turn signal MITSUBISHI LANCER EVOLUTION IX 2005 Workshop Manual
[x] Cancel search | Manufacturer: MITSUBISHI, Model Year: 2005, Model line: LANCER EVOLUTION IX, Model: MITSUBISHI LANCER EVOLUTION IX 2005Pages: 364, PDF Size: 14.38 MB
Page 59 of 364

13A-19MPI – TROUBLESHOOTING
Check the operation of the inter-
cooler water spray
•Ignition switch: ON
•Inter-cooler water spray
switch (manual): ON
OK:Inter-cooler water spray
operates
Check the operation of the inter-
cooler water spray
•Undo the engine ECU
connector C-50, and earth
terminal 56.
•Ignition switch: ON
OK:Inter-cooler water spray
operates
Check connector:C-220
Check the inter-cooler water
spray relay (Refer to Section 15:
Intake/Exhaust)
Go on to the next page
Measure at the inter-cooler water
spray switch connector D-32
•Undo the connector and
measure on the harness side
•Ignition switch: ON
•Voltage across earth at 5
OK:battery voltage
Check connectors: C-22 & C-50
Check connector: D-32
Inspect the harness between the
engine ECU and the inter-cooler
water spray switch
•Check if the signal wire is cut
or has short circuited
Replace the engine ECU
Check connectors: C-22 & C-50
Measure at the inter-cooler water
spray switch connector D-32
•Undo the connector and
measure on the harness side
•Ignition switch: ON
•Voltage across earth at 3 & 5
OK:battery voltage
Replace the inter-cooler water
spray relayReplace engine ECU
Check the inter-cooler water
spray switch (Ref Section 15:
Intake/Exhaust)
Inspect the harness between the
inter-cooler water spray switch
and the engine ECU
•Check if the signal wire is
damaged
Temporary malfunction (Ref
Section 00: Dealing with
temporary malfunctions)
Check connector:D-32
Check the inter-cooler water
spray switch
(Ref Section 15: Intake/Exhaust)
Check connector:C-107
Replace the inter-cooler water
spray relayInspect the harness
between the inter-cooler water
spray switch and earth
•Check if the earth wire is cut
or damaged
Inspect the harness between the
inter-cooler water spray switch
and the engine ECU, repair if
necessary
•Check if the signal wire is
damaged
Inspect the harness between the
engine ECU and the inter-cooler
water spray switch
•Check if the signal wire is cut
or has short circuited
OK
NG
NG
OK
NG
NG
OK
OK
OK
OK
NG
OK
OK
NG
NG
Repair
Inspection procedure 35
Inter-cooler water spray circuit systemProbable causes of the malfunction
•If the inter-cooler water spray switch (manual) is turned ON, the inter-cooler
water spray manual ‘ON’ signal will be input in the engine ECU. When this
signal is received, the engine ECU will turn the inter-cooler water spray relay
ON, and will start the inter-cooler water spray motor. Water will be sprayed
into the inter-cooler to cool intake air, and filling efficiency will improve.
•If the inter-cooler water spray switch (auto) is turned ON, the inter-cooler
water spray auto ‘ON’ signal will be input in the engine ECU. When this
signal is received the engine ECU will intermittently run at a high load, it will
turn the inter-cooler water spray relay ON, and it will start the inter-cooler
water spray motor. Water will be sprayed into the inter-cooler to cool intake
air, and filling efficiency will improve.•Malfunction of the inter-cooler water
spray switch.
•Malfunction of the inter-cooler water
spray relay.
•Malfunction of the inter-cooler water
spray motor.
•Circuit break, short circuit or a faulty
connection in the inter-cooler water
spray relay circuit.
•Circuit break, short circuit or a faulty
connection in the inter-cooler water
spray switch circuit.
•Malfunction of the ignition switch.
•Malfunction of the engine ECU.
Replace the engine ECU
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
OKNGRepair
Repair
Page 154 of 364

LAYOUT DIAGRAMS - ENGINE COMPARTMENT1-4
A-01 (2-grey) Side turn signal lamp (RH)
A-02 (2-grey) Brake fluid level switch
A-04 (2-grey) Side turn signal lamp (LH)
A-05 (2-black) Front ABS sensor (LH)
A-06X Fog lamp relay or spare connector for fog
lamp relay
A-07X Horn relay
A-08X Condenser fan relay (LO)
A-09X Condenser fan relay (HI)
A-11X Radiator fan control relay
A-12X Front ECUA-13X (11) Front ECU
A-14 (2-black) Junction between front harness (LH) and
control harness
A-16 (2-black) Headlamp (HI : LH)
A-19 (3-grey) Radiator fan controller
A-20 (1-black) Horn (HI)
A-21 (2-brown) External air temperature sensor (vehicle
fitted with fully automatic A/C)
A-22 (1-black) Horn (LO)
A-23 (2-black) Headlamp (HI: RH)
A-28 Spare connector for fog lamp
A-29 Dummy connector
ENGINE COMPARTMENT
Connector Symbol
Front harness (RH)
Page 188 of 364

3-1
SECTION 3
CIRCUIT DIAGRAMS
CONTENTS
J/B ............................................................3-4
J/C ............................................................3-6
Central Junction....................................3-11
Power Supply ........................................3-18
Starting System ....................................3-23
Ignition ...................................................3-24
Charging ................................................3-26
Engine Control ......................................3-28
Cooling ..................................................3-36
Lighting
Headlights (excl. discharge type).....................3-38
Headlights (discharge type) .............................3-42
Tail lights, position lights, licence plate
lights, lighting monitor report buzzer................3-46
Cabin lights, boot compartment lights,
ignition key cylinder illumination light,
door ajar indicator light ....................................3-50
Fog lamps ........................................................3-54
Headlight levelling system ...............................3-58
Signals
Turn signal lights, hazard warning lights .........3-60
Reversing lights ...............................................3-64
Stop lights ........................................................3-65
Horn .................................................................3-66
Meters
Needle meters..................................................3-68
Remaining fuel warning light, oil pressure
warning light, brake warning light,
seatbelt warning light .......................................3-70
Door Opening / Closing Control
Power windows ................................................3-72
Central door locking
(vehicle without keyless entry) .........................3-78
Central door locking
(vehicle with keyless entry) ..............................3-80
Temperature Control
Heater ..............................................................3-86
Manual air-conditioning ....................................3-90
Fully automatic air-conditioning .......................3-96
Vision / Safety
Windscreen washer / wipers ..........................3-104
Rear washer / wiper .......................................3-108
Demister
(vehicle with heater or manual A/C) ...............3-110
Demister, door mirror heating elements
(vehicle with full auto A/C)..............................3-112
Electric stowable remote control
door mirrors ....................................................3-114
Accessories
Spare audio connectors .................................3-118
Clock ..............................................................3-120
Cigarette lighter, ashtray illumination lamp ....3-121
Cont. on next page
Page 193 of 364

CIRCUIT DIAGRAMS - J/C3-6
J/C
Note :
In the actual vehicle, any of the terminals connected inside the J/C
may be used. Therefore the terminal numbers indicated on the circuit
diagrams may not correspond to the terminal sequence in the vehicle.
• Windscreen
washer/wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning
buzzer•Fog lamps
•Headlights
•Headlight
levelling
system
•Rear washer /
wiper
Full auto A/C
Generic spare
connector
Generic spare
connectorFog lamps
Spare audio
connector
• Demister (vehicle w/out
full auto A/C)
• Demister, door mirror
heating elements (vehicle
with full auto A/C)
• Heater
• Full auto A/C
• Manual A/CCigarette
lighter, ashtray,
illumination
light
Clock• ACD (vehicle
w/out AYC)
• ACD, AYC
Head-light
levelling systemTurn signal
lights, hazard
lights
Inter-cooler
water spray• ACD (vehicle w/out AYC)
• ACD, AYC
• Intercooler water spray
• Clock
• Cigarette lighter, ashtray
illumination lights
• Needle meters
• Turn signal lights, hazard
lights
• Demister (vehicle w/out full
auto A/C)
• Demister, door mirror heating
elements (vehicle with full
auto A/C)
• Tail lights, position lights,
licence plate lights, lighting
monitor warning buzzer
• Generic spare connector
• Fog lamps
• Full auto A/C Clock
Spare audio
connector• ACD (vehicle
w/out AYC)
• ACD, AYC
• Engine control
• Warning lights
• Needle metersGeneric
fuse
J/B
(
)
Generic
fuse
Page 194 of 364

CIRCUIT DIAGRAMS - J/C3-7
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer•Fog lamps
•Full auto A/C
•Headlights
•Headlight
levelling
system
•Manual A/C
•Cooling
• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights• Ignition key
reminder
buzzer
• Windscreen
washer / wiper
• Sunroof
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer• Power windows
• Fog lamps
• Headlight
• Rear washer /
wiper Generic spare
connector
Vehicle speed
sensor• Windscreen washer /
wiper
• Electric stowable
remote control door
mirrors
• Cabin lights, boot
compartment lights,
ignition key cylinder
illumination light, door
ajar indicator light
Diagnosis
connector• ABS
• ACD
(vehicle
w/out AYC)
• ACD, AYC Needle meters• Heater
• Full auto A/C
• Manual A/C
J/B
Sunroof
Power
windows• Windscreen
washer / wiper
• Turn signal
lights, hazard
lights
• Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
• Fog lamps
• Headlights
• Rear washer /
wiperDiagnosis
connectorReversing
lights
Rear washer/
wiper• Reversing lights
• Rear washer /
wiper Generic
fuse
(
)
Page 195 of 364

CIRCUIT DIAGRAMS - J/C3-8
J/C (cont’d)
•Ignition key
reminder
buzzer
•Windscreen
washer / wiper
•Sunroof
•Security alarm
•Central door
locking
•Turn signal
lights, hazard
lights•Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning buzzer
•Electric
stowable
remote control
door mirrors
•Power
windows
•Heater
•Fog lamps•Full auto A/C
•Headlights
•Manual A/C
•Rear washer /
wiper
•Cabin lights,
boot
compartment
lights, ignition
key cylinder
illumination
light, door ajar
indicator light•Ignition key reminder buzzer
•Intercooler water spray
•Security alarm
•Central door locking (vehicle
with keyless entry)
•Cabin lights, boot
compartment lights, ignition
key cylinder illumination light,
door ajar indicator light
•Warning lights
•Starting system
Electric stowable
remote control
door mirror
Headlight
levelling
system
•ABS
•ACD
(vehicle
w/out AYC)
•ACD, AYC•Clock
•Turn signal
lights,
hazard lights
Fog lamps
Headlight
levelling systemFog lamps
Cigarette
lighter
illumination
light•Demister (vehicle
w/out full auto A/C)
•Demister, door
mirror heating
elements (vehicle
with full auto A/C)
•Heater
•Full auto A/C
•Manual A/C•ACD (vehicle
w/out AYC)
•ACD, AYC
Intercooler
water spray
Turn signal lights,
hazard lightsNeedle meters
Page 197 of 364

CIRCUIT DIAGRAMS - J/C3-10
J/C (cont’d)
Diagnosis
connector
Full auto
A/C
•ABS
•ACD (vehicle
w/out AYC)
•ACD, AYC•ACD (vehicle
w/out AYC)
•ACD, AYC
•Engine
control
•IgnitionNeedle meter•Engine control
•Needle meter
•Ignition
•Engine control
•Full auto A/C
•Manual A/C
•Cooling
Engine immobiliser system •Engine
immobiliser
system
•Engine control Engine
control
•Engine immobiliser system
•Engine control
•Full auto A/C
•Manual A/C
•Cooling •ACD (vehicle
w/out AYC)
•ACD, AYC
•ABS
•ACD (vehicle
w/out AYC)
•ACD, AYC •ACD (vehicle w/out
AYC)
•ACD, AYC
•ABS
•ACD (vehicle
w/out AYC)
•ACD, AYC •ABS
•ACD (vehicle
w/out AYC)
•ACD, AYC•Security alarm
•Horn Security alarm
Horn
•Ignition key
reminder
buzzer
•Windscreen
washer /
wiper
•Sunroof
•Security alarm
•Central door
locking•Turn signal
lights, hazard
lights
•Tail lights,
position lights,
licence plate
lights, lighting
monitor
warning
buzzer •Electric
stowable
remote control
door mirrors
•Power
windows
•Fog lamps
•Rear washer /
wiper •Cabin lights,
boot
compartment
lights, ignition
key cylinder
illumination
light, door ajar
indicator light
Page 205 of 364

3-18CIRCUIT DIAGRAMS - POWER DISTRIBUTION
Battery
Fusible
links
Charging
Charging •ACD (vehicle
w/out AYC)
•ACD, AYC•Full auto A/C
•Manual A/C
•Cooling
Dedicated
fuses
•Full auto A/C
•Manual A/C
•CoolingEngine control
•Security alarm
•Central door
locking (keyless
entry)
•Turn signal
lights, hazard
lights•Full auto
A/C
•Manual
A/C
•Cooling•ABS
•ACD
(vehicle
w/out AYC)
•ACD, AYC
•Stop lights•Heater
•Full auto
A/C
•Manual
A/C
POWER DISTRIBUTION
Page 206 of 364

CIRCUIT DIAGRAMS - POWER DISTRIBUTION3-19
Headlight
relay LOHeadlight
relay HITail light
relay
•Engine
immobiliser
system
•Engine
control
•Ignition•Security
alarm
•Horn•Fog lamps
•Spare
connector
for fog
lampsHeadlights Headlights Headlights Headlights
Front ECU
Headlight
levelling
systemTail lights, position
lights, licence
plate lights,
lighting monitor
warning buzzer
•ACD (vehicle
w/out AYC)
•ACD, AYC
•Intercooler water
spray
•Spare audio
connector
•Clock
•Cigarette lighter,
ashtray illumination
lights
•Needle meter
•Turn signal lights,
hazard lights
•Tail lights, position
lights, licence plate
lights, lighting
monitor warning
buzzer •Demister (vehicle
w/out full auto A/C)
•Demister, door
mirror heating
elements (vehicle
with full auto A/C)
•Generic spare
connector
•Heater
•Fog lamps
•Full auto A/C
•Headlight levelling
system
•Manual A/C Note :
*1 : Except discharge type headlights
*2 : Discharge type headlights
(((
)
))
Page 207 of 364

CIRCUIT DIAGRAMS - POWER DISTRIBUTION3-20
Power distribution (continued)
Fusible link
Dedicated
fuse
Intercooler
water spray Ignition
switch
•Engine control
•Starting system
Ignition
•ABS
•ACD (vehicle
w/out AYC)
•ACD, AYC
•SRS airbags,
seatbelt pre-
tensioners
•Ignition key
reminder buzzer
•Intercooler water
spray
•Windscreen
washer / wiper
•Warning lights
•Engine control
•Sunroof
•Needle meters
•Charging
•Security alarm
•Central door
locking•Turn signal lights,
hazard lights
•Tail lights, position
lights, licence plate
lights, lighting
monitor warning
buzzer
•Electric stowable
remote control
door mirrors
•Power windows
•Generic spare
connector
•Fog lamps
•Headlights
•Rear washer /
wiper
•Cabin lights, boot
compartment
lights, ignition key
cylinder
illumination light,
door ajar indicator
light •SRS airbags,
seatbelt pre-
tensioners
•Reversing
lights
•Rear washer /
wiper Engine control