transmission fluid OPEL AGILA 2009 Owners Manual

5-9Instruments and controls
X Driver’s seat belt
Will illuminate in red when ignition is
switched on if driver’s seat belt is not
engaged.
If vehicle speed exceeds 15 km/h
(9 mph) and driver’s seat belt is not
engaged, the control indicator will
flash for approx. 90 seconds along
with a warning chime and then
illuminate until driver’s seat belt is
fastened correctly.
Seat belts 3 3-5.
v Airbag systems, belt
tensioners
Will flash in red several times when
the ignition is switched on, then
extinguish.
If it does not flash when the ignition is
switched on, stays lit, illuminates or
flashes whilst driving, there is a fault
with the airbag systems or with the
belt tensioners. The systems might
not therefore be triggered in the event
of an accident. Seek the assistance
of a workshop immediately.
Belt tensioners 3 3-6, airbags 3 3-13.
p Charging system
Will illuminate in red when ignition is
switched on. Extinguishes after
engine is started.
If it stays lit after the ignition is
switched on or illuminates during
driving: stop vehicle and switch off
engine. The battery is not being
charged and the engine cooling may
be interrupted. The brake servo unit
may cease to be effective. Interrupt
your journey immediately.
Remove ignition key and check drive
belt condition and tensioning before
seeking the assistance of a
workshop.
s Service transmission 3
Will illuminate briefly in yellow when
the ignition is switched on.
If it flashes, there is a fault in the
automatic transmission. Seek the
assistance of a workshop
immediately.
Automatic transmission 39-3.
R Brake system
Will illuminate in red when ignition is
switched on. Extinguishes after
engine is started.
Illuminates when engine is running if
parking brake is applied and/or fluid
level for brake hydraulics is too low.
Further information 3 9-9,
brake fluid level 3 10-6.
u Anti-lock Brake System
(ABS)
Will illuminate briefly in yellow when
ignition is switched on.
At the same time, the system
performs a self-check. When the
control indicator extinguishes, the
system is ready for operation.
Caution
If it illuminates when the parking
brake is not applied: stop vehicle;
interrupt your journey immediately.
Seek the assistance of a workshop.

9-2Driving and operating
To release the steering column lock,
turn ignition key to position ACC and
rotate steering wheel slightly.
Before starting-off, check:
„Tyre pressures and condition.
„Engine oil level and fluid levels in
engine compartment 3 10-3.
„All windows, mirrors, exterior
lighting and license plates are free
from dirt, snow and ice and are
operational.
„Objects are securely located and
will not be thrown forward in the
event of sudden braking.
„Seats, seat belts and mirrors are
correctly adjusted.
„All gauges and control indicators.
„Brake operation.
Starting the engine
With manual transmission in neutral,
depress clutch and foot brake,
(automatic transmission 3 in P or N),
do not accelerate.
Petrol engines: Turn key to START
and release it.
Diesel engines: Turn key to ON,
when preheating control indicator N
extinguishes, turn key to START and
release it.
Preheating system switches on only if
outside temperature is low.
Key returns automatically to ON
position when released.Start attempts should not last longer
than 15 seconds. If engine does not
start, wait 15 seconds before
repeating starting procedure. If
necessary, depress accelerator
before repeating starting procedure.
Parking the vehicle
„Apply the parking brake firmly
without actuating the release
button. On a downhill or uphill
slope, apply as firmly as possible.
Depress foot brake at the same
time to reduce operating forces.
„Push key into ignition switch before
turning to LOCK position and
removing (vehicles with automatic
transmission3: depress foot brake
and shift into P). Turn steering
wheel until lock is felt to engage
(anti-theft protection).
„If the vehicle is parked on a level
surface or a hill, select 1st gear
before switching the ignition off,
(vehicles with automatic
transmission 3: shift into P). Also
turn front wheels away from kerb if
parked on an uphill slope.

11-4 Service and maintenance
⊕Additional operations.o Under extreme operating conditions and if required by country-specific conditions, the intervals are reduced.
Service operations by year 1)
km ( x 1000)1)
miles ( x 1000)1)
1
15
102
30
203
45
304
60
405
75
506
90
60
o⊕Automatic transmission fluid level: check correct x x x
Fluid hose: inspectx
Fluid: change every 165,000 km/110,000 miles
Engine, transmission, A/C compressor: check for leaks x x x x x x
oBrake drum: remove, clean, visual check x
Steering system boots, track rods, final drive: visual check x x
Track rod end and supporting ball joint: check x x x
⊕Brake and clutch fluid: change every 2 years
Wheel fastening: loosen and tighten to torque
Tyre condition and pressures: check, correctxxxxxx
First aid kit: visual check every 2 years
Headlamp aiming: check, adjust x x x
Door hinges, door stop, lock cylinder, lock striker, bonnet catch, tailgate
hinges and check links: lubricate xxx
Test drive, final check
Service interval display and oil life monitor: reset - if applicablexxxxxx
1)Whichever occurs first.

11-7Service and maintenance
The system is factory-filled with
coolant designed for frost protection
down to approx. -28 °C. This
concentration should be maintained
all year-round.
Coolant additives intended to give
additional corrosion protection or seal
against minor leaks can cause
function problems. Liability for
consequences resulting from the use
of coolant additives will be rejected.
Brake and clutch fluid
Only use DOT4 brake fluid.
Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified
interval.
Brake fluid should be stored in a
sealed container to avoid water
absorption. Ensure it does not become
contaminated with fluids containing
mineral oil (oil, petrol, cleaner) as this
can damage the seals and sleeves of
the brake system.Transmission fluid
Use fluid meeting specification
Grade: API GL-4
Viscosity: 75W-85 or 75W-90.
Automatic transmission fluid
Use fluid meeting specification
ATF3309.
9 Warning
Brake fluid is poisonous!
Caution
Due to its corrosive nature, it must
not come in contact with the
paintwork. Flush any escaped
brake fluid with plenty of water.

13-1 Index
IndexA
ABS ........................................... 9-9
Accessories
............... 3-9, 4-5, 10-6
Accessory socket
....................... 5-4
Air conditioning system ....... 8-1, 8-3
Air intake
.................................... 8-6
Air recirculation
.......................... 8-3
Air vents ..................................... 8-4
Airbags
.................................... 3-13
Alternator, see Charging system
5-9
Antenna .......................... 7-6, 10-30
Antifreeze
....................... 10-4, 11-6
Antifreeze protection
....... 10-4, 10-5
Anti-knock quality of fuel .......... 9-12
Octane number
.................... 12-3
Anti-theft locking system
............ 2-6
Anti-theft protection ................... 9-2
Ashtrays
..................................... 5-5
Automatic transmission
............. 9-3
Automatic mode ..................... 9-4
Engine braking assistance
..... 9-4
Fault
....................................... 9-5
Interruption of power supply ... 9-5
Kickdown
................................ 9-4
Rocking the vehicle
................ 9-5
Selector lever ......................... 9-4
Transmission display
.............. 9-3
Automatic wiping
....................... 5-3B
Battery
..................................... 10-6
Interruption of power supply
... 9-5
Before starting-off
...................... 9-2
Belt force limiters ....................... 3-6
Belt tensioners
........................... 3-6
Belts
................................ 3-5, 10-29
Bleeding, diesel fuel system .... 10-7
Bonnet
..................................... 10-2
Boot, see Luggage compartment
3-3
Brake assist ............................. 9-10
Brake fluid
................................ 11-7
Brake system
............................. 9-9
Brakes ....................................... 9-9
ABS
........................................ 9-9
Brake assist
.......................... 9-10
Brake fluid ............................ 10-6
Brake lamps
......................... 10-9
Foot brake
.............................. 9-9
Parking brake ......................... 9-9
Bulb replacement
..................... 10-7
C
Capacities
................................ 12-5
Care
....................................... 10-29
Catalytic converter
..................... 9-8
Central locking system ....... 2-3, 2-4
Centre high-mounted
stoplamp (CHMSL)
Bulb replacement
............... 10-10

13-2Index
Changing the battery
Remote control ....................... 2-2
Changing tyre/wheel type
...... 10-17
Changing wheels
................... 10-22
Charging system ........................ 5-9
Chassis number, see Vehicle
Identification Number
......12-1, 12-2
Child restraint systems ............... 3-9
Child safety locks
....................... 2-4
Cigarette lighter
.......................... 5-5
Cleaning ................................. 10-30
Climate controls
......................... 8-1
Clock
.......................................... 5-3
Clutch fluid ............................... 10-6
Clutch operation
..................9-2, 9-6
Cold starts
.................................. 9-8
Control indicators ....................... 5-5
ABS
........................................ 5-9
Airbags
................................... 5-9
Belt tensioners ........................ 5-9
Brake system
.......................... 5-9
Charging system
..................... 5-9
Diesel particle filter ........5-13, 9-7
Door ajar
........................2-5, 5-12
Driver’s seat belt
..............3-7, 5-9
Electronic Stability Program .5-10
Engine coolant temperature
.5-11
Engine electronics
................ 5-13
Engine oil change ........5-12, 5-14Engine oil pressure
............... 5-11
ESP .............................5-10, 9-11
Exhaust
................................. 5-11
Exhaust emissions
................ 5-11
Front fog lamps ..............5-12, 6-3
Fuel level
............. 5-7, 5-11, 5-13
Headlamp range adjustment
5-12
High beam .....................5-12, 6-2
Immobiliser
....................2-7, 5-12
Passenger airbag status
....... 3-18
Power steering ...................... 5-10
Preheating
............................ 5-11
Rear fog lamp
................5-12, 6-3
Service transmission .......5-9, 9-5
Service vehicle soon
............. 5-12
Theft-deterrent
...............2-7, 5-12
Traction Control Support
System off
....................5-10, 9-11
Turn signal lamps
................. 5-13
Coolant ............................10-4, 11-6
Coolant level
............................ 10-4
Coolant temperature
................ 5-11
Cooling ....................................... 8-3
Cooling fan
................ 9-3, 9-7, 10-1
Correcting time
........................... 5-3
Corrosion
protection
............ 10-4, 10-31, 11-6
Courtesy lamps
.......................... 6-4
Bulb replacement ................ 10-11Cup holders
................................4-1
Curtain airbags .........................3-16
D
Dashboard - see
Instrument panel
........................1-5
Data
..........................................12-1
Demisting and defrosting
...........8-2
Diesel .......................................9-12
Diesel fuel system
....................10-7
Diesel particle filter (DPF)
5-13, 9-7
Dimensions ..............................12-6
Dipped beam
..............................6-2
Bulb replacement
..................10-7
Display ............................... 5-6, 5-7
Door locks
..............................10-30
Doors
................................ 2-5, 5-12
Driver’s airbag ..........................3-13
Driving abroad
............................6-3
Driving hints
...............................9-1
E
Electric throttle body system
....5-11
Electrical system
....................10-11
Electronic Stability Program .....9-10
Emissions
....................... 9-13, 12-4
Engine braking assistance
.........9-4
Engine code ................... 12-2, 12-3
Engine coolant temperature
.....5-11
Engine data
..............................12-3

13-4Index
Interior lamps ............................. 6-4
Bulb replacement ................ 10-11
Interior mirror
............................. 2-9
Interior stowage
......................... 4-1
Interruption of power supply ....... 9-5
Selector lever lock
.................. 9-5
ISOFIX
............................3-11, 3-12
J
Jack
........................................ 10-25
K
Key
............................................. 2-1
Locking doors
......................... 2-3
Removing
............................. 5-13
Replacement .......................... 2-1
Starting
............................9-1, 9-2
Steering column lock
.............. 9-1
Kickdown .................................... 9-4
L
Lashing eyes
.............................. 4-3
Leather trim ............................ 10-29
License plate lamps
Bulb replacement
.................. 10-9
Light switch ................................ 6-1
Lighting
...................................... 6-1
Driving abroad
........................ 6-3
Loading .............................4-3, 12-7
Locking doors
............................. 2-3
Locking from the inside
.............. 2-4
Locks ...................................... 10-30Luggage compartment
............... 2-5
Bulb replacement .................. 10-9
Cover
...................................... 4-5
Lighting
................................... 6-4
Loading ..........................4-3, 12-7
Under floor storage
................. 4-4
M
Main beam, see high beam
........ 6-2
Maintenance
............................ 11-1
Air conditioning
....................... 8-4
Antifreeze protection ............. 10-4
Brake fluid
............................. 10-6
Brakes
.................................... 9-9
Engine oil .............................. 10-3
Infotainment system
............. 7-10
Tyre pressure
..................... 10-16
Tyres ................................... 10-17
Windscreen wipers
............... 10-5
Manual transmission
.................. 9-6
Mirrors ......................... 2-8, 2-9, 8-5
Misted windows
.......................... 8-2
Mobile telephones
.................... 7-10
Muffler, see Exhaust system ...... 9-8
N
Neutral
................................9-4, 9-6
O
Octane numbers
...................... 12-3
Odometer
................................... 5-6
Display brightness .................. 5-6Oil
................................... 10-3, 11-6
Additives ...............................11-6
Topping up
.................. 10-3, 11-6
Viscosity
................................11-6
Oil level and consumption ........10-3
Oil life monitor
..........................5-14
Oil pressure
..............................5-11
Outside temperature ..................5-4
P
Paintwork damage
.................10-31
Parking .......................................9-2
Parking brake
.............................9-9
Parking lamps
Bulb replacement
..................10-8
Payload
....................................12-7
Pedals
........................................9-1
Performance .............................12-4
Petrol
.............................. 9-12, 12-3
Pollen filter
.................................8-6
Power mirrors .............................2-8
Power outlet
...............................5-4
Power steering
.........................5-10
Power windows ........................2-10
Child safety system
...............2-11
Preheating
........................ 5-11, 9-2
R
Radio
..........................................7-6
Radio equipment (CB)
..............7-10
Radio remote control

13-5 Index
Central locking system .... 2-1, 2-3
RDS (Radio Data System) ......... 7-7
Rear fog lamp
............................ 6-3
Bulb replacement
................. 10-9
Rear lamps
Bulb replacement
................. 10-9
Rear seats
................................. 3-3
Folding seatbacks .................. 3-3
Restoring rear seatbacks
....... 3-5
Rear window
washer system
.................. 5-3, 10-5
Antifreeze protection
............ 10-5
Capacities
............................ 12-5
Washer fluid reservoir .......... 10-5
Rear window wiper
........... 5-3, 10-6
Refuelling
................................. 9-12
Fuel filler cap ........................ 9-12
Remote control
Central locking system
.... 2-1, 2-3
Replacement keys ..................... 2-1
Reversing lamps
........................ 6-3
Bulb replacement
................. 10-9
Ride control systems ............... 9-10
Roof rack
............................ 4-4, 4-6
Running-in
................................. 9-1
Brakes .................................... 9-9
S
Safeguard against
unauthorised use
................ 7-3, 9-1Safety
...................................... 10-1
Safety accessories ............. 3-9, 4-5
Safety locks
............................... 2-4
Seat adjustment
......................... 3-2
Seat belt reminder ..................... 5-9
Seat belts
........................ 3-5, 10-29
Driver’s seat belt reminder
3-7, 5-9
Height adjustment .................. 3-8
Seat height adjustment
.............. 3-3
Seat position
.............................. 3-2
Seats ......................................... 3-2
Adjustment
............................. 3-2
Selector lever
............................. 9-4
Self-help
Automatic transmission
.......... 9-5
Remote control
....................... 2-2
Service ..................................... 11-1
Service interval display
............ 5-14
Service intervals
............. 11-1, 11-2
Additional operations ............ 11-5
Interim service
...................... 11-1
Main service
......................... 11-1
Severe operating conditions .11-5
Side airbags
............................. 3-15
Sidemarker lamps
Bulb replacement
............... 10-10
Spare keys
................................. 2-1
Spare wheel
........................... 10-24
Speedometer ............................. 5-5Starting the engine
.................... 9-2
Steam-jet cleaners ...... 10-30, 10-31
Steering column lock
................. 9-1
Steering wheel adjustment
........ 5-1
Steering wheel
remote control
..................... 5-1, 7-2
Storage compartments
.............. 4-1
Sun visors ................................ 2-11
Sunglasses storage
compartment
.............................. 4-3
T
Tachometer
............................... 5-6
Tail lamps
Bulb replacement
................. 10-9
Tailgate
...................................... 2-5
Tank
Fuel gauge
............................. 5-7
Technical data
......................... 12-1
Telephone, see
Mobile telephones
................... 7-10
Temperature
.............................. 8-1
Temporary spare wheel
......... 10-24
The first 1000 km ....................... 9-1
Tightening torque
................... 10-24
Tools
...................................... 10-25
Top-Tether ............................... 3-11
Towing
........................ 10-28, 10-29
Traction Control Support
System (TCSS)
........................ 9-11

13-6Index
Transmission display ..........5-7, 9-3
Trip computer ........................... 5-14
Trip odometer
............................. 5-6
Turn signal lamps
....................... 6-2
Bulb replacement .................. 10-8
Tyre chains
............................ 10-17
Tyre condition
........................ 10-17
Tyre pressure ................10-16, 12-8
Tyre repair kit
......................... 10-18
U
Units of measure
...................... 5-16
Unleaded fuel
..................9-12, 12-3
V
Vehicle care
............................. 10-1
Vehicle checks
......................... 10-1
Vehicle dimensions
.................. 12-6
Vehicle Identification
Number
...........................12-1, 12-2
Vehicle keys, see Key
................ 2-1
Vehicle tools ........................... 10-25
Vehicle weights
........................ 12-7
Ventilation
...........................8-1, 8-4
W
Warning chimes
....................... 5-13
Warning triangle
......................... 4-5
Washer fluid reservoir .............. 10-5
Washing the vehicle
............... 10-30
Weights
.................................... 12-7
Wheel condition ..................... 10-17Wheel covers
......................... 10-17
Wheels, tyres ......................... 10-15
Windows
...........................2-10, 8-5
Demisting and defrosting
........ 8-2
Windscreen washer
system
...............................5-3, 10-5
Antifreeze protection
............. 10-5
Capacities ............................. 12-5
Washer fluid reservoir
........... 10-5
Windscreen wipers
............5-2, 10-5
Winter operation
Coolant, antifreeze
............... 10-4
Fuel for diesel engines
......... 9-12
Heating ............................8-1, 8-3
Locks
.................................. 10-30
Tyre chains
......................... 10-17
Window demisting and
defrosting
................................ 8-2
Winter tyres
........................ 10-15