seat OPEL ASTRA K 2017 Repair Manual

196Driving and operatingonly occur if a vehicle ahead is
detected, indicated by the vehicle ahead indicator A 3 191.
If equipped only with front camera the
system operates up to a speed of 60
km/h.
Below a speed of 40 km/h the system can apply full braking.
Emergency automatic braking may
slow the vehicle to a complete stop to
try to avoid a potential crash. If this
happens, emergency automatic
braking may engage the electric
parking brake to hold the vehicle at a
stop. To release press the electric
parking brake button or firmly press
the accelerator pedal.9 Warning
Emergency automatic braking is
an emergency crash preparation
feature and is not designed to
avoid crashes. Do not rely on the
system to brake the vehicle.
Emergency automatic braking will
not brake outside of its operating speed range and only responds to
detected vehicles.
Forward looking brake assist
In addition to the brake preparation
system and emergency automatic
braking, the forward looking brake
assist function makes the brake assist more sensitive. Therefore, pressing
the brake pedal less strongly results
in immediate hard braking. This
function helps the driver brake
quicker and harder before the
imminent collision.
If equipped only with front camera the
system operates up to a speed of 85
km/h.9 Warning
Active emergency braking is not
designed to apply hard
autonomous braking or to
automatically avoid a collision. It is designed to reduce the vehicle
speed before a collision. It may not
react for pedestrians or animals.
After a sudden lane change, the
system needs a certain time to
detect the next preceding vehicle.
The complete attention of the
driver is always required while
driving. The driver shall always be ready to take action and apply the
brakes and steer to avoid
collisions. The system is designed to work with all occupants wearingtheir seat belts.
Intelligent Brake Assist
If the vehicle is equipped with radar
sensor Intelligent brake assist may
activate when the brake pedal is
applied quickly by providing a boost
to braking based on the speed of
approach and distance to a vehicle
ahead.
Minor brake pedal pulsations or pedal movement during this time is normal
and the brake pedal should continue to be applied as needed. Intelligent
brake assist will automatically
disengage only when the brake pedal is released.

Vehicle care229Vehicle battery
The vehicle battery is located in the
load compartment under the rear floor cover behind the rear seats. Rear
floor cover 3 80.
There are connecting points for jump starting in the engine compartment.
Jump starting 3 265.
The vehicle battery is maintenance-
free provided that the driving profile
allows sufficient charging of the
battery. Short-distance-driving and
frequent engine starts can discharge
the battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Laying up the vehicle for more than
four weeks can lead to battery
discharge. Disconnect the clamp from
the negative terminal of the vehicle
battery.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
Battery discharge protection 3 144.
Disconnecting the battery
If the vehicle's battery is to be
disconnected (e.g. for maintenance
work), the alarm siren must be
deactivated as follows: Switch the ignition on then off, then disconnect
the vehicle's battery within
15 seconds.
Replacing the vehicle battery
Note
Any deviation from the instructions
given in this section may lead to
temporary deactivation of the stop-
start system.
When the vehicle battery is being
replaced, please ensure that there
are no open ventilation holes in the
vicinity of the positive terminal. If a
ventilation hole is open in this area, it
must be closed off with a dummy cap,
and the ventilation in the vicinity of the negative terminal must be opened.
In vehicles with an AGM (Absorptive
Glass Mat) battery, ensure the battery
is replaced with another AGM battery.

Vehicle care243Engine compartment fusebox
The fuse box is in the front left of the
engine compartment.
Disengage the cover and remove it.
No.Circuit1Starter2Starter3Exhaust sensor4Engine control module5Engine functions6Transmission control module7–8Engine control module9Climate control system10Diesel exhaust system11Tailgate locking system, Trans‐
mission12Seat lumbar massage13After boil pump14Diesel exhaust system15Exhaust sensor16Fuel injection17Fuel injection

246Vehicle careNo.Circuit1–2Climate control system, fan3Power seat driver side4Cigarette lighter/Power outlet
front5–6Power window front7ABS8Heated steering wheel9Body control module10Power window rear11Sunroof12Body control module13Seat heating (only on vehicles
without alarm horn)14Exterior mirror15Body control module16Body control moduleNo.Circuit17Body control module18Body control module19Data link connector20Airbag system21Climate control system22Central locking system, tailgate23Electronic key system24Power seat memory function25Airbag system steering wheel26Ignition switch/Steering column
lock27Body control module28USB socket29–30Selector lever31Rear window wiper32Transmission control moduleNo.Circuit33Anti-theft alarm system/Power
sounder34Parking assist/Side blind spot
alert/Infotainment system/USB
socket35OnStar36Info display/Instrument cluster/ CD player37Infotainment system, radio
After having changed defective fuses,
close the fuse box cover and press
until it engages.
Vehicles with power connector: 1. Apply the cover on the right side.

248Vehicle careNo.Circuit1–2DC/AC Inverter3Trailer module4Power seat passenger side5–6Distance warning module7–8–9Rear seat heating (on vehicles
without alarm horn)10Service11–12Front seat heating (on vehicles
with alarm horn)13Rear seat heating (on vehicles
with alarm horn)14Ignition15Seat ventilationNo.Circuit16Trailer outlet17Trailer outlet18–19–20–21Electrical rear seat folding22Power tailgate
After having changed defective fuses,
close the fuse box cover and press
until it engages.
Additional fuses are located near the
vehicle battery.
No.Circuit1Fuel pump2Engine control module3Power supply

264Vehicle care
2. Place the loop end of the strapthrough the front lashing eye on
the appropriate side.
3. Place the hook end of the strap through the loop and pull it until
the strap is fastened securely to
the lashing eye.4. Insert the strap through the spokes of the wheel as shown in
the illustration.
5. Mount the hook to the rear lashing
eye.
6. Tighten the strap and secure it using the buckle.
9 Danger
Always drive with folded up and
engaged rear seat backrests when stowing a damaged full size wheel
in the load compartment.
Stowing a damaged full size
wheel in the load compartment,
Sports Tourer
All permitted wheel sizes can be
stowed in the spare wheel well. To
secure the wheel:
1. Remove centre cap with the brand
emblem by pushing from the
inside.
2. Position the wheel outside down in the wheel well.

Vehicle care271After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.
Air shutter Clean the shutter system in the front
bumper to maintain correct
functionality.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using a soft damp cloth. If necessary use aweak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water
or interior cleaner.Caution
Close Velcro fasteners as open
Velcro fasteners on clothing could damage seat upholstery.
The same applies to clothing with
sharp-edged objects, like zips or
belts or studded jeans.
Plastic and rubber parts
Plastic and rubber parts can be
cleaned with the same cleaner as
used to clean the body. Use interior cleaner if necessary. Do not use any
other agent. Avoid solvents and petrol in particular. Do not use high-
pressure jet cleaners.

286Technical dataVehicle dimensions5-door hatchbackSports TourerLength [mm]43704702Width without exterior mirrors [mm]18091809Width with two exterior mirrors [mm]20422042Height (without antenna) [mm]1437-15311452-1580Length of load compartment floor [mm]8281065Length of load compartment with folded rear seats [mm]15751872Load compartment width [mm]10011050Load compartment height [mm]588399Wheelbase [mm]26622662Turning circle diameter [m]11.05-11.4411.05-11.44

299Control indicators........................ 108
Control of the vehicle .................156
Controls ........................................ 91
Convex shape .............................. 39
Coolant and antifreeze ...............273
Cruise control ....................113, 180
Cupholders .................................. 71
Curtain airbag system .................. 62
Curve lighting.............................. 136
D
Danger, Warnings and Cautions ...4
Daytime running lights ...............136
Declaration of conformity ............292
Diesel fuel system bleeding .......230
Diesel particle filter ....................166
Door open .................................. 114
Doors ............................................ 30
Driver assistance systems ..........180
Driver Information Centre ...........114
Driving characteristics and towing tips .............................. 218
Driving hints ................................ 156
E Electric adjustment ......................39
Electrical system......................... 242
Electric parking brake .........110, 175
Electric parking brake fault .........110
Electronic climate control system 148Electronic driving programmes .
........................................ 169, 173
Electronic key system ...................22
Electronic Stability Control.......... 178
Electronic Stability Control and Traction Control system ..........111
Electronic Stability Control off..... 111
End-of-life vehicle recovery .......224
Engine compartment fuse box ...243
Engine coolant ........................... 227
Engine coolant temperature gauge ..................................... 106
Engine data ............................... 280
Engine exhaust .......................... 165
Engine identification ...................276
Engine oil ................... 226, 273, 277
Engine oil pressure ....................112
Entry lighting .............................. 143
Event data recorders ..................296
Exit lighting ................................ 143
Exterior care .............................. 269
Exterior light ............................... 113
Exterior lighting ....................13, 134
Exterior mirrors ............................. 39
F
Fault ................................... 169, 173
First aid kit ................................... 86
Fixed air vents ........................... 153
Fog light ..................................... 113Fog lights ................................... 233
Folding mirrors ............................. 39
Following distance ......................111
Following distance indication ......194
Forward collision alert................. 191
Fragrance diffuser ........................98
Front airbag system .....................61
Front fog lights ........................... 140
Front seats.................................... 47
Front storage ................................ 72
Fuel............................................. 215
Fuel consumption - CO 2-
Emissions ............................... 216
Fuel for diesel engines ..............215
Fuel for petrol engines ...............215
Fuel gauge ................................. 106 Fuses ......................................... 242
G
Gauges ....................................... 104
Gear shifting ............................... 111
General information ...................217
Glovebox ..................................... 71
H
Halogen headlights ....................231
Hand brake ......................... 174, 175
Hazard warning flashers ............139
Headlight flash ........................... 135
Headlight range adjustment ......135
Headlights................................... 134

300Headlights when driving abroad 136
Head restraint adjustment .............8
Head restraints ............................ 46
Heated mirrors ............................. 40
Heated rear window ..................... 43
Heated steering wheel .................92
Heating .................................. 54, 55
Heating and ventilation system . 145
High beam ......................... 113, 135
High beam assist ........................113
Hill start assist ........................... 177
Horn ....................................... 14, 92
I
Identification plate .....................275
Ignition switch positions .............156
Immobiliser .......................... 38, 113
Indicators .................................... 104
Info display ................................. 119
Information displays.................... 114
Instrument cluster ......................101
Instrument panel fuse box .........245
Instrument panel illumination .....241
Instrument panel illumination control .................................... 142
Instrument panel overview ........... 10
Interior care ............................... 271
Interior lighting ............................ 142
Interior lights ...................... 142, 241
Interior mirrors .............................. 40Interruption of power supply ......169
Introduction .................................... 3
J Jump starting ............................. 265
K Key, memorised settings ..............24
Keys ............................................. 20
Keys, locks ................................... 20
L
Lane keep assist ................111, 213
Lashing eyes ............................... 81
LED headlights ...................113, 136
Lighting features .........................143
Light switch ................................ 134
Load compartment ................30, 73
Load compartment cover .............79
Load compartment fuse box ......247
Loading information .....................88
Low fuel ..................................... 112
M Malfunction indicator light ..........110
Manual anti-dazzle ......................40
Manual mode .....................168, 173
Manual seat adjustment ...............48
Manual transmission .................. 170
Manual transmission automated 171
Manual windows ..........................41Massage....................................... 55
Maximum speed ......................... 250
Memorised settings ......................24
Midlevel display .......................... 114
Mirror adjustment ........................... 9 Misted light covers .....................141
N
New vehicle running-in ..............156
Number plate light .....................241
O Object detection systems ...........198
Odometer ................................... 105
Oil, engine .......................... 273, 277
OnStar ........................................ 129
Outside temperature ....................95
Overrun cut-off ........................... 161
P Parking ................................ 19, 164
Parking assist ............................ 198
Parking brake ............................ 175
Parking lights ............................. 141
Particulate filter ........................... 166
Performance .............................. 282
Performing work ........................225
Pollen filter ................................. 154
Power button .............................. 157
Power connector........................... 98
Power outlets ............................... 97