A-08X
A-09X
A AL\,
$~~~;~.--.-.*/hhA, ”
L^---,.-I II-m 1 lta>.I
J
n-1°KA-11X
\
LI
ueriotes a sermon covereaby a corrugated tube.236F0122
A-01X Headlight relayA-18A-02X ABS power relayA-l 9ignition timing adjustment connector
Front washer motorA-03X Fog light relayA-20
A-04XRadiator fan motor relay(L0)A-21Evaporative emission purge solenoid
EGR solenoidA-05X Taillight relay
A-06X Horn relay
A-22(Vehicles for California)
A-07X Radiator fan motor relay (HI)EGR temperature sensor
A-09X Starter relayA-23(Vehicles for California)
No connection A-l OX Generator relayA-24Brake fluid level sensorA-11XIOD or Storage connectorA-25
A-12ABS front speed sensor (RH)A-26ECS front shock absorber (LH)
Theft-alarm horn
A-13Theft-alarm horn
A-14ECS front shock absorber (RH)A-27
Washer fluid level sensorA-28
Auto-cruise vacuum pump
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 38CONFIGURATION DIAGRAMS - Engine Compartment
ENGINE COMPARTMENT
(UP TO 1993 MODELS)
Connector
symbol
A
01xthru
34X

A-20A-21
A-22
A-01X
A-02X
A-03X
A-04X
A-05X
A-06X
A-07X
A-08X
A-09XHeadlight relayABS power relay
Fog light relay
Radiator fan motor relay (LO)
Taillight relay
Horn relay
Radiator fan motor relay (HI)
Pop-up motor relayStarter
relavA-12 A-13A-14 A-15 A-16A:174-18
A-79 q-20 A:21 4-22
A-10X
A-11X
A-12
A-13
A-14
A-l 5
A-16
A-17
A-18Generator relayIOD or Storage connector
ABS front speed sensor (RH)
ECS front shock absorber (RH)
Washer fluid level sensor
Front wiper motor
Engine speed detection connector
Fuel pump check connector
Ignition timing adjustment connector
1 TSB RevisionI

Downloaded from www.Manualslib.com manuals search engine A-23A-24 A-25A-26
A-27
CONFIGURATION DIAGRAMS - Engine Compartment39
sJ=+?6Foo1300004251
A-l 9
A-20
A-21
A-22A-23
A-24
A-25
A-26
Front washer motor
Evaporative emission purge solenoid
EGR solenoid (Vehicles for California)
EGR temperature sensor
(Vehicles for California)
No connection
Brake fluid level sensor
ECS front shock absorber (LH)
Theft-alarm horn
piFE&l
A-27
A-26
A-29
A-30
A-31X
A-32X
A-33X
A-34X
Theft-alarm horn
Auto-cruise vacuum pump
ABS front speed sensor (LH)4WS fluid level sensor

Condenser fan motor relay (HI)
Radiator fan motor control relay
Magnetic clutch relay
Condenser fan motor relay (LO)

Downloaded from www.Manualslib.com manuals search engine CONFIGURATION DIAGRAMS - Engine Compartment

A-69A-70
\ \
36FOO14
A-35
A-36
A-37
A-38
A-39
A-40
A-41
A-42
A-43
A-44A-72 A-71A-67+
A-5
A-57 A-55A-54 A-53 A-52 A-51A-47A-48
A-49
A-50
Dual pressure switchAir conditioning relay box
Air conditioning relay box
SW front impact sensor (LH)
Front combination light (LH)inspection light switch
Headlight (LH)Front wiring harness and headlight wiring
harness (LH) combination
Fog light (LH)
POWJO motor (LH)A-45
A-46
A-47
A-48
A-49
A-50
A-51
A-52
A-53
A-54
A-55
Condenser fan motor
Condenser fan motor
Horn
Horn
Horn
Horn
Fuel pump resistor
A/T fluid temperature sensor
Kickdown servo switch GAIT>
Pulse generator
Radiator fan motor
TSB Revision