steering OPEL VIVARO 2015 Owner's Manual

Driving and operating137
In the case of trailer loads of
1200 kg or more, the vertical coupling load should not be less than 50 kg.
Rear axle load
When the trailer is coupled and the
towing vehicle fully loaded (including all occupants), the permissible rear
axle load (see identification plate or
vehicle documents) must not be
exceeded.
Trailer stability assist If the system detects snaking
movements, engine power is reduced
and the vehicle/trailer combination is selectively braked until the snaking
ceases. While the system is working, keep steering wheel as still as
possible.
Trailer stability assist (TSA) is a
function of the Electronic Stability
Program 3 125.

142Vehicle careEngine coolantThe coolant provides freeze
protection down to approx. -28 °C.Caution
Only use approved antifreeze.
Coolant level
Caution
Too low a coolant level can cause engine damage.
If the cooling system is cold, the
coolant level should be just above the
MINI mark. Top up if the level is low.9Warning
Allow the engine to cool before
opening the cap. Carefully open
the cap, relieving the pressure
slowly.
Top up with antifreeze. If no
antifreeze is available, use clean tap
water or distilled water. Install the cap
tightly. Have the antifreeze
concentration checked and have the
cause of the coolant loss remedied by a workshop.
If a substantial amount of coolant is
required, it will be necessary to bleed
any trapped air from the cooling
system. Seek the assistance of a
workshop.
If the coolant temperature is too high, control indicator W 3 88 illuminates
red in the instrument cluster, together
with C 3 86. Consult a workshop if
coolant level is sufficient.
Power steering fluidCaution
Extremely small amounts of
contamination can cause steering
system damage and cause it to not work properly. Do not allow
contaminates to contact the fluid
side of the reservoir cap or from
entering the reservoir.
The power steering fluid reservoir is located below the front wheel arch,
behind a trim panel.
The fluid level normally does not need
to be checked. If an unusual noise is
heard during steering or if the power
steering reacts conspicuously, seek
the assistance of a workshop.

Vehicle care155
No.Circuit1Vehicle battery (with electronic
key system)2APC battery backup (with elec‐
tronic key system)3Heating and ventilation system4Adaptations5Adaptations6Heating and ventilation system7Additional heating and ventila‐
tion, air conditioning system8Supplementary heating and
ventilation system9Electric exterior mirrors, addi‐
tional adaptations10Heated exterior mirrors11Radio, multimedia, electric exte‐ rior mirrors, diagnostic socket12Multimedia, trailer hitchNo.Circuit13Courtesy lights, battery
discharge protection14Fuel injection system, tyre pres‐ sure monitoring system, elec‐
tronic key system15Hazard warning flashers, turn and lane-change signals16Central locking17Left-hand high beam, right-hand
low beam, tail lights, left-hand
daytime running light18Front fog lights, rear fog lights,
number plate lighting19Alarm, horn, lighting, wiper20Instrument cluster21Light switch22Rear window wiper, windscreen
washer pump, horn23APC general battery24Reversing lightsNo.Circuit25Brake switch26Fuel injection, starter27Airbag, steering column lock28Passenger power window29Power steering30Brake lights31APC battery backup (with elec‐
tronic key system)32Service display33Cigarette lighter, power outlet34Right-hand high beam, left-
hand low beam, sidelights,
right-hand daytime running light35Brake lights, ABS, immobiliser36Interior lighting, air conditioning37Starting with electronic key
system38Rear window wiper

162Vehicle care
Tyre chains are only permitted on thefront wheels.
Always use fine mesh chains that add
no more than 15 mm to the tyre tread
and the inboard sides (including chain
lock).
For tyre size 215/60 R17, consult a
workshop.9 Warning
Damage may lead to tyre blowout.
Wheel covers on steel wheels may
come into contact with parts of the
chains. In such cases, remove the
wheel covers.
Tyre chains may only be used at
speeds up to 50 km/h and, when
travelling on roads that are free of
snow, they may only be used for brief
periods since they are subject to rapid wear on a hard road and may snap.
The use of tyre chains is not permitted on the temporary spare wheel.
Tyre repair kit
Minor damage to the tyre tread or
sidewall can be repaired with the tyre
repair kit.
Do not remove foreign bodies from
the tyres.
Tyre damage exceeding 4 mm or that
is at tyre sidewall near the rim cannot
be repaired with the tyre repair kit.9 Warning
Do not drive faster than 80 km/h.
Do not use for a lengthy period.
Steering and handling may be
affected.
If the vehicle has a flat tyre:
Apply the parking brake and engage
first gear or reverse gear.
The tyre repair kit is located under the
driver's seat. Vehicle tools 3 156.
1. Remove the compressor and sealant bottle from the tyre repairkit case.
2. Remove the electrical connection cable and air hose from the
compartments on the underside
of the compressor.
3. Screw the air hose to the connection on the sealant bottle.
4. Fit the sealant bottle into the retainer on the compressor.
Set the compressor near the tyre
in such a way that the sealant
bottle is upright.
5. Unscrew valve cap from defective
tyre.

170Vehicle careCaution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Caution
Activate the child locks in the rear
doors if the rear seats are
occupied. Child locks 3 30.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the air recirculation system 3 102 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and replace cap.
Towing another vehicle
The fixed towing eye is located under the rear bumper.
Attach a tow rope - or better still a tow
rod - to the rear towing eye, never to
the rear axle and suspension units.
The rear towing eye must only be
used for towing and not recovering a
vehicle.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
Trailer hitch 3 136.

197
Child restraint installationlocations ................................... 61
Child restraints.............................. 60
Child restraint systems ................60
Cigarette lighter ........................... 79
Cleaning the vehicle ...................171
Climate control ............................. 17
Climate control systems .............101
Clock ............................................ 78 Coat hooks ................................... 68
Control indicators.......................... 83
Control of the vehicle .................113
Controls ........................................ 75
Controls in steering wheel ............75
Convex shape .............................. 38
Coolant ....................................... 142
Coolant and antifreeze ...............176
Coolant heater ............................ 106
Cooling (AC) ............................... 102
Cornering light .............................. 97
Cruise control ...................... 89, 126
Cupholders .................................. 68
Curtain airbag system .................. 58
D Danger, Warnings and Cautions ...3
Dashboard .................................... 10
Daytime running lights ............95, 97
Declaration of conformity ............193
Demisting and defrosting ..............17Diesel fuel filter .......................... 146
Diesel fuel system bleeding .......146
Diesel particle filter ....................120
Door locks..................................... 25
Door open .................................... 90
Doors ............................................ 31
Double cab ................................... 69
DPF (diesel particle filter) ...........120
Driver assistance systems ..........126
Driver Information Centre .............90
Driving characteristics and towing tips .............................. 136
Driving economically................... 112
Driving hints ................................ 112
E ECO mode .................................. 112
ecoScoring.................................... 92
Electric adjustment ......................38
Electrical system......................... 152
Electronic climate control system 103
Electronic key system ...................23
Electronic Stability Program .....
.................................. 87, 125, 137
Electronic Stability Program off ...88
End-of-life vehicle recovery .......139
Engine air filter............................ 141
Engine air flow indicator .............141
Engine coolant ........................... 142
Engine coolant temperature ........88Engine data ............................... 182
Engine exhaust .......................... 120
Engine identification ...................179
Engine oil ................... 140, 176, 181
Engine oil additives ....................176
Engine oil level ............................ 92
Engine oil pressure ......................88
Engine oil viscosity grades .........176
Enhanced Traction function 124, 125
Entry lighting .............................. 100
Event data recorders ..................193
Exhaust gases ....................120, 169
Exit lighting ................................ 100
Exterior care .............................. 171
Exterior light ................................. 89
Exterior lighting ......................14, 95
Exterior mirrors ............................. 38
F
Fault messages ............................ 91
First aid kit ................................... 72
Fixed air vents ........................... 110
Fog light ....................................... 89
Fog lights .............................. 98, 148
Fog tail light ............................... 151
Folding centre seatback ...............68
Folding front centre passenger seat ........................................... 46
Folding mirrors ............................. 38
Front airbag system .....................57

199
Manual transmission .................. 121
Messages ..................................... 91
Mirror adjustment ........................... 8
Mirrors .................................... 38, 39
Misted light covers .......................98
N
New vehicle running-in ..............113
Number plate light .....................150
O Object detection systems ...........130
Octane rating .............................. 182
Odometer ..................................... 81
Oil ............................................... 140
Oil, engine .......................... 176, 181
Oil pressure .................................. 88
Outside temperature ....................78
Overcab storage ..........................70
Overrun cut-off ........................... 117
P Parking ................................ 20, 119
Parking assist ............................ 130
Parking brake ............................ 123
Particulate filter ........................... 120
Performing work ........................139
Pollen filter ................................. 111
Power button ........................ 18, 114
Power outlets ............................... 79Power steering fluid....................142
Power windows ............................ 40
Preheating ........................... 88, 116
Puncture ..................................... 165
R Radio Frequency Identification (RFID) ..................................... 194
Radio remote control ...................21
Rear air conditioning system .....105
Rear doors ................................... 31
Rear fog light ............................... 89
Rear fog lights ........................ 95, 98
Rear heating system .................. 105
Rear seats .................................... 47
Rear view camera ...................... 132
Rear windows .............................. 41
Rear window wiper/washer .......... 77 Recommended fluids and lubricants ........................ 176, 181
Refuelling ................................... 134
Remote control ............................. 21
Reversing light ........................... 150
Reversing lights ........................... 98
Ride control systems ..................124
Roof load ...................................... 73
Roof rack ..................................... 73S
Safety belts ................................... 50
Safety net .................................... 71
Seat adjustment ....................... 7, 45
Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 50
Seat folding .................................. 46
Seat heating ................................. 47
Seat position ................................ 44
Seats ............................................ 69
Service ............................... 111, 174
Service display ............................ 82
Service information ....................174
Service vehicle soon .................... 86
Side airbag system ......................57
Sidelights ...................................... 95
Side turn signal lights ................149
Sliding door .................................. 31
Spare wheel ............................... 166
Spare wheel security tool ...........156
Speed limiter......................... 80, 130
Speedometer ............................... 80
Starting and operating ................113
Starting off ................................... 18
Starting the engine ...............18, 116
Steering ...................................... 113
Steering column controls ..............76
Steering wheel adjustment ......9, 75

200
Steering wheel controls ...............75
Stop engine .................................. 86
Stop-start system.................. 18, 117
Storage ......................................... 67
Storage box .................................. 69
Storage compartments .................67
Sun visors .................................... 42
Symbols ......................................... 4
T Tachograph .................................. 94
Tachometer ................................. 81
Tailgate ......................................... 33
Tail lights ................................... 149
Technical data ............................ 182
Three-point seat belt .................... 51
Tools .......................................... 156
Top-tether fastening eyes ............66
Torx key ...................................... 156
Tow bar....................................... 136
Towing ................................ 136, 169
Towing another vehicle .............170
Towing a trailer ........................... 136
Towing eye ......................... 156, 169
Towing the vehicle .....................169
Traction Control system ............. 124
Trailer coupling ........................... 136
Trailer stability assist .................137
Trailer towing ............................. 136
Transmission ............................... 18Tread depth ............................... 160
Trip computer .............................. 92
Trip odometer .............................. 81
Turbo engine warm-up ...............116
Turn and lane-change signals .....97
Turn signal ................................... 85
Tyre chains ................................ 161
Tyre changing ............................. 165
Tyre designations ......................157
Tyre pressure ............................ 157
Tyre pressure monitoring system ............................... 88, 158
Tyre pressures ........................... 192
Tyre repair kit ............................. 162
Tyres .......................................... 157
Tyres and wheel size, changing. 161
U Ultrasonic parking assist............. 130
Underseat storage .......................69
Upholstery .................................. 172
Upshift .......................................... 87
Using this manual ..........................3
V Vehicle battery ........................... 144
Vehicle checks............................ 139
Vehicle data ................................ 181
Vehicle data recording and privacy ..................................... 193Vehicle dimensions .................... 186
Vehicle Identification Number ....178
Vehicle jack ................................ 156
Vehicle messages .......................91
Vehicle security ............................ 34
Vehicle shutdown ......................117
Vehicle specific data ......................3
Vehicle storage ........................... 138
Vehicle tools ....................... 156, 169
Vehicle unlocking ........................... 6
Vehicle weight ........................... 183
Ventilation ................................... 101
W
Warning chimes ........................... 91
Warning lights ............................... 80
Warning messages .......................91
Warning triangle .......................... 72
Washer and wiper systems .........16
Washer fluid ............................... 143
Washing the vehicle ...................171
Welcome lighting ........................100
Wheel changing .........................165
Wheel cover hook .......................156
Wheel covers ............................. 161
Wheels and tyres .......................157
Wheel wrench ............................. 156
Wide view mirror ........................... 39
Windows ....................................... 40
Windscreen................................... 40