steering wheel NISSAN PATROL 2002 Electronic Repair Manual

Supplemental Restraint System (SRS) ªAIR
BAGº and ªSEAT BELT PRE-TENSIONERº
The Supplemental Restraint System such as ªAIR BAGº and ªSEAT BELT PRE-TENSIONERº used along
with a seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. The SRS system composition which is available to NISSAN MODEL Y61 is as follows (The
composition varies according to the destination and optional equipment.):
+For a frontal collision
The Supplemental Restraint System consists of driver air bag module (located in the center of the
steering wheel), front passenger air bag module (located on the instrument panel on passenger side),
seat belt pre-tensioners, a diagnosis sensor unit, warning lamp, wiring harness and spiral cable.
+For a side collision
The Supplemental Restraint System consists of front side air bag module (located in the outer side of
front seat), satellite sensor, diagnosis sensor unit (one of components of air bags for a frontal collision),
wiring harness, warning lamp (one of components of air bags for a frontal collision).
Information necessary to service the system safely is included in theRS sectionof this Service Manual.
WARNING:
+To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance should be per-
formed by an authorized NISSAN dealer.
+Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and
Air Bag Module, see the RS section.
+Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow harness connector.
PRECAUTIONS
AT-3002

Supplemental Restraint System (SRS) ªAIR
BAGº and ªSEAT BELT PRE-TENSIONERº
The Supplemental Restraint System such as ªAIR BAGº and ªSEAT BELT PRE-TENSIONERº used along
with a seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. The SRS system composition which is available to NISSAN MODEL Y61 is as follows (The
composition varies according to the destination and optional equipment.):
+For a frontal collision
The Supplemental Restraint System consists of driver air bag module (located in the center of the
steering wheel), front passenger air bag module (located on the instrument panel on passenger side),
seat belt pre-tensioners, a diagnosis sensor unit, warning lamp, wiring harness and spiral cable.
+For a side collision
The Supplemental Restraint System consists of front side air bag module (located in the outer side of
front seat), satellite sensor, diagnosis sensor unit (one of components of air bags for a frontal collision),
wiring harness, warning lamp (one of components of air bags for a frontal collision).
Information necessary to service the system safely is included in theRS sectionof this Service Manual.
WARNING:
+To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance should be per-
formed by an authorized NISSAN dealer.
+Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and
Air Bag Module, see the RS section.
+Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. SRS wiring harnesses can be identified by yellow harness connector.
Precautions for Trouble Diagnoses
CAN SYSTEM
+Do not apply voltage of 7.0V or higher to the measure-
ment terminals.
+Use the tester with its open terminal voltage being 7.0V
or less.
Precautions for Harness Repair
CAN SYSTEM
+Solder the repaired parts, and wrap with tape. [Frays of
twisted line must be within 110 mm (4.33 in)]
PKIA0306E
PRECAUTIONS AND PREPARATION
EL-3004

Supplemental Restraint System (SRS) ªAIR
BAGº and ªSEAT BELT PRE-TENSIONERº
The Supplemental Restraint System such as ªAIR BAGº and ªSEAT BELT PRE-TENSIONERº used along
with a seat belt, helps to reduce the risk or severity of injury to the driver and front passenger for certain
types of collision. The SRS system composition which is available to NISSAN MODEL Y61 is as follows (The
composition varies according to the destination and optional equipment.):
+For a frontal collision
The Supplemental Restraint System consists of driver air bag module (located in the center of the
steering wheel), front passenger air bag module (located on the instrument panel on passenger side),
seat belt pre-tensioners, a diagnosis sensor unit, warning lamp, wiring harness and spiral cable.
+For a side collision
The Supplemental Restraint System consists of front side air bag module (located in the outer side of
front seat), satellite sensor, diagnosis sensor unit (one of components of air bags for a frontal collision),
wiring harness, warning lamp (one of components of air bags for a frontal collision).
Information necessary to service the system safely is included in theRS sectionof this Service Manual.
WARNING:
+To avoid rendering the SRS inoperative, which could increase the risk of personal injury or death
in the event of a collision which would result in air bag inflation, all maintenance should be per-
formed by an authorized NISSAN dealer.
+Improper maintenance, including incorrect removal and installation of the SRS, can lead to per-
sonal injury caused by unintentional activation of the system. For removal of Spiral Cable and
Air Bag Module, see the RS section.
+Do not use electrical test equipment on any circuit related to the SRS unless instructed to in this
Service Manual. Spiral cable and wiring harnesses covered with yellow insulation tape either just
before the harness connectors or for the complete harness are related to the SRS.
PRECAUTIONS AND PREPARATIONMANUAL AND AUTO
HA-3002

Multi-remote control system .................. EL-3144
N
NATS (Nissan Anti-theft System) .......... EL-3168
NATS - Wiring diagram ..... EL-3168, 3169, 3171
P
POWER - Wiring diagram ..................... EL-3007
Parking brake control ............................ BR-3004
Parking lamp .......................................... EL-3046
Power door lock ..................................... EL-3120
Power supply routing ............................. EL-3006
R
R/COOL - Wiring diagram (front
auto A/C) ........................................... HA-3008
ROOM/L - Wiring diagram ..................... EL-3070
Radio - See Audio ................................. EL-3109
Rear axle (drum brake type) ................. RA-3002
Rear disc brake ..................................... BR-3003
Rear window defogger .......................... EL-3107
Refrigeration cycle ................................ HA-3003
Room lamp - See Interior lamp ............. EL-3069
S
S/LOCK - Wiring diagram ...................... EL-3134
S/TANK - Wiring diagram ...................... FE-3004
STAB - Wiring diagram ......................... RA-3003
Speedometer ......................................... EL-3079
Stabilizer release device - Wiring
diagram ............................................. RA-3003
Stabilizer release device ....................... RA-3003
Starter .................................................... EL-3038
Starting system ...................................... EL-3038
Steering switch ...................................... EL-3036
Steering wheel and column ................... ST-3002
Sub fuel tank control system ................. FE-3002
Super lock .............................................. EL-3133
Supplemental restraint system - Wiring
diagram ................................... RS-3003, 3007
T
TAIL/L - Wiring diagram ........................ EL-3046
TCM circuit diagram .............................. AT-3003
THEFT - Wiring diagram ............. EL-3157, 3162
TURN - Wiring diagram ......................... EL-3058
Tachometer ............................................ EL-3079
Tail lamp ................................................ EL-3046
Theft warning system ............................ EL-3156Tread-FR&RR (Dimensions) .................. GI-3007
Turn signal lamp .................................... EL-3058
V
VSS - Wiring diagram ........................... EC-3005
Vehicle identification number ................. GI-3006
Vehicle speed sensor (VSS) ................. EC-3005
W
WARN - Wiring diagram ........................ EL-3086
WIPER - Wiring diagram ....................... EL-3100
Warning chime ....................................... EL-3098
Warning lamps ....................................... EL-3084
Washer, front ......................................... EL-3100
Water temperature gauge ..................... EL-3079
Wheelbase (Dimensions) ....................... GI-3007
Width (Dimensions) ................................ GI-3007
Wiper deicer .......................................... EL-3106
Wiper, front ............................................ EL-3100
ALPHABETICAL INDEX
IDX-3003

STEERING SYSTEM
SECTION
ST
MODIFICATION NOTICE:
+Tightening torque for air bag module has been changed.
CONTENTS
STEERING WHEEL AND STEERING
COLUMN.............................................................. 3002Removal and Installation ................................. 3002

ST

Removal and Installation
V1Air bag module
V2Steering wheel
V3Spiral cable
V4Combination switch
V5Steering column assembly
V6Column cover
V7Lower shaft
V8Coupling
SST013D
STEERING WHEEL AND STEERING COLUMN
ST-3002