engine Peugeot 407 C Dag 2008 Workshop Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2008, Model line: 407 C Dag, Model: Peugeot 407 C Dag 2008Pages: 211, PDF Size: 11.75 MB
Page 133 of 211
1010
120
Before disconnecting the bat-
tery, you must wait for 2 minu-
tes after switching off the
ignition.
Never disconnect a terminal when the
engine is running.
N e v e r c h a r g e a b a t t e r y w i t h o u t fi r s t
disconnecting the terminals.
Open the windows and close the sun-
roof before disconnecting the battery.
If they do not operate normally follow-
ing reconnection of the battery, they
must be reinitialised (see paragraphs
"Reinitialisation of the electric win-
dows" and "Sunroof").
After every reconnection of the bat-
tery, switch on the ignition and wait
1 minute before starting to allow the
electronic systems to be initialised.
H o w e v e r , i f s l i g h t d i f fi c u l t i e s a r e e x -
perienced after this, please contact a
PEUGEOT dealer.
On the 2.7 litre 24V HDI engine, if
there is no battery in the boot, do
not connect a slave battery to the
positive (+) and negative (-) termi-
nals under the bonnet as a short
circuit may occur.
The batteries contain harmful
substances such as sulphuric
acid and lead. They must be
disposed of in accordance
with regulations and must never be
discarded with household waste.
Take used batteries to an approved
collection point.
open the bonnet,
use the two additional positive (+)
and negative (-) terminals located
under the bonnet,
open the red cover of the positive
(+) terminal,
connect the red cable between the
positive (+) terminal and the positive
(+) terminal of the slave battery,
connect the green or black cable
between the negative (-) terminal
and the negative (-) terminal of the
slave battery,
operate the starter, let the engine
run,
wait for the engine to return to idle,
then disconnect the cables,
close the red cover of the positive
(+) terminal,
r e fi t t h e l e f t s i d e c o v e r ,
close the bonnet. BOOT) *
* V e h i c l e s fi t t e d w i t h t h e 2 . 7 l i t r e H D I
24 V engine.
The battery is in the left boot trim.
To charge the battery using a battery
charger (boot open):
fold down the panel to gain access
to the battery,
disconnect the battery,
follow the instructions for use given
by the battery charger manufacturer,
reconnect starting with the nega-
tive (-) terminal,
raise the panel and close it. To start the vehicle from another
battery:
Page 134 of 211
1010
121
TOWING YOUR VEHICLE
From the rear:
Unclip the cover, pulling the upper
rib towards you,
Screw in the towing eye as far as it
will go.
Special featuresof the automatic gearbox
Lifting (2 wheels only on the ground)
It is preferable to raise the vehicle with
a professional lifting device.
When towing with the engine
switched off, there is no brak-
ing or steering assistance.
From the front:
Unclip the left part of the cover,
Screw in the towing eye as far as it
will go. Towing a vehicle with an auto-
matic gearbox in reverse gear
is
prohibited (absence of
lubrication).
When being towed with all four wheels
on the ground, it is imperative that the
following rules are obeyed:
- selector lever in position N ,
- the vehicle must be towed at a speed of less than 30 mph (50 km/h) over
a maximum distance of 30 miles
(50 km),
- do not add oil to the gearbox.
Without lifting (4 wheels on the ground)
You must always use a towbar.
The removable towing eye is inside
the spare wheel.
Page 135 of 211
1010
122
In all cases, pay attention to the coolant
temperature.
Brakes: towing increases the braking
distance. Drive at a moderate speed,
change down early and brake gradually.
Side wind: sensitivity to side wind is
increased. Drive smoothly and at a
moderate speed. TOWING A TRAILER, CARAVAN, BOAT, ETC...
We recommend the use of original
PEUGEOT towbars which have been
tested and approved from the design
stage of your vehicle and that the tow-
b a r i s fi t t e d b y a P E U G E O T d e a l e r .
Driving advice
Distribution of loads: distribute the
load in the trailer so that the heavi-
est loads are as close as possible to
the axle and the nose weight is close
to the maximum authorised without,
however, exceeding it.
Cooling: towing a trailer on a slope in-
creases the coolant temperature.
As the fan is electrically controlled, its
cooling capacity is not dependent on
the engine speed.
Note: in certain cases of par-
ticularly arduous use (towing
the maximum load in high
temperatures), the engine au-
tomatically limits its power and selects
the appropriate automatic gearbox
gear in manual mode. In this case,
cutting off the air conditioning allows
the engine power to be recovered, and
therefore the towing capacity to be in-
creased.
If the coolant temperature
warning light comes on, stop
the vehicle and switch off the
engine as soon as possible.
Tyres: check the tyre pressures of the
towing vehicle (label on the central
door pillar on the driver's side) and of
the trailer towed, observing the recom-
mended pressure.
Page 137 of 211
11
124
* D r a i n i n g b y g r a v i t y w i t h o i l fi l l e r c a p o p e n .
ENGINES AND GEARBOXES
Model codes: 6J..
3FYH XFVJ
ENGINES PETROL 2.2 litre 16V 3 litre V6 24V
C u b i c c a p a c i t y ( c m 3
) 2 231 2 946
B o r e x s t r o k e ( m m ) 8 6 x 9 6 8 7 x 8 2 . 6
E U s t a n d a r d m a x i m u m p o w e r ( k W ) / ( b h p ) 1 2 0 / 1 6 3 1 5 5 / 2 1 1
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 5 876 6 000
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 220 290
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 4 126 3 750
F u e l U n l e a d e d U n l e a d e d
C a t a l y t i c c o n v e r t e r Y e s Y e s
Gearbox M a n u a l ( 6 - s p e e d ) A u t o m a t i c ( 6 - s p e e d )
Oil capacity (in litres)
E n g i n e ( w i t h c a r t r i d g e r e p l a c e m e n t ) * 4 . 7 5 5 . 2 5
Page 138 of 211
11
126
* D r a i n i n g b y g r a v i t y w i t h o i l fi l l e r c a p o p e n .
ENGINES AND GEARBOXES
Model codes: 6J... RHRH UHZJ
DIESEL ENGINES 2 litre HDI 16V 2.7 litre HDI V6 24V
C u b i c c a p a c i t y ( c m 3
) 1 997 2 720
B o r e x s t r o k e ( m m ) 8 5 x 8 8 8 1 x 8 8
E U s t a n d a r d m a x i m u m p o w e r ( k W ) / ( b h p ) 100 1 5 0 / 2 0 4
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 4 000 4 000
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 320 440
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 2 000 1 900
F u e l D i e s e l D i e s e l
C a t a l y t i c c o n v e r t e r Y e s Y e s
P a r t i c l e e m i s s i o n fi l t e r ( P E F ) Y e s Y e s
Gearbox Manual
( 6 - s p e e d ) A u t o m a t i c
( 6 - s p e e d )
Oil capacity (in litres)
E n g i n e ( w i t h c a r t r i d g e r e p l a c e m e n t ) * 5 . 2 5 5 . 8 0
Page 139 of 211
11
125
TECHNICAL DATA
T h e c o n s u m p t i o n fi g u r e s s h o w n h e r e c o r r e s p o n d t o t h e v a l u e s c o m m u n i c a t e d a t t h e t i m e o f p r i n t i n g . T h e s e c o n s u m p t i o n
v a l u e s w e r e e s t a b l i s h e d i n a c c o r d a n c e w i t h E C D i r e c t i v e 8 0 / 1 2 6 8 ( a s a m e n d e d ) . T h e y m a y v a r y d e p e n d i n g o n t h e s t y l e
o f d r i v i n g , t r a f fi c c o n d i t i o n s , w e a t h e r c o n d i t i o n s , t h e l o a d i n t h e v e h i c l e , t h e m a i n t e n a n c e o f t h e v e h i c l e a n d t h e u s e o f t h e
a c c e s s o r i e s .
* * T h e k e r b w e i g h t i s e q u a l t o t h e u n l a d e n v e h i c l e + d r i v e r ( 7 5 k g ) .
* * * T h e s p e e d o f a t o w i n g v e h i c l e m u s t n o t e x c e e d 6 0 m p h ( 1 0 0 k m / h ) ( c o m p l y w i t h t h e l e g i s l a t i o n i n f o r c e i n y o u r c o u n t r y ) .
Petrol engines Gearboxes Model codes
Urban driving mpg
(litres/100 km )
Inter-urban
driving mpg
(litres/100 km) Mixed driving mpg
(litres/100 km)
Emission of
CO 2 by mass
(g/km)
2.2 litre 16V Manual 6J3FYH 2 1 . 6 ( 1 3 . 1 ) 4 0 . 9 ( 6 . 9 ) 3 0 . 7 ( 9 . 2 ) 219
3 litre V6 24V A u t o m a t i c 6JXFVJ 1 8 . 8 ( 1 5 . 0 ) 3 8 . 7 ( 7 . 3 ) 2 7 . 6 ( 1 0 . 2 ) 242
( a ) T h e b r a k e d t r a i l e r v a l u e c o r r e s p o n d s t o t h e t o w i n g c a p a c i t y o f t h e v e h i c l e o n a 1 2 % i n c l i n e .
T h e b r a k e d t r a i l e r w e i g h t m a y b e i n c r e a s e d b y ( 1 ) 2 5 0 k g , o n c o n d i t i o n t h a t t h e l o a d i n t h e v e h i c l e i s r e d u c e d s o t h a t t h e G T W
i s n o t e x c e e d e d .
H i g h e x t e r i o r t e m p e r a t u r e s m a y r e s u l t i n a r e d u c t i o n i n t h e p e r f o r m a n c e o f t h e v e h i c l e i n o r d e r t o p r o t e c t t h e e n g i n e ; w h e n t h e
e x t e r i o r t e m p e r a t u r e i s h i g h e r t h a n 3 7 ° C , l i m i t t h e w e i g h t t o w e d t o 6 0 0 k g , w i t h o u t l o a d t r a n s f e r .
Petrol engines
2.2 litre 16V 3 litre V6 24V
Gearbox
Manual Automatic
Model codes: 6J3FYH 6JXFVJ
Page 140 of 211
11
127
TECHNICAL DATA
T h e c o n s u m p t i o n fi g u r e s s h o w n h e r e c o r r e s p o n d t o t h e v a l u e s c o m m u n i c a t e d a t t h e t i m e o f p r i n t i n g . T h e s e c o n s u m p t i o n
v a l u e s w e r e e s t a b l i s h e d i n a c c o r d a n c e w i t h E C D i r e c t i v e 8 0 / 1 2 6 8 ( a s a m e n d e d ) . T h e y m a y v a r y d e p e n d i n g o n t h e s t y l e
o f d r i v i n g , t r a f fi c c o n d i t i o n s , w e a t h e r c o n d i t i o n s , t h e l o a d i n t h e v e h i c l e , t h e m a i n t e n a n c e o f t h e v e h i c l e a n d t h e u s e o f t h e
a c c e s s o r i e s .
* * T h e k e r b w e i g h t i s e q u a l t o t h e u n l a d e n v e h i c l e + d r i v e r ( 7 5 k g ) .
* * * T h e s p e e d o f a t o w i n g v e h i c l e m u s t n o t e x c e e d 6 0 m p h ( 1 0 0 k m / h ) ( c o m p l y w i t h t h e l e g i s l a t i o n i n f o r c e i n y o u r c o u n t r y ) .
( a ) T h e b r a k e d t r a i l e r v a l u e c o r r e s p o n d s t o t h e t o w i n g c a p a c i t y o f t h e v e h i c l e o n a 1 2 % i n c l i n e .
T h e b r a k e d t r a i l e r w e i g h t m a y b e i n c r e a s e d b y ( 1 ) 2 5 0 k g , o n c o n d i t i o n t h a t t h e l o a d i n t h e v e h i c l e i s r e d u c e d s o t h a t t h e G T W
i s n o t e x c e e d e d .
H i g h e x t e r i o r t e m p e r a t u r e s m a y r e s u l t i n a r e d u c t i o n i n t h e p e r f o r m a n c e o f t h e v e h i c l e i n o r d e r t o p r o t e c t t h e e n g i n e ; w h e n t h e
e x t e r i o r t e m p e r a t u r e i s h i g h e r t h a n 3 7 ° C , l i m i t t h e w e i g h t t o w e d t o 6 0 0 k g , w i t h o u t l o a d t r a n s f e r .
WEIGHTS AND TOWED LOADS (IN KG)
CONSUMPTION
Diesel engines
2 litre HDI 16V 2.7 litre HDI V6 24V
Gearbox
Manual Automatic
Model codes: 6 J R H R H 6JUHZJ
Page 143 of 211
130
JUKEBOX FUNCTION (10 GB)/GPS (EUROPE)
The SERVICE BOX internet site provides additional animated information about the WIP Com. It can be consulted at the following address: http://public.servicebox.peugeot.com. Simple registration permits access and free consultation of the handbook.
The WIP Com audio and telematics system is coded i n such a way that it will only operate in your vehicle. If it is to be installed in another vehicle, contact a PEUG EOT d e a l e r f o r c o n fi g u r a t i o n o f t h e s y s t e m .
For safety reasons, it is imperative that the driver carries out operations which require prolonged attention wh ile the vehicle is stationary. When the engine is switched off and to prevent discharging of the battery, the WIP Com audio and telematics system may switch off after a few minutes.
CONTENTS
Page 173 of 211
171
( T A ) i s d i s p l a y e d . I d o n o t r e c e i v e a n y t r a f fi c information.
T u n e t o a r a d i o s t a t i o n w h i c h b r o a d c a s t s t r a f fi c information. T h e r a d i o s t a t i o n i s n o t p a r t o f t h e r e g i o n a l t r a f fi c i n f o r m a t i o n n e t w o r k .
QUESTION SOLUTION RESPONSE
The quality of reception of the radio station listened to gradually deteriorates or the stored stations do not function (no sound, 87.5 Mhz is d i s p l a y e d . . . ) .
The vehicle is too far from the transmitter used b y the station listened to or there is no transmitter in the geographical area th rough which the vehicle is travelling.
T h e e n v i r o n m e n t ( h i l l s , b u i l d i n g s , t u n n e l s , b a s e m e n t c a r p a r k s . . . ) b l o c k reception, including in RDS mode.
The aerial is absent or has been damaged (for exam ple when going t h r o u g h a c a r w a s h o r i n t o a n u n d e r g r o u n d c a r p a r k ) .
Activate the RDS function to enable the system to check whether there is a more powerful transmitter in the geographical area.
This phenomenon is normal and does not indicate a failure of the audio equipment.
Have the aerial checked by a PEUGEOT dealer.
Sound cut-outs of 1 to 2 seconds in radio mode.
During this brief sound cut-out, the RDS searches for any frequency permitting better reception of the station. Deactivate the RDS function if the phenomenon is too frequent and always on the same route.
With the engine off, the audio equipment switches off after a few minutes of use.
When the engine is switched off, the audio equipme nt operating time depends on the battery charge. The switch-off is normal: the audio equipment switches to economy mode and switches off to prevent discharging of the vehicle's battery.
Start the vehicle's engine to increase the battery charge.
The stored stations do not function (no sound, 8 7 . 5 M h z i s d i s p l a y e d . . . ) .
An incorrect waveband is selected. Press the BAND AST button to return to the w a v e b a n d ( A M , F M 1 , F M 2 , F M A S T ) o n w h i c h t h e stations are stored.
The message "the audio system is overheated" appears on the display.
Switch the audio system off for a few minutes to allow the system to cool. In order to protect the installation if the surrounding temperature is too high, the audio equipment switches to an automatic thermal protection mode leading to a reduction of the volume or stopping of the playing of the CD.