spare wheel NISSAN ALMERA N16 2003 Electronic User Guide

SBR686C
Precautions
PRECAUTIONSNJSU0024When installing each rubber part, final tightening must be
carried out under unladen condition* with tires on ground.
Oil will shorten the life of rubber bushes. Be sure to wipe
off any spilled oil.
*: Fuel, radiator coolant and engine oil full. Spare tire, jack,
hand tools and mats in designated positions.
Use flare nut wrench when removing or installing brake
tubes.
After installing removed suspension parts, check wheel
alignment.
Do not jack up at the trailing arm and lateral link.
Always torque brake lines when installing.
Lock nuts are unreusable parts; always use new ones.
When replacing, do not wipe the oil off of the new lock nut
before tightening.
Preparation
COMMERCIAL SERVICE TOOLSNJSU0026
Tool name Description
Equivalent to
1 Flare nut crowfoot
2 Torque wrench
NT360
Removing and installing brake piping
a: 10 mm (0.39 in)
Spring compressor
NT717
Removing and installing coil spring
Noise, Vibration and Harshness (NVH)
Troubleshooting
NJSU0027Refer to “Noise, Vibration and Harshness (NVH) Troubleshooting”,
“FRONT SUSPENSION”, SU-4.
REAR SUSPENSION
Precautions
SU-16

SMA525A
On-vehicle Service
REAR SUSPENSION PARTSNJSU0029Check axle and suspension parts for excessive play, wear or dam-
age.
Shake each rear wheel to check for excessive play.
SSU036
Retighten all nuts and bolts to the specified torque.
Tightening torque:
Refer to “REAR SUSPENSION”, SU-17.
SMA113
Check shock absorber for oil leakage or other damage.
Check wheelarch height. Refer to “On-vehicle Service”,
“FRONT SUSPENSION PARTS”, SU-6.
REAR WHEEL ALIGNMENTNJSU0030Before checking rear wheel alignment, be sure to make a prelimi-
nary inspection (Unladen*).
*: Fuel, radiator coolant and engine oil full. Spare tire, jack, hand
tools and mats in designated positions.
SFA975B
Preliminary InspectionNJSU0030S011. Check tires for wear and improper inflation.
2. Check wheels for deformation, cracks and other damage.
If deformed, remove wheel and check wheel runout.
a. Remove tire from wheel and mount wheel on a tire balance
machine.
b. Set dial indicator as shown in the illustration.
Wheel runout (Dial indicator value):
Refer to SDS, SU-15.
3. Check front wheel bearings for looseness.
REAR SUSPENSION
On-vehicle Service
SU-18

Service Data and Specifications (SDS)
GENERAL SPECIFICATIONS (REAR)=NJSU0039
Suspension type Multi-link beam suspension
Shock absorber type Double-acting hydraulic
REAR WHEEL ALIGNMENT (UNLADEN*)NJSU0040
Camber
Degree minute (Decimal degree)Minimum −2°15′(−2.25°)
Nominal −1°03′(−1.05°)
Maximum −0°45′(−0.75°)
Total toe-in Distance (A − B)
mm (in)Minimum −2 (−0.08)
Nominal 2 (0.08)
Maximum 6 (0.24)
Angle (left plus right)
Degree minute (Decimal degree)Minimum −0°12′(−0.20°)
Nominal 0°12′(0.20°)
Maximum 0°36′(0.60°)
*: Fuel, radiator coolant and engine oil full. Spare tire, jack, hand toolsand mats in designated positions.
GI
MA
EM
LC
EC
FE
CL
MT
AT
AX
BR
ST
RS
BT
HA
SC
EL
IDX
REAR SUSPENSION
Service Data and Specifications (SDS)
SU-25

Power antenna ..............................................EL-214
Power door lock ............................................EL-261
Power door mirror .........................................EL-251
Power steering fluid level..................................ST-7
Power steering gear........................................ST-15
Power steering hydraulic pressure ...................ST-9
Power steering pressure (PSP) sensor
(QG engine)................................EC-261, EC-680
Power steering system bleeding.......................ST-8
Power supply routing.......................................EL-11
Power window ...............................................EL-253
Precations for Leak detection dye..................ATC-9
Precautions (General) .......................................GI-4
Pressure plate - See Clutch cover .................CL-22
PRGVLV - Wirng diagram (QG engine) .......EC-673
Priming pump (YD engine) ......................EC-32, 48
PS/SEN - Wiring diagram
(QG engine)................................EC-262, EC-681
Q
Quick-glow system (YD engine)...................EC-188
R
Radiator <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011002f00260010[16, 41
Radio - See Audio.........................................EL-192
Rear air spoiler ...............................................BT-47
Rear axle (disc brake type) ............................AX-24
Rear axle <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110011[.AX-22
Rear bumper <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100250037[-10
Rear combination lamp removal and
installation <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
11[BT-47
Rear disc brake ........................................BR-31, 39
Rear door <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110011[.BT-16
Rear seat belt .................................................RS-11
Rear seat <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110011[.BT-59
Rear suspension ............................................SU-16
Rear window defogger ..................................EL-173
Rear window <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100250037[-68
Recirculation (REC) switch (manual
A/C) <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011001100110011001100110011[..HA-40
Refregerant pressure sensor (manual
A/C) <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011001100110011001100110011[..HA-65
Refrigerant connection precaution
(manual A/C) .................................................HA-3
Refrigerant connection precaution .................ATC-5
Refrigerant discharging evacuating
charging <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
24>7&133
Refrigerant general precaution (manual
A/C) <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011001100110011001100110011[....HA-2
Refrigerant general precaution .......................ATC-4
Refrigerant lines (manual A/C) .......................HA-90
Refrigerant lines .........................................ATC-133
Refrigerant pressure sensor
(QG engine) ................EC-388, EC-707, ATC-15,
ATC-86, ATC-143
Refrigeration cycle (manual A/C) ...................HA-12Refrigeration cycle ........................................ATC-15
Release bearing (clutch) ..........................CL-17, 20
Removal and installation (A/T) ......................AT-411
Reverse idler shaft (M/T) ...................MT-30, 54, 93
Reverse lamp switch (M/T) - See
Back-up lamp switch (M/T) .........................MT-21
Reverse main gear (M/T) ...................MT-31, 55, 93
Road wheel size ..............................................GI-44
Rocker cover (QG engine).............................EM-29
Roof trim <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110011[..BT-43
Room lamp - See Interior lamp ......................EL-80
RP/SEN - Wiring diagram
(QG engine)................................EC-389, EC-708
RRO2 - Wiring diagram
(QG engine)................................EC-641, EC-657
S
S/LOCK - Wiring diagram .....................EL-264, 306
SAE J1930 terminology list .............................GI-51
Seal - See Exterior .........................................BT-47
Seat belt pre-tensioner disposal ....................RS-35
Seat belt pre-tensioner .....................................RS-3
Seat belt, front ..................................................RS-5
Seat belt, rear .................................................RS-11
Seat, front <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011[..BT-56
Seat, rear <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
11001100110011[..BT-59
Self-diagnostic results (YD engine)................EC-35
SEN/PW - Wiring diagram
(QG engine)................................EC-354, EC-627
SHIFT - Wiring diagram ................................AT-400
Shift control components (M/T) .........MT-32, 56, 94
Shift fork (M/T) ...................................MT-32, 56, 94
Shift lever <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011[..MT-29
Shift lock system ...........................................AT-399
Shift schedule ................................................AT-516
Shift solenoid valve A
(A/T) ................................AT-134, AT-139, AT-151
Shift solenoid valve B (A/T) .............AT-134, AT-139
Shock absorber (front) ...................................SU-10
Shock absorber (rear) ....................................SU-21
Side air bag <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110035[S-33
Side trim <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110011[...BT-31
Spare tire size .................................................GI-44
Spark plug (QG engine).................................EM-25
Specification value (QG engine) ....EC-106, EC-483
Speedometer .................................................EL-11 0
Spiral cable<0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011[.RS-29
Spot lamp <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011001100110028[L-108
Spring (Wheelarch) height ...............................SU-6
SROOF - Wiring diagram .............................EL-249
SRS - See Supplemental Restraint
System <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
11001100110011001100110035[S-20
SRS - Wiring diagram ....................................RS-46
Stabilizer bar (front) ........................................SU-11
Stall test (A/T) ....................................AT-64, AT-263
Standardized relay ............................................EL-9
START - Wiring diagram ................................SC-16
Start signal (YD engine) ...............................EC-205
Starter <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011001100110011[.....SC-18
ALPHABETICAL INDEX
IDX-8