engine oil OPEL VIVARO 2015 User Guide
[x] Cancel search | Manufacturer: OPEL, Model Year: 2015, Model line: VIVARO, Model: OPEL VIVARO 2015Pages: 205, PDF Size: 4.47 MB
Page 143 of 205

Vehicle care141
When the engine oil level has
dropped to the MIN mark, top-up
engine oil.Caution
Do not allow the engine oil level to drop below the minimum level!
We recommend the use of the same
grade of engine oil that was used at
the last change.
The engine oil level must not exceed the maximum mark MAX on the
dipstick.
Caution
Overfilled engine oil must be
drained or suctioned out.
To prevent spillage when
replenishing the engine oil, we
recommend using a funnel. Ensure funnel is securely located onto the
filler pipe.
A stabilization of the engine oil
consumption will not take place until
the vehicle has been driven several
thousand kilometres. Only then can
the actual degree of consumption be
established.
If consumption exceeds more than
0.5 litres every 1000 km after this
running-in period, consult a
workshop.
Capacities 3 191.
Fit the cap on straight and tighten it.
Engine air filter
Engine air flow indicator
On certain models, an indicator is
located in the engine induction
system and indicates if the air-intake
to the engine is restricted.
Clear=No restrictionRed tell-tale=Restricted
If the red tell-tale is displayed when
the engine is running, consult a
workshop.
Page 148 of 205

146Vehicle careDiesel fuel filter
Drain diesel fuel filter of residual
water at every engine oil change.
Place a container underneath the
filter housing. Loosen the knurled
screw on the lower part of the filter by approx. one turn, to drain off the
water.
The filter is drained as soon as water-
free diesel fuel emerges. Retighten
the screw.
Check diesel fuel filter at shorter
intervals if the vehicle is subjected to
extreme operating conditions.
Diesel fuel system
bleeding
If the fuel tank has been run dry, it will
be necessary to air vent or bleed the
diesel fuel system.
Refuel then proceed as follows:
With ignition key ■ Switch on the ignition (key to position M) for 5 seconds at a time.
■ Switch off ignition (key to position A) for 3 seconds.
■ Repeat this process multiple times.
■ Start the engine (key to position D)
then switch off (key to position St).
Ignition switch positions 3 114.
With power button ■ Insert the electronic key in the card
reader.
■ Press the Start/Stop button without
pressing any of the pedals.
■ Wait a few minutes before starting engine.
Power button 3 114.If the engine fails to start, seek the
assistance of a workshop.
Starting the engine 3 116.
Wiper blade replacement Wiper blades on the windscreen
Lift the wiper arm, press button to
disengage the wiper blade and
remove.
Attach new wiper blade slightly
angled to the wiper arm and push until
it engages.
Lower wiper arm carefully.
Page 178 of 205

176Service and maintenance
service is essential if any warranty or
goodwill claims are to be met, and is
also a benefit when selling the
vehicle.
Service display
The service interval is based on
several parameters depending on
usage.
The service display, located in the
Driver Information Centre, indicates
when the next service is due. Seek
the assistance of a workshop.
Service display 3 82.Recommended fluids,
lubricants and parts
Recommended fluids and
lubricants Only use products that meet the
recommended specifications.
Damage resulting from the use of
products not in line with these
specifications will not be covered by
the warranty.9 Warning
Operating materials are
hazardous and could be
poisonous. Handle with care. Pay
attention to information given on
the containers.
Engine oil
Engine oil is identified by its quality
and its viscosity. Quality is more
important than viscosity when
selecting which engine oil to use. The oil quality ensures e.g. engine
cleanliness, wear protection and oil
aging control, whereas viscosity
grade gives information on the oil's
thickness over a temperature range.
Dexos is the newest engine oil quality
that provides optimum protection for petrol and diesel engines. If it is
unavailable, engine oils of other listed qualities must be used.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 181.
Topping up engine oil
Engine oils of different manufacturers
and brands can be mixed as long as
they comply with the required engine
oil quality and viscosity.
Use of engine oil with only
ACEA A1/B1 or only A5/B5 quality is
prohibited, since it can cause long-
term engine damage under certain
operating conditions.
Select the appropriate engine oil
based on its quality and on the
minimum ambient temperature
3 181.
Page 179 of 205

Service and maintenance177
Additional engine oil additives
The use of additional engine oil
additives could cause damage and
invalidate the warranty.
Engine oil viscosity grades
The SAE viscosity grade gives
information of the thickness of the oil.
Multigrade oil is indicated by two
figures, e.g. SAE 5W-30. The first
figure, followed by a W, indicates the
low temperature viscosity and the
second figure the high temperature viscosity.
Select the appropriate viscosity grade depending on the minimum ambient
temperature 3 181.
All of the recommended viscosity
grades are suitable for high ambient
temperatures.
Coolant and antifreeze
Use only silicate-free long life coolant (LLC) antifreeze approved for thevehicle. Consult a workshop.
The system is factory filled with
coolant designed for excellent
corrosion protection and frostprotection down to approx. -28 °C.
This concentration should be
maintained all year round. The use of
additional coolant additives that
intend to give additional corrosion
protection or seal against minor leaks can cause function problems. Liability
for consequences resulting from the
use of additional coolant additives will be rejected.
Brake fluid Over time, brake fluid absorbs
moisture which will reduce braking
effectiveness. The brake fluid should
therefore be replaced at the specified interval.
Page 183 of 205

Technical data181Vehicle dataRecommended fluids and lubricantsRequired engine oil qualityEngine oil qualitydexos 2✔
In case dexos quality is unavailable in International countries, you may use the oil qualities listed below:
Engine oil qualityACEA A3/B4/C3✔
Engine oil viscosity grades
Oil viscositySAE 0W-30, SAE 0W-40, SAE 5W-30, SAE 5W-40
Page 193 of 205
![OPEL VIVARO 2015 User Guide Technical data191CapacitiesEngine oilEngineR9MEngine oil including filter [l]6.3 - 6.5between MIN and MAX [l] (approx.)2.0 - 2.4
Fuel tank
Fuel tank, nominal capacity [l]80 OPEL VIVARO 2015 User Guide Technical data191CapacitiesEngine oilEngineR9MEngine oil including filter [l]6.3 - 6.5between MIN and MAX [l] (approx.)2.0 - 2.4
Fuel tank
Fuel tank, nominal capacity [l]80](/img/37/58240/w960_58240-192.png)
Technical data191CapacitiesEngine oilEngineR9MEngine oil including filter [l]6.3 - 6.5between MIN and MAX [l] (approx.)2.0 - 2.4
Fuel tank
Fuel tank, nominal capacity [l]80
Page 199 of 205

197
Child restraint installationlocations ................................... 61
Child restraints.............................. 60
Child restraint systems ................60
Cigarette lighter ........................... 79
Cleaning the vehicle ...................171
Climate control ............................. 17
Climate control systems .............101
Clock ............................................ 78 Coat hooks ................................... 68
Control indicators.......................... 83
Control of the vehicle .................113
Controls ........................................ 75
Controls in steering wheel ............75
Convex shape .............................. 38
Coolant ....................................... 142
Coolant and antifreeze ...............176
Coolant heater ............................ 106
Cooling (AC) ............................... 102
Cornering light .............................. 97
Cruise control ...................... 89, 126
Cupholders .................................. 68
Curtain airbag system .................. 58
D Danger, Warnings and Cautions ...3
Dashboard .................................... 10
Daytime running lights ............95, 97
Declaration of conformity ............193
Demisting and defrosting ..............17Diesel fuel filter .......................... 146
Diesel fuel system bleeding .......146
Diesel particle filter ....................120
Door locks..................................... 25
Door open .................................... 90
Doors ............................................ 31
Double cab ................................... 69
DPF (diesel particle filter) ...........120
Driver assistance systems ..........126
Driver Information Centre .............90
Driving characteristics and towing tips .............................. 136
Driving economically................... 112
Driving hints ................................ 112
E ECO mode .................................. 112
ecoScoring.................................... 92
Electric adjustment ......................38
Electrical system......................... 152
Electronic climate control system 103
Electronic key system ...................23
Electronic Stability Program .....
.................................. 87, 125, 137
Electronic Stability Program off ...88
End-of-life vehicle recovery .......139
Engine air filter............................ 141
Engine air flow indicator .............141
Engine coolant ........................... 142
Engine coolant temperature ........88Engine data ............................... 182
Engine exhaust .......................... 120
Engine identification ...................179
Engine oil ................... 140, 176, 181
Engine oil additives ....................176
Engine oil level ............................ 92
Engine oil pressure ......................88
Engine oil viscosity grades .........176
Enhanced Traction function 124, 125
Entry lighting .............................. 100
Event data recorders ..................193
Exhaust gases ....................120, 169
Exit lighting ................................ 100
Exterior care .............................. 171
Exterior light ................................. 89
Exterior lighting ......................14, 95
Exterior mirrors ............................. 38
F
Fault messages ............................ 91
First aid kit ................................... 72
Fixed air vents ........................... 110
Fog light ....................................... 89
Fog lights .............................. 98, 148
Fog tail light ............................... 151
Folding centre seatback ...............68
Folding front centre passenger seat ........................................... 46
Folding mirrors ............................. 38
Front airbag system .....................57
Page 201 of 205

199
Manual transmission .................. 121
Messages ..................................... 91
Mirror adjustment ........................... 8
Mirrors .................................... 38, 39
Misted light covers .......................98
N
New vehicle running-in ..............113
Number plate light .....................150
O Object detection systems ...........130
Octane rating .............................. 182
Odometer ..................................... 81
Oil ............................................... 140
Oil, engine .......................... 176, 181
Oil pressure .................................. 88
Outside temperature ....................78
Overcab storage ..........................70
Overrun cut-off ........................... 117
P Parking ................................ 20, 119
Parking assist ............................ 130
Parking brake ............................ 123
Particulate filter ........................... 120
Performing work ........................139
Pollen filter ................................. 111
Power button ........................ 18, 114
Power outlets ............................... 79Power steering fluid....................142
Power windows ............................ 40
Preheating ........................... 88, 116
Puncture ..................................... 165
R Radio Frequency Identification (RFID) ..................................... 194
Radio remote control ...................21
Rear air conditioning system .....105
Rear doors ................................... 31
Rear fog light ............................... 89
Rear fog lights ........................ 95, 98
Rear heating system .................. 105
Rear seats .................................... 47
Rear view camera ...................... 132
Rear windows .............................. 41
Rear window wiper/washer .......... 77 Recommended fluids and lubricants ........................ 176, 181
Refuelling ................................... 134
Remote control ............................. 21
Reversing light ........................... 150
Reversing lights ........................... 98
Ride control systems ..................124
Roof load ...................................... 73
Roof rack ..................................... 73S
Safety belts ................................... 50
Safety net .................................... 71
Seat adjustment ....................... 7, 45
Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 50
Seat folding .................................. 46
Seat heating ................................. 47
Seat position ................................ 44
Seats ............................................ 69
Service ............................... 111, 174
Service display ............................ 82
Service information ....................174
Service vehicle soon .................... 86
Side airbag system ......................57
Sidelights ...................................... 95
Side turn signal lights ................149
Sliding door .................................. 31
Spare wheel ............................... 166
Spare wheel security tool ...........156
Speed limiter......................... 80, 130
Speedometer ............................... 80
Starting and operating ................113
Starting off ................................... 18
Starting the engine ...............18, 116
Steering ...................................... 113
Steering column controls ..............76
Steering wheel adjustment ......9, 75