wheel NISSAN PATHFINDER 1998 R50 / 2.G Workshop Manual

To ensure smooth, trouble-free, safe and eco-
nomical driving, NISSAN provides two differ-
ent maintenance schedules that may be used,
depending upon the conditions in which you
usually drive. These schedules contain both
distance and time intervals, up to 60,000 miles
(96,000 km)/48 months. For most people, the
odometer reading will indicate when service is
needed. However, if you drive very little, your
vehicle should be serviced at the regular time
intervals shown in the schedule.
After 60,000 miles (96,000 km) or 48
months, continue periodic maintenance at
the same mileage/time intervals.SCHEDULE 1Follow Periodic Maintenance Schedule 1 if
your driving habits frequently include one or
more of the following driving conditions:
IRepeated short trips of less than 5 miles
(8 km).
IRepeated short trips of less than 10
miles (16 km) with outside temperatures
remaining below freezing.
IOperating in hot weather in stop-and-go
rush hour traffic.
IExtensive idling and/or low speed driv-ing for long distances, such as police,
taxi or door-to-door delivery use.
IDriving in dusty conditions.
IDriving on rough, muddy, or salt spread
roads.
ITowing a trailer, using a camper or a
car-top carrier.
SCHEDULE 2Follow Periodic Maintenance Schedule 2 if
none of the driving conditions shown in Sched-
ule 1 apply to your driving habits.
Maintenance for offroad drivingWhenever you drive offroad through sand,
mud or water as deep as the wheel hub, more
frequent maintenance may be required of the
following items:G
Brake pads and discs
G
Brake lining and drums
G
Brake lines and hoses
G
Wheel bearing grease
G
Differential, transmission and transfer oil
G
Steering linkage
G
Propeller shafts and front drive shafts
G
Air cleaner filter
G
Clutch housing (See ªClutch housing drainº
in the ª8. Do-it-yourselfº section for check-
ing water entry.)
These items should be checked frequently to
assure safe and proper operation of your ve-
hicle.
PERIODIC MAINTENANCE
SCHEDULES
Maintenance
9-5
Z
01.1.31/R50-D
X

SCHEDULE 1Abbreviations: R = Replace I = Inspect. Correct or replace if necessary. L = Lubricate [ ]: At the mileage intervals onlyMAINTENANCE OPERATIONMAINTENANCE INTERVAL
Perform at number of miles, kilometers
or months, whichever comes first.Miles´1,000 3.75 7.5 11.25 15 18.75 22.5 26.25 30 33.75 37.5 41.25 45 48.75 52.5 56.25 60
(km´1,000) (6) (12) (18) (24) (30) (36) (42) (48) (54) (60) (66) (72) (78) (84) (90) (96)
Months 3 6 9 12 15 18 21 24 27 30 33 36 39 42 45 48
Chassis and body maintenance
Brake lines & cablesIIII
Brake pads, discs, drums & liningsIIIIIIII
Automatic transmission & transfer fluid,
manual transmission & differential gear oil
(exc. LSD)See NOTE (1)IIII
Limited-slip differential (LSD) gear oil See NOTE (1)IRIR
Steering gear & linkage, axle & suspension partsIIIIIIII
Drive shaft boots & propeller shaft (
) IIIIIIII
Propeller shaft grease See NOTE (2)LLLLLLLL
Front wheel bearing grease (4x2)II
Front wheel bearing grease (
) See NOTE (3)IRIR
Exhaust systemIIIIIIII
Supplemental air bag system See NOTE (4)
NOTE: (1) If towing a trailer, using a camper or a car-top carrier, or driving on rough or muddy roads, change (not just inspect) oil at every 30,000 miles(48,000 km)
or 24 months except for LSD. Change LSD gear oil every 15,000 miles (24,000 km) or 12 months.
(2) The propeller shaft should be re-greased daily if it is immersed in water.
(3) If operating frequently in water, replace grease every 3,750 miles (6,000 km) or 3 months.
(4) Inspect the supplemental air bag system 10 years after the date of manufacture noted on the F.M.V.S.S. certification label.
Maintenance
9-7
Z
01.1.31/R50-D
X

SCHEDULE 2Abbreviations: R = Replace I = Inspect. Correct or replace if necessary. L = Lubricate [ ]: At the mileage intervals onlyMAINTENANCE OPERATIONMAINTENANCE INTERVAL
Perform at number of miles, kilometers or
months, whichever comes first.Miles´1,000 7.5 15 22.5 30 37.5 45 52.5 60
(km´1,000) (12) (24) (36) (48) (60) (72) (84) (96)
Months 6 12 18 24 30 36 42 48
Chassis and body maintenance
Brake lines & cablesIIII
Brake pads, discs, drums & liningsIIII
Automatic transmission & transfer fluid, manual transmission & dif-
ferential gear oil (exc. LSD)IIII
Limited-slip differential (LSD) gear oilIRIR
Steering gear & linkage, axle & suspension parts I I
Drive shaft boots (
) IIII
Propeller shaft grease See NOTE (1)LLLL
Front wheel bearing grease (4x2)II
Front wheel bearing grease (
) IRIR
Exhaust systemII
Supplemental air bag system See NOTE (2)
NOTE: (1) The propeller shaft should be re-greased daily if it is immersed in water.
(2) Inspect the supplemental air bag system 10 years after the date of manufacture noted on the F.M.V.S.S. certification label.
Maintenance
9-9
Z
01.1.31/R50-D
X

Propeller shaft greaseApply specified
grease to the greasing points of propeller
shafts in accordance with the maintenance
schedule. In the case of driving in water,
greasing should be performed immediately
afterwards.
Front wheel bearing greaseCheck the wheel
bearing for grease leakage around grease
seals, axial end play and smooth turning (4x2).
Check the wheel bearing grease condition or
repack these in accordance with the mainte-
nance schedule. In case of frequent driving in
muddy water, the bearing grease inspection
should be performed more frequently (
).
Exhaust systemVisually check the exhaust
pipes, muffler, and hangers for proper attach-
ment, leaks, cracks, chafing, abrasion, dete-
rioration, etc. Under severe driving conditions,
inspection should be performed more fre-
quently.
Supplemental air bag systemCheck the
supplemental air bag system components for
proper attachment, damage, deformities,
cracks, rust, etc. Work around and on the
supplemental air bag system should be done
by an authorized NISSAN dealer.
Maintenance
9-11
Z
01.1.31/R50-D
X

10 Technical and consumer informationCapacities and recommended fuel/lubricants ......... 10-2
Specifications .......................................................... 10-9
Tires and wheels ................................................... 10-10
When traveling or registering your
vehicle in another country ..................................... 10-11
Vehicle identification ............................................. 10-12
Vehicle loading information ................................... 10-14
Towing a trailer ..................................................... 10-15
Emission control system warranty ........................ 10-19
Reporting safety defects (US only) ....................... 10-19
Readiness for inspection/
maintenance (I/M) test (US only) .......................... 10-20
Z
01.1.31/R50-D
X

For US
Grade Road wheel/
offset in (mm)Tire Spare tire size
4x2 PATH-
FINDERXE
LE15x6-1/2JJ/1.97
(50)
15x6-1/2JJ
Aluminum/1.97
(50)P235/70R15
102SP235/70R15
102S
4x4 PATH-
FINDERXE
LE15x6-1/2JJ/1.97
(50)
15x6-1/2JJ
Aluminum/1.97
(50)P235/70R15
102SP235/70R15
102S
SE 15x7JJ/1.57 (40)
15x7JJ
Aluminum/1.57
(40)P265/70R15
110SP265/70R15
110S
For Canada
Grade Road
wheel/offset in
(mm)Tire Spare tire size
4x4 PATH-
FINDERLE 15x6-1/2JJ/1.97
(50)
15x6-1/2JJ
Aluminum/1.97
(50)P235/70R15
102SP235/70R15
102S
XE
SE15x7JJ/1.57 (40)
15x7JJ
Aluminum/1.57
(40)P265/70R15
110SP265/70R15
110S
TIRES AND WHEELS10-10
Technical and consumer information
Z
01.1.31/R50-D
X

DIMENSIONS AND WEIGHTSPATHFINDER
Overall length*1 in (mm) 178.3 (4,530)
Overall width in (mm) 68.7 (1,745)
72.4 (1,840)*2*3
Overall height in (mm) 67.1 (1,705)
67.9 (1,725)*2
Front tread in (mm) 58.3 (1,480)
59.1 (1,500)*2
Rear tread in (mm) 58.5 (1,485)
59.3 (1,505)*2
Wheelbase in (mm) 106.3 (2,700)
Gross vehicle weight rating
lb (kg)See the ªF.M.V.S.S. certification
labelº on the driver's side lock
pillar.
Gross axle weight rating
Front lb (kg)
Rear lb (kg)
*1: On spare tire carrier equipped models, the spare tire carrier adds 9.45 in (240
mm) to the overall length.
*2: SE models
*3: XE models with overfender
When planning to travel in another country,
you should first find out if the fuel available is
suitable for your vehicle's engine.
Using fuel with too low an octane rating
may cause engine damage. All gasoline
vehicles can be operated with unleaded
gasoline. Therefore, avoid taking your ve-
hicle to areas where appropriate fuel is not
available.
When transferring the registration of your
vehicle to another country, state, province
or district,it may be necessary to modify the
vehicle to meet local laws and regulations.
The laws and regulations for motor vehicle
emission control and safety standards vary
according to the country, state, province or
district; therefore, vehicle specifications may
differ.
When any vehicle is to be taken into an-
other country, state, province or district
and registered, its modifications, transpor-
tation and registration are the responsibil-
ity of the user. NISSAN is not responsible
for any inconvenience that may result.WHEN TRAVELING OR
REGISTERING YOUR VEHICLE IN
ANOTHER COUNTRYTechnical and consumer information
10-11
Z
01.1.31/R50-D
X

ICheck regularly to make sure that all
trailer hitch mounting bolts are se-
curely fastened.
ITo reduce the possibility of additional
damage if your vehicle is struck from
the rear, where practical, remove the
hitch when not in use. Remove the
receiver when not in use.Tire pressuresIWhen towing a trailer, inflate the vehicle
tires to the recommended cold tire pressure
indicated on the tire placard (affixed to the
glove box lid).
ITrailer tire condition, size, load rating and
proper inflation pressure should be in ac-
cordance with the trailer and tire manufac-
turers' specifications.Safety chainAlways use a suitable chain between your
vehicle and the trailer. The chain should be
crossed and should be attached to the hitch,
not to the vehicle bumper or axle. Be sure to
leave enough slack in the chain to permit
turning corners.
Trailer lightsTrailer lights should comply with Federal
and/or local regulations.
When wiring vehicle for towing connection,
connect stop and tail light pickup into the
vehicle electrical circuit at point between
the sensor and stop light switch or light
switch.Trailer brakesIf your trailer is equipped with a braking sys-
tem, make sure it conforms to Federal and/or
local regulations and that it is properly in-
stalled.Never connect a trailer brake system
directly to the vehicle brake system.Trailer towing tipsIn order to gain skill and an understanding of
the vehicle's behavior, you should practice
turning, stopping and backing up in an area
which is free from traffic. Steering stability and
braking performance will be somewhat differ-
ent than under normal driving conditions.IAlways secure items in the trailer to prevent
load shift while driving.
IAvoid abrupt starts, acceleration or stops.
IAvoid sharp turns or lane changes.
IAlways drive your vehicle at a moderate
speed.
IAlways block the wheels on both vehicle
and trailer when parking. Parking on a
slope is not recommended; however, if you
must do so, and if your vehicle is equipped
with automatic transmission, first block the
wheels and apply the parking brake, and
then move the transmission selector lever
into the P position. If you move the selector
lever to the P position before blocking the
wheels and applying the parking brake,
transmission damage could occur.
IWhen going down a hill, shift into a lower
gear and use the engine braking effect.
When ascending a long grade, downshift
the transmission to a lower gear and reduce
speed to reduce chances of engine over-
loading and/or overheating.
However, for long steep grades, do not stay in
1st or 2nd gear when driving above 35 MPH
(56 km/h).
IIf the engine coolant rises to an extremely
10-18
Technical and consumer information
Z
01.1.31/R50-D
X

11 Index
A
ABS ................................................................. 5-25
Adjusting the time ........................................... 2-33
Adjustment
Front manual seat ....................................... 1-2
Front power seat ......................................... 1-4
Head restraint .............................................. 1-8
Rear seat ..................................................... 1-5
Shoulder belt ............................................. 1-22
Air bag
System....................................................... 1-13
Warning label ............................................ 1-15
Warning light .................................... 1-15, 2-10
Air cleaner....................................................... 8-16
Air conditioner
Manual ......................................................... 4-3
Operation, Manual ....................................... 4-5
Operation, Semiautomatic ......................... 4-11
Semiautomatic ............................................. 4-9
Servicing .................................................... 4-13
Specification label ................................... 10-14
Air conditioning system refrigerant and
lubricant recommendations ............................. 10-8
Aluminum alloy wheels, Cleaning ..................... 7-3
Anchor point location, Top strap..................... 1-35
Antenna........................................................... 4-25
Anti-freeze, Cold weather ............................... 5-26
Anti-lock Brake System (ABS) ........................ 5-25Appearance care
Exterior ........................................................ 7-2
Interior ......................................................... 7-4
Armrest ............................................................. 1-8
Ashtray ............................................................ 2-22
Audio system .................................................. 4-14
Automatic
Sunroof, Operation .................................... 2-32
Transmission fluid ....................................... 8-9
Transmission, Driving .................................. 5-9
Avoiding collision and rollover .......................... 5-4
B
Back door.......................................................... 3-9
Battery
Cold weather ............................................. 5-26
Maintenance .............................................. 8-13
Replacement, Multi-remote control ............. 3-6
Before starting the engine ................................ 5-8
Belt
Drive .......................................................... 8-14
Extender, Seat........................................... 1-25
Height adjustment, Shoulder ..................... 1-22
Maintenance, Seat .................................... 1-25
Seat ........................................................... 1-17
Brake
Booster ...................................................... 8-19
Fluid ........................................................... 8-11Parking ...................................................... 5-15
Pedal ......................................................... 8-18
System....................................................... 5-24
Warning light ............................................. 2-10
Break-in schedule ........................................... 5-18
Bulb
Checking...................................................... 2-9
Indicator ..................................................... 2-12
Replacement ............................................. 8-22
Warning light ............................................... 2-9
Buzzer ............................................................. 2-13
C
Capacities and recommended fuel/lubricant .. 10-2
Car phone ....................................................... 4-26
Carbon monoxide, Exhaust gas ....................... 5-2
Cassette tape player operation....................... 4-16
Cassette tape player operation, with
compact disc (CD) player type ....................... 4-22
Catalytic converter, Three way catalyst............ 5-3
CB radio or car phone .................................... 4-26
Certification label, F.M.V.S.S. ....................... 10-13
Chain, Tire ...................................................... 8-27
Changing
A flat tire ...................................................... 6-2
Engine coolant............................................. 8-5
Engine oil..................................................... 8-8
Engine oil filter............................................. 8-9
Tire and wheel........................................... 8-28
Z
01.1.31/R50-D
X

Checking
Brake pedal ............................................... 8-18
Bulb ............................................................. 2-9
Engine coolant level .................................... 8-4
Engine oil level ............................................ 8-7
Parking brake ............................................ 8-18
Seat belt operation, Three-point ............... 1-21
Child restraint.................................................. 1-25
Installation on front seat ............................ 1-36
Installation on rear seat center ................. 1-27
Installation on rear seat outboard ............. 1-30
Precaution ................................................. 1-25
Top strap ................................................... 1-34
Child safety
Rear door lock ............................................. 3-3
Seat belt .................................................... 1-18
Chrome parts, Cleaning .................................... 7-3
Cigarette lighter and ashtray .......................... 2-22
Cleaner, Air ..................................................... 8-16
Cleaning
Exterior ........................................................ 7-2
Interior ......................................................... 7-4
Clock ............................................................... 2-33
Adjusting .................................................... 2-33
Operation ................................................... 2-34
Clutch
Fluid ........................................................... 8-11
Housing drain,
................................. 8-30
Pedal ......................................................... 8-20
Cold weather driving ....................................... 5-26
Compact disc (CD) player operation, with
cassette player type........................................ 4-23
Compass display .............................................. 2-7
Console box .................................................... 2-25Controls, Heater and manual air conditioner.... 4-3
Controls, Heater and semiautomatic air
conditioner ........................................................ 4-9
Cooling system, Engine .................................... 8-4
Corrosion protection ......................................... 7-5
Cover, Tonneau .............................................. 2-29
Cruise control.................................................. 5-16
Cup holder ...................................................... 2-24
D
Defogger switch, Rear window and outside
mirror............................................................... 2-16
Dimensions and weights, Vehicle ................. 10-11
Door .................................................................. 3-2
Door open warning light ................................. 2-10
Drinking alcohol/drugs and driving ................... 5-4
Drive belt......................................................... 8-14
Driving
Cold weather ............................................. 5-26
On snow or ice .......................................... 5-28
On-pavement and offroad ........................... 5-4
Precaution ................................................... 5-2
The vehicle .................................................. 5-9
Drugs ................................................................ 5-4
EEconomy, Fuel ................................................ 5-19
Emission control
Information label ...................................... 10-13
System warranty...................................... 10-19
Engine
Block heater .............................................. 5-28Compartment check location....................... 8-3
Coolant heater ........................................... 5-28
Coolant temperature gauge ........................ 2-4
Cooling system ............................................ 8-4
Oil ................................................................ 8-7
Oil and oil filter recommendation .............. 10-6
Overheat ...................................................... 6-9
Serial number .......................................... 10-12
Specifications ............................................ 10-9
Exhaust gas (Carbon monoxide) ...................... 5-2
Explanation of maintenance items .......... 9-2, 9-10
Exterior and interior light, Replacement ......... 8-23
F
F.M.V.S.S. certification label......................... 10-13
Fastening the seat belt
Three-point ................................................ 1-20
Two-point ................................................... 1-23
Filling, Fuel filler lid ......................................... 3-11
Filter, Air ......................................................... 8-16
Flasher switch, Hazard warning ..................... 2-19
Flat tire .............................................................. 6-2
Floor mats, Cleaning ........................................ 7-4
Fluid
Automatic transmission ............................... 8-9
Brake ......................................................... 8-11
Engine ......................................................... 8-7
Power steering .......................................... 8-11
Window washer ......................................... 8-12
Fog light switch ............................................... 2-19
Four by four clutch housing drain ................... 8-30
Four wheel drive, Using .................................. 5-20
Z
01.1.31/R50-D
X
11-2