clutch MITSUBISHI PAJERO 1996 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine YLEISESTI , ,.,'. .' .,.... GEN~~At li\fFORMi,XTIOI\f
10
Asbestos safety instructions EB07A·Ac
For England "Certain parts fitted to this vehicle contain Asbestos . Please follow the Garage Workers Asbestos Code' listed below when handling such components."
1.
DON'T blow dust with an air line .
2 . DON'T grind or drill , unless the machine has exhaust
ventilation or a ventilated booth to work in.
3 . DON'T use a brush to sweep up the dust.
4 . DON 'T take protective clothing home. It should be cleaned
by your employer .
5 . DON 'T use equipment if it is not maintained and checked .
If in doubt. ask to see the examination reports.
6 . DO use properly designed equipment which prevents dust escaping , or use clean wet rags . When used, place the used
rags in a plastic waste bag while still wet.
7 . DO use a special (Type H) vacuum cleaner to remove dust if applicable .
8 . DO
wet the dust thoroughly and scrape it up if the above
vacuum cleaner is not available .
9 . DO wear protective clothing, such as overalls that your employer provides.
10. DO dispose of Asbestos waste in accordance with the
regulations.
The
complete Garage Workers Asbestos Code can be
obtained free of charge from The Environmental Health
Department of your local authority or The Health and
Safety Executive.
PLEASE NOTE
"THIS MODEL USES
ASBESTOS FREE BRAKE AND CLUTCH PARTS."

Downloaded from www.Manualslib.com manuals search engine KAYNNISTYS JA AJO . STARTING AND DRIVING
Suurin sallittu vetokoukun palloniveleen kohdistuva
kuormitus
Alkaa koskaan ylittakb Teknillisissa tiedoissa ilmoitettua sail it­
tua kuormitusta. (Katsokaa sivua 115.)
Kayttovihjeita
(1) Alkaa antako kytkimen luistaa (ajoneuvoissa joissa on
kasivaihteisto ainoastaan). alk aaka lisatkb kayn-nistaessanne tarpeettomasti moottorin nopeutta. (2) Alkaa ylittakb nopeutta, joka on suosite ltu peravaunua
hinattaessa .
(3) Valttaaksenne tybntbjarrusta johtuvia tbytaisyja painakaa jarrupoljinta ensin kevyesti ja sitten voimakkaammin. (4) Saadaksenne tayden hybdyn moottorijarrusta vaihtakaa
pienemmalle ennen alamakea . (5) Peravaunun hinaaminen tuottaa lisarasitusta rungolle, jar­ruille, kytkimelle ja alustalle. (6) Peravaunun paino ja suurempi kitka ja ilmanvastus lisaavat polttoaineenku lutusta.
lisavarotoimenpiteita ajoneuvoille joissa on auto­
maattinen vaihteisto
Asentoa "2" suositellaan kaytettavaksi rinteissa tai alhal-sella nopeudella ajettaessa. Kayttakaa asentoa "L" vuoristoteilla,
koska silloin moottorijarru toimii parhaiten edesauttaen nain
jarrujarjestelmaa. Varmistakaa kuitenkin etta nopeus ei ylita valitulle vaihteelle asetettua nopeusrajoiutsta.
Mita tulee maksiminopeuteen, katso kohtaa "Mahdollinen ajo­nopeU(>" sivulta 131.
116
Maximum trailer-nose weight
Never exceed the maximun trailer-nose weight as listed in the specifications. (Refer to page 115.)
Operating hints
(1) Do not let the clutch slip (vehicles with a manual trans­mission only) and do not increase the engine speed more than necessary when starting. (2) Be sure that the driving speed does not exceed the maximum speed for trailer operation. (3) To prevent shocks from the overrun brake, depress the brake pedal lightly at first and then more strongly. (4) To make full use of engine braking, change to a lower gear
before descending a slope . (5) The body, brakes, clutch, and chassis will be under addi ­tional strain when towing a trailer . (6) The heavier weight and the higher rolling and air resistance
w ill increase fuel consumption.
Additional precautions for vehicles equipped with
an automatic transmission
It is recommended the "2" position on slopes or at low speed.
Us e the "L " position in mountainous areas in order to make
better use of engine braking and to assist the brake system. However, be sure that the speed does not exceed the maximum speed limit for the selected gear.
For
maximum speed, refer to the description of the "Possible driving speed" on page 131.

Downloaded from www.Manualslib.com manuals search engine KAVNNISTYS JA AJO.'· . STARTING AND DRIVING
Bensiinikayttoi-set ajoneyvot
Tama auto on varustettu elektronisesti ohjatulla suihkutusjar­
jestelmalla, joka saatelee automaattisesti polttoaineen maaran.
Kaynnistaessasi
moottoria ala paina kaasupoljinta.
1 . Veda kasijarru paalle.
2 . Kasivalitteisella vainteistolla varustetussa autossa siirretaan
vainde "
N" asentoon (vapaalle) ja kytkin painetaan poh­
jaan . Automaattivaihteisessa autossa sarretaan vaihteenva ­
litsin
"P" asentoon .
3 . Kaynnista moottori painamatta kaasupoljinta .
HUOM Mikali moottori on saanut liikaa polttoainetta, pyorita moottoria 5 -6 sekuntia kaasupoljin pohjaan painettuna. Kaynnista moot­tori taman
jalkeen koskematta kaasupolkimeen.
Erittain kylmassa ympariston lampotilassa
Jos moottori ei tahdo kaynnistya, painakaa kaasutinpoljinta
noin puolivaliin saakka samalla kun yritatte kaynnistaa mootto­ria. Heti kun moottori kaynnistyy, vapauttakaa kaasutinpoljin.
120
Petrol-powered vehicles
This vehicle is equipped with an electronically controlled
injection device and fuel injection amount is automatically controlled. When starting the engine, do ot depress the accel ­
erator pedal.
1 .
Apply the parking brake.
2 . On vehicles with a manual transmission , move the gearshift lever to the "N" position (Neutral) and depress the clutch pedal all the way. On vehicles with an automatic transmis ­
sion, move the selector lever to the "P" position. 3 . Start the engine without depressing the accelerator pedal.
NOTE
If the engine has become flooded during starting , first operate
the starter for 5 or 6 seconds while depressing the accelerator
pedal fully, and then start the engine without depressing the
accelerator pedal.
At extreme cold ambient temperature
If the engine won't start, depress the accelerator pedal about halfway during cranking the engine. Once the engine starts,
release the accelerator pedal.

Downloaded from www.Manualslib.com manuals search engine -
KAVNNISTYS JA AJO· . STARTING AND DRIVING·
Dieselkayttoiset ajoneuvot HI02S·K
Ajoneuvot. joissa el ole dieselin esilammityksen
merkkivaloa
1. Pankaa pysakbintijarru paalle.
2 . Ajoneuvoissa joissa on kasivaihteisto , siirretaan vaihdevipu
vapaalle ja painetaan
kytkin aivan pohjaan. Ajoneuvoissa
joissa on automaattivaihtesto, slirretaan valitsinvipu "P"­asentoon. 3. Kayttakaa kaasupoljinta seuraavasti:
(1) Kin ilman lampbtila on normaali tai moottori lammin kayn­
nistakaa
moottori painamatta kaasupoljinta. (2) Kun ilman lampbtila on matala ja moottori on kylma
kaynnistakaa moottori samalla painaen kaasupoljinta . 11-man lampbtilan ollessa hyvin matala kaynnistyy moottori helpommin jos virta-avaimen kaantaa "ON" asentoon
muutamaksi sekunniksi ennenkuin moottori kaynnistetaan.
Ajoneuvot. joissa on dieselin esilammityksen merk­
kivalo
1. Pankaa pysakbintijarru paalle. 2. Ajoneuvoissa joissa on kasivaihteisto, siirretaan vaihdevipu
vapaalle ja painetaan kytkin aivan pohjaan . Ajoneuvoissa
joissa on automaattivhteisto, slirr etaan valitsinvipu "P"­asentoon.
3 . Kaantakaa virta-avain ON asentoon . Dieselin esilam­
mityksen merkkivalo palaa ensin punaisena ,
muuttuen het­
ken kuluttui vihreaksi merkiksi siita, etta esilammitys on
suoritettu.
Diesel-powered vehicles EI02S·K
Vehicles not equipped with diesel preheat indica­
tion lamp
1 . Apply the parking brake.
2. On vehicles with a manual transmission , move the gearshift
lever to neutral and depress the clutch pedal all the way. On
vehicles with an automatic transmi ssion, move the selector
lever to the" P" position . 3. Operate the accelerator pedal as described below in accor­
dance with the atmospheric temperature and/or engine condition and then start the engine .
(1) When the atmospheric temperature is moderate or the
engine is warm , start the engine without depressing the
accelerator pedal.
(2) When the atmospheric temperature is low and the engine is cold, start the engine while depressing the accelerator
pedal. If the atmospheric temperature is very low, setting
the ignition switch to ON for one or two seconds before attempting to start the engine will make it easier to start
Vehicles equipped with the diesel preheat indication
lamp
1. Apply the parking brake. 2. On vehicles with a manual transmission , move the gearshift
lever to neutral and depress the clutch pedal all the way. On
vehicles with an automatic transmission , move the selector
lever to the" P" position .
3. Turn the ignition key to the "ON" position. The diesel­
preheat indication lamp will first illuminate in red , and then
after a short time change
to green, indicating that preheat­
ing is completed.
121

Downloaded from www.Manualslib.com manuals search engine KAVNNISTYS JA AJO' . .', . 0.' STARTING AND DRIVING ., " ,-'" , .
HUOM Nuppi tulee veta a ulos niin pitkalle, etta se palautuu korkein­taan 10 mm:n etaisyydelle kokonaan ulosvedetysta asennosta. Jos nuppi liikkuu liian jaykasti , tai palautuu liikaa , saatakaa pidiketta kaantamalla .
& VAROITUS Alkaa milloinkaan yrittako tyhjakayntianupilla ajon aikana .
Kasivalintainen vaihteisto
Vaihdekaava on merkitty vaihdetangon nuppiin. Paina kytkinpoljin pohjaan
saakka joka kerran vaihtaessasi. Viitos­
vaihteelta peruutusvaihteelle vaihtaes­
sasi siirra vaihde ensin
N-asentoon (va­paalle) ja sitten peruutusvaihteelle .
& VAROITUS Ala koskaan vaihda peruutusvaih­teelle auton ·liikkuessa eteenpain;
se
vahingoittaa vaihteistoa.
NOTE
The knob should be pulled out to the extent that it returns less
then about 10 mm (0. 4 in.) from the fully pulled out position. If the knob doesn't move freely enough, or returns more than 10 mm (0.4 in.), adjust by turning the holder cap.
& CAUTION Never attempt to adjust the vehicle during driving by using the control knob.
71 N0031
Manual transmission FI29AA
The shift pattern is shown on the gear ­shift lever knob. Be sure to always fully depress the clutch pedal before attempt­ing to shift the lever. To shift into revers e from 5th gear, move the gearshift lever to the "N" position,
and then shift it into reverse .
& CAUTION Do not move the gearshift lever into reverse while the vehicle is
moving forward; doing so will damage the transmission .
123

Downloaded from www.Manualslib.com manuals search engine KAYNNISTYS JA AJO . STARTING AND DRIVING
Shift lever position and 2WD/4WD operation indi­
cation lamp El30B-A
Shift lever
posi tion
2 H
2WD/4WD operation indica­
tion lamp
~ 74E0025 D
rive U
se
When driving on dry normal 2WD roads and expressway economically
---------1------1 ---------
4H
74E0026
4HLc
74E0024
N
74E0023
4LLc
74E0024
Basic position of Super­
Fuli -tlme4WD select 4WD. W he n dri vin g
Io n n ormal roa ds, expressway an d s lippe ry roads.
Center
dlfferen- When dnvlng on rough. sand
tlal and deep
snow roads
lock lamp
Neu t
ral
Low range
cen te r differ ­
ential lock
4WD
When th e mechan ical winch IS used. (The vehicle can not be driven with the shift lever In this position)
When dnvlIlg up or descend ·
ing steep slopes or rough road
such as muddy road (Espe­
Cially when Increased drive power IS required.)
~PO· I d I th I t on IS on y mo e S WI manua ransmlSSlOn .
·Lh CAUTION (1) Don't drive your vehicle in the "4llc" or "4Hlc" position on the public road; this would result in early wear of the tyres, clutch and other parts,
increased fuel consumption and possible noise
generation.
(2) Use 1st gear in the "4LLc" position for very low­speed off-road driving. (3) The operation indication lamp flashes while shift­ing is in progress.
.,

Downloaded from www.Manualslib.com manuals search engine KAVNNISTYS JA AJO , STARTING AND DRIVING
Kasivalitteisella vaihteistolla va­rustetut ajoneuvot
Vehicles with manual transmission
4LLc [=:J"2H" <=t "4H" <=t "4HLc"
=="2H" <=t "4H" <=t "4HLc" N
Vaihto
niiiden asentojen viilillii on mah ­
dollista ajoneuvon ollessa pysiiytetty tai sen liikkuessa . Jos vaihto aiotaan tehdii ajoneuvon liikkuessa, vaihda kaasu­polkimen vapauttamisen jiilkeen ajoneu­von kulkiessa suoraan eteenpiiin.
HUOM Vaihto asentojen "2H" ja "4H" viilillii
tulee tehdii aile 100 km/h nopeudessa.
_ "4HLc" <=t "N" <=t "4LLc"
Vaihto
niiiden asentojen viilillii on mahdollista ajoneuvon 01-lessa pysiiytetty.
Vaihto on suoritettava joko sen jiilkeen , kun kytkin on painettu
pohjaan tai vaihteiston vipu on asetettu vapaalle painettaessa
jakovaihteiston vipua alas.
71EOO30
The lever can be operated between these positions while the vehicle is either
stopped or moving. In case the opera­tion is to be made while the vehicle is moving, ope rate the lever after easing
the accelerator pedal with the vehicle running straight ahead.
NOTE Shifting of the lever between "2H" <=t "4H" should be made at the speed be­low 100 km/h(62 mph).
_ "
4HLc" <=t "N" <=t "4LLc"
The lever can be operated
between these positions while the
vehicle is stopped .
The operation should be made after either depressing the clutch pedal or setting the transmission shift lever to the neutral
position while keeping the transfer shift lever pushed down.
137

Downloaded from www.Manualslib.com manuals search engine '-
KAVNNISTYS JA AJO STARTING AND DFJIVING
Shift lever position and 2WD/4WD operation indi­
cation lamp EI3 t B ·A
Shift leve r
2WD/4WD
posit ion o peration in dica -Drive Use
t io n lamp
2H
~,
2WD When dnving on norma l roads
and expressw ay
4H
~
Whe n dnv ing deep snow. sand
High lange
or r ough roads w ith normal
'i 74 E 02 8
4WD spe ed
~W"
When the mec h anIcal win ch IS
N Neulral used
(The vehicle can nO I b e driven with the shift lever in thi S pos ition .)
W hen dn
ving up o r descend ·
~'"
ing Sleep slo pes or r ou g h ro ads
4L Low rang e su ch as m uddy
road (Espe· 4WD cially when Inc reased dnve
power is requir ed )
& CAUTION '" \':: .. , '(1) Four-wheei dr!ve' should never 6e used on paved
road
!?urfaceS. Do not drive your ve.~icle in the "4L " position on the 'pul)lic road; this "would reSult in
early wear of the. tvres; .cLutchand other .parts. increased fuel c()ns~mption and pos~ible noise
generation. .'
.' " .
(2) Use 1 st gear in the "4L" position for very low-speed off-road driving . ' '. .'.
141

Downloaded from www.Manualslib.com manuals search engine ,KAVNNISTYS JA AJO · STARTING AND·DRIVING
Jakovaihteiston vivun kaytto
(Kasisaatoisilla napalukoilla va­
rustetut ajoneuvot) HI31C·A
¢ "2H" --> "4H"
1 . Aseta kasisaatoiset napalukot asen­toon "LOCK". 2. Vaihto naiden asentojen valilla on mahdollista ajoneuvon ollessa joko pysaytettyna tai sen liikkuessa . Jos aiotaan vaihtaa ajoneuvon liik­
kuessa, vaihda sen jalkeen , kun olet
vapauttanut kaasupolkimen ajoneu­von kulkiessa suoraan eteenpain .
_ "4H" ;::t "N" ;::t "4L"
N
Vaihto naiden asentojen valilla voidaan suorittaa ajoneuvon ollessa pysahtyneena. Vaihda sen jalkeen , kun olet joko paina­
nut kytkimen alas tai asettanut vaihdevivun vapaalle .
~ "4H" --> "2H"
Vaihto naiden asentojen valilla on mahdollista ajoneuvon 01-lessa joko pysaytettyna tai liikkuessa . Jos vaihto aiotaan suo­
rittaa ajoneuvon liikkuessa , vaihda vapautettuasi kaasupolki­
men ajoneuvon kulkiessa suoraan eteenpain .
142
71 EOO32
Transfer shift lever operation
(Vehicles equipped with manual
free-wheeling hubs) EI31C·A
¢ "2H" --> "4H"
1 . Set the manual free-wheeling hubs to "LOCK" position.
2 . The lever can be operated between
these positions
while the vehicle is
either stopped or moving. In case
the operation is to be made while the vehicle is moving, operate the
lever after easing the accelerator
pedal
with the vehicle running straight ahead.
_ "4H" ;::t "N" ;::t "4L"
The lever can be operated between these positions while the
vehicle is stopped.
Operate the transfer shift lever after either depressing the clutch pedal or setting the transmission shift lever to neutral position .
~ "4H" --> "2H"
The lever can be operated between these positions while the vehicle is either stopped or moving. In case the operation is to be made while the vehicle is moving,
operate the lever after easing the accelerator pedal with the
vehicle
running straight ahead.

Downloaded from www.Manualslib.com manuals search engine KAVNNISTYS JA AJO, STARTING AND DRIVING . . . .
Vivun kay to (Automaattisilla na­
palukoilla varustetut ajoneuvot) . HI31D ·B
¢ "2H" -> "4H"
Vipua voidaan kayttaa tiilla tavalla ajo­
neuvon ollessa pysahtyneena painet­
taessa tai painamatta kytkinpoljinta.
HUOM Kun vipu on asetettu asentoon "4H" ja
on ajettu pienen matkaa. napalukot luk­kiutuvat automaattisesti ja ajoneuvo kyt­
keytyy nelipyoravedolle.
_ "
4H" ~ "N" ~ "4L"
Vipua voidaan vaihtaa naiden asentojen valilla ajoneuvon ollessa pysahtyneena ja kytkin poljettuna tai vaihd evipu va­
paalla .
~ "4H" .... "2H"
Vipua voidaan vaihtaa naiden asentojen
valilla ajoneuvon ollessa pysahtyne ena tai sen liikkuessa painettaessa tai paina ­
matta
kytkinta.
N
71 EOOJ2
N
71EOOJ2
Lever operation
equipped with
free-wheeling hubs)
¢ "2H" -> "4H"
(vehicles
automatic
F I3 1D ·A
The lever can be operated in this way while the vehicle is stopped. with or without depressing the clutch pedal.
NOTE After the lever has been set to the "4H" position and the vehicle is driven a short
distance. the free
-wheeling hubs will automatically lock and the ve hicl e will change to four-wheel drive.
_
"4H" ~ "N" ~ "4L "
The lever can be operated between these
positions
while the vehicle is stopped and the clutch pedal depressed. or the
tran smissio n shift lever is set to neutral
position .
~ "4H" -> "2H"
The lever can be operated in this way
while the vehicle is either stopped or moving. with or without depressing the
clutch pedal.
143