window OPEL COMBO E 2019.1 Workshop Manual

Vehicle care219● See the Owner's Manual forfurther information.
● Explosive gas may be present in the vicinity of the vehicle battery.
Diesel fuel system bleeding If the tank has been run dry, the diesel
fuel system must be bled. Switch on the ignition three times for
15 seconds at a time. Then crank the
engine for a maximum of
40 seconds. Repeat this process after
no less than five seconds. If the
engine fails to start, seek the
assistance of a workshop.Wiper blade replacement
Windscreen
Switch off the ignition.
Within one minute after switching off
the ignition, operate the wiper lever to positon the wiper blades vertically on
the windscreen.
Lift the wiper arm until it stays in the
raised position, press button to
disengage the wiper blade and
remove.
Attach the wiper blade to the wiper
arm and push until it engages.
Lower the wiper arm carefully.
Rear window
Lift the wiper arm. Disengage the
wiper blade as shown in the
illustration and remove.
Attach the wiper blade slightly angled
to the wiper arm and push until it
engages.
Lower the wiper arm carefully.

Vehicle care2453. Connect the black lead to thenegative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point
of your vehicle in the engine
compartment.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump.
2. After five minutes, start the other engine. Start attempts should be
made for no longer than 15 s at an interval of 1 min.
3. Allow both engines to idle for approx. three minutes with the
leads connected.
4. Switch on electrical consumers e.g. headlights, heated rear
window of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle
Wrap a cloth around the tip of a flat
screwdriver, for example, to prevent
paint damage. Insert the screwdriverin the slot at the lower part of the cap.
Release the cap carefully.
The towing eye is stowed with the vehicle tools 3 230.
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for
towing and not for recovering the
vehicle.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.

246Vehicle careCaution
Deactivate the driver assistance
systems like active emergency
braking 3 182, otherwise the
vehicle may automatically brake during towing.
Switch the selector lever to neutral.
Release the parking brake.
Caution
Never tow a vehicle equipped with All Wheel Drive (AWD) with the
front or rear tyres on the road. If
you tow a vehicle equipped with
AWD while the front or rear tyres
are rolling on the road, the drive
system in the vehicle could be
severely damaged. When towing
vehicles equipped with AWD, all
four tyres must not be in contact
with the road.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with automatic transmission: The vehicle must be towed facing
forwards, not faster than 80 km/h nor further than 100 km. In all other cases
and when the transmission is
defective, the front axle must be
raised off the ground.
Seek the assistance of a workshop.
After towing, unscrew the towing eye.
Insert cap with the flange into the
recess and fix cap by pushing.
Towing another vehicle
Wrap a cloth around the tip of a flat
screwdriver, for example, to prevent paint damage. Insert the screwdriverin the slot at the lower part of the cap.
Release the cap carefully.
The towing eye is stowed with the vehicle tools 3 230.

248Vehicle careIf using a vehicle wash, comply with
the vehicle wash manufacturer's
instructions. The windscreen wiper and rear window wiper must be
switched off. Remove antenna and
external accessories such as roof
racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Wax painted parts of the vehicle
regularly.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.
Clean bright metal mouldings with a
cleaning solution approved for
aluminium to avoid damages.Caution
Always use a cleaning agent with
a pH value of 4 to 9.
Do not use cleaning agents on hot surfaces.
Do not clean the engine compartmentwith a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Have the door hinges of all doors
greased by a workshop.
Do not use hard objects to remove
spots of tar. Use tar removal spray on
painted surfaces.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax the vehicle regularly at the latest when water no longer beads.
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts must not be treated
with wax or polishing agents.
Windows and wiper blades
Switch off wipers before handling in their areas.
Use a soft lint-free cloth or chamois
leather together with window cleaner
and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Clean smearing wiper blades with a
soft cloth and window cleaner.
Remove dirt residues from smearing
wiper blades by using a soft cloth and window cleaner. Also make sure to
remove any residues such as wax,
insect residues and similar from the
window.

Vehicle care249Ice residues, pollution and continuous
wiping on dry windows will damage or
even destroy the wiper blades.
Glass panel Never clean with solvents or abrasive
agents, fuels, aggressive media e.g.
paint cleaner, acetone-containing
solutions, acidic or highly alkaline
media or abrasive pads.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust areas repaired by a workshop.Underbody
Some areas of the vehicle underbody
have a PVC undercoating while other
critical areas have a durable
protective wax coating.
After the underbody is washed, check the underbody and have it waxed if
necessary.
Bitumen / rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Liquid gas system9 Danger
Liquid gas is heavier than air and
can collect in sink points.
Take care when performing work
at the underbody in a pit.
For painting work and when using a
drying booth at a temperature above
60 °C, the liquid gas tank must be
removed.
Do not make any modifications to the
liquid gas system.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.
Interior care
Interior and upholstery
Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.

278Glass panel .................................. 45
Glovebox ..................................... 71
Glovebox cooler ......................... 142 Graphic Info Display ...................118
H Halogen headlights ....................220
Hand brake ................................. 162
Hazard warning flashers ............126
Headlight flash ........................... 125
Headlight range adjustment ......126
Headlights................................... 123 Headlights when driving abroad 126
Head restraint adjustment .............8
Head restraints ............................ 46
Head-up display.......................... 114
Heated mirrors ............................. 39
Heated rear window ..................... 43
Heated steering wheel .................90
Heated windscreen .......................44
Heating ........................................ 51
Heating and ventilation system . 132
High beam ......................... 109, 124
High beam assist ................109, 124
Hill start assist ........................... 165
Horn ....................................... 14, 91
I
Identification plate .....................257
Ignition switch positions .............145
Immobiliser .................................. 37Indicators...................................... 99
Inductive charging ........................95
Info Display ................................. 113
Installing seats .............................. 53
Instrument cluster ........................97
Instrument panel fuse box .........229
Instrument panel illumination control .................................... 129
Instrument panel overview ........... 10
Interior care ............................... 249
Interior lighting ............................ 129
Interior lights ...................... 129, 227
Interior mirrors .............................. 39
Introduction .................................... 3
J Jump starting ............................. 244
K Keys ............................................. 21
Keys, locks ................................... 21
L Ladder flap.................................... 76
Lane keep assist ................106, 201
Lashing eyes ............................... 80
LED headlights ...................109, 222
Lighting features .........................130
Light switch ................................ 123
Load compartment ................32, 76
Load compartment cover .............77Load compartment grille ...............83
Loading ............................. 49, 52, 53
Loading information .....................87
Low beam ................................... 109
Low fuel ..................................... 108
M
Malfunction indicator light ..........104
Manual anti-dazzle ......................39
Manual mode ............................. 158
Manual transmission .................. 160
Mirror adjustment ........................... 8
Misted light covers .....................128
Multimedia .................................. 118
Multimedia Navi Pro ...................118
N
New vehicle running-in ..............145
Number plate light .....................227
O Object detection systems ...........186
Odometer ................................... 100
Oil, engine .......................... 255, 259
Outside temperature ....................93
Overhead console .......................73
Overrun cut-off ........................... 149
P Panoramic view system ..............196
Parking ................................ 20, 152

279Parking assist ............................ 186
Parking brake ..................... 105, 162
Parking heater ............................ 140
Parking lights ............................. 128
Particulate filter ........................... 153
Passenger side camera ..............195
Performing work ........................214
Peripheral lighting .......................131
Power button .............................. 146
Power outlets ............................... 94
Power saving mode ....................147
Power windows ............................ 41
Preheating ................................. 107
Puncture ..................................... 240
R Radio Frequency Identification (RFID) ..................................... 275
Radio remote control ...................22
Rain sensor ................................ 109
REACH ....................................... 271
Reading lights ............................ 129
Rear doors ................................... 31
Rear fog light .............109, 128, 224
Rear view camera ...................... 199
Rear view display .................40, 116
Rear windows .............................. 43
Rear window wiper and washer ..93
Recommended fluids and lubricants ........................ 255, 259Refuelling ................................... 206
Registered trademarks ...............271
Removing seats ............................ 53
Reversing lights .........................128
Ride control systems ..................165
Roller blinds ................................. 44
Roof .............................................. 45
Roof load ...................................... 87
Roof rack ..................................... 86
S Safety net .................................... 81
Seat adjustment ....................... 7, 48
Seat belt ........................................ 8
Seat belt reminder .....................103
Seat belts ..................................... 56
Seat folding .................................. 49
Seat heating ................................. 51
Seat position ................................ 47
Second row seats ........................52
Selective catalytic reduction .......154
Selective ride control ..................168
Selector lever ............................. 158
Service ............................... 143, 252
Service display .......................... 102
Service information ....................252
Service vehicle soon .................. 105
Side airbag system ......................62
Side blind spot alert ............110, 194
Sidelights .................................... 123Side turn lights ........................... 226
Sliding door .................................. 30
Sliding side door ........................... 30
Spare wheel ............................... 240
Speed limiter....................... 110, 172
Speedometer ............................... 99
Starting and operating ................145
Starting off ................................... 18
Starting the engine ....................148
Steering ...................................... 145
Steering wheel adjustment ......9, 90
Steering wheel controls ...............90
Stop engine ................................ 105
Stop-start system........................ 149
Storage ......................................... 71
Storage compartments .................71
Sunvisor lights ........................... 130
Sun visors .................................... 44
Symbols ......................................... 4
System check ............................. 105
T
Tachometer ............................... 100
Tailgate ......................................... 32
Tail lights ................................... 224
Third row seats ............................ 53
Three-point seat belt .................... 57
Tools .......................................... 230
Tow bar....................................... 208
Towing ................................ 208, 245

280Towing another vehicle .............246
Towing equipment .....................209
Towing the vehicle .....................245
Trailer coupling ........................... 208
Trailer stability assist .................211
Trailer towing ............................. 208
Transmission ............................... 18
Transmission display .................157
Tread depth ............................... 234
Trip odometer ............................ 100
Turn lights .......................... 103, 127
Tyre chains ................................ 235
Tyre deflation detection system . 233
Tyre designations ......................232
Tyre pressure ............................ 232
Tyre pressures ........................... 266
Tyre repair kit ............................. 236
U
Ultrasonic parking assist............. 186
Underseat storage .......................74
Upholstery .................................. 249
USB port ....................................... 94
Using this manual ..........................3
V Valet mode ................................. 113
Vehicle battery ........................... 217
Vehicle checks............................ 214
Vehicle data ................................ 259Vehicle data recording and
privacy ..................................... 272
Vehicle detected ahead ..............109
Vehicle dimensions .................... 264
Vehicle Identification Number ....257
Vehicle jack ................................ 230
Vehicle locator lighting ...............131
Vehicle messages .....................117
Vehicle personalisation .............118
Vehicle security ............................ 35
Vehicle specific data ......................3
Vehicle storage ........................... 213
Vehicle tools ............................... 230
Vehicle unlocking ........................... 6
Ventilation ................................... 140
W
Warning chimes .........................117
Warning lights ............................... 99
Warning triangle .......................... 86
Washer and wiper systems .........14
Washer fluid ............................... 217
Wheel changing .........................239
Wheel covers ............................. 235
Wheels and tyres .......................231
Windows ....................................... 41
Windscreen................................... 41
Windscreen wiper and washer ....91
Winter tyres ............................... 231
Wiper blade replacement ..........219