wheel OPEL MERIVA 2017 Repair Manual

212Vehicle careStoring a replaced wheel in the
spare wheel well using an
extension bar
Use the extension bar placed in the
tool box. Vehicle tools 3 195.
● Turn the wing nut anticlockwise and remove temporary spare
wheel.
● Take the extension bar from the tool box and screw it on the bolt.
● Store the damaged wheel and secure it by turning the wing nut
clockwise.
The floor cover can be placed on the
projecting wheel.
Remove the extension bar before
fitting the spare wheel in the well after renewing or repairing the defective
wheel.9 Warning
Storing a jack, a wheel or other
equipment in the load
compartment could cause injury if they are not fixed properly. During a sudden stop or a collision, loose
equipment could strike someone.
Store jack and tools always in the
respective storage compartments
and secure them by fixing.
Place the damaged wheel always
in the load compartment secured
by the strap or in the spare wheel
well secured by the wing nut.
Temporary spare wheel
Caution
The use of the temporary spare
wheel could affect driveability.
Have the defective tyre renewed
or repaired as soon as possible.
Only mount one temporary spare
wheel. The permissible maximum
speed on the label on the temporary
spare wheel is only valid for the
factory-fitted tyre size.
If your vehicle gets a flat tyre in the
rear while towing another vehicle,
mount the temporary spare wheel in
the front and the full tyre in the rear.
Tyre chains 3 202.
Spare wheel with directional tyre If possible, fit directional tyres such
that they roll in the direction of travel.
The rolling direction is indicated by a
symbol (e.g. an arrow) on the
sidewall.
The following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible
and fit it instead of the spare
wheel.
● Drive particularly carefully on wet
and snow-covered road
surfaces.

Vehicle care215
Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for towing and not for recovering the
vehicle.
Caution
Activate the child lock in both rear
doors if the rear seats are
occupied. Child locks 3 26.
Switch on ignition to release steering
wheel lock and to permit operation of
brake lights, horn and windscreen
wiper.
Transmission in neutral.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust gases from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with automatic transmission: The vehicle must be towed facing
forwards, not faster than 80 km/h nor further than 100 km. In all other cases
and when the transmission is
defective, the front axle must be
raised off the ground.
Seek the assistance of a workshop.
After towing, unscrew the towing eye.
Insert cap at the bottom and close
cap.
Towing another vehicle
Disengage the cap at the bottom and
remove downwards.
The towing eye is stowed with the
vehicle tools 3 195.

Vehicle care217If using a vehicle wash, comply with
the vehicle wash manufacturer's
instructions. The windscreen wiper and rear window wiper must be
switched off. Remove antenna and
external accessories such as roof
racks etc.
If you wash your vehicle by hand,
make sure that the insides of the
wheel housings are also thoroughly
rinsed out.
Clean edges and folds on opened
doors and the bonnet as well as the
areas they cover.Caution
Always use a cleaning agent with
a pH value of 4 to 9.
Do not use cleaning agents on hot surfaces.
Have the door hinges of all doors
greased by a workshop.
Do not clean the engine compartment with a steam-jet or high-pressure jet
cleaner.
Thoroughly rinse and leather-off the vehicle. Rinse leather frequently. Use
separate leathers for painted and
glass surfaces: remnants of wax on
the windows will impair vision.
Do not use hard objects to remove
spots of tar. Use tar removal spray on
painted surfaces.
Exterior lights
Headlight and other light covers are
made of plastic. Do not use any
abrasive or caustic agents, do not use
an ice scraper, and do not clean them
dry.
Polishing and waxing
Wax the vehicle regularly (at the
latest when water no longer beads).
Otherwise, the paintwork will dry out.
Polishing is necessary only if the paint
has become dull or if solid deposits
have become attached to it.
Paintwork polish with silicone forms a
protective film, making waxing
unnecessary.
Plastic body parts must not be treated with wax or polishing agents.Windows and windscreen wiper
blades
Use a soft lint-free cloth or chamois
leather together with window cleaner and insect remover.
When cleaning the rear window from
inside, always wipe in parallel to the
heating element to prevent damage.
For mechanical removal of ice, use a
sharp-edged ice scraper. Press the
scraper firmly against the glass so
that no dirt can get under it and
scratch the glass.
Remove dirt residues from smearing wiper blades by using a soft cloth and window cleaner. Also make sure to
remove any residues such as wax,
insect residues and similar from the
window.
Ice residues, pollution and continuous
wiping on dry windows will damage or even destroy the wiper blades.

218Vehicle careMoonroof
Never clean with solvents or abrasive agents, fuels, aggressive media (e.g.
paint cleaner, acetone-containing
solutions etc.), acidic or highly
alkaline media or abrasive pads. Do
not apply wax or polishing agents to
the middle part of the moonroof.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust areas repaired by a workshop.
Underbody
Some areas of the vehicle underbody
have a PVC undercoating while other critical areas have a durable
protective wax coating.After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Liquid gas system9 Danger
Liquid gas is heavier than air and
can collect in sink points.
Take care when performing work
at the underbody in a pit.
For painting work and when using a
drying booth at a temperature above
60 °C, the liquid gas tank must be
removed.
Do not make any modifications to the
liquid gas system.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.
Rear carrier system Clean the rear carrier system with a
steam-jet or high-pressure jet cleaner
at least once a year.
Operate the rear carrier system
periodically if not in regular use, in
particular during winter.
Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean the leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.

Technical data233Vehicle dimensionsMerivaLength [mm]4300Width without exterior mirrors [mm]1812Width with two exterior mirrors [mm]1994Height (without antenna) [mm]1615Length of load compartment floor [mm]815Length of load compartment with folded rear seats [mm]1642Load compartment width [mm]1038Load compartment height [mm]803Height of load compartment opening [mm]791Wheelbase [mm]2644Turning circle diameter [m]11.90

Technical data237Comfort with up to 3
peopleECO with up to 3 peopleWith full loadEngineTyresfrontrearfrontrearfrontrear[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])[kPa/bar]
([psi])A17DTI205/55 R16,250/2.5 (36)230/2.3 (33)300/3.0 (43)280/2.8 (41)270/2.7 (39)320/3.2 (46)225/45 R17225/40 R18270/2.7 (39)250/2.5 (36)300/3.0 (43)280/2.8 (41)280/2.8 (41)320/3.2 (46)AllTemporary spare wheel
115/70 R16420/4.2 (61)420/4.2 (61)––420/4.2 (61)420/4.2 (61)

242Customer informationoriginal source. Such altered
versions also must not be
misrepresented as being Info-ZIP
releases--including, but not
limited to, labeling of the altered
versions with the names “Info-
ZIP” (or any variation thereof,
including, but not limited to,
different capitalizations), “Pocket
UnZip,” “WiZ” or “MacZip” without
the explicit permission of Info-ZIP. Such altered versions are further
prohibited from misrepresentative
use of the Zip-Bugs or Info-ZIP e- mail addresses or of the Info-ZIP
URL(s).
4. Info-ZIP retains the right to use the names “Info-ZIP,” “Zip,”
“UnZip,” “UnZipSFX,” “WiZ,” “Pocket UnZip,” “Pocket Zip,” and
“MacZip” for its own source and
binary releases.Vehicle data recording
and privacy
Event data recorders Data storage modules in the
vehicle
A large number of electronic
components of your vehicle contain
data storage modules temporarily or
permanently storing technical data
about the condition of the vehicle,
events and errors. In general, this
technical information documents the
condition of parts, modules, systems
or the environment:
● operating conditions of system components (e.g. filling levels)
● status messages of the vehicle and its single components (e.g.
number of wheel revolutions / rotational speed, deceleration,
lateral acceleration)
● dysfunctions and defects in important system components● vehicle reactions in particulardriving situations ( e.g. inflation of
an airbag, activation of the
stability regulation system)
● environmental conditions (e.g. temperature)
These data are exclusively technical
and help identifying and correcting
errors as well as optimising vehicle
functions.
Motion profiles indicating travelled
routes cannot be created with these
data.
If services are used (e.g. repair
works, service processes, warranty
cases, quality assurance),
employees of the service network
(manufacturer included) are able to
read out this technical information
from the event and error data storage
modules applying special diagnostic
devices. If required, you will receive
further information at these
workshops. After an error has been
corrected, the data are deleted from
the error storage module or they are
constantly overwritten.

244IndexAAccessories and vehicle modifications .......................... 172
Active head restraints ...................36
Adaptive brake light ....................150
Adaptive forward lighting ..100,
123, 182
Adjustable air vents ...................136
Airbag and belt tensioners ...........95
Airbag deactivation ................53, 95
Airbag label................................... 49 Airbag system .............................. 49
Air conditioning regular operation ................................ 137
Air conditioning system .............. 130
Air intake .................................... 137
Air vents...................................... 136
Alert ............................................ 108
Antifreeze ................................... 175
Antilock brake system ................ 150
Antilock brake system (ABS) .......97
Anti-theft alarm system ................28
Anti-theft locking system .............. 28
Appearance care ........................216
Armrest ................................... 40, 43
Armrest storage ........................... 63
Ashtrays ....................................... 88
Automatic anti-dazzle ..................31
Automatic light control ...............121
Automatic locking ................25, 100Automatic transmission .............146
Autostop ..................................... 142
Auxiliary heater ........................... 136
B Battery discharge protection ......128
Battery voltage ........................... 109
Belts.............................................. 45 Bicycle rack .................................. 64
Bonnet ....................................... 173
Brake and clutch fluid .................221
Brake and clutch system .............96
Brake assist ............................... 152
Brake fluid .................................. 176
Brakes ............................... 150, 176
Breakdown.................................. 214
Bulb replacement ....................... 180
C Capacities .................................. 234
Car Pass ...................................... 21
Catalytic converter .....................146
Central locking system ................22
Centre console lighting ..............127
Changing tyre and wheel size ...201
Charging system .......................... 96
Child locks ................................... 26
Child restraint installation locations ................................... 57
Child restraints.............................. 55
Child restraint systems ................55

245Cigarette lighter ........................... 88
Climate control ............................. 16
Climate control, service ..............137
Climate control systems .............129
Clock............................................. 86
Code ........................................... 106
Collision damage repair ..............240
Control indicators.......................... 92
Control of the vehicle .................139
Controls ........................................ 82
Controls in steering wheel ............82
Convex shape .............................. 29
Coolant ....................................... 175
Coolant and antifreeze ...............221
Coolant temperature gauge ..........90
Coupling ball bar ........................168
Cruise control ....................100, 154
Cupholders .................................. 61
Curtain airbag system .................. 53
Curve lighting.............................. 123
D
Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running light ..................121
Daytime running lights ...............123
Declaration of conformity ............238
Diesel fuel system bleeding .......179
Diesel particle filter ...............98, 145
Door open .................................. 100Doors............................................ 26
Driver assistance systems ..........154
Driver Information Centre ...........101
Driving characteristics and towing tips .............................. 167
Driving hints ................................ 139
E Electric adjustment ......................29
Electrical system......................... 189
Electric parking brake ...........97, 151
Electric parking brake fault ...........97
Electronic climate control system 132
Electronic driving programmes ..148
Electronic Stability Control.......... 153
Electronic Stability Control and Traction Control system ............98
Electronic Stability Control off....... 98
End-of-life vehicle recovery .......172
Engine compartment fuse box ...191
Engine coolant ........................... 175
Engine coolant temperature gauge ....................................... 90
Engine data ............................... 228
Engine exhaust .......................... 145
Engine identification ...................224
Engine oil ................... 174, 221, 225
Engine oil pressure ......................99
Entry lighting .............................. 127
Event data recorders ..................242Exhaust gases ............................ 145
Exit lighting ................................ 127
Exterior care .............................. 216
Exterior light ................................. 99
Exterior lighting ....................13, 120
Exterior mirrors ............................. 29
F
Fault ........................................... 148
First aid ......................................... 78
First aid kit ................................... 78
Fixed air vents ........................... 137
Flex-Fix system ............................ 64
Fog light ..................................... 100
Fog lights .................... 124, 125, 184
Folding mirrors ............................. 30
Folding tray .................................. 78
Front airbag system .....................52
Front fog lights ........................... 124
Front seats.................................... 37
Front storage ................................ 63
Front turn signal light ..................180
Front turn signal lights ...............184
Fuel............................................. 160
Fuel consumption - CO 2-
Emissions ............................... 165
Fuel for diesel engines ..............160
Fuel for liquid gas operation .......160
Fuel for petrol engines ...............160
Fuel gauge ................................... 90

246Fuel selector ................................ 90
Fuse box ..................................... 191
Fuses ......................................... 189
G Gauges ......................................... 89
General information ...................166
Glovebox ..................................... 61
Graphic-Info-Display, Colour- Info-Display ............................ 104
H Halogen headlights ....................180
Hand brake ......................... 150, 151
Hazard warning flashers ............124
Headlight flash ........................... 122
Headlight range adjustment ......122
Headlights .......................... 120, 122
Headlights when driving abroad 122
Head restraint adjustment .............8
Head restraints ............................ 35
Heated mirrors ............................. 30
Heated rear window ..................... 33
Heated steering wheel .................82
Heating ........................................ 41
Heating and ventilation system . 129
High beam ......................... 100, 122
Hill start assist ........................... 152
Horn ....................................... 14, 83I
Identification plate .....................224
Ignition switch positions .............140
Immobiliser ............................ 29, 99
Indicators ...................................... 89
Information displays.................... 101
Instrument cluster ........................89
Instrument panel fuse box .........193
Instrument panel illumination .....189
Instrument panel illumination control .................................... 126
Instrument panel overview ........... 10
Interior care ............................... 218
Interior lighting ............................ 126
Interior lights ...................... 126, 189
Interior mirrors .............................. 30
Interruption of power supply ......148
Introduction .................................... 3
ISOFIX child restraint systems ....60
J
Jump starting ............................. 213
K Keys ............................................. 20
Keys, locks ................................... 20
Keys, memorised settings ............22
L Lashing eyes ............................... 76
Light covers, misted.................... 125Lighting features .........................127
Light switch ................................ 120
Load compartment ................27, 73
Load compartment cover .............74
Load compartment fuse box ......194
Loading information .....................79
Low fuel ....................................... 99
M Malfunction indicator light ............96
Manual anti-dazzle ......................30
Manual mode ............................. 148
Manual transmission .................. 149
Manual windows ..........................31
Memorised settings ......................22
Midlevel-Display ......................... 101
Mirror adjustment ........................... 8
Misted light covers .....................125
Moonroof ..................................... 34
N New vehicle running-in ..............140
Number plate light .....................188
O
Object detection systems ...........156
Octane rating .............................. 228
Odometer ..................................... 89
Oil ............................................... 174
Oil, engine .......................... 221, 225
Oil pressure .................................. 99