key OPEL MOVANO_B 2019 Service Manual

190Vehicle careFill the tank with fuel and proceed asfollows:
1. Place a suitable container underneath the fuel filter vent
screw to collect fuel.
2. Loosen the vent screw (arrowed) by one turn.
3. Manually operate the in-line supply pump slowly and steadily
until fuel discharging from the
loosened vent screw is free of air
bubbles.
4. Retighten the vent screw.
In vehicles without an in-line supply
pump, fill the tank with fuel and
proceed as follows:Caution
Do not turn ignition key to position 3 before beginning the bleeding
procedure.
Ignition switch positions 3 138.
1. Turn ignition key to position 2 and
hold for 5 seconds.
2. Turn key back to position 1 and
wait for 3 seconds.
3. Repeat Step 1 and 2 multiple times.
4. Turn key to position 3, then return
to 0.
If the engine cannot be started after
several attempts to bleed the diesel
fuel system, seek the assistance of a
workshop.
Wiper blade replacement
Wiper blades on the windscreen If required, use the step located below
the headlights to reach the
windscreen wiper.Lift wiper arm, press retaining clip
towards wiper arm and detach wiper
blade.
Attach the wiper blade slightly angled
to the wiper arm and push until it
engages.
Lower wiper arm carefully.

Service and maintenance227International service intervalsAlbania, Bosnia-Herzegovina,
Kosovo, Macedonia, Montenegro,
Serbia, Romania, Bulgaria, Moldova,
Cyprus:
Maintenance of your vehicle is
required every 30,000 km or after
two years, whichever occurs first,
unless otherwise indicated by the
service display.
Turkey, Morocco:
Maintenance of your vehicle is
required every 20,000 km or after one year, whichever occurs first,
unless otherwise indicated by the
service display.
Russia, Ukraine, Belarus,
Kazakhstan, Malta:
Maintenance of your vehicle is
required every 15,000 km or after
one year, whichever occurs first,
unless otherwise indicated by the
service display.Algeria, Tunisia:
Maintenance of your vehicle is
required every 10,000 km or after
one year, whichever occurs first,
unless otherwise indicated by the service display.
Severe operating conditions exist if
one or more of the following
circumstances occur frequently: Cold
starting, stop and go operation, trailer operation, mountain driving, driving
on poor and sandy road surfaces,
increased air pollution, presence of
airborne sand and high dust content,
driving at high altitude and large
variations of temperature. Under
these severe operating conditions,
certain service work may be required more frequently than the regular
service interval.
Confirmations Confirmation of service is recorded inthe Service and warranty booklet.
The date and mileage is completed
with the stamp and signature of the
servicing workshop.Make sure that the Service and
warranty booklet is completed
correctly as continuous proof of
service is essential if any warranty or
goodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service display The service interval is based on
several parameters depending on
usage.
The service display, located in the
Driver Information Centre, indicates
when the next service is due. Seek
the assistance of a workshop.
Service display 3 96.
Engine oil lever monitor 3 96.

234Customer informationCustomer
informationCustomer information ................234
Declaration of conformity .........234
REACH .................................... 238
Registered trademarks ............238
Vehicle data recording and pri‐
vacy ........................................... 238
Event data recorders ...............238
Radio Frequency Identification (RFID) ..................................... 241Customer information
Declaration of conformity
Radio transmission systems
This vehicle has systems that
transmit and / or receive radio waves
subject to Directive 2014/53/EU. The
manufacturers of the systems listed
below declare conformity with
Directive 2014/53/EU. The full text of
the EU declaration of conformity for each system is available at the
following internet address:
www.opel.com/conformity.
Importer is
Opel / Vauxhall, Bahnhofsplatz,
65423 Ruesselsheim am Main,
Germany.
Radio remote control receiver Visteon Electronics
04 Rue Nelson Mandela, Zone
Industrielle Borj Cedria, 2055 Bir El
Bey, Tunisia
Operation frequency: 433 MHz
Maximum output: 10 mW ERPRadio remote control transmitter
Visteon Electronics
04 Rue Nelson Mandela, Zone
Industrielle Borj Cedria, 2055 Bir El
Bey, Tunisia
Operation frequency: 433 MHz
Maximum output: 10 mW ERP
Electronic key transmitter
ALPS ELECTRIC EUROPE GmbH
Ohmstrasse 4, 85716
Unterschleissheim, Germany
Operation frequency: 433 MHz
Maximum output: 10 mW ERP
Immobiliser
Visteon Electronics
04 Rue Nelson Mandela, Zone
Industrielle Borj Cedria, 2055 Bir El
Bey, Tunisia
Operation frequency: 125 kHz
Maximum output:
42 dBμA/m @ 10 m
Immobiliser
ALPS ELECTRIC EUROPE GmbH

238Customer informationREACHRegistration, Evaluation,
Authorisation and Restriction of
Chemicals (REACH) is a European
Union regulation adopted to improve
the protection of human health and
the environment from the risks that
can be posed by chemicals. Visit
www.opel.com/reach for further
information and for access to the
Article 33 communication.
Registered trademarksApple Inc.
Apple CarPlay™ is a trademark of
Apple Inc.
App Store ®
and iTunes Store ®
are
registered trademarks of Apple Inc.
iPhone ®
, iPod ®
, iPod touch ®
, iPod
nano ®
, iPad ®
and Siri ®
are registered
trademarks of Apple Inc.Bluetooth SIG, Inc.
Bluetooth ®
is a registered trademark
of Bluetooth SIG, Inc.DivX, LLC
DivX ®
and DivX Certified ®
are
registered trademarks of DivX, LLC.EnGIS Technologies, Inc.
BringGo ®
is a registered trademark of
EnGIS Technologies, Inc.Google Inc.
Android™ and Google Play™ Store
are trademarks of Google Inc.Stitcher Inc.
Stitcher™ is a trademark of Stitcher,
Inc.Verband der Automobilindustrie e.V.
AdBlue ®
is a registered trademark of
the VDA.Vehicle data recording
and privacy
Event data recorders
Electronic control units are installed in
your vehicle. Control units process
data which is received by vehicle
sensors, for example, or which they
generate themselves or exchange
amongst themselves. Some control
units are necessary for the safe
functioning of your vehicle, others
assist you while you drive (driver
assistance systems), while others
provide comfort or infotainment
functions.
The following contains general
information about data processing in
the vehicle. You will find additional
information as to which specific data
is uploaded, stored and passed on to third parties and for what purpose in
your vehicle under the key word Data Protection closely linked to the
references for the affected functional
characteristics in the relevant owner's
manual or in the general terms of
sale. These are also available online.

Customer information239Operating data in the vehicleControl units process data for
operation of the vehicle.
This data includes, e.g.: ● vehicle status information (e.g. speed, movement delay, lateral
acceleration, wheel rotation rate,
"seat belts fastened" display)
● ambient conditions (e.g. temperature, rain sensor,
distance sensor)
As a rule such data is transient, not
stored for longer than an operational
cycle, and only processed on board
the vehicle itself. Control units often
include data storage (including the
vehicle key). This is used to allow
information to be documented
temporarily or permanently on vehicle
condition, component stress,
maintenance requirements and
technical events and errors.Depending on technical equipment
level, the data stored is as follows:
● system component operating states (e.g. fill level, tyre
pressure, battery status)
● faults and defects in important system components (e.g. lights,brakes)
● system reactions in special driving situations (e.g. triggering
of an airbag, actuation of the
stability control systems)
● information on events damaging the vehicle
● for electric vehicles the amount of
charge in the high-voltage
battery, estimated range
In special cases (e.g. if the vehicle
has detected a malfunction), it may be
necessary to save data that would
otherwise just be volatile.
When you use services (e.g. repairs,
maintenance), the operating data
saved can be read together with the
vehicle identification number and
used when necessary. Staff working
for the service network ( e.g. garages,
manufacturers) or third parties (e.g.breakdown services) can read the
data from the vehicle. The same
applies to warranty work and quality
assurance measures.
Data is generally read via the OBD
(On-Board Diagnostics) port
prescribed by law in the vehicle. The operating data which is read out,
documents the technical condition of
the vehicle or individual components
and assists with fault diagnosis,
compliance with warranty obligations
and quality improvement. This data,
in particular information on
component stress, technical events,
operator errors and other faults, is
transmitted to the manufacturer
where appropriate, together with the
vehicle identification number. The
manufacturer is also subject to
product liability. The manufacturer
potentially also uses operating data
from vehicles for product recalls. This
data can also be used to check
customer warranty and guarantee
claims.
Fault memories in the vehicle can be
reset by a service company when
carrying out servicing or repairs or at
your request.

243Child locks ................................... 31
Child restraint installation locations ................................... 70
Child restraints.............................. 67
Child restraint systems ................67
Cigarette lighter ........................... 93
Cleaning the vehicle ...................222
Climate control ............................. 17
Climate control systems .............120
Clock ............................................ 91
Coat hooks ................................... 77
Control indicators.......................... 97
Control of the vehicle .................137
Controls ........................................ 88
Convex shape .............................. 40
Coolant ....................................... 185
Coolant and antifreeze ...............228
Coolant heater ............................ 127
Cornering light ....................115, 191
Cornering lights .......................... 115
Coupling ball bar ........................178
Cruise control ....................105, 163
Cupholders .................................. 77
D
Danger, Warnings and Cautions ...4
Dashboard .................................... 11
Daytime running lights ...............115
Declaration of conformity ............234
DEF ............................................ 147Demisting and defrosting..............17
Diesel exhaust fluid ....................147
Diesel fuel ................................... 174
Diesel fuel filter .......................... 189
Diesel fuel system bleeding .......189
Diesel particle filter ....................146
Door locks..................................... 25
Door open .................................. 106
Doors ............................................ 32
DPF (diesel particle filter) ...........146
Drain fuel filter ........................... 105
Drink holders ................................ 77
Driver assistance systems ..........163
Driver Information Centre ...........106
Driving characteristics and towing tips .............................. 177
Driving economically................... 137
Driving hints ................................ 137
E
ECO mode .................................. 137
ecoScoring.................................. 109
Electric adjustment ......................41
Electrical accessories ...................91
Electrical system......................... 200
Electronic climate control system 122
Electronic driving programmes ..156
Electronic key system ...................24
Electronic Stability Control 103, 161, 178Electronic Stability Control off..... 103
Emergency exit .......................44, 46
End-of-life vehicle recovery .......182
Engine compartment fuse box ...201
Engine coolant ........................... 185
Engine coolant temperature ......103
Engine coolant temperature gauge ....................................... 95
Engine drag torque control .........161
Engine exhaust .......................... 146
Engine identification ...................231
Engine oil ................... 183, 228, 232
Engine oil additives ....................228
Engine oil level monitor ................96
Engine oil pressure ....................104
Engine oil viscosity grades .........228
Enhanced Traction function....... ................................ 160, 161, 163
Event data recorders ..................238
Exhaust gases ............................ 146
Exit lighting ................................ 119
Exterior care .............................. 222
Exterior light ............................... 105
Exterior lighting ....................15, 112
Exterior mirrors ............................. 40
F
Fault ........................................... 157
Fire extinguisher ........................... 84
First aid ......................................... 84

244First aid kit ................................... 84
Fixed air vents ........................... 134
Fog lights .................................... 116
Folding mirrors ............................. 41
Folding seat .................................. 77
Front airbag system .....................64
Front courtesy light .....................117
Front fog lights ...105, 112, 116, 194
Front reading light....................... 118
Front seats.................................... 48
Front storage ................................ 77
Front turn lights .......................... 194
Fuel economy rating (ecoScoring) ............................ 109
Fuel for diesel engines ..............174
Fuel gauge ................................... 95
Fuel tank ..................................... 232
Fuse box ............................. 201, 202
Fuses ......................................... 200
G
Gauges ......................................... 93
Gear shifting ............................... 102
General information ...................177
Glass panel .................................. 46
Glovebox ..................................... 77
Glovebox cooler ......................... 134
Grab handles ................................ 79
Ground clearance .......................144H
Hand brake - see Parking brake. 159
Hazard warning flashers ............115
Headlight flash ........................... 114
Headlight range adjustment ......114
Headlights .................. 112, 113, 191
Headlights when driving abroad 115
Head restraint adjustment .............8
Head restraints ............................ 47
Heated exterior mirrors .................17
Heated mirrors ............................. 41
Heated rear window ...............17, 45
Heating ........................................ 54
Heating and ventilation system . 120
High beam ......................... 105, 113
High beam assist ................105, 113
Hill start assist ........................... 160
Horn ....................................... 16, 88
Hub cap hook ............................. 204
I
Identification plate .....................231
Idle speed control .......................140
Ignition switch positions .............138
Immobiliser .................................. 40
Indicators ...................................... 93
Info Display ................................. 107
Information displays.................... 106
Infotainment system ...................107
Initial drive information.................... 6Instrument cluster ........................93
Instrument panel fuse box .........201
Instrument panel illumination .....199
Instrument panel overview ........... 11
Instrument panel storage ..............76
Interior care ............................... 224
Interior lighting ............................ 117
Interior lights ...................... 117, 198
Interior mirrors .............................. 42
Interruption of power supply ......158
Introduction .................................... 3
ISOFIX .......................................... 67
J Jack ............................................ 204
Journey record............................ 109
Jump starting ............................. 218
K Keys ............................................. 22
Keys, locks ................................... 22
L
Lane departure warning .....103, 173
Lashing eyes ............................... 79
Lashing straps .............................. 79
Laying up the vehicle ..................187
Light covers, misted.................... 116
Lighting ....................................... 112
Lighting features .........................119
Light switch ................................ 112