warning OPEL INSIGNIA BREAK 2019.5 Manual user

264Vehicle careilluminates. For the further three
wheels the system remains
operational.
The use of commercially available
liquid tyre repair kits can impair the
function of the system. Factory-
approved repair kits can be used.
Operating electronic devices or being close to facilities using similar wave
frequencies could disrupt the tyre
pressure monitoring system.
Each time the tyres are replaced, tyre
pressure monitoring system sensors
must be dismounted and serviced. For the screwed sensor, replace
valve core and sealing ring. For the
clipped sensor, replace complete
valve stem.
Vehicle loading status
Adjust tyre pressure to load condition according tyre information label or
tyre pressure chart 3 298, and select
the appropriate setting in Tyre Load
within the vehicle information menu
3 112. This setting determines the
reference pressures for the tyre
pressure warnings.The Tyre Load menu only appears
when the vehicle is at a standstill and the parking brake is applied. On
vehicles with automatic transmission
the selector lever must be in P.
Select:
● Light for comfort pressure up to
3 people.
● Eco for Eco pressure up to
3 people.
● Max for full loading.
Auto learn function After changing wheels or wheel
positions the vehicle must be
stationary for approx. 20 minutes,
before the system recalculates. The
following relearn process takes up to
10 minutes of driving in a speed range
of 40 to 100 km/h. Avoid to drive
outside of this range for a longer time.
If possible, use a country road or
similar which allows continuous
driving. During relearn process $
can be displayed or pressure values can swap in the Driver Information
Centre.
If problems occur during the relearn
process, a failure message is
displayed in the Driver Information
Centre. w will flash for 60 seconds
and then illuminate continuously.
If this happens, repeat learning
process. Keep your vehicle stationary for approx. 20 minutes and then drive
again for 10 minutes as described
above.
Tread depth
Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm
(4 mm for winter tyres).

Vehicle care265For safety reasons, it is
recommended that the tread depth of
the tyres on one axle should not vary
by more than 2 mm.
The legally permissible minimum
tread depth (1.6 mm) has been
reached when the tread has worn
down as far as one of the tread wear
indicators (TWI). Their position is
indicated by markings on the
sidewall.
If there is more wear at the front than
the rear, swap round front wheels and rear wheels periodically. Ensure that
the direction of rotation of the wheels
remains the same.
Tyres age, even if they are not used.
We recommend tyre replacement
every 6 years.
Changing tyre and wheel
size
If tyres of a different size than those
fitted at the factory are used, it may be necessary to reprogramme the
nominal tyre pressure and make
other vehicle modifications.
After converting to a different tyre
size, have the label with tyre
pressures replaced and the tyre
pressure monitoring system
reinitialised 3 262.9 Warning
The use of unsuitable tyres or
wheels may lead to accidents and will invalidate the vehicle
operating permit.
Wheel covers
Wheel covers and tyres that are
factory approved for the respective
vehicle and comply with all of the
relevant wheel and tyre combination
requirements must be used.
If the wheel covers and tyres used are
not factory approved, the tyres must
not have a rim protection ridge.
Wheel covers must not impair brake
cooling.9 Warning
Use of unsuitable tyres or wheel
covers could lead to sudden
pressure loss and thereby
accidents.
Vehicles with steel wheels: When
using locking wheel nuts, do not
attach wheel covers.

266Vehicle careTyre chains
Tyre chains are only permitted on the
front wheels.
Always use fine mesh chains that add no more than 10 mm to the tyre tread
and the inboard sides (including chain lock).
9 Warning
Damage may lead to tyre blowout.
Tyre chains are only permitted on
tyres of size 215/60 R16, 215/55 R17 ,
225/55 R17 and 235/45 R18.
Temporary spare wheel
The use of tyre chains is not permitted on the temporary spare wheel.
Tyre repair kit
Minor damage to the tyre tread can be
repaired with the tyre repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding 4 mm or that is at tyre's side wall cannot be
repaired with the tyre repair kit.9 Warning
Do not drive faster than 80 km/h.
Do not use for a lengthy period.
Steering and handling may be
affected.
Two types of tyre repair kit are
available:
● Type 1 indicated by the on/off
switch at the top of the
compressor.

Vehicle care271Wheel changing
Make the following preparations and observe the following information:
● Park the vehicle on a level, firm and non-skid surface. The front
wheels must be in the straight- ahead position.
● Apply the parking brake and engage first gear, reverse gear or
P .
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Take heavy objects out of the vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the vehicle when it is
raised on the jack.
● Clean wheel nuts and thread with
a clean cloth before mounting the
wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
Jacking positions
The jacking positions shown refer to
the use of lifting arms and accessory
jacks used for changing winter /
summer tyres.
Rear arm position of the lifting
platform centrically under the relevant
vehicle jacking point.
Front arm position of the lifting
platform centrically under the relevant vehicle jacking point.
Spare wheel The spare wheel can be classified as
a temporary spare wheel depending
on the size compared to the other
mounted wheels and country
regulations. In this case a permissible maximum speed applies, even
though no label at the spare wheel
indicates this.

Vehicle care273● Use the jack only to changewheels in case of puncture, not
for seasonal winter or summer
tyre change.
● The jack is maintenance-free.
● If the ground on which the vehicle
is standing is soft, a solid board
(max. 1 cm thick) should be
placed under the jack.
● Take heavy objects out of the vehicle before jacking up.
● No people or animals may be in the vehicle when it is jacked-up.
● Never crawl under a jacked-up vehicle.
● Do not start the vehicle when it is
raised on the jack.
● Clean wheel nuts and thread with
a clean cloth before mounting the wheel.9 Warning
Do not grease wheel bolt, wheel
nut and wheel nut cone.
1. Steel wheels with cover: Pull off the wheel cover.
Alloy wheels: Disengage wheel
nut caps with a flat screwdriver
and remove. To protect the wheel paint and the cap, wrap a cloth
around the screwdriver tip.
2. Fold out the wheel wrench and install ensuring that it locates
securely and loosen each wheel
nut by half a turn.
The wheels might be protected by
locking wheel nuts. To loosen
these specific nuts, first attach the adapter for the locking wheel nuts
onto the head of the nut before
installing the wheel wrench. The
adapter is located in the glovebox.
3. Ensure the jack is correctly positioned under the relevant
vehicle jacking point.
Some versions have sill panels
with covered vehicle jacking

Vehicle care275
1. Stick the extension bolt onto thethread bolt.
2. Store the damaged wheel outside
up in the spare wheel well and
secure it by turning the wing nut
clockwise on the extension bolt.
9 Warning
Storing a jack, a wheel or other
equipment in the load
compartment could cause injury if they are not fixed properly. During
a sudden stop or a collision, looseequipment could strike someone.
Always store jack and tools in the
respective storage compartments
and secure them by fixing.
Damaged wheel placed in the load
compartment must always be
secured with the strap.
Spare wheel with directional tyre
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible
and fit it instead of the spare
wheel.
● Drive particularly carefully on wet
and snow-covered road
surfaces.
Jump starting
A vehicle with a discharged vehicle
battery can be started using jump
leads and the vehicle battery of
another vehicle.
Do not start with quick charger.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
● Never expose the vehicle battery
to naked flames or sparks.

284Service and maintenancedriving at high altitude and large
variations of temperature. Under
these severe operating conditions,
certain service work may be required more frequently than the regular
service interval.
The international service intervals are
valid for the countries which are not
listed in the European service
intervals.
Service display 3 104.
Confirmations Confirmation of service is recorded inthe Service and Warranty Booklet.
The date and mileage is completed
with the stamp and signature of the
servicing workshop.
Make sure that the Service and
warranty booklet is completed
correctly as continuous proof of
service is essential if any warranty or
goodwill claims are to be met. It is also
a benefit when selling the vehicle.Recommended fluids,
lubricants and parts
Recommended fluids andlubricants
Only use products that meet the
recommended specifications.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 288.
Topping up engine oilCaution
In case of any spilled oil, wipe it up and dispose it properly.
Engine oils of different manufacturersand brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oils for all petrol
engines with only ACEA quality is
prohibited, since it can cause engine
damage under certain operating
conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 288.
Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.

317Child restraint systems ................64
Climate control ............................. 16
Clock............................................. 92
Collision damage repair ..............309
Control indicators........................ 105
Control of the vehicle .................158
Controls ........................................ 88
Convex shape .............................. 37
Coolant and antifreeze ...............284
Cruise control ....................111, 182
Cupholders .................................. 73
Curtain airbag system .................. 62
Curve lighting.............................. 138
D Danger, Warnings and Cautions ...4
Daytime running lights ...............138
Declaration of conformity ............305
DEF ............................................ 167
Diesel exhaust fluid ....................167
Diesel fuel system bleeding .......243
Door open .................................. 111
Doors ............................................ 29
Driver assistance systems ..........182
Driver Information Centre ...........112
Driving characteristics and towing tips .............................. 231
Driving hints ................................ 158E
Electric adjustment ......................37
Electrical system......................... 254
Electric parking brake .........107, 176
Electric parking brake fault .........107
Electronic climate control system 148
Electronic driving programmes ..172
Electronic key system ...................22
Electronic Stability Control.......... 179
Electronic Stability Control and Traction Control system ..........108
Electronic Stability Control off..... 108
End-of-life vehicle recovery .......236
Engine compartment fuse box ...255
Engine coolant ........................... 239
Engine coolant temperature ......109
Engine coolant temperature gauge ..................................... 104
Engine data ............................... 291
Engine exhaust .......................... 165
Engine identification ...................287
Engine oil ................... 238, 284, 288
Engine oil pressure ....................109
Entry lighting .............................. 143
Event data recorders ..................312
Exhaust filter ............................... 165
Exit lighting ................................ 143
Exterior care .............................. 279
Exterior light ............................... 110Exterior lighting ....................13, 134
Exterior mirrors ............................. 37
F
Fault ........................................... 173
First aid kit ................................... 84
Fixed air vents ........................... 155
Folding mirrors ............................. 37
Following distance ......................108
Following distance indication ......199
Forward collision alert................. 196
Front airbag system .....................61
Front fog lights ...........110, 140, 246
Front pedestrian protection ........203
Front seats.................................... 47
Front storage ................................ 74
Fuel............................................. 227
Fuel for diesel engines ..............228
Fuel for petrol engines ...............227
Fuel gauge ................................. 103 Funnel......................................... 229
Fuses ......................................... 254
G Gauges ....................................... 101
Gear selection ........................... 170
Gear shifting ............................... 108
General information ...................231
Glovebox ..................................... 73

318HHalogen headlights ....................244
Hand brake ................................. 175
Hazard warning flashers ............139
Headlight flash ........................... 137
Headlight range adjustment ......137
Headlights................................... 134
Headlights when driving abroad 137
Head restraint adjustment .............8
Head restraints ............................ 45
Head-up display.......................... 120 Heated mirrors ............................. 38
Heated rear window ..................... 42
Heated steering wheel .................88
Heated windscreen .......................42
Heating .................................. 54, 55
High beam ......................... 110, 135
High beam assist ................110, 135
Hill start assist ........................... 177
Horn ....................................... 14, 89
I
Identification plate .....................286
Immobiliser .......................... 36, 110
Indicators .................................... 101
Inductive charging ........................94
Info Display ................................. 118
Instrument cluster ........................96
Instrument panel fuse box .........258Instrument panel illumination
control .................................... 141
Instrument panel overview ........... 10
Interactive driving system ...........180
Interior care ............................... 281
Interior lighting ............................ 141
Interior lights ...................... 142, 254
Interior mirrors .............................. 39
Interruption of power supply ......173
Introduction .................................... 3
J
Jump starting ............................. 275
K Key, memorised settings ..............25
Keys ............................................. 20
Keys, locks ................................... 20
L
Lane change alert .......................213
Lane keep assist ................108, 224
Lashing eyes ............................... 80
LED headlights ...........110, 138, 246
Lighting features .........................143
Light switch ................................ 134
Load compartment ................29, 75
Load compartment cover .............78
Loading information .....................85
Low fuel ..................................... 110M
Malfunction indicator light ..........107
Manual anti-dazzle ......................39
Manual mode ............................. 171
Manual seat adjustment ...............48
Manual transmission .................. 174
Massage ....................................... 55
Memorised settings ......................25
Midlevel display .......................... 112
Mirror adjustment ........................... 8
Misted light covers .....................141
N New vehicle running-in ..............158
Number plate light .....................254
O Object detection systems ...........205
Odometer ................................... 102
Oil, engine .......................... 284, 288
OnStar ........................................ 129
Outside temperature ....................92
Overrun cut-off ........................... 162
P
Panoramic view system ..............215
Parking ................................ 19, 164
Parking assist ...................... 39, 205
Parking brake ............................ 176
Parking lights ............................. 141
Particulate filter ........................... 165

320Traffic sign assistant...........111, 220
Trailer coupling ........................... 231
Trailer stability assist .................234
Trailer towing ............................. 231
Transmission ............................... 17
Transmission display .................169
Tread depth ............................... 264
Trip odometer ............................ 102
Turn lights .......................... 105, 140
Tyre chains ................................ 266
Tyre designations ......................261
Tyre pressure ............................ 261
Tyre pressure monitoring system ............................. 109, 262
Tyre pressures ........................... 298
Tyre repair kit ............................. 266
U
Upholstery .................................. 281
Uplevel display ........................... 112
USB port ....................................... 93
Using this manual ..........................3
V
Valet mode ................................. 118
Vehicle battery ........................... 241
Vehicle checks............................ 237
Vehicle data ................................ 288
Vehicle data recording and privacy ..................................... 312
Vehicle detected ahead ..............111Vehicle dimensions .................... 296
Vehicle identification number ....286
Vehicle jack ................................ 259
Vehicle messages .....................123
Vehicle personalisation .............124
Vehicle security ............................ 34
Vehicle specific data ......................3
Vehicle storage ........................... 236
Vehicle tools ............................... 259
Vehicle unlocking ........................... 6
Ventilating ..................................... 54
W
Warning chimes .........................123
Warning lights ............................. 101
Warning triangle .......................... 83
Washer and wiper systems .........14
Washer fluid ............................... 240
Wheel changing .........................271
Wheel covers ............................. 265
Wheels and tyres .......................260
Windows ....................................... 40
Windscreen................................... 40
Windscreen wiper and washer ....89
Winter tyres ............................... 260
Wiper blade replacement ..........243