battery NISSAN GT-R 2009 Service Manual

Black plate (249,1)
Model "R35-D" EDITED: 2008/ 5/ 20
WARNING
Antifreeze is poisonous and should be
stored carefully in marked containers
out of the reach of children.
Fill the window washer fluid reservoir periodi-
cally. Add window washer fluid when the low
washer fluid warning appears on the vehicle
information display. (
“LOW WASHER
FLUID WARNING” page 2-38)
To fill the window washer fluid reservoir, lift the
cap off the reservoir tank and pour the window
washer fluid into the tank opening. Add a washer solvent to the washer for better
cleaning. In the winter season, add a windshield
washer antifreeze. Follow the manufacturer’s
instructions for the mixture ratio.
Refill the reservoir more frequently when driving
conditions require an increased amount of
window washer fluid.
NOTICE
.
Do not substitute engine anti-freeze
coolant for window washer solution.
This may result in damage to the
paint.
. Do not fill the window washer
reservoir tank with washer fluid
concentrates at full strength. Some
methyl alcohol based washer fluid
concentrates may permanently stain
the grille if spilled while filling the
window washer reservoir tank.NOTE:Pre-mix washer fluid concentrates with
water to the manufacturer’s recommended
levels before pouring the fluid into the
window washer reservoir. Do not use the
window washer reservoir to mix the
washer fluid concentrate and water.
.Keep the battery surface clean and dry.
Clean the battery with a solution of baking
soda and water.
. Make certain the terminal connections are
clean and securely tightened.
. If the vehicle is not to be used for 30 days or
longer, disconnect the negative ( ) battery
terminal cable to prevent discharging it.PRECAUTIONS
NOTICE
When the battery cable is removed from
the battery terminal, do not close either
of the front doors. The automatic win-
dow adjusting function will not work,
and the side roof panel may be da-
maged.
To disconnect the negative ( ) battery terminal,
perform the procedure in the following order.
Otherwise, the window and the side roof panel
may contact and be damaged.
1. Close the windows.
2. Open the hood.
3. Close and lock all the doors.
4. Disconnect the negative ( ) battery terminal.
Maintenance and do-it-yourself
8-15
WINDOW WASHER FLUID BATTERY
,QIRUPDWLRQ3URYLGHGE\

Black plate (250,1)
Model "R35-D" EDITED: 2008/ 5/ 20
5. Securely close the hood.
To connect the negative () battery terminal,
perform the procedure in the following order.
Otherwise, the window and the side roof panel
may contact and be damaged.
1. Unlock and open the driver side door. Do not close the door.
2. Open the hood.
3. Connect the negative ( ) battery terminal.
Then close the hood.
4. Fully open the driver side door window.
5. Close the driver side door and the window.FLUID LEVEL CHECK
WARNING
. Do not expose the battery to flames
or electrical sparks. Hydrogen gas
generated by the battery is explo-
sive. Do not allow battery fluid to
contact your skin, eyes, fabrics, or
painted surfaces. After touching a
battery or battery cap, do not touch
or rub your eyes. Thoroughly wash
your hands. If the acid contacts your
eyes, skin or clothing, immediately
flush with water for at least 15 minutes and seek medical attention.
. Do not operate the vehicle if the
fluid in the battery is low. Low
battery fluid can cause a higher load
on the battery which can generate
heat, reduce battery life, and in
some cases lead to an explosion.
. When working on or near a battery,
always wear suitable eye protection
and remove all jewelry.
. Battery posts, terminals and related
accessories contain lead and lead
compounds. Wash hands after
handling.
. Keep the battery out of the reach of
children.
Check the fluid level in each cell (Remove the
battery cover if it is necessary) . It should be
between the UPPER LEVEL
*1
and LOWER
LEVEL
*2
lines.
If it is necessary to add fluid, add only distilled
water to bring the level to the indicator in each
filler opening. Do not overfill.
8-16
Maintenance and do-it-yourself
,QIRUPDWLRQ3URYLGHGE\

Black plate (251,1)
Model "R35-D" EDITED: 2008/ 5/ 20
1. Remove the cell plugs
*A
.
2. Add distilled water up to the UPPER LEVEL
*1
line.
If the side of the battery is not clear, check
the distilled water level by looking directly
above the cell; the condition
*1
indicates
OK and the conditions
*2
needs more to
be added.
3. Tighten cell plugs
*A
.
Vehicles operated in high temperatures or under
severe conditions require frequent checks of the
battery fluid level.
JUMP STARTINGIf jump starting is necessary, see the following
section. (
“JUMP STARTING” page 6-3)
If the engine does not start by jump starting, the
battery may have to be replaced. Contact a
GT-R certified NISSAN dealer.
1. Power steering fluid pump
2. Alternator
3. Crankshaft pulley
4. Air conditioner compressor
5. Drive belt auto-tensioner
WARNING
Be sure the ignition switch is in the OFF
or LOCK position before servicing drive
belts. The engine could rotate unex-
pectedly.
1. Visually inspect each belt for signs of unusual wear, cuts, fraying or looseness. If
the belt is in poor condition or loose, have it
Maintenance and do-it-yourself
8-17
DRIVE BELTS
,QIRUPDWLRQ3URYLGHGE\

Black plate (256,1)
Model "R35-D" EDITED: 2008/ 5/ 20
ENGINE COMPARTMENT
CAUTION
Never use a fuse of a higher or lower
amperage rating than that specified on
the fuse box cover. This could damage
the electrical system or cause a fire.
If any electrical equipment does not operate,
check for an open fuse.
1. Be sure the ignition switch is pushed to the OFF or LOCK position and the headlight
switch is turned to OFF. 2. Open the engine hood and remove the
cover on the battery and the fuse/fusible link
holder.
3. Remove the fuse/fusible link holder cover.
4. Remove the fuse with the fuse puller that is located in the engine compartment fuse box.
5. If the fuse is open
*A
, replace it with a new
fuses
*B. Spare fuses are stored in the
passenger compartment fuse box.
6. If a new fuse also opens, have the electrical system checked and repaired by a GT-R
certified NISSAN dealer.
Fusible linksIf any electrical equipment does not operate and
fuses are in good condition, check the fusible
links. If any of these fusible links are melted,
replace only with genuine NISSAN parts.
8-22
Maintenance and do-it-yourself
FUSES
,QIRUPDWLRQ3URYLGHGE\

Black plate (257,1)
Model "R35-D" EDITED: 2008/ 5/ 20
PASSENGER COMPARTMENT
CAUTION
Never use a fuse of a higher or lower
amperage rating than that specified on
the fuse box cover. This could damage
the electrical system or cause a fire.
If any electrical equipment does not operate,
check for an open fuse.
1. Be sure the ignition switch is pushed to the OFF or LOCK position and the headlight
switch is turned to OFF.
2. Open the fuse box lid.
3. Remove the fuse with the fuse puller
*A
.
4. If the fuse is open, replace it with a new fuse.
5. If a new fuse also opens, have the electrical system checked and repaired by a GT-R
certified NISSAN dealer.
WARNING
Be careful that batteries and other
removed components are not swal-
lowed by children.
NOTICE
There is the possibility that the key may
be damaged when the battery is re-
placed. It is recommended that you
have the battery replaced by a GT-R
certified NISSAN dealer.
Maintenance and do-it-yourself
8-23
INTELLIGENT KEY BATTERY
REPLACEMENT
,QIRUPDWLRQ3URYLGHGE\

Black plate (258,1)
Model "R35-D" EDITED: 2008/ 5/ 20
Recommended battery: Lithium battery CR2032
or an equivalent.
1. Disengage the lock on the reverse side ofthe Intelligent Key while pulling out the
mechanical key.
2. Insert a flat-bladed screwdriver
*1
wrapped with a cloth into the slit
*2
and
twist it to separate the case into the upper
and lower parts.
NOTICE
Because there is the risk of scratching
the key, wrap a cloth or similar item
around the screwdriver when separat-
ing the parts. If the screwdriver is
inserted too far into the key, it may
damage the internal circuit board.
3. Remove the old battery and insert a new battery with the + side facing down.
NOTICE
.Be sure that the + and sides of the
battery are facing in the correct
directions when the battery is in-
serted.
. Do not touch the internal circuits or
electronic terminals. Doing so may
damage them.
4. Reconnect the upper and lower parts of the Intelligent Key.
See a GT-R certified NISSAN dealer if you
need any assistance for replacement.NOTE:After replacing the battery, be sure to
check and check that all Intelligent Key
system functions operate correctly.
FCC Notice:
This equipment has been tested and found
to comply with the limits for a Class B
digital device pursuant to part 15 of the
FCC Rules. These limits are designed to
provide reasonable protection against
8-24
Maintenance and do-it-yourself
,QIRUPDWLRQ3URYLGHGE\

Black plate (294,1)
Model "R35-D" EDITED: 2008/ 5/ 20
If you believe that your vehicle has a defect
which could cause a crash or could cause
injury or death, you should immediately
inform the National Highway Traffic Safety
Administration (NHTSA) in addition to
notifying NISSAN.
If NHTSA receives similar complaints, it
may open an investigation, and if it finds
that a safety defect exists in a group of
vehicles, it may order a recall and remedy
campaign. However, NHTSA cannot be-
come involved in individual problems be-
tween you, your dealer, or NISSAN.
To contact NHTSA, you may call the
Vehicle Safety Hotline toll-free at 1-888-
327-4236 (TTY: 1-800-424-9153); go to
http://www.safercar.gov; or write to: Ad-
ministrator, NHTSA, 400 Seventh Street,
SW., Washington DC 20590. You can also
obtain other information about motor vehi-
cle safety from http://www.safercar.gov.
You may notify NISSAN by contacting our
Consumer Affairs Department, toll-free, at
1-866-668-1GTR (1-866-668-1487) .
A vehicle equipped with All-Wheel Drive (AWD)
should never be tested using a two wheel
dynamometer (such as the dynamometers used
by some states for emissions testing) , or similar
equipment. Make sure you inform test facility
personnel that your vehicle is equipped with
AWD before it is placed on a dynamometer.
Using the wrong test equipment may result in
transmission damage or unexpected vehicle
movement which could result in serious vehicle
damage or personal injury.
Due to legal requirements in some states/ areas,
your vehicle may be required to be in what is
called the “ready condition” for an Inspection/
Maintenance (I/M) test of the emission control
system.
The vehicle is set to the “ready condition” when
it is driven through certain driving patterns.
Usually, the “ready condition” can be obtained
by ordinary usage of the vehicle.
If a powertrain system component is repaired or
the battery is disconnected, the vehicle may be
reset to a “not ready condition”. Before taking
the I/M test, check the vehicle’s inspection/
maintenance test readiness condition. Push the
ignition switch to the ON position without
starting the engine. If the Malfunction Indicator
Light (MIL) comes on steady for 20 seconds and
then blinks for 10 seconds, the I/M test
condition is “not ready”. If the MIL does notblink after 20 seconds, the I/M test condition is
“ready”.
If the MIL indicates the vehicle is in a “not ready”
condition, drive the vehicle through the following
pattern to set the vehicle to the “ready condi-
tion”. If you cannot or do not want to perform the
driving pattern, a GT-R certified NISSAN dealer
can conduct it for you.
WARNING
Always drive the vehicle in a safe and
prudent manner according to traffic
conditions and obey all traffic laws.
1. Start the engine. Allow the engine to idle until the engine coolant temperature gauge
needle points between the C and H (normal
operating temperature) .
2. Accelerate the vehicle to 55 MPH (88 km/h) , then quickly release the accelerator
pedal completely and keep it released for at
least 10 seconds.
3. Quickly depress the accelerator pedal for a moment, then drive the vehicle at a speed of
53 to 60 MPH (86 to 96 km/h) for at least 9
minutes.
4. Stop the vehicle. Leave the engine running.
5. Accelerate the vehicle to 35 MPH (55 km/h)
9-16
Technical and consumer information
REPORTING SAFETY DEFECTS (US
only) READINESS FOR INSPECTION/
MAINTENANCE (I/M) TEST (US only)
,QIRUPDWLRQ3URYLGHGE\

Black plate (1,1)
10 Index
A
Additional maintenance items ................... GTR-6
Air cleaner .......................................... 8-19
Air conditioner Air conditioner specification label ............ 9-10
Air conditioning system refrigerant and
lubricant recommendations ......................... 9-5
All-season tires ................................... GTR-5
All-Wheel Drive .................................... 5-34
All-Wheel Drive driving safety precautions ........ 5-7
Aluminum alloy wheels .............................. 7-3
Anti-freeze .......................................... 5-42
Anti-lock Braking System ......................... 5-39
Anti-lock Braking System warning ................ 2-34
Audible reminders ................................. 2-30
Automatic Automatic door lock system .................... 3-5
Average fuel consumption and speed ............ 2-15
Avoiding collision and rollover ...................... 5-5
AWD clutch high temperature warning .......... 2-35
AWD system characteristics ...................... 5-35
AWD system warning ............................. 2-36
AWD warning light ................................ 5-34
B
Battery ....................................... 5-42, 8-15
Intelligent Key battery discharge .............. 5-10
Intelligent Key battery discharge indicator . . . 2-42
Intelligent Key battery replacement ........... 8-23
Before starting the engine ........................ 5-11
Body repair ....................................... GTR-5 Booster seat installation
........................... 1-29
Booster seats ...................................... 1-27
Brake Brake assist .................................... 5-39
Brake dust .................................... GTR-9
Brake fluid ............................. GTR-3, 8-14
Brake pad and disc rotor .................... GTR-3
Brake pad wear indicators .................... 8-20
Brake system ................................... 5-38
Brakes .......................................... 8-20
High performance brake system .............. 8-21
Inspection and adjustments of tires,
suspension and brakes ...................... GTR-6
Low brake fluid warning ....................... 2-34
Parking brake .................................. 5-27
Parking brake break-in ......................... 5-39
Parking brake release warning ................ 2-34
Replacing the brake pads ..................... 8-21
Self-adjusting brakes .......................... 8-20
Braking precautions ............................... 5-38
Break-in schedule .................................. 5-32
C
Capacities and recommended fuel/lubricants ..... 9-2
Changing Changing engine coolant ...................... 8-11
Changing engine oil and filter ................. 8-12
Changing wheels and tires .................... 8-37
Checking Checking bulbs ................................ 2-23
Checking engine coolant level ................ 8-11
Checking engine oil level ...................... 8-12 Checking the tire pressure
.................... 8-32
Child restraint installation using LATCH. ......... 1-17
Child restraint installation using the seat
belts ................................................. 1-21
Child restraints ..................................... 1-13
Child safety ........................................... 1-7
Chrome parts ........................................ 7-3
Cleaning ............................................ 8-19
Cleaning exterior ..................................... 7-2
Cleaning interior ..................................... 7-4
Clearing the programmed information ............ 2-63
Closing the fuel-filler door ........................ 3-24
Closing the hood .................................. 3-18
Coat hooks ......................................... 2-56
Cockpit ............................................... 2-2
Cold weather driving .............................. 5-42
Console box ........................................ 2-56
Cool down ........................................ GTR-7
Coolant Changing engine coolant ...................... 8-11
Checking engine coolant level ................ 8-11
Coolant mixture ratio ......................... GTR-7
Draining of coolant water ..................... 5-42
Engine coolant temperature gauge ............. 2-6
Replenishing coolant ........................ GTR-6
Corrosion protection ................................. 7-5
Cruise control ............................... 2-14, 5-28
Cruise control operations ......................... 5-29
Cruise control system warning .................... 2-37
Cup holders ........................................ 2-53
Current fuel consumption ......................... 2-14
Model "R35-D" EDITED: 2008/ 5/ 20
,QIRUPDWLRQ3URYLGHGE\

Black plate (3,1)
GaugeEngine coolant temperature gauge ............. 2-6
Fuel gauge ....................................... 2-7
Meters and gauges .............................. 2-4
General maintenance .......................... 8-2, 8-3
Glass ................................................. 7-3
Glove box. .......................................... 2-55
GT-R performance optimization services ....... GTR-4
GT-R special specification parts ................ GTR-2
GT-R specific information ....................... GTR-2
GT-R specific vehicle characteristics ........... GTR-7
H
Hazard warning flasher switch .................... 2-50
Headlight Headlight and turn signal switch ............. 2-47
Headlight switch ............................... 2-48
Headlights ...................................... 8-26
Xenon headlights .............................. 2-47
Heated seats ....................................... 2-51
High performance brake system .................. 8-21
Hill Start Assist .................................... 5-31
HomeLink
®Universal Transceiver ................. 2-60
Hood ................................................ 3-17
Horn ................................................ 2-50
I
Idle speed is not steady ......................... GTR-7
If your vehicle is stolen ............................ 2-63
If your vehicle overheats ............................. 6-6
Ignition switch operation ............................ 5-8
Ignition switch positions ............................. 5-9
In the event of a collision .......................... 9-19 Increasing fuel economy
........................... 5-33
Indicator lights ..................................... 2-28
Indicators and display ............................. 5-29
Injured persons ....................................... 1-9
Inside mirror ........................................ 3-26
Inspection and adjustments of tires,
suspension and brakes .......................... GTR-6
Installing front license plate ....................... 9-11
Instrument brightness control ..................... 2-10
Instrument panel ..................................... 2-3
Intelligent Key ........................................ 3-2
Intelligent Key battery discharge .................. 5-10
Intelligent Key battery discharge indicator ....... 2-42
Intelligent Key battery replacement ............... 8-23
Intelligent Key functions ............................. 3-9
Intelligent Key insertion indicator ................. 2-41
Intelligent Key removal indicator .................. 2-41
Intelligent Key system ............................... 3-8
Interior light control switch ........................ 2-59
Interior lights ....................................... 2-58
J
Jacking vehicle and removing wheels ............ 8-39
Jump starting .................................. 6-3, 8-17
K
Key Intelligent Key .................................... 3-2
Intelligent Key battery discharge .............. 5-10
Intelligent Key battery discharge indicator . . . 2-42
Intelligent Key battery replacement ........... 8-23
Intelligent Key functions ......................... 3-9
Intelligent Key insertion indicator ............. 2-41Intelligent Key removal indicator
.............. 2-41
Intelligent Key system ........................... 3-8
Keys............................................... 3-2
Locking with mechanical key .................... 3-6
No key warning ................................ 2-39
Remote keyless entry functions ............... 3-12
L
Light AWD warning light ............................ 5-34
Exterior and interior lights ..................... 8-27
Headlight and turn signal switch ............. 2-47
Headlight switch ............................... 2-48
Headlights ...................................... 8-26
Indicator lights ................................. 2-28
Interior light control switch .................... 2-59
Interior lights ................................... 2-58
Lights ........................................... 8-26
Map lights ...................................... 2-58
Supplemental air bag warning light .......... 1-43
Vanity mirror lights ............................. 2-60
Warning lights .................................. 2-23
Warning/indicator lights and audible
reminders ....................................... 2-23
Xenon headlights .............................. 2-47
Limited Slip Differential ............................ 5-36
Loading tips ........................................ 9-13
Lock Anti-lock Braking System ..................... 5-39
Anti-lock Braking System warning ............ 2-34
Automatic door lock system .................... 3-5
Freeing a frozen door lock .................... 5-42
Locking with inside lock knob .................. 3-5
Locking with mechanical key .................... 3-6
10-3
Model "R35-D" EDITED: 2008/ 5/ 20
,QIRUPDWLRQ3URYLGHGE\