engine coolant OPEL MOVANO_B 2019 Manual user

Vehicle care185Engine coolant
The coolant provides freeze
protection down to approx. -28 °C.Caution
Only use approved antifreeze.
Coolant level
Caution
Too low a coolant level can cause engine damage.
If the cooling system is cold, the
coolant level should be just above the
MINI mark. Top up if the level is low.9Warning
Allow the engine to cool before
opening the cap. Carefully open
the cap, relieving the pressure
slowly.
Top up with antifreeze. If no
antifreeze is available, use clean tap
water or distilled water. Install the cap
tightly. Have the antifreeze
concentration checked and have the
cause of the coolant loss remedied by a workshop.
If a substantial amount of coolant is
required, it will be necessary to bleed
any trapped air from the cooling
system. Seek the assistance of a
workshop.
Power steering fluidCaution
Extremely small amounts of
contamination can cause steering
system damage and cause it to not work properly. Do not allow
contaminates to contact the fluid
side of the reservoir cap or from
entering the reservoir.
The fluid level normally does not need
to be checked. If an unusual noise is
heard during steering or if the power
steering reacts conspicuously, seek
the assistance of a workshop.
Depending on vehicle, the power
steering fluid reservoir may be
located in the engine compartment
(Type A) or below the front wheel
arch, behind a trim panel (Type B).

200Vehicle careElectrical systemFuses
Data on the replacement fuse must
match the data on the defective fuse.
There are two fuse boxes in the
vehicle:
● on the left-hand side of the instrument panel, behind the trimpanel
● in the engine compartment located below the coolant
expansion tankCombi
An additional fuse box is located
behind a trim panel on the right-hand
side of the load compartment, beside
the rear door.Bus
An additional fuse box is located on
the lower right-hand side of the load
compartment, below the step trim
panel.
Before replacing a fuse, turn off the
respective switch and the ignition.A blown fuse can be recognised by its melted wire. Do not replace the fuse
until the cause of the fault has been
remedied.
It is advisable to carry a full set of
fuses. Consult a workshop.
Some functions are protected by
several fuses.
Fuses may also be inserted without existence of a function.
Note
Not all fuse box descriptions in this
manual may apply to your vehicle.
When inspecting the fuse box, refer
to the fuse box label.
Fuse extractor

Vehicle care201
To help in replacing fuses, a fuse
extractor is located in the instrument
panel fuse box.
Place the fuse extractor on the
various types of fuse from the top or
side, and withdraw fuse.
Engine compartment fusebox
Located below the coolant expansion tank.
Some circuits may be protected by
several fuses.
Due to restricted accessibility, have
fuses replaced by a workshop.SymbolCircuitSRight side lightsTLeft side lightsWRight low beamaLeft low beam>Front fog lightLLeft high beamNRight high beamuABSKWindscreen wiperSymbolCircuitnHeating and ventilation
system / Air conditioningVHeated windscreenQPneumatic suspension
Instrument panel fuse box
Located behind the trim panel on the
left-hand side of the instrument panel.
Pull upper part of trim panel to
remove.
Do not store any objects behind this
panel.

228Service and maintenanceRecommended fluids,lubricants and parts
Recommended fluids and lubricants
Only use products that meet the
recommended specifications.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for diesel engines. If it is unavailable,
engine oils of other listed qualities
must be used.
Select the appropriate engine oil based on its quality and on the
minimum ambient temperature
3 232.
Topping up engine oilCaution
In case of any spilled oil, wipe it up and dispose of it properly.
Engine oils of different manufacturersand brands can be mixed as long as
they comply with the required engine oil quality and viscosity.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 232.
Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature
viscosity.
Select the appropriate viscosity grade depending on the minimum ambient
temperature 3 232.
All of the recommended viscosity grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only silicate-free long life coolant
(LLC) antifreeze approved for the
vehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frost
protection down to approx. -28 °C.
This concentration should be
maintained all year round. The use of additional coolant additives that
intend to give additional corrosion

243Child locks ................................... 31
Child restraint installation locations ................................... 70
Child restraints.............................. 67
Child restraint systems ................67
Cigarette lighter ........................... 93
Cleaning the vehicle ...................222
Climate control ............................. 17
Climate control systems .............120
Clock ............................................ 91
Coat hooks ................................... 77
Control indicators.......................... 97
Control of the vehicle .................137
Controls ........................................ 88
Convex shape .............................. 40
Coolant ....................................... 185
Coolant and antifreeze ...............228
Coolant heater ............................ 127
Cornering light ....................115, 191
Cornering lights .......................... 115
Coupling ball bar ........................178
Cruise control ....................105, 163
Cupholders .................................. 77
D
Danger, Warnings and Cautions ...4
Dashboard .................................... 11
Daytime running lights ...............115
Declaration of conformity ............234
DEF ............................................ 147Demisting and defrosting..............17
Diesel exhaust fluid ....................147
Diesel fuel ................................... 174
Diesel fuel filter .......................... 189
Diesel fuel system bleeding .......189
Diesel particle filter ....................146
Door locks..................................... 25
Door open .................................. 106
Doors ............................................ 32
DPF (diesel particle filter) ...........146
Drain fuel filter ........................... 105
Drink holders ................................ 77
Driver assistance systems ..........163
Driver Information Centre ...........106
Driving characteristics and towing tips .............................. 177
Driving economically................... 137
Driving hints ................................ 137
E
ECO mode .................................. 137
ecoScoring.................................. 109
Electric adjustment ......................41
Electrical accessories ...................91
Electrical system......................... 200
Electronic climate control system 122
Electronic driving programmes ..156
Electronic key system ...................24
Electronic Stability Control 103, 161, 178Electronic Stability Control off..... 103
Emergency exit .......................44, 46
End-of-life vehicle recovery .......182
Engine compartment fuse box ...201
Engine coolant ........................... 185
Engine coolant temperature ......103
Engine coolant temperature gauge ....................................... 95
Engine drag torque control .........161
Engine exhaust .......................... 146
Engine identification ...................231
Engine oil ................... 183, 228, 232
Engine oil additives ....................228
Engine oil level monitor ................96
Engine oil pressure ....................104
Engine oil viscosity grades .........228
Enhanced Traction function....... ................................ 160, 161, 163
Event data recorders ..................238
Exhaust gases ............................ 146
Exit lighting ................................ 119
Exterior care .............................. 222
Exterior light ............................... 105
Exterior lighting ....................15, 112
Exterior mirrors ............................. 40
F
Fault ........................................... 157
Fire extinguisher ........................... 84
First aid ......................................... 84