automatic transmission OPEL ZAFIRA 2009 Owner's Manual

186
Vehicle care
â–  Wear eye protection and protective
clothing when handling a battery.
â–  Use a booster battery with the same voltage (12 volts). Its capacity
(Ah) must not be much less than
that of the discharged battery.
â–  Use jump leads with insulated terminals and a cross section of at
least 16 mm 2
(25 mm 2
for diesel
engines).
â–  Do not disconnect the discharged battery from the vehicle.
â–  Switch off all unnecessary electrical consumers.
â–  Do not lean over the battery during jump starting.
â–  Do not allow the terminals of one lead to touch those of the other
lead.
â–  The vehicles must not come into contact with each other during the
jump starting process.
â–  Apply the handbrake, transmission in neutral, automatic transmission
in P. Lead connection order:
1.
Connect the red lead to thepositive terminal of the booster
battery.
2. Connect the other end of the red lead to the positive terminal of the
discharged battery.
3. Connect the black lead to the negative terminal of the booster
battery.
4. Connect the other end of the black lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as
far away from the discharged
battery as possible. Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine:
1.

Start the engine of the vehicleproviding the jump.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than 15
seconds at an interval of 1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.

Vehicle care
187
Towing
Towing the vehicle Version with cover strip: Disengage
strip at bottom, slide to side and
remove.
Version with cover cap: Disengage
cap at bottom and remove
downwards.
The towing eye is stowed with the
vehicle tools
3 173. Screw in the towing eye as far as it will
go until it stops in a horizontal
position.
Attach
a tow rope – or better still a tow
rod – to the towing eye.
The towing eye must only be used for
towing and not recovering the vehicle.
Switch on ignition to release steering
column lock and to permit operation
of brake lamps, horn and windscreen
wipers.
Open&Start system 3 29.
Transmission in neutral. Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
When the engine is not running,
considerably

more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the
air recirculation and close the
windows.
Vehicles with automatic transmission
must be towed facing forwards, not
faster than 80 km/h and further than
100 km. Otherwise or if the
transmission is defective, the front
axle must be raised off the ground.
Seek the assistance of a workshop.
Manual transmission automated
3 136.
After towing, unscrew the towing eye
clockwise and refit the cover.

212
Technical data
Performance
Engine Z16XEP Z16XER Z16XE1 Z16YNG Z18XER Z20LER
Top speed
2)
[km/h]
Manual transmission 177 185 177 165 197 225
Manual transmission automated –– – – 197 –
Automatic transmission – – – – – –
Engine Z20LEH Z22YH A17DTJ A17DTR Z19DTL Z19DT
Top speed
2)
[km/h]
Manual transmission 231 200 179 189 174 186
Manual transmission automated –– – –––
Automatic transmission – 190 – – – 182
2)
The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment
could reduce the specified maximum speed of the vehicle.

Technical data
213
Engine Z19DTH
Top speed
2)
[km/h]
Manual transmission 202
Manual transmission automated –
Automatic transmission 198
Fuel consumption - CO
2-emissions
Tyre width up to 195 mm with manual transmission / manual transmission automated / automatic transmission.
Engine Z16XEP Z16XER Z16XE1 Z18XER Z20LER Z20LEH
urban [l/100 km] 9.3/–/– 9.2/–/– 9.3/–/– 9.8/9.6/– –/–/– –/–/–
extra-urban [l/100 km] 5.8/–/– 5.7/–/– 5.8/–/– 5.9/5.7/– –/–/– –/–/–
total [l/100 km] 7.1/–/– 7.0/–/– 7.1/–/– 7.3/7.1/– –/–/– –/–/–
CO
2 [g/km] 170/–/– 167/–/– 169/–/– 174/169/– –/–/– –/–/–
2)
The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment
could reduce the specified maximum speed of the vehicle.

214
Technical data
Engine Z22YH A17DTJ A17DTR Z19DTL Z19DT Z19DTH
urban [l/100 km] –/–/– 7.0/–/– 7.0/–/– 7.5/–/– 7.5/–/– –/–/–
extra-urban [l/100 km] –/–/– 4.8/–/– 4.8/–/– 5.0/–/– 5.0/–/– –/–/–
total [l/100 km] –/–/– 5.6/–/– 5.6/–/– 5.9/–/– 5.9/–/– –/–/–
CO
2 [g/km] –/–/– 149/–/– 149/–/– 156/–/– 156/–/– –/–/–
Tyre width up to 225 mm with manual transmission / manual transmission automated / automatic transmission.
Engine
Z16XEP Z16XER Z16XE1 Z18XER Z20LER Z20LEH
urban [l/100 km] 9.5/–/– 9.3/–/– 9.4/–/– 9.9/9.7/– 13.3/–/– 13.4/–/–
extra-urban [l/100 km] 6.0/–/– 5.8/–/– 5.9/–/– 6.0/5.8/– 7.3/–/– 7.4/–/–
total [l/100 km] 7.3/–/– 7.1/–/– 7.2/–/– 7.4/7.2/– 9.5/–/– 9.6/–/–
CO
2 [g/km] 175/–/– 169/–/– 172/–/– 177/172/– 228/–/– 230/–/–
Engine Z22YH A17DTJ A17DTR Z19DTL Z19DT Z19DTH
urban [l/100 km] 11.3/–/11.6 7.1/–/– 7.1/–/– 7.6/–/– 7.6/–/9.7 7.6/–/9.7
extra-urban [l/100 km] 6.4/–/6.7 4.9/–/– 4.9/–/– 5.1/–/– 5.1/–/5.6 5.1/–/5.6
total [l/100 km] 8.2/–/8.5 5.7/–/– 5.7/–/– 6.0/–/– 6.0/–/7.1 6.0/–/7.1
CO
2 [g/km] 197/–/204 152/–/– 152/–/– 159/–/– 159/–/192 160/–/192
Tyre width up to 225 mm with manual transmission.

216
Technical data
Vehicle weight
Kerb weight, basic model
Zafira Engine Manual transmission Manual transmission
automated Automatic transmission
without/with air conditioning
[kg] Z16XER, Z16XEP,
Z16XE1 1505/1520 – –
Z16YNG 1665/1680 – –
Z18XER 1503/1518 1503/1518 –
Z20LER –/1610 – –
Z20LEH –/1665 – –
Z22YH 1570/1585 – 1595/1610
A17DTJ, A17DTR 1600/1615 – –
Z19DTL 1613/1628 – –
Z19DT 1613/1628 – 1650/1665
Z19DTH 1613/1628 – 1643/1658

222
Technical data
Comfort with up to 3 people ECO with up to 3 people With full load
Engine Tyres front
rearfrontrearfrontrear
[kPa/bar] [kPa/bar] [kPa/bar] [kPa/bar] [kPa/bar] [kPa/bar]
A17DTJ, A17DTR 195/60 R 16 260/2.6 240/2.4 – – 280/2.8 320/3.2
195/65 R 15
6)
, 240/2.4 220/2.2 –
–260/2.6 310/3.1
205/55 R 16,
225/45 R 17 225/40 R 18 250/2.5 230/2.3 – – 270/2.7 310/3.1
Z19DTL,
Z19DT,
Z19DTH 195/60 R16 260/2.6 240/2.4 – – 280/2.8 320/3.2
205/55 R 16,
240/2.4 220/2.2 – –260/2.6 310/3.1
225/45 R 17 205/55 R 16
7)
, 250/2.5 230/2.3 –
–260/2.6 310/3.1
225/45 R 17 4) 225/40 R 18
8) 250/2.5 230/2.3 – – 270/2.7 310/3.1
all Temporary spare wheel 420/4.2 420/4.2 – – 420/4.2 420/4.2
6)
Only with A17DTJ.
7) Z19DTH with automatic transmission and moon roof.
4) For a correct speed display reprogramme the speedometer.
8) Not for Z19DTL.

224
Index
A
Accessories and vehicle
modifications .......................... 154
Active head restraints on front seats .........................................
23
Adaptive Forward Lighting ........ .................................... 25, 92, 110
Additional servicing .................... 204
Adjustable air vents ...................124
Airbag and belt tensioners ...........87
Airbag system .............................. 57
Air conditioning regular operation ................................ 126
Air conditioning system .............. 119
Air intake .................................... 125
Air quality sensor ........................121
Antilock brake system ................ 140
Antilock brake system (ABS) ....... 89
Anti-theft alarm system ........ 36, 101
Anti-theft locking system .............. 36
Apply footbrake ............................ 92
Armrest ........................................ 49
Ashtrays ....................................... 82
Automatic anti-dazzle ..................40
Automatic climate control system .................................... 120
Automatic level control ..............144
Automatic light control ...............108
Automatic transmission .............131 Auxiliary devices
........................116
Auxiliary heater ........................... 124
B
Battery ....................................... 158
Battery discharge protection ......114
Battery voltage ...........................
100
Board-Info-Display .......................93
Bonnet ....................................... 155
Brake and clutch system ............. 89
Brake assist ............................... 142
Brake fluid .................................. 158
Brake light switch ....................... 101
Brakes ............................... 140, 158
Bulb replacement ....................... 160
C
Capacities .................................. 219
Cargo management system ........71
Car Pass ...................................... 27
Catalytic converter .....................130
Central locking system ................32
Centre console lighting ..............114
Changing tyre and wheel size ...178
Charging system .......................... 88
Check control ............................... 23
Child locks ................................... 35
Child restraint installation locations ................................... 63