service OPEL COMBO 2017 Manual user

Driving and operating113Diesel engine: turn the key to position
1 for preheating until control
indicator ! extinguishes.
Turn the key briefly to position 2 and
release.
Before restarting or to switch off the
engine, turn the key back to position
0.
Autostop
During an Autostop, the engine is
restarted automatically by depressing
the clutch pedal.
Vehicles with manual transmission
automated (MTA): Shift to a forward
gear, release brake pedal or move
lever to +, – or R to enable an
automatic restart.
Stop-start system 3 114.Starting the vehicle at low
temperatures
The start of the engine without
additional heaters is possible down to -25 °С for diesel engines and -30 °C
for petrol engines. Required is an
engine oil with the correct viscosity,
the correct fuel, performed services
and a sufficiently charged vehicle
battery.
Turbo engine warm-up
Upon start-up, engine available
torque may be limited for a short time, especially when the engine
temperature is cold. The limitation is
to allow the lubrication system to fully protect the engine.
Vehicle shutdown Fuel cut-off system In the event of a collision of a certain
severity, the fuel system is cut-off and
the engine is switched off
automatically, for safety reasons.Control indicator 9 illuminates if the
fuel cut-off switch is triggered and, depending on version, a
corresponding warning message may
also appear in the Driver Information
Centre 3 89.
Generic warning control indicator 9
3 80.
Note
In addition, the vehicle is
automatically unlocked and the
hazard warning flashers and interior lights are illuminated.
Turn the ignition key to position 0 to
prevent vehicle battery discharge and
seek the assistance of a workshop
immediately. Have the vehicle
checked for fuel leaks in the engine
compartment, beneath the vehicle
and near the fuel tank.
To reset the fuel cut-off system and
enable the vehicle to be driven:
1. Turn the ignition key to position 1 3 112.
2. Fully actuate the right turn signal light 3 100.
3. Deactivate the right turn signal light.

138Vehicle careCaution
When transporting the vehicle on
a train or on a recovery vehicle, the
mud flaps might be damaged.
Vehicle storage
Storage for a long period of time
If the vehicle is to be stored for several months:
● Wash and wax the vehicle.
● Have the wax in the engine compartment and underbody
checked.
● Clean and preserve the rubber seals.
● Fill up fuel tank completely.
● Change the engine oil.
● Drain the washer fluid reservoir.
● Check the coolant antifreeze and
corrosion protection.
● Adjust tyre pressure to the value specified for full load.
● Park the vehicle in a dry, wellventilated place. Engage first or
reverse gear to prevent the
vehicle from rolling.
● Do not apply the parking brake.
● Open the bonnet, close all doors and lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Beware that all systems
are not functional, e.g. anti-theft
locking system.
Putting back into operation
When the vehicle is to be put back into operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Activate the electronics
of the power windows.
● Check tyre pressure.
● Fill up the washer fluid reservoir.
● Check the engine oil level.
● Check the coolant level.
● Fit the number plates if necessary.End-of-life vehicle recovery
Information on end-of-life vehicle
recovery centres and the recycling of
end-of-life vehicles is available on our website. Only entrust this work to an
authorised recycling centre.
Natural gas vehicles must be recycled by a service centre authorised for
natural gas vehicles.

158Vehicle careA spare wheel or temporary spare
wheel is not equipped with pressure
sensors. TPMS is not operational for
these wheels. For the further three
wheels, TPMS remains operational.
Spare wheel 3 163, Wheel changing
3 162.
Control indicator w and (depending
on version) a corresponding message appears at each ignition cycle untilthe tyres are inflated to the correct
tyre pressure.
Driver Information Centre 3 89.
Relearn function
After changing wheels, TPMS needs
to recalculate. The relearn process
takes up to 20 minutes of driving with
a minimum speed of 20 km/h.
If problems occur during the relearn
process, control indicator w flashes
for several seconds then illuminates
continuously and (depending on
version) a warning message is
displayed in the Driver Information
Centre.
Driver Information Centre 3 89.General information
The use of tyre chains or
commercially available liquid tyre
repair kits can impair the function of
the system. Factory-approved tyre
repair kits can be used.
Tyre repair kit 3 159, Tyre chains
3 159.
Operating electronic devices or being
close to facilities using similar wave
frequencies could disrupt the tyre
pressure monitoring system.
Each time the tyres are replaced, TPMS sensors must be dismounted
and serviced by a workshop.
Tread depth Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm
(4 mm for winter tyres).
For safety reasons, it is
recommended that the tread depth of
the tyres on one axle should not vary
by more than 2 mm.
The legally permissible minimum
tread depth (1.6 mm) has been
reached when the tread has worn
down as far as one of the tread wear
indicators (TWI). Their position is
indicated by markings on the
sidewall.
If there is more wear at the front than
the rear, swap round front wheels and
rear wheels periodically. Ensure that
the direction of rotation of the wheels
is the same as before.
Tyres age, even if they are not used.
We recommend tyre replacement
every six years.

172Service and maintenanceService and
maintenanceGeneral information ...................172
Service information ..................172
Recommended fluids, lubricants
and parts .................................... 173
Recommended fluids and lubricants ................................ 173General information
Service information In order to ensure economical and
safe vehicle operation and to
maintain the value of your vehicle, it
is of vital importance that all
maintenance work is carried out at the proper intervals as specified.
The detailed, up-to-date service
schedule for your vehicle is available
at the workshop.
Service display 3 77.
Service intervals - petrol and CNG
engines
Maintenance of your vehicle is
required every 30,000 km or
two years, whichever occurs first.
Service intervals - diesel enginesMaintenance of your vehicle is
required every 35,000 km or
two years, whichever occurs first,
unless otherwise indicated in the
Driver Information Centre 3 89.A shorter service interval can be valid
for severe driving behaviour, e.g. for
taxis and police vehicles.
Service display 3 77.
International service intervals Maintenance of your vehicle is
required every 20,000 km or after 1 year , whichever occurs first, unless
otherwise indicated by the service
display.
The international service intervals are
valid for:
Albania, Belarus, Bosnia-
Herzegovina, Georgia, Macedonia,
Moldova, Montenegro, Serbia,
Ukraine.
Service display 3 77.
Confirmations Confirmation of service is recorded inthe Service and warranty booklet.
The date and mileage is completed
with the stamp and signature of the servicing workshop.
Make sure that the Service and
warranty booklet is completed
correctly as continuous proof of

Service and maintenance173service is essential if any warranty orgoodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service interval with remaining
engine oil life duration
The service interval is based on
several parameters depending on
usage.
When the engine oil requires
changing, control indicator I will
flash in the instrument cluster 3 87.
Depending on version, a message
may also appear in the Driver
Information Centre 3 87.
Service display 3 77.Recommended fluids,
lubricants and parts
Recommended fluids and lubricants
Only use products that meet the
recommended specifications.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
ageing control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for
petrol and diesel engines. If it is
unavailable, engine oils of other listed qualities must be used.
Recommendations for petrol engines
are also valid for Compressed Natural
Gas (CNG) fuelled engines.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 177.
Topping up engine oil
Engine oils of different manufacturers
and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 177.

174Service and maintenanceAdditional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity
The SAE viscosity grade gives
information on the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature
viscosity.
Select the appropriate viscosity grade depending on the minimum ambient
temperature 3 177.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C. In
regions with very low temperatures,the factory filled coolant provides frost
protection down to approx. -37 °C.
This concentration should be
maintained all year round.
The use of additional coolant
additives that intend to give additional
corrosion protection or seal against
minor leaks can cause function
problems. Liability for consequences
resulting from the use of additional
coolant additives will be rejected.
Washer fluid
Use only washer fluid approved for
the vehicle to prevent damage of
wiper blades, paintwork, plastic and
rubber parts. Consult a workshop.
Brake and clutch fluidOver time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified interval.

Technical data177Vehicle data
Recommended fluids and lubricants
Required engine oil qualityEngine oil quality: Europedexos 2✔
For countries with International
service interval 3 172, you may use
the oil qualities listed below:
Engine oil quality: Internationaldexos 2✔ACEA C3✔ACEA A3/B4✔Engine oil viscosity gradesAmbient temperaturedown to -25 °CSAE 5W-30 or
SAE 5W-40below -25 °CSAE 0W-30 or
SAE 0W-40

Customer information187● vehicle reactions in particulardriving situations (e.g. inflation ofan airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
This data is exclusively technical and
helps identifying and correcting errors
as well as optimizing vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with this
data.
If services are used (e.g. repair
works, service processes, warranty cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data is deleted from the error storage module or it is
constantly overwritten.When using the vehicle, situations
may occur in which technical data
related to other information (accident
report, damages on the vehicle,
witness statements etc.) may be
associated with a specific person -
possibly, with the assistance of an
expert.
Additional functions contractually
agreed upon with the client (e.g.
vehicle location in emergency cases)
allow the transmission of particular vehicle data from the vehicle.
Radio Frequency
Identification (RFID)
RFID technology is used in some
vehicles for functions such as tyre
pressure monitoring and ignition
system security. It is also used in
connection with conveniences such
as radio remote controls for door
locking/unlocking and starting, and in-
vehicle transmitters for garage door
openers. RFID technology in Opel
vehicles does not use or record
personal information or link with any
other Opel system containing
personal information.

189Cigarette lighter ........................... 74
Climate control ............................. 16
Climate control systems .............105
Clock....................................... 71, 89
CNG............................................ 184
Collision damage repair ..............186
Control indicators.......................... 78
Control of the vehicle .................111
Controls ........................................ 69
Convex shape .............................. 30
Coolant and antifreeze ...............173
Cruise control ...................... 89, 127
Cupholders .................................. 60
D Danger, Warnings and Cautions ...4
Date .............................................. 89
Daytime running lights ............89, 99
Declaration of conformity ............186
Diesel particle filter ...............85, 117
Distance to next service ...............89
Door open .................................... 89
Doors ...................................... 26, 27
Drain fuel filter ............................. 88
Driver assistance systems ..........127
Driver Information Centre .............89
Driving characteristics and towing tips .............................. 135
Driving hints ................................ 111E
Eco mode (E).............................. 122
Electric adjustment ......................30
Electrical system......................... 151
Electronic climate control system 107
Electronic driving programmes ..122
Electronic Stability Control ..84, 126
Electronic Stability Control (ESC). 84
End-of-life vehicle recovery .......138
Engine compartment fuse box ...152
Engine coolant ........................... 141
Engine coolant temperature ........85
Engine coolant temperature gauge ....................................... 77
Engine data ............................... 178
Engine exhaust .......................... 117
Engine identification ...................176
Engine oil ...........140, 173, 177, 184
Engine oil pressure ......................86
ESC (Electronic Stability Control) 126
Event data recorders ..................186
Exit lighting ................................ 104
Extendable load compartment cover ................................... 62, 66
Exterior care .............................. 169
Exterior light ................................. 88
Exterior lighting ......................13, 98
Exterior mirrors ............................. 30F
Fault ........................................... 122
Fixed air vents ........................... 109
Fog light ....................................... 89
Fog lights ................................... 147
Folding front passenger seat ........38
Folding mirrors ............................. 30
Folding seats .......................... 40, 42
Front airbag system .....................51
Front fog lights ........................... 100
Front passenger seat Folding ...................................... 38
Table position ............................ 38
Front seats.................................... 36
Front storage ................................ 60
Front turn signal light ..................145
Fuel............................................. 131
Fuel consumption .........................89
Fuel consumption - CO 2-
Emissions ............................... 134
Fuel cut-off system .........80, 95, 113
Fuel for diesel engines ..............131
Fuel for natural gas operation ...131
Fuel for petrol engines ...............131
Fuel gauge ................................... 76
Fuel selector ................................ 76
Fuel system messages .........95, 113
Fuel tank ..................................... 184
Fuses ......................................... 151

191OObject detection systems ...........129
Odometer ..................................... 75
Oil, engine .......................... 173, 177
Operating windows from outside ..31
Outside temperature ....................71
Overhead console .......................60
Overrun cut-off ........................... 114
P Parking ................................ 19, 116
Parking assist ............................ 129
Parking brake ............................ 124
Particulate filter ........................... 117
Payload......................................... 66
Pedals......................................... 111
Performance .............................. 181
Performing work ........................139
Pollen filter ................................. 110
Power outlets ............................... 73
Power steering fluid ....................141
Power windows ............................ 31
Preheating ................................... 85
Puncture ..................................... 162
R Radio Frequency Identification (RFID) ..................................... 187
Radio info ..................................... 89
Radio remote control ...................21
Rear doors ................................... 26Rear fog light ............................... 89
Rear fog lights ........................... 100
Rear parcel shelf .......................... 62
Rear seats .................................... 40
Rear storage ................................. 61
Rear windows .............................. 33
Rear window wiper/washer .......... 70
Recommended fluids and lubricants ........................ 173, 177
Refuelling ................................... 132 Remote control ............................. 21
Removing seats ............................ 42
Reversing lights .........................100
Ride control systems ..........125, 126
Roof bars ...................................... 61
Roof load ...................................... 66
Roof rack ..................................... 65
Roof racks .................................... 66
S Safety belts ................................... 44
Seat adjustment ....................... 7, 37
Seat belt ........................................ 8
Seat belt reminder .......................81
Seat belt reminder warning chime 89
Seat belts ..................................... 44
Seat folding .................................. 38
Seat heating ................................. 40
Seat position ................................ 36
Second row seats ........................40Selector lever ............................. 120
Service ............................... 110, 172
Service display ......................77, 89
Service information ....................172
Settings menu............................... 89
Side airbag system ......................52
Sidelights ...................................... 98
Side turn signal lights ................148
Sliding door .................................. 26
Sliding side door ........................... 26
Spare wheel ............................... 163
Speed limit warning chime............ 89
Speedometer ............................... 75
Standard display ........................... 89
Starting and operating ................112
Starting off ................................... 17
Starting the engine ............112, 119
Steering ...................................... 111
Steering wheel adjustment ......9, 69
Steering wheel controls ...............69
Stop engine .................................. 80
Stop-start system.................. 88, 114
Storage ......................................... 59
Storage compartments .................59
Sun visors .................................... 34
Symbols ......................................... 4
T
Tachometer ................................. 75
Tailgate ......................................... 27