brake OPEL ANTARA 2014 Service Manual

180Vehicle care9Warning
Do not drive faster than 80 km/h.
Do not use for a lengthy period.
Steering and handling may be
affected.
If you have a flat tyre:
Apply the electrical parking brake
3 137 and engage first gear, reverse
gear or P.
The tyre repair kit is in a storage
compartment below the floor cover in the load compartment.
To remove the tyre repair kit, open the
tailgate.
Pull the floor cover handle upwards
3 69.
Vehicle tools 3 173.
Caution
Do not allow objects to protrude
above the top of the rear floor
storage compartment, to avoid
damage to the storage area and
the load compartment floor.
1. Release the sealant filler hose 1
and the power plug 2.
2. Unscrew valve cap from defective
tyre.
Screw the sealant filler hose onto
the tyre valve.
3. Connect the power plug to the power outlet. Unplug all items
from other power outlets.
4. Switch on ignition. To avoid discharging the battery, werecommend running the engine.
5. Turn the selector switch anticlockwise to the sealant ＋
air position.

Vehicle care183
Make the following preparations and
observe the following information:
■ Park the vehicle on a level, firm and
non-slippery surface. The front wheels must be in the straight-ahead position.
■ Apply the electrical parking brake 3 137 and engage first gear,
reverse gear or P.
■ Remove the spare wheel 3 185.
■ Never change more than one wheel
at a time.
■ Block wheel diagonally opposite the wheel to be changed, by placing
wedge blocks or equivalent in front
and behind the wheel.
■ Use the jack only to change wheels
in case of puncture, not for
seasonal winter or summer tyre
changes.
■ Never exceed jack maximum working load (900 kg).
■ If the ground on which the vehicle is standing is soft, a solid board
(max. 1 cm thick) should be placed
under the jack.■ Do not raise the vehicle more than is necessary to change a wheel.
■ No people or animals may be in the
vehicle when it is jacked-up.
■ Never crawl under a jacked-up vehicle.
■ Do not start the engine when it is raised on the jack.
■ Clean wheel nuts and thread before
mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Pull off the wheel cover.
2. Install the wheel wrench ensuring that it locates securely and loosen
each wheel nut by one turn by
turning anticlockwise.
3. The location of front and rear jacking points is indicated by
notches on the bottom edge of the
vehicle, under the doors.

Vehicle care187Jump starting
Do not start with quick charger.
A vehicle with a discharged battery
can be started using jump leads and the battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
■ Never expose the battery to naked flames or sparks.
■ A discharged battery can alreadyfreeze at a temperature of 0 °C.
Defrost the frozen battery before
connecting jump leads.
■ Wear eye protection and protective
clothing when handling a battery.
■ Use a booster battery with the same voltage (12 Volts). Its
capacity (Ah) must not be much less than that of the discharged
battery.
■ Use jump leads with insulated terminals and a cross section of at
least 16 mm 2
(25 mm 2
for diesel
engines).
■ Do not disconnect the discharged battery from the vehicle.
■ Switch off all unnecessary electrical
consumers. The Infotainment
system may be damaged if
switched on while jump starting.
■ Do not lean over the battery during jump starting.
■ Do not allow the terminals of one lead to touch those of the other
lead.■ The vehicles must not come into contact with each other during the
jump starting process.
■ Apply the electrical parking brake 3 137, transmission in neutral,
automatic transmission in P.
■ Open the positive terminal protection caps of both batteries.
Lead connection order:
1. Connect the red lead to the positive terminal 1 of the booster
battery.
2. Connect the other end of the red lead to the positive terminal 2 of
the discharged battery.

Vehicle care189
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope - or better still a tow
rod - to the front towing eye, never to
the bumper or front suspension units.
Do not tow the vehicle from the rear.
The front towing eye must only be
used for towing and not recovering a
vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Transmission in neutral.
Turn key to ignition switch position
ACC and release the electrical
parking brake before towing the
vehicle.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
Keep tow rope clear of front bumper, and ensure it is securely fixed to the
towing eye at both ends. Pull on the tow rope to check.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation system 3 116 and
close the windows.
Vehicles with manual transmission:
The vehicle must be towed facing
forwards. The maximum speed is
88 km/h . In all other cases, and when
the transmission is defective, the front axle must be raised off the ground.
Vehicles with automatic transmission:
Do not tow the vehicle using the
towing eye. Towing with a tow rope
could cause severe damage to the
transmission. When towing a vehicle with automatic transmission, use flat
bed or wheel lift equipment.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and replace the spoiler lip. Store
towing eye in the storage
compartment below the floor cover in the load compartment.
Vehicle tools 3 173.

196Service and maintenance
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 199.
Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade
depending on the minimum ambient
temperature 3 199.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.Coolant and antifreeze
Use only silicate-free long life coolant
(LLC) antifreeze. Consult a
workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C. In
northern countries with very low
temperatures the factory filled coolant
provides frost protection down to
approx. -37°C. This concentration
should be maintained all year round.
The use of additional coolant
additives that intend to give additional corrosion protection or seal against
minor leaks can cause function
problems. Liability for consequences
resulting from the use of additional
coolant additives will be rejected.
Brake and clutch fluid Only use high-performance DOT4+
brake fluid approved for the vehicle.
Consult a workshop.Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified
interval.
Brake fluid should be stored in a
sealed container to avoid water
absorption.
Ensure brake fluid does not become contaminated.

210IndexAAccessories and vehicle modifications .......................... 151
Accessory sockets ........................78
Active head restraints .............34, 35
Adjustable air vents ...................120
Airbag and belt tensioners ...........84
Airbag deactivation ......................49
Airbag label................................... 44 Airbag system .............................. 44
Air conditioning regular operation ................................ 121
Air conditioning system .............. 116
Air intake .................................... 121
Air vents...................................... 120
All wheel drive .....................86, 134
Antilock brake system ................ 136
Antilock brake system (ABS) .......86
Anti-theft alarm system ..........24, 91
Anti-theft locking system .............. 24
Appearance care ........................190
Apply footbrake ............................ 90
Armrest ......................................... 40
Armrest storage ........................... 58
Automatic anti-dazzle ..................29
Automatic dimming ......................29
Automatic headlight levelling system ...................................... 90
Automatic level control .......107, 140Automatic light control ...............106
Automatic transmission ........85, 129
AUX input ..................................... 58
B Battery .......................................... 84
Battery discharge protection ......114
Battery, jump starting.................. 187
Belt pretensioners......................... 41
Belts.............................................. 41
Bicycle rack .................................. 58
Board-Info-Display .......................92
Bonnet ....................................... 153
Bonnet open ................................. 91
Brake and clutch fluid .................195
Brake assist ............................... 138
Brake fluid .................................. 156
Brakes ............................... 136, 156
Brake system ............................... 85
Breakdown.................................. 188
Bulb replacement ....................... 160
C Capacities .................................. 206
Card holder ................................... 57
Car Pass ...................................... 19
Catalytic converter ................85, 129
CD tray ......................................... 57
Central locking system ................21
Centre console storage ...............58

211
Centre high-mounted brakelight.................................. 110, 165
Change engine oil .......................89
Changing tyre and wheel size ...178
Charging system .......................... 84
Check control.............................. 100
Child locks ................................... 22
Child restraint installation locations ................................... 52
Child restraints.............................. 51
Child restraint systems ................51
Cleaning the vehicle ...................190
Climate control ............................. 15
Climate control systems .............115
Clock ............................................ 77
Clutch fluid .................................. 157
Coin storage ................................. 57
Console box.................................. 58
Console net .................................. 57
Control indicators.......................... 81
Control of the vehicle .................123
Controls ........................................ 73
Controls in steering wheel ............73
Convex shape .............................. 27
Coolant and antifreeze ...............195
Coupling ball bar ........................148
Cruise control ...................... 91, 141
Cupholders .................................. 56
Curtain airbag system .................. 49D
Danger, Warnings and Cautions ...3
Daytime running lights ...............108
Declaration of conformity ............208
Descent control system .......87, 139
Diesel fuel filter .......................... 159
Diesel fuel system bleeding .......159
Diesel particle filter .........85, 88, 128
Door open .................................... 91
Doors ............................................ 23
Drain fuel filter ............................. 90
Drink holders ................................ 56
Driver assistance systems ..........141
Driving characteristics and towing tips .............................. 147
Driving hints ................................ 123
E
Electric adjustment ......................27
Electrical parking brake ........86, 137
Electrical parking brake fault ........86
Electrical system......................... 166
Electronic climate control system 117
Electronic driving programmes ..131
Electronic Stability Control ..87, 138
Electronic Stability Control off....... 88 End-of-life vehicle recovery .......152
Engine compartment fuse box ...167
Engine coolant ........................... 154Engine coolant temperature ........88
Engine data ............................... 202
Engine exhaust .......................... 128
Engine identification ...................198
Engine oil ................... 153, 195, 199
Engine oil life monitor ...................89
Engine oil pressure ......................88
Entry lighting .............................. 113
Event data recorders ..................208
Exhaust gases ............................ 128
Exit lighting ................................ 113
Exterior care .............................. 190
Exterior lighting ....................13, 106
Exterior mirrors ............................. 27
F
Fault ........................................... 132
Fire extinguisher ........................... 70
First aid kit ................................... 70
Fixed air vents ........................... 121
Flex-Fix system ............................ 58
Fog light ....................................... 90
Fog lights .................... 109, 110, 163
Folding mirrors ............................. 28
Front airbag system .....................47
Front fog lights ........................... 109
Front passenger seat undertray ...58
Front seats.................................... 35
Front storage ................................ 57
Fuel............................................. 144

212
Fuel consumption - CO2-
Emissions ............................... 146
Fuel economy mode .....................89
Fuel filler cap ................................ 85
Fuel for diesel engines ..............145
Fuel for petrol engines ...............144
Fuel gauge ................................... 81
Fuses ......................................... 166
G Gauges ......................................... 80
General information ...................147
Glovebox ..................................... 56
Graphic-Info-Display, Colour- Info-Display .............................. 94
H Halogen headlights ....................161
Hand brake ................................. 137
Hazard warning flashers ............108
Headlight flash ........................... 107
Headlight range adjustment ......107
Headlights .................. 106, 107, 160
Headlights when driving abroad 108
Headlight washer ..........................74
Head restraint adjustment .............8
Head restraints ............................ 34
Heated mirrors ............................. 28
Heated rear window ..................... 31
Heating ........................................ 39Heating and ventilation system . 115
High beam ........................... 90, 107
Hill start assist ........................... 138
Horn ....................................... 14, 74
I
Identification plate .....................198
Ignition switch positions .............124
Immobiliser ............................ 27, 90
Indicators ...................................... 80
Information displays...................... 92
Instrument cluster ........................80
Instrument panel fuse box .........170
Instrument panel illumination .....166
Instrument panel illumination control .................................... 111
Instrument panel overview ........... 10
Interior care ............................... 192
Interior lighting ............................ 111
Interior lights ...................... 111, 165
Interior mirrors .............................. 29
Interruption of power supply ......132
Introduction .................................... 3
ISOFIX child restraint systems ....55
J Jump starting ............................. 187K
Kerb weight........................... 71, 204
Keys ............................................. 19
Keys, locks ................................... 19
Kickdown .................................... 131
L
Lashing eyes ............................... 70
Light covers, misted.................... 110
Lighting ....................................... 106
Lighting features .........................113
Light switch ................................ 106
Load compartment ................23, 68
Load compartment cover .............68
Load compartment lighting .........112
Load compartment storage ..........68
Loading information .....................71
Low engine oil level .....................89
Low fuel ....................................... 90
M Malfunction indicator light ............85
Manual anti-dazzle ......................29
Manual mode ............................. 131
Manual transmission .................. 133
Mirror adjustment ........................... 9
Mirrors .................................... 27, 29
Misted light covers .....................110

213
NNew vehicle running-in ..............123
Number plate light .....................165
O Object detection systems ...........142
Octane rating .............................. 202
Odometer ..................................... 80
Oil ............................................... 153
Oil, engine .......................... 195, 199
Oil life monitor............................... 89
Outside temperature ....................76
Overrun cut-off ........................... 125
P Parking ................................ 18, 127
Parking assist ............................ 142
Parking brake ....................... 86, 137
Parking lights ............................. 110
Particulate filter ........................... 128
Performance .............................. 203
Performing work ........................152
Pollen filter ................................. 121
Power outlets .......................... 58, 78
Power seat adjustment .................38
Power steering.............................. 87 Power steering fluid ....................155
Power windows ............................ 30
Preheating ................................... 88
Puncture ..................................... 182R
Radio Frequency Identification (RFID) ..................................... 209
Radio remote control ...................19
Rain sensor .................................. 74
Reading lights ............................ 112
Rear carrier system ......................58
Rear floor storage cover ..............69
Rear fog light ............................... 91
Rear fog lights ........................... 110
Rear seats ............................. 39, 40
Rear window wiper/washer .......... 76
Recommended fluids and lubricants ........................ 195, 199
Reduced engine power ................90
Refuelling ................................... 145
Remote control ............................. 19
Reversing lights .........................110
Roof .............................................. 32
Roof load ...................................... 71
Roof rack ..................................... 71
S
Safety belts ................................... 41
Seat adjustment ....................... 6, 36 Seat belt ........................................ 8
Seat belt reminder ..................42, 84
Seat belts ..................................... 41
Seat folding .................................. 37Seat heating ................................. 39
Seat position ................................ 35
Selector lever ............................. 130
Service ............................... 121, 194
Service display ......................81, 89
Service information ....................194
Service vehicle soon .................... 85
Side airbag system ......................48
Sidelights .................................... 106
Side turn signal lights ................164
Spare wheel ............................... 185
Speedometer ............................... 80
Speed warning.............................. 91
Starting and operating ................123
Starting off ................................... 17
Starting the engine ....................124
Steering wheel adjustment ......9, 73
Steering wheel controls ...............73
Stop-start system........................ 125
Storage ......................................... 56
Storage compartments .................56
Sunglasses storage .....................57
Sunroof ........................................ 32
Sunvisor lights ........................... 113
Sun visors .................................... 32
Symbols ......................................... 4
T
Tachometer ................................. 80
Tailgate ......................................... 23