transmission OPEL VIVARO B 2019 Owner's Manual

18In briefElectronic climate control system
● Press Ê. LED illuminates in the
button when activated.
● Temperature, air distribution and cooling are regulated
automatically and the fan runs at
high speed.
● Switch on heated rear window Ü
3 45.
Electronic climate control system
3 120.
Transmission
Manual transmission
Reverse: with the vehicle stationary,
wait three seconds after depressing
clutch pedal and then pull up the
collar on the selector lever and
engage the gear.
If the gear does not engage, set the
lever to neutral, release the clutch
pedal and depress again; then repeat
gear selection.
Manual transmission 3 147.
Starting off
Check before starting off ● Tyre pressure 3 188 and
condition 3 216.
● Engine oil level and fluid levels 3 169.
● All windows, mirrors, exterior lighting and number plates are
free from dirt, snow and ice and
are operational.
● Proper position of mirrors 3 41,
seats 3 47 and seat belts
3 56.
● Brake function at low speed, particularly if the brakes are wet.

126Climate control2 l:Adjusts values up3
OFF:Switch heater off, or press
Y and OFF simultaneously
to confirm selection4 Y:Switch heater on, or press Y
and OFF simultaneously to
confirm selection5 k:Adjusts values down
If no buttons are pressed within
30 seconds the display automatically
turns off.
9 Warning
When refuelling, switch off the
remote control unit as well as the
heater!
The remote control has a maximum
range of 1000 m. The range may be
reduced due to environmental
conditions and as the battery
becomes weaker.
Remote control (Type B) fault
displaysZ:poor signal – adjust positionFAIL:error during signal
transmission –
move closer or check heater
fuseÜ:battery low – replace battery
Teach remote control (Type B)
Up to four additional remote control
units may also be configured. During
additional teaching processes, the
oldest transmitter will be deleted each
time.
Remove the heater fuse for
5 seconds, then refit the fuse. Within
2–6 seconds press OFF for
1 second. Teaching is completed.
If the remote has not been used for a long period, press the OFF button six
times at intervals of 2 seconds, then
press and hold for another
2 seconds, then wait 2 minutes.
Manual control
Depending on version, the auxiliary
heater can also be switched on for the
last duration time or the default
duration 30 minutes, or cut-off
immediately, using the button on the
lower part of the instrument panel,
beside the steering wheel.
The LED in the button confirms
operation.
Battery replacement
Replace the battery when the range
of the remote control is reduced or when the battery charge symbol
flashes.

Driving and operating131Driving and
operatingDriving hints ............................... 131
Driving economically ...............131
Control of the vehicle ...............132
Steering ................................... 132
Starting and operating ...............133
New vehicle running-in ............133
Ignition switch positions ...........133
Power button ........................... 133
Starting the engine ..................135
Idle speed control ....................136
Vehicle shutdown ....................136
Overrun cut-off ........................ 137
Stop-start system ....................137
Parking .................................... 140
Engine exhaust .......................... 141
Diesel particle filter ..................141
Catalytic converter ...................141
AdBlue ..................................... 142
Manual transmission ..................147
Brakes ........................................ 148
Antilock brake system .............148
Parking brake .......................... 149Brake assist............................. 149
Hill start assist ......................... 149
Ride control systems .................150
Traction Control system ..........150
Electronic Stability Control ......151
Driver assistance systems .........153
Cruise control .......................... 153
Speed limiter ........................... 155
Parking assist .......................... 156
Rear view camera ...................159
Fuel ............................................ 161
Fuel for diesel engines ............161
Refuelling ................................ 162
Trailer hitch ................................ 164
General information .................164
Driving characteristics and towing tips .............................. 164
Trailer towing ........................... 164
Trailer stability assist ...............165Driving hints
Driving economically ECO mode
ECO mode is a function that
optimises fuel consumption. It affects engine power and torque,
acceleration, gear shift indication,
heating, air conditioning and electrical consumers.
Activation
Press ECO. Control indicator ECO
illuminates in the instrument cluster when activated.

Driving and operating135These functions stop working when
the driver's door is opened and the vehicle is locked.
Note
Always take the electronic key with
you when exiting the vehicle.
The electronic key being left in the
card reader is indicated by a warning
chime 3 105 and a message in the
Driver Information Centre 3 104
when the driver's door is opened.9 Danger
Never leave an electronic key
inside the vehicle when children or animals are left in the vehicle, to
avoid unintended operation of
windows, doors or engine. Risk of
fatal injury.
Fault
If the engine cannot be started, the
cause may be one of the following:
● Fault in electronic key.
● Electronic key out of reception range.
● Battery voltage too low.
● Overload of the central locking system by operating at frequentintervals, the power supply is
interrupted for a short time.
● Interference from higher-power radio waves from other sources.
Battery replacement 3 22.
Central locking system 3 26.
Electronic key system 3 23.
Starting the engine
Manual transmission: operate clutch.
Do not accelerate.
Diesel engines: turn the key to
position 2 for preheating until control
indicator ! extinguishes in the
instrument cluster 3 101.
Turn key to position 3 and release.
The increased engine speed
automatically returns to normal idling
speed as the engine temperature
rises.
Start attempts should not last longer
than 15 seconds. If engine does not
start, wait 15 seconds before
repeating starting procedure. If
necessary, depress accelerator
before repeating starting procedure.
Before restarting or to switch off the
engine, turn key back to 0.
During an Autostop, the engine can
be started by depressing the clutch
pedal.
Stop-start system 3 137.

Driving and operating1475.Mount one end of the hose on the
canister and screw the other end
on the filler neck.
6. Lift the canister until it is empty, or
until the flow from the canister has stopped. This can take up to
5 minutes.
7. Place the canister on the ground to empty the hose, wait
15 seconds.
8. Unscrew the hose from the filler neck.
9. Mount the protective cap and turn
clockwise until it engages.
10. Close fuel filler flap and left-hand door.
Note
Dispose of AdBlue canister
according to environmental
requirements. Hose can be reused
after flushing with clear water before AdBlue dries out.
Note
Allow the vehicle to idle for at least
ten seconds to allow the system to
detect the AdBlue refill.Failure to observe this procedure will
result in the system only recognising the AdBlue refill after approx.
20 minutes of driving.
If the AdBlue refill is detected
successfully, AdBlue level warnings
will disappear.
If the AdBlue refill is not detected
some time after running the engine,
seek the assistance of a workshop.
Filler cap
Only use genuine filler caps. AdBlue
tank has a special filler cap.
Fault
If the system detects an operating fault, control indicator Y illuminates
together with j and a warning
chime. Seek the assistance of a
workshop immediately.
A corresponding message appears in
the Driver Information Centre 3 103.Manual transmission
To engage reverse, with the vehicle
stationary depress the clutch pedal, pull up the collar on the selector lever
and engage the gear against the
resistance.
If the gear does not engage, set the
lever in neutral, release the clutch
pedal and depress again. Then
repeat gear selection.
Do not slip the clutch unnecessarily.
When operating, depress the clutch
pedal completely. Do not use the
pedal as a foot rest.

Vehicle care199Jump starting
Do not start with a quick charger.
A vehicle with a discharged battery
can be started using jump leads and
the vehicle battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
● Never expose the battery to naked flames or sparks.
● A discharged vehicle battery canalready freeze at a temperature
of 0 °C. Defrost the frozen battery
before connecting jump leads.
● Wear eye protection and protective clothing when
handling a battery.
● Use a booster battery with the same voltage (12 V). Its capacity
(Ah) must not be much less than
that of the discharged battery.
● Use jump leads with insulated terminals and a cross section of
at least 16 mm 2
(25 mm 2
for
diesel engines).
● Do not disconnect the discharged
vehicle battery from the vehicle.
● Switch off all unnecessary electrical consumers.
● Do not lean over the battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.
● The vehicles must not come into contact with each other during
the jump starting process.● Apply the parking brake, transmission in neutral.
● Open the positive terminal protection caps of both batteries.
The battery is located in the engine compartment.
Remove cover to access the battery.
Note
If present, the additional battery is automatically connected to the main vehicle battery only when the engine
is running. It does not need to be manually disconnected before jump
starting the vehicle.
Vehicle battery 3 173.

Customer information217Customer
informationCustomer information ................217
Declaration of conformity .........217
REACH .................................... 221
Registered trademarks ............221
Vehicle data recording and pri‐ vacy ........................................... 221
Event data recorders ...............221
Radio Frequency Identification (RFID) ..................................... 224Customer information
Declaration of conformity
Radio transmission systems
This vehicle has systems that
transmit and / or receive radio waves
subject to Directive 2014/53/EU. The
manufacturers of the systems listed
below declare conformity with
Directive 2014/53/EU. The full text of
the EU declaration of conformity for each system is available at the
following internet address:
www.opel.com/conformity.
Importer is
Opel / Vauxhall, Bahnhofsplatz,
65423 Ruesselsheim am Main,
Germany.
Electronic key transmitter
Continental Automotive
1 Rue de Clairefontaine, 78120
Rambouillet, France
Operation frequency: 433 MHz
Maximum output: 10 mW ERPImmobiliser
Visteon Electronics
04 Rue Nelson Mandela, Zone
Industrielle Borj Cedria, 2055 Bir El
Bey, Tunisia
Operation frequency: 125 kHz
Maximum output:
42 dBµA/m @ 10 m
Immobiliser
Continental Automotive
1 Rue de Clairefontaine, 78120
Rambouillet, France
Operation frequency: 125 kHz
Maximum output:
42 dBµA/m @ 10 m
IntelliLink Touch
Continental Automotive
1 Rue de Clairefontaine, 78120
Rambouillet, France
Operation frequency: N/A
Maximum output: N/A
NAVI 50 IntelliLink / NAVI 80
IntelliLink
LG Electronics

229KKeys ............................................. 21
Keys, locks ................................... 21
L
Lashing eyes ............................... 79
Lashing straps .............................. 79
Laying up the vehicle ..........167, 173
LED spotlights ............................ 114
Light covers, misted.................... 114
Lighting ....................................... 110
Lighting features .........................116
Light switch ................................ 110
Load compartment ................35, 78
Load compartment cover .............79
Load compartment grille ...............81
Load compartment lighting .........116
Loading information .....................82
Load-through feature ....................76
Low fuel ..................................... 102
Luggage floor net .........................79
M
Malfunction indicator light ............99
Manual adjustment ......................40
Manual anti-dazzle ......................42
Manual transmission .................. 147
Maximum speed limiter............... 155
Messages ................................... 104
Mirror adjustment ........................... 8Mirrors .................................... 40, 42
Misted light covers .....................114
N New vehicle running-in ..............133
Number plate light .....................181
O
Object detection systems ...........156
Odometer ..................................... 92 Oil ............................................... 169
Oil, engine .................. 169, 207, 211
Oil pressure ................................ 101
Outside temperature ....................87
Overcab storage ..........................78
Overrun cut-off ........................... 137
P Parking ................................ 20, 140
Parking assist ............................ 156
Parking brake ............................ 149
Parking distance control .............156
Parking heater ............................ 124
Particulate filter ........................... 141
Pedals......................................... 132
Performing work ........................168
Phone controls.............................. 85
Phone holder ................................ 73
Power button ........................ 18, 133
Power outlets ............................... 89
Power steering fluid ....................171Power windows ............................ 43
Preheating ......................... 101, 135
Puncture ..................................... 196
R Radio Frequency Identification (RFID) ..................................... 224
Radio remote control ...................22
REACH ....................................... 221
Reading lights ............................ 116
Rear air conditioning system .....123
Rear courtesy lights ....................114
Rear door manual lock .................25
Rear doors .............................. 25, 33
Rear fog light .....................103, 114
Rear heating system .................. 122 Rear parcel shelf .......................... 79
Rear seats ................................... 51
2nd row seats ............................ 51
3rd row seats............................. 51
Folding ...................................... 51
Installing .................................... 51
Rear seat access ......................51
Removing .................................. 51
Seat cushion adjustment ...........51
Rear seats lights .........................114
Rear view camera ...................... 159
Rear windows .............................. 44
Rear window wiper and washer ..87

230Recommended fluids andlubricants ........................ 207, 211
Refuelling ................................... 162 Registered trademarks ...............221
Remote control ............................. 22
Restraining lattice .........................81
Reversing light ........................... 180
Reversing lights .........................114
Ride control systems ..................150
Roof load ...................................... 82
Roof rack ..................................... 82
S Safety belts ................................... 55
Safety net .................................... 80
Seat adjustment ....................... 7, 48 Seat belt ........................................ 8
Seat belt reminder .......................98
Seat belts ..................................... 55
Seat folding .................................. 50
Seat heating ................................. 50
Seat position ................................ 47
Seats ............................................ 76
Selective catalytic reduction .......142
Service ............................... 130, 205
Service display ............................ 94
Service information ....................205
Service vehicle soon .................... 99
Side airbag system ......................63
Sidelights .................................... 110Side turn lights ........................... 179
Sliding door .................................. 32
Sliding side door ........................... 32
Spare wheel ............................... 197
Spare wheel security tool ...........187
Speed limiter ................91, 103, 155
Speedometer ............................... 91
Starting and operating ................133
Starting off ................................... 18
Starting the engine ...............18, 135
Steering ...................................... 132
Steering column controls ..............85
Steering wheel adjustment ......9, 85
Steering wheel controls ...............85
Stop engine .................................. 99
Stop-start system.......... 18, 102, 137
Storage ......................................... 73
Storage box .................................. 76
Storage compartment ...................75
Storage compartments .................73
Sun visors .................................... 45
Symbols ......................................... 4
T
Tablet holder................................. 73
Tachograph ........................ 103, 108
Tachometer ................................. 92
Tailgate ......................................... 35
Tailgate emergency release .........35
Tail lights ................................... 178Temporary spare wheel ..............197
Three-point seat belt .................... 56
Toll road stickers .......................... 43
Tools .......................................... 187
Top-Tether .................................... 66
Torx key ...................................... 187
Touchscreen ............................... 104
Tow bar....................................... 164
Towing ................................ 164, 200
Towing another vehicle .............201
Towing a trailer ........................... 164
Towing eye ......................... 187, 200
Towing the vehicle .....................200
Traction Control system ............. 150
Trailer coupling ........................... 164
Trailer stability assist .................165
Trailer towing ............................. 164
Transmission ............................... 18
Tread depth ............................... 191
Trip computer ............................ 106
Trip odometer .............................. 92
Turbo engine warm-up ...............135
Turn lights ............................ 97, 113
Tyre chains ................................ 192
Tyre changing ............................. 196
Tyre designations ......................188
Tyre pressure ............................ 188
Tyre pressure monitoring system ............................. 101, 190
Tyre pressures ........................... 216