lock Oldsmobile Cutlass Supreme 1994 s Workshop Manual

Service & Appearance Care
4. Remove the wiring connector fkom
the headlight s~ocltet by lifting the
plastic locking tabs on the connector
and pulling it
from the socket.
5. Check the new headlight again. The
number
on the top of the light (A)
must match the number on the
headIight being replaced. The letter,
U or L, must also match.
5. Plug the wiring connector into the
headlight s-oclcet. Snap the locking
tabs onto the socket.
headlight
assembly. The socket must
be pointing-in the same direction the
socket an the burned-out bulb was.
7. Place the new headlight in the

.. .
.Headlfght Replacement
(4-DOOR MODES)
See thelndm under Replacement
Bulbs
to check thetype of bulb to use.
To Replace a Bulb:
1. Turn the-Lshaped bulb assembly
counterclockwise
M turn until the
flanges-align with the slots
in the
retainer ring,
You may need to twist
it back and
forth slightly to loosen it.
~~~~~~
2. Pull out the bulb assembly.
3. Disconnect the bulb wiring harness
from the socket bulb assembly by
.lifting the plastic locking tab.
4. Snap. a new bulb assembly into the
wiring harness.
-5. Replace the bulb .assembly by
reversing step one.
Taill[ght Bulb Replacement
(2-DOOR MODES)
For the type of bulb, see the Index
under Replacement Bulbs.
1. Remove the two large plastic Screws
and pull the carpet away from the
rear corner of the trunk.

Service & Appearance Care
Add-on Electrical
Equijment
NOTICE:
Don’t add anything electrical to
your Oldsmobile unless you check
with your dealer first. Some
electrical equipment can damage
your vehicle and the damage
wouldn’t be covered by your
warranty. Some add-on electrical
equipment can keep other
components from working as they
should.
Your vehicle has an air bag system.
Before attempting to add anything
electrical to your Oldsmobile, see
Servicing Your Air Bag-Equipped
Oldsrnobile in the Index.
h
.. ...- . . . ... .. ....... . . _. . , 1
1 Fuses & Circuit Breakers
The wiring circuits in your vehicle are
protected from short circuits by a
combination of fuses, circuit breakers,
and fusible thermal links in the wiring
itself. This greatly reduces the chance of
damage caused by electrical problems.
Some fuses are located
in a fuse block
in the glove box as shown.above. To
locate the fuse block, lift out the storage
bin inside the glove box. See the
diagram later in this section. Another
set of fuses is located in the
component center, under the
instrument panel.
Additional fuses are located in the
underhood electrical centers
on the
right and left sides of the engine
compartment.

Service & Appearance Care
Glove Box Fuse Block
n I I
1111211311
RADIO INDlC BLMTR I
1411511611
WIPER T/SIG STOP I
CTSY ARBGI DRLKS I
C/LTR VATS HVAC I
'uu' w bij I
ELEC CLSTR ABS I
ARBGP
1
2
8
9
10
11
12
13
14
15
16
17
18
Fuse Rating Circuitry
(AMP)
10 Radio & Clock
10 Rear Defogger Timer Relay; Instrument Cluster; Chime
Module; Cruise Control; DIU Module (Canada); ABS
Lamp Driver Module; SIR
20 Blower Motor
25 Windshield Wiper & Washer
10 Turn Signals/Flasher
15 Brake Lights
10 Courtesy, Glove Box, Underhood, Trunk, Header
15 SIR
20 Door Locks
15 Cigarette Lighter
Lights; Lighted
Inside Rearview Mirror
5 Vehicle Anti-Theft System (Pass-I 15 Blower Control Switch; Solenoid
15 Radio
& Clock; Passive Restraint Lockout, Passive
15 Cluster; HVAC Controls; HUD; DRL
5 ABS Control Module
Restraint
Timer; Chime Module; ABS; VATS
10 Power Door Lock Switch; Seat Belts; Power Outside
Mirrors; Power Antenna
Not Used
SIR (crank)
5

~ ~~ Component
Center
Fuse Rating Circuitry
(AMP)
1
2
3
4 30
5 30
6 30
7
8
9
10
20
Defogger Timer Relay
Air Conditioner Blower Relay (HI) (Electronic AC only)
Air Conditioner Blower Relay (LO) (Electronic AC only)
Rear Defogger Circuit Breaker
Power Accessories Circuit Breaker
Power Windows and Sunroof Circuit Breaker
Not Used
Lock Control
Chime Module
Hazard Flasher

Normal -Maintenance Replacement Parts
Air Cleaner Element
3100 V6 ........................................................................\
................ AC Type A-905
Twin Dual Cam (DOHC) 3.4L V6
.............................................. AC Type A-1129 C
Engine Oil Filter
3100 V6 ........................................................................\
................ AC Type PF-47
Twin Dual Cam (DOHC) 3.4L V6
.............................................. AC Type PF-51
PCV Valve
3100 V6 ........................................................................\
................ AC Type CV-899C
Twin Dual Cam (DOHC) 3.4L V6
............................................. AC Type CV-881C
Spark Plugs
3100 V6 ........................................................................\
............... AC Type R44LTSM6
Gap: 0.060 inch
(1.52 mm)
Gap: 0.045 inch (1.14
mm)
Twin Dual Cam (DOHC) 3.4L V6 ............................................. AC Type eR42LTSM
Batteries
Remote Lock Control Transmitter ............................................. 2016 (2)

I At Least Once a Year
~~
CHECK
I OR SERVICE
Key Lock Cylinders
Body Lubrication
Starter Switch
Steering Column
Lock
WHAT TO DO
~. ~ .
Lubricate the key lock cylinders with the lubricant specified in Section D.
Lubricate all body door hinges. Also lubricate all hinges and latches, including those for the
hood, rear compartment, glove box door, console door and any folding seat hardware. Section
D
tells you what to use.
CAUTION: When you.are doing this check, the vehicle could move suddenly.\
If it does, you
or others could be injured. Follow.the steps below.
1. .Before you start, be sure you have enough room around the vehicle.
2. Firmly apply both. the parking brake (see Parking Brake in the Index if necessary) and the
NOTE:
Do not use the accelerator pedal, and be ready to turn off the engine immediately if it starts.
3. Try to start the engine in each gear. The starter should work only in P (Park) or N (Neutral). If
regular brake.
the starter works in any other position, your vehicle needs service.
While parked, and with the parking brake set,
try to turn the key to Lock in each shift lever
position.
The ley should turn to Lock only when the shift lever is in P (Park).
. The key should come out only in Lock.
245

Section C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at least twice a year (for instance, each spring and fall).
You should let your GM dealer’s service department or other qualified service center
do these jobs. Make sure any necessary
Bepairs are completed at once.
INSPECTION
OR SERVICE
Restraint Systems
Steering, Suspension
and FrontWheel-
Drive Axle Boot and
Seal Inspection
Exhaust System
Inspection
Throttle Linkage
Inspection
Brake System Inspection
WHAT SHOULD BE DONE
Now and then, make sure all your belts, buckles, latch plates, retractors, anchorages and
reminder systems are working properly. Look for any loose parts or damage.
If you see anything
that might keep a restraint system from doing its job, have it repaired.
Inspect the front and rear suspension and steering system for damaged, loose or missing parts,
signs of wear, or lack
of lubrication. Inspect the power steering lines and hoses for proper
hookup, binding, leaks, cracks, chafing, etc. Clean and then inspect the drive axle boot seals for
damage, tears or leakage. Replace seals if necessary.
Inspect the complete exhaust system. Inspect the body near the exhaust system. Look for broken,
damaged, missing or out-of-position parts as well as open seams, holes, loose connections, or
other conditions which could cause a heat build-up in the floor pan or could let exhaust fumes
into the vehicle. See
Engine Exhaust in the Index.
.. -
Inspect the throttle linkage for interference or binding, and for damaged or missing parts.
-Replace parts as needed.
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Inspect other bralte
parts, including calipers, parking brake, etc. Check parking bralte adj\
ustment. You may need to have
your brakes inspected more often
if your driving habits or conditions result in frequent braking.
NOTE:-A low brake fluid level can indicate worn disc brake pads which may need to be serviced.
Also,
if the bralte system warning light stays on or comes on, something may be wrong with the
brake system. See
Brake System Warning Light in the Index. If your vehicle is equipped with anti-
lock brakes and the anti-lock bralte system warning
light stays on, comes on or flashes, something
may be wrong with the anti-lock brake system. See
Anti-Lock Brake System Warning Light in the Index.
247

I Section D: Recommended Fluids and Lubricants
VOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.
I 248
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake System
Parking Brake Guides
Power Steering System
Automatic Transaxle
Key Lock Cylinders
Automatic Transaxle Shift Linkage
FLUID/LUBRICANT
API service SH or SG Energy Conserving I1 oils of the proper viscosity. The “SH) or “SG’ designation
may be shown alone or
in combination with others, such as “SH/CD,” “SH,SG,CD,”“SG/CD,” etc.\
To
determine the preferred viscosity for your vehicle’s engine, see Engine Oil in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant conforming to GM Specification
1825M.
Delco Supreme 1 1s Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
GM Hydraulic Power Steering Fluid (GM Part No. 1052884 or equivalent).
DEXRONB-I11
or DEXRONB-IIE Automatic Transmission Fluid.
Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120), synthetic SAE 5W-30 engine
oil or silicone lubricant (GM Part No. 1052276 or 1052277).
Engine oil.

Passing ........................................... 132
Winter Driving
............................... 140
With a Trailer
................................ 146
Drunken Driving
.............................. 126
Electric Outside Mirror Control
..... 82
Electrical Center, Underhood
.......... 220
Electrical Equipment.
Adding
............................. 60. 111. 220
Electronic Climate Control
.............. 107
Emergencies on the Road
................. 149
Emergency Starting
.......................... 150
Emergency Towing .......................... 154
Engine Block Heater
.......................... 61
Engine Coolant
................................ 190
Checking &Adding
.............. 160, 161
Heater
...................................... 61, 186
Low Coolant Warning Light ........... 94
Proper Mixture to Use
.................. 161
Safety Warnings About
.................. 159, 160, 181, 190
Temperature Gage
........................... 93
Engine Exhaust
.................................. 69
Engine Identification
....................... 219
Engine Oil
........................................ 184
Additives
........................................ 186
1 Capacity ......................................... 227
Through Deep Standing Water
....... 60
Emergencies. Braking in
.................. 130
Emergencies. Steering in
................. 131
Checking & Adding ....................... 184
Disposing of Used Oil
................... 187
Energy Conserving
........................ 186
Filter
.............................................. 186
Pressure Gage .................................. 95
Starburst
........................................ 185
Warning Light
.................................. 94
When to Change
............................ 186
Engine Overheating ......................... 158
Engine Specifications
....................... 232
Engine Starting
.................................. 59
Ethanol in Gasoline
......................... 177
Exhaust Dangerous Gas in
............. 57. 69. 142
Parking with the Engine
Running
.................................. 68. 70
Expectant Mothers. Use
of Safety
Belts
................................................. 27
Expressway Driving
......................... 137
Extender. Safety Belt
......................... 46
Exterior Appearance (see
Appearance
Fabric Cleaning (see Appearance Care)
Fan Warnings ........................... 152. 181
Filling the Fuel Tank ........................ 179
Filter Air
.................................................. 187
Fuel
................................................ 233
Oil
.......................................... 186. 233
Care)
Finish Care ....................................... 217
Finish Damage
................................. 217
Flash-to-Pass
...................................... 79
Flashers. Hazard Warning
............... 150
Flat Tire ............................................ 165
Flooded Engine
.................................. 60
Fluid Automatic Transaxle
..................... 188
Bralte .............................................. 194
Capacities
...................................... 227
Power Steering
.............................. 192
Windshield Washer
....................... 193
Fluids
& Lubricants ................. 229. 248
Fog Lights
.................................. 80. 204
Fold-Down Storage Compartment
.... 83
Foreign Material ................................ 217
Freeway Driving
............................... 137
French Language Manual
.................... 2
Fuel ................................................... 177
Alcohol in Fuel
.............................. 177
Capacity
................................. 179. 272
Exhaust Warnings
................... 57. 142
Filling Your Tank
.......................... 179
Fuels with Alcohol
........................ 177
Gage
................................................. 93
In Foreign Countries
..................... 178
Low Fuel Warning Light
................. 98
Requirements
................................ 177
Fuses
& Circuit Breakers ................ 220
L
265