timing belt NISSAN PATHFINDER 1996 R50 / 2.G Owners Manual

SCHEDULE 1
Abbreviations: R = Replace I = Inspect. Correct or replace if necessary. [ ]: At the mileage intervals only
MAINTENANCE OPERATIONMAINTENANCE INTERVAL
Perform at number of miles, kilometers or
months, whichever comes first.Miles´1,000 3.75 7.5 11.25 15 18.75 22.5 26.25 30 33.75 37.5 41.25 45 48.75 52.5 56.25 60
(km´1,000) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90) (96)
Months 3 6 9 12 15 18 21 24 27 30 33 36 39 42 45 48
Emission control system maintenance
Drive beltsI* I*
Air cleaner filter See NOTE (1) [R] [R]
Vapor linesI* I*
Fuel linesI* I*
Fuel filter See NOTE (3)*
Engine coolant See NOTE (4)R*
Engine oilRRRRRRRRRRRRRRRR
Engine oil filter
(Use Part No. 15208 31U00 or equivalent.)RRRRRRRRRRRRRRRR
Spark plugs[R] [R]
Timing beltReplace every 105,000 miles (168,000 km)
NOTE: (1) If operating mainly in dusty conditions, more frequent maintenance may be required.
(2) If operating mainly in dusty conditions, replace every 30,000 miles (48,000 km).
(3) If vehicle is operated under extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or
extremely high, the filters might become clogged. In such an event, replace them immediately.
(4) After 60,000 miles (96,000 km) or 48 months, replace every 30,000 miles (48,000 km) or 24 months.
(5) Maintenance items and intervals with ª*º are recommended by NISSAN for reliable vehicle operation. The owner need not perform such
maintenance in order to maintain the emission warranty or manufacturer recall liability. Other maintenance items and intervals are required.
8-6
Z01.2.1/R50-DX

SCHEDULE 2
Abbreviations: R = Replace I = Inspect. Correct or replace if necessary. [ ]: At the mileage intervals only
MAINTENANCE OPERATIONMAINTENANCE INTERVAL
Perform at number of miles, kilometers or
months, whichever comes first.Miles´1,000 7.5 15 22.5 30 37.5 45 52.5 60
(km´1,000) (12) (24) (36) (48) (60) (72) (84) (96)
Months 6 12 18 24 30 36 42 48
Emission control system maintenance
Drive beltsI* I*
Air cleaner filter[R] [R]
Vapor linesI* I*
Fuel linesI* I*
Fuel filter See NOTE (1)*
Engine coolant See NOTE (2)R*
Engine oilRRRRRRRR
Engine oil filter (Use Part No. 15208 31U00 or equivalent.)RRRRRRRR
Spark plugs[R] [R]
Timing beltReplace every 105,000 miles (168,000 km)
NOTE: (1) If vehicle is operated under extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or
extremely high, the filters might become clogged. In such an event, replace them immediately.
(2) After 60,000 miles (96,000 km) or 48 months, replace every 30,000 miles (48,000 km) or 24 months.
(3) Maintenance items and intervals with ª*º are recommended by NISSAN for reliable vehicle operation. The owner need not perform such
maintenance in order to maintain the emission warranty or manufacturer recall liability. Other maintenance items and intervals are required.
8-8
Z01.2.1/R50-DX

EXPLANATION OF MAINTENANCE
ITEMS
Additional information on the following
items with ª*º is found in the ªDo-it-
yourself operationsº section.
Emission control system
maintenance
Drive belts*Check drive belts for wear, fray-
ing or cracking and also for proper tension.
Replace the drive belts if found damaged.
Air cleaner filterUnder normal driving condi-
tions, the air cleaner filter should be replaced
in accordance with the maintenance schedule.
However, driving the vehicle in dusty areas
may cause more rapid clogging of the element.
Consequently, the element may have to be
replaced more frequently.
Vapor linesCheck vapor lines and connec-
tions for failure or looseness. If leaks are
found, replace the lines.
Fuel linesCheck the fuel hoses, piping and
connections for leaks, looseness or deteriora-
tion. Replace any parts if they are damaged.
Fuel filterIf the vehicle is operated under
extremely adverse weather conditions or in
areas where ambient temperatures are either
extremely low or extremely high, the filtermight become clogged. In such an event,
replace the filter immediately.
Engine coolant*Flush and refill the cooling
system.
Engine oil & oil filter*Under normal driving
conditions, the engine oil and oil filter should
be replaced in accordance with the mainte-
nance schedule. However, under severe driv-
ing conditions, they may have to be replaced
more frequently.
Spark plugs*Replace with new plugs having
the correct heat range.
Timing belt
Replace the timing belt for driving the cam-
shafts.
Chassis and body maintenance
Brake lines & cablesCheck the brake lines
and hoses (including brake booster vacuum
hoses, connections & check valve) and park-
ing brake cables for proper attachment, leaks,
cracks, chafing, abrasion, deterioration, etc.
Brake pads, discs, drums & liningsCheck
these and the other neighboring brake compo-
nents for wear, deterioration and leaks. Under
severe driving conditions, they may have to be
inspected more frequently.Manual and automatic transmission, trans-
fer & differential gear oilVisually inspect for
signs of leakage and replace oil for limited-slip
differential. Under severe driving conditions,
the oil should be replaced at the specified
interval.
Steering gear & linkage, axle & suspension
parts & drive axle shaft bootsCheck for
damage, looseness and leakage of oil or
grease. Under severe driving conditions, more
frequent inspection should be performed.
Steering linkage ball joints & front suspen-
sion ball jointsCheck the ball joints for dam-
age, looseness and grease leakage. Under
severe driving conditions, more frequent in-
spection should be performed.
Propeller shaft(s)Check the propeller
shaft(s) for damage, looseness and grease
leakage under severe driving condition
(only).
Propeller shaft greaseApply specified
grease to the greasing points of propeller
shafts in accordance with the maintenance
schedule. In the case of driving in water,
greasing should be performed immediately
afterwards.
8-10
Z01.2.1/R50-DX

Model VG33E
Type Gasoline, 4-cycle
Cylinder arrangement 6-cylinder, V-slanted at 60É
Bore´Stroke in (mm) 3.602´3.268 (91.5´83.0)
Displacement
cu in (cm
3)199.84 (3,275)
Firing order 1-2-3-4-5-6*1
Idle speed rpm
See the ªEmission Control
Labelº on the underside of the
hood. Ignition timing (BTDC)
degree/rpm
CO percentage at idle speed
[No air] %
Spark plug BKR4ES-11 (Hot)
BKR5ES-11 (Standard)
BKR6ES-11 (Cold)
Spark plug gap in (mm) 0.039 to 0.043 (1.0 to 1.1)
Camshaft operation Timing belt*2
Alternator belt size
Width´Length
in (mm)0.8409´41.93 (21.36´1,065)
*2: Periodic maintenance is necessary. Refer to the appropriate maintenance
schedule in chapter 8.
The spark ignition system of this vehicle meets all requirements of
the Canadian Interference-Causing Equipment Regulations.
TI0001-A
ENGINE
9-10
Z01.2.1/R50-DX

Seat belt
2-point type with retractor (Center
position of rear seat) ................................. 2-28
3-point type with retractor ......................... 2-25
Precautions on seat belt usage ................ 2-24
Seat belt extenders ................................... 2-29
Seat belt maintenance .............................. 2-30
Seat belts ......................................... 2-24, 2-25
Semiautomatic air conditioner .......................... 3-7
Spare tire carrier ............................................... 2-7
Spark plug replacement .................................. 7-14
Speedometer and odometer ............................. 1-3
Spot light ......................................................... 1-30
Starting
Before starting the engine ........................... 4-6
Jump starting ..................................... 5-7, 7-13
Precautions when starting and driving ........ 4-2
Push starting ............................................... 5-8
Starting the engine .................................... 4-11
Steering
Power steering fluid................................... 7-11
Tilting steering wheel ................................ 2-36
Sun visor ......................................................... 2-37
Sunroof ........................................................... 1-28
Supplemental air bag warning light ................ 2-22
Supplemental restraint system (Supplemental air
bag system) .................................................... 2-18
Switch
Front fog light switch ................................. 1-19
Hazard warning flasher switch .................. 1-19
Headlight and turn signal switch ............... 1-15
Ignition switch .............................................. 4-4
Rear window defogger switch ................... 1-18Rear window wiper and washer
switch......................................................... 1-17
Windshield wiper and washer switch ........ 1-16
T
Tachometer ....................................................... 1-4
Theft warning (If so equipped)........................ 1-13
Three-way catalyst ............................................ 4-3
Tilting steering wheel ...................................... 2-36
Timing belt ...................................................... 9-10
Tire
Flat tire ........................................................ 5-2
Spare tire carrier ......................................... 2-7
Tire placard ............................................... 9-14
Wheels and tires .............................. 7-26, 9-11
Tonneau cover ................................................ 1-26
Tow truck towing ............................................. 5-10
Towing
2-wheel drive models ................................ 5-10
4-wheel drive models ................................ 5-11
Tow truck towing ....................................... 5-10
Towing load/specification chart ................. 9-18
Towing point .............................................. 5-12
Trailer towing ............................................. 9-16
Trailer towing .................................................. 9-16
Transfer case shifting procedures for
4-wheel drive vehicles .................................... 4-16
Transmission
Automatic transmission fluid ....................... 7-9
Driving with automatic transmission............ 4-6
Driving with manual transmission ............. 4-10V
Vanity mirror light ............................................ 1-30
Vehicle identification ....................................... 9-13
Vehicle identification number (Chassis
number) ..................................................... 9-13
Vehicle identification number plate ........... 9-13
Vehicle loading ............................................... 9-20
Vehicle loading information............................. 9-15
W
Warning
Hazard warning flasher switch .................. 1-19
Supplemental air bag warning light........... 2-22
Theft warning (If so equipped) .................. 1-13
Warning labels........................................... 2-22
Warning/indicator light and buzzer.............. 1-9
Wheels and tires ................................... 7-26, 9-11
When traveling or registering your vehicle in an-
other country ................................................... 9-12
Window washer fluid ....................................... 7-12
Windshield wiper and washer switch.............. 1-16
Wiper
Rear window wiper and washer
switch......................................................... 1-17
Windshield wiper and washer switch ........ 1-16
Wiper blade ............................................... 7-17
10-4
Z01.2.1/R50-DX