check engine Peugeot 301 2012 Owner's Guide

161
10
Checks














Diesel engine
1.
Screenwash fluid reservoir. 2.Coolant header tank.3.Air filter.4.
Brake fluid reservoir.
5. Battery.
6.Fusebox.7. Engine oil dipstick.8.Engine oil filler cap.9.
Priming pump.

162
Checks
On vehicle fitted with HDi engines, the fuelsystem must be primed if you run out of fuel; refer to the engine compar tment view on the
"Diesel engine" section.
If the tank on your vehicle is fitted with a misfuel prevention device, refer to the corresponding section.











Running out of fuel (Diesel)


If the engine does not star t first time, don't keep trying. Start the procedureagain from the beginning.

)
Fill the fuel tank with at least five litres of
diesel. )
Open the bonnet.)
Squeeze and release the priming pump
repeatedly until resistance is felt (there may
be resistance at the first press).
) Operate the star ter until the engine starts(if the engine does not star t at the first
attempt, wait around 15 seconds before
trying again). ) If the engine does not star t after a few
attempts, operate the priming pump again
then start the en
gine. ) Close the bonnet.



HDi 92 engine

163
10
Checks






Checking levels
Oil level
The check of the oil level is carried
out with the dipstick, located under
the bonnet. For the position o
f the dipstick, refer
to the description of your engine compar tment in this section.
Engine oil change
Refer to the servicing booklet for details of theinterval for this operation.
In order to maintain the reliability of the engine and emission control system, the use of additives in the engine oil is prohibited.
Oil specifi cation
The oil must be the correct grade for your
en
gine and conform to the manufacturer'srecommendations.



Take care when working under the bonnet, as certain areas of the engine may be extremely
hot (risk of burns) and the cooling fan could star t at any time (even with the ignition off).

If a level drops si
gnificantly, have the corresponding system checked by a PEUGEOT dealer or a qualified workshop.
Check all of these levels regularly, in line with the ser vicing booklet and the requirements of the warranty. Top them up if necessary, unless other wise indicated.
It is normal to top up the oil levelbetween two ser vices (or oil changes).PEUGEOT recommends that you check the level, and top up if necessary, every3 000 miles (5 000 km). This check will onl
y be correct if the vehicle is
on level ground and the engine has been off for more than 30 minutes.
Dipstick
There are two marks on the dipstick:
A= maximum
If you fill past this mark, contact a PEUGEOT dealer
or a qualified workshop.B= minimum
Never allow the level to fall below this mark.

164
Checks
The coolant level should be closeto the "MA X" mark but should never exceed it.
In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
To a v o i d a ny risk of scalding, unscrew the cap by two turns to allow the pressure to drop. When the pressure has dropped, remove the cap and top up the level.


Changing the coolant
The coolant does not have to be changed.


Fluid specifi cation

The coolant must conform to themanufacturer's recommendations. When the engine is warm, the temperature o
f
the coolant is regulated by the fan.
The cooling fan may star t after switching off the engine: take care with ar ticles and
clothing that might become caught by the
fan blades.
The brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fl uid
Refer to the ser vicing booklet for details of the
interval for this operation.
Fluid specifi cation
The brake fluid must conform to themanufacturer's recommendations and meet the
DOT3 or DOT4 standard.

165
10
Checks

Fluid specifi cation

For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.
Screenwash fluid level
Top up the level when necessary. Avoid prolonged contact of used oil or fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.

Do not discard used oil or fluids into sewers or onto the ground.
Take used oil to a PEUGEOT dealer or a qualified workshop (France) or to anauthorised waste disposal site.








Used products
To p p i ng up
This additive must be topped up by a PEUGEOT dealer or a qualified workshopwithout delay.

Diesel additive level
(Diesel engine with particle
emission filter)
A low additive level is indicated by illumination
of the ser vice warning lamp, accompaniedby an audible warning and a message in the screen.

166
Checks






Checks

The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
Par ticle emissions filter (Diesel)
The start of saturation of thepar ticle filter is indicated by the
temporary illumination of this warning lamp
accompanied by a warning message in the screen.
As soon as the traffic conditions permit,
regenerate the filter by driving at a speed of at
least 40 mph (60 km/h) until the warning lampgoes off.
If the warning lamp stays on, this indicates a
low additive level.
On a new vehicle, the first particlefilter regeneration operations may be accompanied by a "burning" smell,
which is perfectly normal.
Following prolonged operation of the vehicle at very low speed or at idle, you may, in exceptional circumstances,notice the emission of water vapour at the exhaust on acceleration. This does not affect the behaviour of the vehicle or the environment. Unless other wise indicated, check these components in accordance with the ser vicin
g booklet and according to your engine.Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Air filter and passenger compartment filter
Refer to the servicing booklet for
details of the replacement inter vals
for these components.
Oil filter
Replace the oil filter each time theengine oil is changed.
Refer to the ser vicing booklet for
details of the replacement inter val for
this component. When carr
ying out work on the battery, refer
to the "Practical information" section for
details of the precautions to be taken before
disconnecting the battery and following itsreconnection. Dependin
g on the environment (e.g. dusty
atmosphere) and the use of the vehicle(e.g. city driving), replace them twice as oftenif necessary.y A clogged passenger compar tment filter may
have an adverse effect on the performance
of the air conditioning system and generateundesirable odours.

226
Visual search
Maintenance - Technical data
Petrol weights 169 Diesel weights 171
Changing bulbs 133 -138 - front- rear


Running out of fuel, Diesel 162
Opening the bonnet 159 Under the bonnet, petrol 160 Under the bonnet, Diesel 161 Petrol engines 168 Diesel engines 170
12V bat tery 14 4 -146 Load reduction, economy mode 146, 147
Engine compar tment fuses 139 -140, 143
Checking levels 163 -165 - oil- brake fluid- coolant- screenwash fluid - additive (Diesel with particleemissions filter)
Checking components 166 -167 - battery - air / passenger compar tment filter - oil filter - particle emissions filter (Diesel)- brake pads / discs
Identification markings 173 Dimensions 172

.
227
Alphabetical index
ABS and EBFD systems ...............................101Accessories..................................................154Accessory socket, 12V...................................72Adjusting headlamps ......................................96Adjusting head restraints................................56Adjusting the steering wheel...........................60Advice on care and maintenance .........154,160Airbags....................................................31, 106Airbags, front.........................................106, 109Airbags, lateral......................................108, 109Air conditioning...................................20, 63, 65Air conditioning, electronic(with screen)...........................................62,65Air conditioning, manual...........................14, 63Air filter..........................................................r166Air flow............................................................61Air vents..........................................................61Alarm...............................................................46Anti-lock braking system (ABS)....................101Anti-theft..........................................................43Armrest, front............................................70, 72Ashtray............................................................70Audible warning............................................100Audio streaming (Bluetooth).................188, 190Audio system (radio).............................175, 205Automatic operation of hazard
warning lamps.............................................100Auxiliary socket .....................................187, 215
Battery ...........................................144-146, 166Battery, charging...................................145, 146Battery, remote control.............................44, 45Bluetooth (hands-free) ..................................189Bonnet...........................................................159Boot.................................................................49Boot (unlocking)..............................................42Brake discs....................................................167Brake lamps..................................................137Brake pads ....................................................167Braking assistance system...........................101
Capacity, fuel tank ..........................................52CD.........................................................182, 211CD MP3 .................................................183, 212Central locking................................................43Changing a bulb.....................................133-138Changing a fuse.....................................139-143Changing a wheel ..................................126-132Changing a wiper blade..........................98,148Changing the date ...........................................35Changing the remote control battery..............44Changing the time...........................................35Checking levels ......................................163-165Checking the engine oil level ........................163Checking tyre pressures (using the kit)........125Checks ...................................................160-167Child lock .......................................................119Children..........................................105, 110-119Child seats .....................................110, 113-115Child seats, conventional ..............................113
AB
C
Cigarette lighter...............................................r72Clock...............................................................35Closing the boot........................................43, 49Closing the doors ......................................43, 48Connectors, audio...................72,185, 187,215Coolant level.................................................164Courtesy lamps ...............................................99Courtesy mirror...............................................r71Cruise control..................................................87Cup holder.......................................................r70
D
Date (setting)...................................................35Daytime running lamps...........................95,135Deactivating the passenger airbag...............106Demisting/defrosting .......................................68Demisting/defrosting, rear..............................r69Dials and gauges............................................22Diesel additive level......................................165Dimensions...................................................172Dipped beam...........................................91,135Dipstick ..........................................................163Direction indicators.......................100, 134, 137Doors...............................................................48Door pockets ...................................................70Driving economically ......................................20